steering SATURN L-SERIES 2004 Owner's Guide

If a Tire Goes Flat
It’s unusual for a tire to “blowout” while you’re driving,
especially if you maintain your tires properly. If air goes
out of a tire, it’s much more likely to leak out slowly.
But if you should ever have a “blowout,” here are a few
tips about what to expect and what to do:
If a front tire fails, the at tire will create a drag that
pulls the vehicle toward that side. Take your foot off the
accelerator pedal and grip the steering wheel rmly.
Steer to maintain lane position, and then gently brake to
a stop well out of the traffic lane.
A rear blowout, particularly on a curve, acts much like a
skid and may require the same correction you’d use
in a skid. In any rear blowout, remove your foot from the
accelerator pedal. Get the vehicle under control by
steering the way you want the vehicle to go. It may be
very bumpy and noisy, but you can still steer. Gently
brake to a stop, well off the road if possible.{CAUTION:
Lifting a vehicle and getting under it to do
maintenance or repairs is dangerous without
the appropriate safety equipment and training.
The jack provided with your vehicle is
designed only for changing a at tire. If it is
used for anything else, you or others could be
badly injured or killed if the vehicle slips off
the jack. Use the jack provided with your
vehicle only for changing a at tire.
If a tire goes at, the next part shows how to use your
jacking equipment to change a at tire safely.
5-69
ProCarManuals.com

Scheduled Maintenance
Service MaintenanceIMaintenanceII
Change engine oil and lter. Reset oil life system. SeeEngine Oil on
page 5-16.An Emission Control Service.••
Visually check for any leaks or damage.See footnote (j).••
Inspect engine air cleaner lter. If necessary, replace lter. SeeEngine Air
Cleaner/Filter on page 5-20.An Emission Control Service. See footnote †.••
Rotate tires and check ination pressures and wear. SeeTires on page 5-54.••
Inspect brake system.See footnote (a).••
Check engine coolant and windshield washer uid levels and add uid as
needed.••
Perform any needed additional services. See “Additional Required Services” in
this section.••
Inspect suspension and steering components.See footnote (b).•
Inspect engine cooling system.See footnote (c).•
Inspect wiper blades.See footnote (d).•
Inspect restraint system components.See footnote (e).•
Lubricate body components.See footnote (f).•
Replace passenger compartment air lter.See footnote (k).•
Inspect throttle system.See footnote (g).•
6-5
ProCarManuals.com

Additional Required Services (cont’d)
Service and Miles (Kilometers)25,000
(41 500)50,000
(83 000)75,000
(125 000)100,000
(166 000)125,000
(207 500)150,000
(240 000)
Engine cooling system service (or
every 5 years, whichever occurs
rst).An Emission Control Service.
See footnote (i).•
3.0L V6 engine only: Replace
timing belt.An Emission Control
Service.•
Inspect engine accessory drive belt.
An Emission Control Service.••••••
Maintenance Footnotes
†The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.(a)Visually inspect brake lines and hoses for proper
hook-up, binding, leaks, cracks, chang, etc. Inspect
disc brake pads for wear and rotors for surface
condition. Inspect other brake parts, including calipers,
parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose or missing parts or
signs of wear. Inspect power steering lines and
hoses for proper hook-up, binding, leaks, cracks,
chang, etc.
6-7
ProCarManuals.com

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number or specication may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM Standard
GM6094M and displays the
American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on page 5-16.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
®Coolant. SeeEngine
Coolant on page 5-23.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
Washer SolventOptikleen
®Washer Solvent.
Parking Brake
Cable GuidesChassis Lubricant (GM Part No.
12377985, in Canada 88901242) or
lubricant meeting requirements of
NLGI #2, Category LB or GC-LB.
Usage Fluid/Lubricant
Power Steering
SystemPower Steering Fluid (Saturn Part
No. 21007583 or GM Part No. U.S.
89021184, in Canada 89021186).
Automatic
TransaxleDEXRON
®-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor
and Release
PawlLubriplate Lubricant Aerosol (Saturn
Part No. 21038869 or GM Part No.
U.S. 12346293, in Canada 992723)
or lubricant meeting requirements of
NLGI #2, Category LB or GC-LB.
Hood, Trunk
and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Sunroof TrackLubriplate Lubricant Aerosol (Saturn
Part No. 21038869 or GM Part No.
U.S. 12346293, in Canada 992723)
or lubricant meeting requirements of
NLGI #2, Category LB or GC-LB.
Weatherstrip
ConditioningDielectric Silicone Grease (GM Part
No. U.S. 12345579, in Canada
992887).
6-12
ProCarManuals.com

