ECU SATURN L-SERIES 2004 Service Manual

10. Now start the vehicle with the good battery and run
the engine for a while.
11. Press UNLOCK on the RKE transmitter to disarm
your security system (if equipped).
12. Try to start the vehicle that had the dead battery. If
it won’t start after a few tries, it probably needs
service.
Notice:If the jumper cables are removed in the
wrong order, electrical shorting may occur and
damage the vehicle. The repairs would not be
covered by your warranty. Remove the jumper
cables in the correct order, making sure that the
cables do not touch each other or other metal.
A. Heavy, Unpainted Metal Engine Part
B. Good Battery
C. Dead BatteryJumper Cable Removal
5-45
ProCarManuals.com

Headlamps, Front Turn Signal,
Sidemarker, and Parking Lamps
1. Open the hood and secure it with the prop rod.
2. Remove push-pin fasteners from grill assembly.
3. Tilt grill assembly forward and lift it up to remove it
from the body of the vehicle.4. Remove fasteners from headlamp assembly.
5-47
ProCarManuals.com

Windshield Wiper Blade
Replacement
Windshield wiper blades should be inspected at least
twice a year for wear or cracking. See “Windshield
Wipers, Blade Check” underScheduled Maintenance on
page 6-4for more information.
Replacement blades come in different types and are
removed in different ways. For proper type and length,
seeNormal Maintenance Replacement Parts on
page 6-13. Here’s how to remove the wiper blades:
1. Turn on the wipers to the low wipe setting.
2. Turn off the ignition while the wipers are at the
outer positions of the wiper pattern. The blades
are more accessible for removal/replacement while
in this position.
3. Pull the windshield wiper arm away from the
windshield.4. While holding the wiper arm away from the glass,
push the release clip from under the blade
connecting point and pull the old blade assembly
down toward the glass to remove it from the
wiper arm.
5. Push the new wiper blade securely on the wiper
arm until you hear the release clip “click” into
place.
5-53
ProCarManuals.com

1. Place the wheel wrench into the clips on the jack.
2. Install the jack in the left side panel of the trunk
for sedans or the spare tire compartment for
wagons and secure as shown on the jacking
instruction label located in the trunk or cargo area.3. Place the at tire, face down, into the spare tire
compartment. When placing an aluminum at tire
into the spare tire compartment, be very careful
to avoid scraping the wheel face on the hold-down
bolt and other hard surfaces. The hold-down
bolt should pass through the rear most wheel vent
hold. The at tirel will protrude above the trunk
oor in this position.
4. Place the nut onto the hold-down bolt and tighten
down until it is snug.
The compact spare is for temporary use only. Replace
the compact spare tire with a full-size tire as soon
as you can. See the storage instructions label to replace
your compact spare into your trunk or cargo area
separately.
Store the at tire in the compact spare tire compartment
and secure the adapter, extension (aluminum wheel
only) and wing bolt. Store the jack and wheel wrench in
the foam tray. Wagon
5-80
ProCarManuals.com

Roadside Assistance Program
Security While You Travel
For vehicles purchased in the U.S. call 1-800-553-6000
(TTY: 1-800-833-6000).
For vehicles purchased in Canada call 1-800-268-6800.
As the proud owner of a new Saturn vehicle, you are
automatically enrolled in the Saturn Roadside
Assistance Program. This value-added service is
intended to provide you with peace of mind as you drive
in the city or travel the open road. Saturn’s Roadside
Assistance toll-free number is staffed by courteous and
capable Roadside Assistance Representatives who
are available 24 hours a day, 365 days a year.We will provide the following services during the
Bumper-to-Bumper warranty period at no expense
to you:Fuel Delivery:Delivery of enough fuel ($5
maximum) for the customer to get to the nearest
service station.
Lock-out Service (identication required):
Replacement keys or locksmith service will
be covered at no charge if you are unable to gain
entry into your vehicle. Delivery of the replacement
key will be covered within 10 miles.
Emergency Tow:Tow to the nearest Saturn
retailer for warranty service or in the event of
a vehicle-disabling accident. Assistance when the
vehicle is mired in sand, mud or snow.
Flat Tire Change:Installation of a spare tire will be
covered at no charge. (The customer is responsible
for the repair or replacement of the tire if not
covered by a warrantable failure.)
Jump Start:No-start occurrences which require a
battery jump start will be covered at no charge.
Saturn Retailer Locator Service
7-6
ProCarManuals.com

