ECU SATURN AURA HYBRID 2010 Service Manual

Dolly Towing
Tow the vehicle with the two rear wheels on the ground
and the front wheels on a dolly:
To tow the vehicle with two wheels on the ground and
a dolly:
1. Put the front wheels on a dolly.
2. Put the gear shift lever in P (Park).
3. Set the parking brake.
4. Clamp the steering wheel in a straight-ahead
position with a clamping device designed for towing.
5. Remove the key from the ignition.6. Secure the vehicle to the dolly.
7. Release the parking brake.
Notice:Towing the vehicle from the rear could
damage it. Also, repairs would not be covered by
the vehicle warranty. Never have the vehicle towed
from the rear.
Towing a Trailer
The vehicle is neither designed nor intended to tow a
trailer.
5-28
ProCarManuals.com

2. Then keep turning the
pressure cap slowly,
and remove it.
3. Fill the coolant surge tank with the proper mixture,
to the FULL COLD mark. Wait about five minutes,
then check to see if the level is below the mark.
If the level is below the FULL COLD mark,
add additional coolant to bring the level up to the
mark. Repeat this procedure until the level remains
constant at the FULL COLD mark for at least
five minutes.4. With the coolant surge tank pressure cap off, start
the engine and let it run until you can feel the upper
radiator hose getting hot. Watch out for the engine
cooling fans.
By this time, the coolant level inside the coolant
surge tank might be lower. If the level is lower than
the FULL COLD mark, add more of the proper
mixture to the coolant surge tank until the level
reaches the FULL COLD mark.
5. Then replace the pressure cap. Be sure the
pressure cap is hand-tight and fully seated.
Notice:If the pressure cap is not tightly installed,
coolant loss and possible engine damage may
occur. Be sure the cap is properly and tightly
secured.
6-27
ProCarManuals.com

Services Provided
•Emergency Fuel Delivery:Delivery of enough fuel
for the vehicle to get to the nearest service station.
•Lock-Out Service:Service is provided to unlock the
vehicle if you are locked out. A remote unlock may
be available if you have OnStar
®. For security
reasons, the driver must present identification
before this service is given.
•Emergency Tow From a Public Road or
Highway:Tow to the nearest Saturn retailer for
warranty service, or if the vehicle was in a crash and
cannot be driven. Assistance is also given when
the vehicle is stuck in sand, mud, or snow.
•Flat Tire Change:Service is provided to change a
flat tire with the spare tire. The spare tire, if
equipped, must be in good condition and properly
inflated. It is the owner’s responsibility for the repair
or replacement of the tire if it is not covered by
the warranty.
•Battery Jump Start:Service is provided to jump
start a dead battery.
•Trip Interruption Benets and Assistance:If your
trip is interrupted due to a warranty failure, incidental
expenses may be reimbursed during the
5 years/100,000 miles (160 000 km) Powertrain
warranty period. Items considered are hotel, meals,
and rental car.
Services Not Included in Roadside
Assistance
•Impound towing caused by violation of any laws.
•Legal fines.
•Mounting, dismounting or changing of snow tires,
chains, or other traction devices.
•Towing or services for vehicles driven on a
non-public road or highway.
Services Specic to Canadian
Purchased Vehicles
•Fuel delivery:Reimbursement is approximately
$5 Canadian. Diesel fuel delivery may be
restricted. Propane and other fuels are not provided
through this service.
•Lock-Out Service:Vehicle registration is required.
•Trip Routing Service:Detailed maps of North
America are provided when requested either
with the most direct route or the most scenic route.
There is a limit of six requests per year. Additional
travel information is also available. Allow three
weeks for delivery.
8-8
ProCarManuals.com

Radio Frequency
Identication (RFID)
RFID technology is used in some vehicles for functions
such as tire pressure monitoring and ignition system
security, as well as in connection with conveniences
such as key fobs for remote door locking/unlocking and
starting, and in-vehicle transmitters for garage door
openers. RFID technology in Saturn vehicles does not
use or record personal information or link with any other
Saturn system containing personal information.
Radio Frequency Statement
This vehicle has systems that operate on a radio
frequency that comply with Part 15 of the Federal
Communications Commission (FCC) Rules and with
RSS-210/211 of Industry and Science Canada.
Operation is subject to the following two conditions:
1. The device may not cause interference.
2. The device must accept any interference received,
including interference that may cause undesired
operation of the device.
Changes or modifications to any of these systems by
other than an authorized service facility could void
authorization to use this equipment.
8-18
ProCarManuals.com