E
Electrical System
Add-On Equipment......................................5-91
Fuses and Circuit Breakers...........................5-92
Power Windows and Other Power Options......5-92
Windshield Wiper Fuses...............................5-91
Emergency Trunk Release Handle (Sedan).........2-15
Emissions Inspection and Maintenance
Programs...................................................3-36
Engine
Air Cleaner/Filter.........................................5-20
Battery.......................................................5-39
Change Engine Oil Light...............................3-38
Check and Service Engine Soon Light............3-34
Coolant......................................................5-23
Coolant Heater............................................2-22
Coolant Temperature Gage...........................3-33
Coolant Temperature Warning Light................3-32
Drive Belt Routing.......................................6-14
Engine Compartment Overview......................5-12
Exhaust.....................................................2-31
Oil .............................................................5-16
Overheating................................................5-26
Reduced Power Light...................................3-38
Starting......................................................2-21
Engine Compartment Fuse Block......................5-95
Engine Cooling When Trailer Towing..................4-46
Engine Oil Additives........................................5-18
Entry Lighting.................................................3-15Event Data Recorders (EDR)............................. 7-8
Express-Down Window....................................2-17
Extender, Safety Belt.......................................1-35
Exterior Lamps...............................................3-13
F
Filter
Engine Air Cleaner......................................5-20
Finding a Station............................3-42, 3-45, 3-50
Finish Care....................................................5-86
Finish Damage...............................................5-88
Fixed Mast Antenna........................................3-73
Flash-to-Pass................................................... 3-7
Flat Tire........................................................5-69
Flat Tire, Changing.........................................5-70
Floor Console Fuse Blocks...............................5-92
Fluid
Automatic Transaxle.....................................5-23
Power Steering...........................................5-34
Windshield Washer......................................5-35
FM ...............................................................3-71
Fog Lamps....................................................3-14
Folding Rear Seat............................................ 1-8
Following Distance..........................................4-44
Fuel............................................................... 5-5
Additives...................................................... 5-7
California Fuel.............................................. 5-6
5
ProCarManuals.com

Fuel (cont.)
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-8
Fuels in Foreign Countries.............................. 5-7
Gage.........................................................3-40
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-6
Low Warning Light.......................................3-40
Fuses
Fuses and Circuit Breakers...........................5-92
Windshield Wiper.........................................5-91
G
Gage
Engine Coolant Temperature.........................3-33
Fuel..........................................................3-40
Speedometer..............................................3-27
Tachometer.................................................3-27
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-6
Glove Box.....................................................2-41
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hazard Warning Flashers................................... 3-4
Head Restraints............................................... 1-7
Headlamp High/Low-Beam Changer.................... 3-7
Headlamps..............................................3-7, 3-13
Bulb Replacement.......................................5-46
Halogen Bulbs............................................5-46
Headlamps, Front Turn Signal, Sidemarker,
and Parking Lamps..................................5-47
Headphones...................................................3-59
Heated Seats................................................... 1-5
Height Adjuster, Driver Seat............................... 1-3
Highway Hypnosis...........................................4-23
Hill and Mountain Roads..................................4-24
Hitches..........................................................4-43
Hood
Checking Things Under................................5-10
Release.....................................................5-10
Horn............................................................... 3-5
How to Add Coolant to the Coolant
Surge Tank.................................................5-31
How to Check................................................5-62
How to Check Power Steering Fluid..................5-34
How to Inspect the Engine Air Cleaner/Filter.......5-20
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-16
Hydroplaning..................................................4-19
6
ProCarManuals.com

Playing the Radio...........................3-42, 3-45, 3-50
Playing the Single CD Player...........................3-54
Playing the Six–Disc CD Player........................3-56
Power............................................................. 1-4
Accessory Outlets........................................3-16
Door Locks.................................................2-10
Electrical System.........................................5-92
Reduced Engine Light..................................3-38
Steering Fluid.............................................5-34
Windows....................................................2-17
Power Steering...............................................4-10
Programmable Automatic Door Locks.................2-11
Q
Questions and Answers About Safety Belts.........1-15
R
Radios..........................................................3-41
AM-FM Radio.............................................3-42
Care of Your Cassette Tape Player................3-72
Care of Your CD and DVD Player..................3-73
Care of Your CDs and DVDs........................3-73
Radio with Cassette and CD.........................3-50
Radio with CD............................................3-45
Setting the Time..........................................3-41
Theft-Deterrent............................................3-69
Understanding Reception..............................3-71Rear Door Security Locks................................2-11
Rear Safety Belt Comfort Guides......................1-33
Rear Seat Entertainment System.......................3-59
Rear Seat Outside Passenger
Positions (Wagon).......................................1-28
Rear Seat Passenger Positions (Sedan).............1-25
Rear Seat Passengers, Safety Belts..................1-25
Rear Window Defogger............................3-20, 3-23
Rear Window Wiper/Washer (Wagon).................. 3-9
Rearview Mirror, Automatic Dimming with
Compass and Temperature Display................2-36
Rearview Mirror, Automatic Dimming with OnStar
®,
Compass and Temperature Display..................2-34
Rearview Mirror with OnStar
®...........................2-33
Rearview Mirrors.............................................2-33
Reclining Seatbacks.......................................... 1-5
Recommended Fluids and Lubricants.................6-12
Recreational Vehicle Towing.............................4-32
Reduced Engine Power Light............................3-38
Remote Control..............................................3-64
Remote Keyless Entry System............................ 2-4
Remote Keyless Entry System, Operation............ 2-5
Removing the Cargo Cover..............................2-44
Removing the Flat Tire and Installing the
Spare Tire..................................................5-74
Removing the Spare Tire and Tools (Sedan).......5-71
Removing the Spare Tire and Tools (Wagon)......5-72
Removing the Wheel.......................................5-74
Replacement Bulbs.........................................5-52
Replacing Brake System Parts..........................5-39
10
ProCarManuals.com