In many instances, mechanical failures are covered
under Saturn’s Bumper-to-Bumper warranty. However,
when other services are utilized, our Roadside
Assistance Representatives will explain any payment
obligations you might incur.
For prompt and efficient assistance when calling, please
provide the following to the Roadside Assistance
Representatives:
Your name, home address, and home telephone
number
Telephone number of your location
Location of the vehicle
Model, year, color, and license plate number
Mileage, Vehicle Identication Number and delivery
date of the vehicle
Description of the problemWhile we hope you never have the occasion to use our
service, it is added security while traveling for you
and your family. Remember we are only a phone call
away. Saturn Roadside Assistance: 1-800-553-6000;
text telephone (TTY) users, call 1-800-833-6000.
Saturn reserves the right to limit services or
reimbursement to an owner or driver when, in Saturn’s
judgment, the claims become excessive in frequency
or type of occurrence.
Roadside Assistance is not part of or included in the
coverage provided by the New Vehicle Limited Warranty.
Saturn reserves the right to make any changes or
discontinue the Roadside Assistance program at any
time without notication.
Canadian Roadside Assistance
Vehicles purchased in Canada have an extensive Saturn
Roadside Assistance program accessible from anywhere
in Canada or the United States. Please refer to the
Warranty and Owner Assistance Information book.
7-7
ProCarManuals.com

Child Restraints
Child Restraint Systems...............................1-42
Infants and Young Children...........................1-38
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-50
Older Children.............................................1-35
Securing a Child Restraint Designed for the
LATCH System........................................1-52
Securing a Child Restraint in a Center Rear
Seat Position...........................................1-56
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-54
Securing a Child Restraint in a Rear Seat
Position..................................................1-52
Securing a Child Restraint in the Right Front
Seat Position...........................................1-58
Top Strap...................................................1-46
Top Strap Anchor Location............................1-47
Where to Put the Restraint...........................1-44
Cigarette Lighter.............................................3-17
Cleaning
Inside of Your Vehicle..................................5-82
Outside of Your Vehicle................................5-85
Underbody Maintenance...............................5-88
Weatherstrips..............................................5-85
Cleaning Aluminum or Chrome-Plated Wheels.....5-87
Cleaning Exterior Lamps/Lenses.......................5-86
Cleaning Fabric/Carpet....................................5-82Cleaning Glass Surfaces..................................5-84
Cleaning Interior Plastic Components.................5-84
Cleaning the DVD Player.................................3-68
Cleaning the Mirror.................................2-36, 2-38
Cleaning the Top of the Instrument Panel...........5-84
Cleaning the Video Screen...............................3-68
Cleaning Tires................................................5-87
Cleaning Vinyl................................................5-84
Cleaning Windshield, Backglass and Wiper
Blades.......................................................5-86
Climate Control System...................................3-17
Air Filter, Passenger Compartment.................3-24
Automatic...................................................3-20
Outlet Adjustment........................................3-24
Compact Spare Tire........................................5-81
Compass Calibration...............................2-35, 2-37
Compass Operation.........................................2-37
Compass Variance..................................2-35, 2-37
Control of a Vehicle.......................................... 4-5
Coolant
Engine Temperature Gage............................3-33
Engine Temperature Warning Light.................3-32
Heater, Engine............................................2-22
Low Warning Light.......................................3-33
Surge Tank Pressure Cap.............................5-26
Cooling System..............................................5-29
Cruise Control................................................3-10
3
ProCarManuals.com

Customer Assistance Information
Customer Assistance for Text Telephone (TTY)
Users....................................................... 7-5
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
Reporting Safety Defects to Saturn................7-10
Reporting Safety Defects to the Canadian
Government............................................7-10
Reporting Safety Defects to the United States
Government.............................................. 7-9
Roadside Assistance Program......................... 7-6
Service Publications Ordering Information........7-10
D
Daytime Running Lamps..................................3-13
Daytime Running Lamps Indicator Light.............3-39
Defensive Driving............................................. 4-2
Defogging and Defrosting.........................3-19, 3-23
Delayed Locking.............................................2-10
Dinghy Towing................................................4-33
Disabling the Theft-Deterrent Feature.................3-71
Doing Your Own Service Work........................... 5-4
Dolly Towing..................................................4-34
Dome Lamp...................................................3-15
Door
Delayed Locking..........................................2-10
Locks.......................................................... 2-9Door (cont.)
Power Door Locks.......................................2-10
Programmable Automatic Door Locks.............2-11
Rear Door Security Locks.............................2-11
Driver
Position, Safety Belt.....................................1-16
Seat Height Adjuster...................................... 1-3
Six-Way Power Seat...................................... 1-4
Driving
At Night.....................................................4-15
City...........................................................4-20
Defensive..................................................... 4-2
Drunken....................................................... 4-2
Freeway.....................................................4-21
Hill and Mountain Roads..............................4-24
In Rain and on Wet Roads...........................4-17
Winter........................................................4-26
Driving on Grades...........................................4-45
Driving on Snow or Ice....................................4-27
Driving Through Deep Standing Water...............4-19
Driving Through Flowing Water.........................4-19
Driving with a Trailer.......................................4-44
DVD
Rear Seat Entertainment System...................3-59
DVD Display Error Messages...........................3-67
DVD Distortion...............................................3-68
DVD Radio....................................................3-62
DVD Radio Error Messages.............................3-68
4
ProCarManuals.com