C
California
Perchlorate Materials Requirements................. 6-4
Warning....................................................... 6-4
California Fuel.................................................. 6-7
Call Waiting...................................................4-77
Calling for Assistance........................................ 8-7
Canadian Owners................................................ ii
Canceling a Remote Start.................................. 1-5
Capacities and Specifications............................6-92
Carbon Monoxide
Engine Exhaust...........................................3-33
Trunk.........................................................3-12
Winter Driving.............................................5-17
Care of
Safety Belts................................................6-76
Care of CDs ..................................................4-60
Care of the CD Player.....................................4-60
CD Messages................................................4-59
CD, MP3 .......................................................4-62
Cellular Phone Usage......................................4-82
Center Console Storage...................................3-37
Chains, Tire...................................................6-64
Charge/Assist Gage........................................4-36
Charging System Light....................................4-27
Check
Engine Lamp..............................................4-31Check Engine Light.........................................4-31
Checking Coolant............................................6-25
Checking Engine Oil........................................6-15
Checking Things Under the Hood......................6-12
Chemical Paint Spotting...................................6-80
Child Restraints
Infants and Young Children...........................2-34
Lower Anchors and Tethers for Children..........2-42
Older Children.............................................2-30
Securing a Child Restraint in a Rear Seat
Position..................................................2-49
Securing a Child Restraint in the Right
Front Seat Position...................................2-52
Systems.....................................................2-38
Where to Put the Restraint...........................2-40
Chime Level Adjustment..................................4-83
Cleaning
Aluminum Wheels........................................6-79
Exterior Lamps/Lenses.................................6-77
Fabric/Carpet..............................................6-75
Finish Care.................................................6-78
Instrument Panel, Vinyl, and Other Plastic
Surfaces.................................................6-76
Interior.......................................................6-73
Tires..........................................................6-79
Underbody Maintenance...............................6-80
3
ProCarManuals.com

Door (cont.)
Power Locks................................................ 3-9
Programmable Automatic Door Locks.............3-10
Rear Door Security Locks.............................3-11
Driver Information Center (DIC).........................4-37
DIC Operation and Displays..........................4-38
DIC Vehicle Personalization..........................4-45
DIC Warnings and Messages........................4-41
Driving
At Night.....................................................5-13
Before a Long Trip......................................5-15
Defensive..................................................... 5-2
Drunk.......................................................... 5-2
Highway Hypnosis.......................................5-15
Hill and Mountain Roads..............................5-16
In Rain and on Wet Roads...........................5-14
Loss of Control...........................................5-12
Off-Road Recovery......................................5-11
Rocking Your Vehicle to Get it Out.................5-20
Winter........................................................5-17
Driving for Better Fuel Economy.......................1-27
Driving on Snow or Ice....................................5-17
Dual Tone Multi-Frequency (DTMF) Tones..........4-78E
EDR .............................................................8-16
Ejecting a CD................................................4-58
Electrical Equipment, Add-On............................6-82
Electrical System
Engine Compartment Fuse Block...................6-86
Fuses........................................................6-83
Instrument Panel Fuse Block.........................6-83
Power Windows and Other Power Options......6-83
Rear Compartment Fuse Block......................6-89
Windshield Wiper Fuses...............................6-82
Electronic Immobilizer
PASS-Key
®III+...........................................3-19
Electronic Immobilizer Operation
PASS-Key
®III+...........................................3-19
Electronic Stability Control................................. 5-6
Electronic Stability Control Indicator Light...........4-29
Emergency Trunk Release Handle.....................3-13
Emissions Inspection and Maintenance
Programs...................................................4-33
Ending a Call.................................................4-77
Engine
Air Cleaner/Filter.........................................6-20
Check and Service Engine Soon Lamp...........4-31
Compartment Overview................................6-14
5
ProCarManuals.com

Lamps (cont.)
Malfunction Indicator....................................4-31
Reading.....................................................4-13
Trunk.........................................................4-13
Lap-Shoulder Belt...........................................2-24
LATCH System for Child Restraints...................2-42
Leaving the Vehicle With the Engine Running.....3-31
Lift Seat, Power............................................... 2-9
Light, Auto Stop Mode.....................................4-36
Lighting
Entry/Exit...................................................4-13
Parade Dimming..........................................4-13
Lights............................................................4-10
Airbag Readiness........................................4-25
Antilock Brake System (ABS) Warning............4-28
Brake System Warning.................................4-27
Charging System.........................................4-27
Cruise Control.............................................4-34
Engine Coolant Temperature Warning.............4-30
Flash-to-Pass............................................... 4-5
Fuel Economy.............................................4-37
Highbeam On.............................................4-34
High/Low Beam Changer................................ 4-5
Oil Pressure...............................................4-33
On Reminder..............................................4-10
Passenger Airbag Status Indicator..................4-26
Safety Belt Reminders..................................4-24
Security.....................................................4-34
Tire Pressure..............................................4-30
Loading a CD................................................4-58Loading Your Vehicle.......................................5-20
Locks
Delayed Locking..........................................3-10
Door ........................................................... 3-9
Lockout Protection.......................................3-12
Power Door .................................................. 3-9
Programmable Automatic Door Locks.............3-10
Rear Door Security Locks.............................3-11
Loss of Control...............................................
5-12
Lower Anchors and Tethers for Children.............2-42
Lumbar
Power Controls............................................. 2-5
M
Maintenance Schedule
Maintenance Record....................................7-13
Maintenance Replacement Parts....................7-11
Owner Checks and Services........................... 7-8
Recommended Fluids and Lubricants.............7-10
Scheduled Maintenance................................. 7-3
MaintenanceI.................................................. 7-3
MaintenanceII................................................. 7-4
Making a Call.................................................4-75
Malfunction Indicator Lamp...............................4-31
Managing the Vehicle Damage Repair Process . . . 8-13
Manual Locks.................................................. 1-6
Manual Reclining Seatbacks............................... 2-6
Manual Seat.................................................... 1-7
9
ProCarManuals.com

