parking brake SATURN ION 2004 Owner's Manual

Automatic Transaxle Shift Lock Control
System Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the vehicle
moves, you or others could be injured.
1. Before you start, be sure you have enough room
around the vehicle. It should be parked on a level
surface.
2. Firmly apply the parking brake. SeeParking Brake
on page 2-30if necessary.
Be ready to apply the regular brake immediately if
the vehicle begins to move.
3. With the engine off, turn the key to the RUN
position, but do not start the engine. Without
applying the regular brake, try to move the shift
lever out of PARK (P) with normal effort. If the shift
lever moves out of PARK (P), contact your
Saturn retailer for service.
Ignition Transaxle Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to OFF in each shift lever position.
With an automatic transaxle, the key should turn to
OFF only when the shift lever is in PARK (P). The
key should come out only in OFF.
With a manual transaxle, the key should come out
only in OFF.
Contact your Saturn retailer if service is required.
6-12
ProCarManuals.com

Parking Brake and Automatic Transaxle
Park (P) Mechanism Check
{CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability: With
the engine running and transaxle in NEUTRAL (N),
slowly remove foot pressure from the regular
brake pedal. Do this until the vehicle is held by the
parking brake only.
To check the PARK (P) mechanism’s holding
ability: With the engine running, shift to PARK (P).
Then release the parking brake followed by the
regular brake.
Contact your Saturn retailer if service is required.
Underbody Flushing Service
At least every spring, use plain water to ush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
6-13
ProCarManuals.com

Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
Washer SolventOptikleen
®Washer Solvent.
Parking Brake
Cable GuidesChassis Lubricant (GM Part No.
12377985, in Canada 88901242) or
lubricant meeting requirements of
NLGI #2, Category LB or GC-LB.
Hydraulic
Clutch SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid
(Saturn Part No. 21013073).
Manual
TransaxleDEXRON III Manual Transaxle
Lubricant (Part No. 21019223).
5-Speed
Automatic
TransaxleSaturn T-IV Fluid
(Part No. 22689186).
VTi Variable
TransaxleDEX-CVT Fluid (Part No. 22688912).
VTi Variable
Transaxle
AdditiveDEX-CVT Fluid Additive
(Part No. 22697447).
Usage Fluid/Lubricant
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor
and Release
PawlLubriplate Lubricant Aerosol
(Saturn Part No. 21038869 or
GM Part No. U.S. 12346293,
in Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood, Trunk
and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
Sunroof TrackLubriplate Lubricant Aerosol
(Saturn Part No. 21038869 or
GM Part No. U.S. 12346293,
in Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Weatherstrip
ConditioningDielectric Silicone Grease
(GM Part No. U.S. 12345579,
in Canada 992887).
6-15
ProCarManuals.com

Automatic Headlamp System............................3-16
Automatic Transaxle........................................2-20
Fluid..........................................................5-24
Operation...................................................2-23
B
Backing Up....................................................4-43
Battery..........................................................5-41
Battery Replacement......................................... 2-8
Battery Run-Down Protection............................3-18
Battery Warning Light......................................3-31
Before Leaving on a Long Trip.........................4-22
Brake
Parking......................................................2-30
System Warning Light..................................3-32
Brake Adjustment............................................5-40
Brake Fluid....................................................5-38
Brake Pedal Travel.........................................5-40
Brake Wear...................................................5-40
Brakes..........................................................5-38
Braking........................................................... 4-6
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-18
Bulb Replacement...........................................5-48
Center High-Mounted Stoplamp (CHMSL)........5-55
Fog Lamps.................................................5-53Bulb Replacement (cont.)
Front Turn Signal and Parking Lamps.............5-53
Front Turn Signal Lamps..............................5-51
Halogen Bulbs............................................5-48
Headlamp Aiming........................................5-47
Headlamps.........................................5-48, 5-50
Replacement Bulbs......................................5-56
Sidemarker Lamps.......................................5-54
Taillamps, Stoplamps and Back-Up Lamps........5-55
Buying New Tires...........................................5-70
C
California Fuel.................................................. 5-6
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Capacities and Specications..........................5-102
Carbon Monoxide...................4-26, 4-39, 2-12, 2-34
Care of
Safety Belts................................................5-89
Your CD Player...........................................3-71
Your CDs ...................................................3-71
Cassette Tape Player Service...........................6-10
CD Messages........................................3-54, 3-67
Center Console Storage Area...........................2-44
Center High-Mounted Stoplamp (CHMSL)...........5-55
Chains, Tires..................................................5-74
2
ProCarManuals.com

N
New Vehicle Break-In......................................2-18
Normal Maintenance Replacement Parts............6-16
O
Odometer......................................................3-29
Off-Road Recovery..........................................4-12
Oil
Engine.......................................................5-15
Pressure Light.............................................3-39
Older Children, Restraints................................1-29
Online Owner Center........................................ 7-4
OnStar
®Personal Calling.................................2-44
OnStar®Services............................................2-43
OnStar®System.............................................2-43
OnStar®Virtual Advisor....................................2-44
Operation..............................................3-20, 3-22
Other Warning Devices...................................... 3-7
Outlet Adjustment............................................3-24
Outside
Convex Mirror.............................................2-42
Power Mirrors.............................................2-42
Remote Control Mirror..................................2-42Owner Checks and Services.............................. 6-9
Owner Publications.........................................7-10
Owners, Canadian............................................... ii
P
Park (P)
Shifting Into................................................2-31
Shifting Out of............................................2-33
Parking
Brake........................................................2-30
Over Things That Burn.................................2-34
Parking on Hills..............................................4-45
Parking Your Vehicle.......................................2-33
Passenger Compartment Air Filter.....................3-25
Passenger Visor Webbing Clip (Coupe)..............2-16
Passing.................................................4-12, 4-43
Passlock
®......................................................2-17
Playing a CD.................................................3-52
Playing the Radio...........................3-47, 3-50, 3-55
Playing the Single CD Player...........................3-60
Playing the Six-Disc CD Player.........................3-62
Power
Accessory Outlets........................................3-18
Door Locks.................................................2-10
Electrical System.........................................5-95
10
ProCarManuals.com