I
If No Steam Is Coming From Your Engine..........5-28
If Steam Is Coming From Your Engine...............5-27
If the Light Is Flashing.....................................3-35
If the Light Is On Steady.................................3-35
If You Are Caught in a Blizzard.........................4-28
If You Are Stuck in Sand, Mud, Ice or Snow.......4-30
If You Do Decide to Pull a Trailer......................4-41
Ignition Positions.............................................2-20
Infants and Young Children, Restraints...............1-38
Ination - Tire Pressure...................................5-61
Installing the Cargo Shade...............................2-44
Instrument Panel
Cluster.......................................................3-26
Overview..................................................... 3-2
Instrument Panel Brightness.............................3-15
Interior Lamps................................................3-15
J
Jump Starting.................................................5-40
K
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
L
Lamps
Exterior......................................................3-13
Fog Lamps.................................................5-49
Interior.......................................................3-15
Lap Belt........................................................1-32
Lap-Shoulder Belt...........................1-17, 1-26, 1-29
LATCH System
Child Restraints...........................................1-50
Securing a Child Restraint Designed for the
LATCH System........................................1-52
Leaving Your Vehicle.......................................2-12
Leaving Your Vehicle With the
Engine Running..........................................2-29
Liftgate Release (Wagon).................................2-14
Liftgate/Trunk.................................................2-13
Light
Air Bag Readiness.......................................3-28
Anti-Lock Brake System Warning...................3-31
Battery Warning..........................................3-29
Brake System Warning.................................3-30
Change Engine Oil......................................3-38
Daytime Running Lamps Indicator..................3-39
Engine Coolant Temperature Warning.............3-32
Low Coolant Warning...................................3-33
Low Fuel Warning.......................................3-40
Low Washer Fluid Warning...........................3-39
7
ProCarManuals.com

Light (cont.)
Malfunction Indicator....................................3-34
Oil Pressure...............................................3-37
Reduced Engine Power................................3-38
Safety Belt Reminder...................................3-28
Security.....................................................3-38
Service Vehicle Soon...................................3-39
TCS Warning Light......................................3-32
Traction Control System (TCS) Warning..........3-32
Trunk Ajar..................................................3-39
Load Floor Storage Box...................................2-42
Loading Your Vehicle.......................................4-34
Lockout Protection..........................................2-12
Locks
Delayed Locking..........................................2-10
Door........................................................... 2-9
Leaving Your Vehicle....................................2-12
Lockout Protection.......................................2-12
Power Door................................................2-10
Programmable Automatic Door Locks.............2-11
Rear Door Security Locks.............................2-11
Loss of Control...............................................4-14
Low Coolant Warning Light..............................3-33
Low Fuel Warning Light...................................3-40
Low Washer Fluid Warning Light.......................3-39
Lumbar
Manual Controls............................................ 1-4M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-9
At Least Once a Month.................................. 6-9
At Least Once a Year..................................6-10
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-7
Maintenance Record....................................6-15
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-13
Owner Checks and Services........................... 6-9
Recommended Fluids and Lubricants.............6-12
Scheduled Maintenance................................. 6-4
Using Your................................................... 6-2
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-46
Making Turns.................................................4-44
Malfunction Indicator Light................................3-34
Manual Lumbar Controls.................................... 1-4
Manual Operation...........................................3-22
Manual Seats................................................... 1-3
Manual Windows............................................2-17
Map Lamps....................................................3-15
Matching Transmitter(s) to Your Vehicle............... 2-7
8
ProCarManuals.com