Service........................................................... 5-3
Adding Equipment to the Outside of Your
Vehicle..................................................... 5-5
Doing Your Own Work................................... 5-4
Engine Soon Light.......................................3-34
Publications Ordering Information...................7-10
Vehicle Soon Light.......................................3-39
Service Bulletins.............................................7-11
Service Engine Soon Light...............................3-34
Service Manuals.............................................7-10
Setting Preset Stations....................3-43, 3-46, 3-51
Setting the Time.............................................3-41
Setting the Tone (Bass/Treble)..........3-44, 3-47, 3-52
Sheet Metal Damage.......................................5-87
Shift Lock Release..........................................2-26
Shifting Into Park (P).......................................2-28
Shifting Out of Park (P)...................................2-30
Shoulder Belt Height Adjuster...........................1-19
Skidding........................................................4-14
Some Other Rainy Weather Tips.......................4-20
Special Fabric Cleaning Problems.....................5-83
Specications, Capacities.................................5-98
Speedometer..................................................3-27
Split Folding Rear Seat..................................... 1-8
Starting Your Engine.......................................2-21
Steering........................................................4-10
Steering in Emergencies..................................4-11
Steering Tips..................................................4-10
Steering Wheel, Tilt Wheel................................. 3-5
Stereo RCA Jacks..........................................3-60Storage Areas
Center Console Storage Area........................2-41
Glove Box..................................................2-41
Load Floor Storage Box...............................2-42
Roof Rack System.......................................2-42
Storing a Flat or Spare Tire and Tools...............5-79
Stuck in Sand, Mud, Ice or Snow......................4-30
Sun Visors.....................................................2-18
Sunroof.........................................................2-45
T
Tachometer....................................................3-27
Taillamps
Turn Signal, Stoplamps and
Back-up Lamps................................5-50, 5-52
TCS Warning Light..........................................3-32
Temperature and Compass Display....................2-34
Temperature Display........................................2-37
Theft-Deterrent, Radio.....................................3-69
Theft-Deterrent System...................................... 2-6
Theft-Deterrent Systems...................................2-18
Passlock
®...................................................2-18
Tilt Wheel........................................................ 3-5
Tire Ination Check........................................... 6-9
Tire Sidewall Labeling......................................5-54
Tire Size.......................................................5-58
Tire Terminology and Denitions........................5-59
Tires.............................................................5-54
12
ProCarManuals.com

Vehicle Storage..............................................5-40
Ventilation Adjustment......................................3-24
Video Screen.................................................3-62
Visor Vanity Mirrors.........................................2-18
Visors...........................................................2-18
W
Wagon..................................................1-10, 1-48
Warning Lights, Gages and Indicators................3-25
Warnings
Hazard Warning Flashers............................... 3-4
Other Warning Devices.................................. 3-5
Safety and Symbols......................................... iii
Vehicle Damage.............................................. iv
Washer Fluid, Low Warning Light......................3-39
Washing Your Vehicle......................................5-85
Weight of the Trailer........................................4-41
Weight of the Trailer Tongue.............................4-42
What Kind of Engine Oil to Use........................5-17
What to Do with Used Oil................................5-20
What to Use..................................5-24, 5-34, 5-35
Wheels
Alignment and Tire Balance..........................5-67
Replacement...............................................5-67When to Add Engine Oil..................................5-16
When to Change Engine Oil (GM Oil
Life System)...............................................5-19
When to Check..............................................5-62
When to Check Power Steering Fluid................5-34
When to Inspect the Engine Air Cleaner/Filter.....5-20
When You Are Ready to Leave After Parking
on a Hill.....................................................4-46
Where to Put the Restraint...............................1-44
Why Safety Belts Work....................................1-12
Window Lock Out...........................................2-18
Windows.......................................................2-16
Manual......................................................2-17
Power........................................................2-17
Windshield Washer........................................... 3-9
Fluid..........................................................5-35
Windshield Wiper
Blade Replacement......................................5-53
Fuses........................................................5-91
Windshield Wiper Lever..................................... 3-8
Winter Driving................................................4-26
Y
Your Vehicle and the Environment....................... 6-2
14
ProCarManuals.com