Parking Brake and Automatic Transmission
P (Park) Mechanism Check............................. 7-9
Passenger Airbag Status Indicator.....................4-26
Passenger Safety Belt Reminder Light...............4-24
Passenger Sensing System..............................2-66
Passing.........................................................5-12
PASS-Key
®III+ Electronic Immobilizer...............3-19
PASS-Key®III+ Electronic Immobilizer Operation . 3-19
Perchlorate Materials Requirements, California...... 6-4
Personalization Menu Modes............................4-46
Phone
Bluetooth
®..................................................4-69
Playing a CD.................................................4-58
Playing a CD-R or CD-RW MP3.......................4-63
Playing an MP3 CD-R or CD-RW Disc...............4-59
Playing the Radio...........................................4-53
Power
Door Locks.................................................. 3-9
Electrical System.........................................6-83
Lift Seat....................................................... 2-9
Lumbar Controls........................................... 2-5
Retained Accessory (RAP)............................3-22
Seat ............................................................ 2-4
Windows....................................................3-15
Power Door Locks............................................ 1-6
Power Lumbar ................................................. 1-9
Power Reclining Seatbacks................................ 2-7
Power Reclining Seatbacks (If Equipped)............. 1-8
Power Seats (If Equipped)................................. 1-8
Pregnancy, Using Safety Belts..........................2-29Privacy..........................................................8-16
Navigation System.......................................8-17
Radio Frequency Identification (RFID).............8-18
Program
Courtesy Transportation.................................. 8-9
Programmable Automatic Door Locks.................3-10
Programming the Power Windows.....................3-15
Programming Transmitters to the Vehicle............. 3-5
Proposition 65 Warning, California....................... 6-4
Propriétaires Canadiens........................................ ii
Q
Questions and Answers About Safety Belts.........2-15
R
Radio Data System (RDS)...............................4-53
Radio Frequency
Identification (RFID).....................................8-18
Statement...................................................8-18
Radio Messages.............................................4-57
Radio(s)........................................................4-53
Radios
Reception...................................................4-82
Setting the Clock.........................................4-52
Theft-Deterrent............................................4-80
Reading Lamps..............................................4-13
Rear Door Security Locks................................3-11
11
ProCarManuals.com

Seats
Head Restraints............................................ 2-2
Heated Seats............................................... 2-5
Power Lift Seat............................................. 2-9
Power Lumbar .............................................. 2-5
Power Seats................................................. 2-4
Reclining Seatbacks...................................... 2-6
Split Folding Rear Seat.................................. 2-9
Securing a Child Restraint
Rear Seat Position......................................2-49
Right Front Seat Position..............................2-52
Securing an Add-On Child Restraint in the
Vehicle.......................................................2-39
Securing the Child Within the Child Restraint......2-39
Security
Light..........................................................4-34
Service........................................................... 6-3
Accessories and Modifications......................... 6-3
Adding Equipment to the Outside of the
Vehicle..................................................... 6-5
Doing Your Own Work................................... 6-4
Engine Soon Lamp......................................4-31
Parts Identification Label...............................6-81
Publications Ordering Information...................8-15
Scheduling Appointments................................ 8-9
Service Bulletins.............................................8-16
Service Manuals.............................................8-15
Services Not Included in Roadside Assistance...... 8-8
Services Provided............................................. 8-8Services Specific to Canadian Purchased
Vehicles....................................................... 8-8
Servicing Your Airbag-Equipped Vehicle..............2-71
Setting the Clock....................................1-18, 4-52
Setting the Tone (Bass/Midrange/Treble).............4-56
Sheet Metal Damage.......................................6-80
Shifting
Out of Park................................................3-32
Shifting Into Park............................................3-30
Shoulder Belt Height Adjuster...........................2-26
Signals, Turn and Lane-Change.......................... 4-4
Skidding........................................................5-12
Specifications and Capacities............................6-92
Speedometer..................................................4-23
Split Folding Rear Seat..................................... 2-9
Start Vehicle, Remote....................................... 3-7
Starter Switch Check........................................ 7-8
Starting the Engine.........................................3-22
Starting the Vehicle........................................... 1-5
Steering........................................................5-10
Steering in Emergencies..................................5-10
Steering Tips..................................................5-10
Steering Wheel Controls, Audio.........................4-80
Steering Wheel, Tilt and Telescopic..................... 4-3
Storage Areas
Center Console...........................................3-37
Convenience Net.........................................3-37
Cupholders.................................................3-36
Glove Box..................................................3-36
13
ProCarManuals.com