belt SATURN L-SERIES 2004 Manual PDF

Engine Drive Belt Routing
2.2L Four Cylinder (L61) Engine3.0L V6 (L81) Engine
6-14
ProCarManuals.com

Vehicle Data Collection and Event
Data Recorders
Your vehicle, like other modern motor vehicles, has a
number of sophisticated computer systems that monitor
and control several aspects of the vehicle’s
performance. Your vehicle uses on-board vehicle
computers to monitor emission control components to
optimize fuel economy, to monitor conditions for air bag
deployment and, if so equipped, to provide anti-lock
braking and to help the driver control the vehicle
in difficult driving situations. Some information may be
stored during regular operations to facilitate repair
of detected malfunctions; other information is stored only
in a crash or near crash event by computer systems
commonly called event data recorders (EDR).In a crash or near crash event, computer systems, such
as the Air Bag Sensing and Diagnostic Module (SDM)
in your vehicle may record information about the
condition of the vehicle and how it was operated, such
as engine speed, brake applications, throttle position,
vehicle speed, safety belt usage, air bag readiness, air
bag performance data, and the severity of a collision.
This information has been used to improve vehicle crash
performance and may be used to improve crash
performance of future vehicles and driving safety. Unlike
the data recorders on many airplanes, these on-board
systems do not record sounds, such as conversation of
vehicle occupants.
To read this information, special equipment is needed
and access to the vehicle or the SDM is required.
GM will not access information about a crash event or
share it with others other than
with the consent of the vehicle owner or, if the
vehicle is leased, with the consent of the lessee,
in response to an official request of police or similar
government office,
as part of GM’s defense of litigation through the
discovery process, or
as required by law.
7-8
ProCarManuals.com

A
Accessory Power Outlets.................................3-16
Activating the Theft-Deterrent Feature................3-69
Adding Windshield Washer Fluid.......................5-35
Additives, Fuel................................................. 5-7
Add-On Electrical Equipment............................5-91
Adjusting the Speakers
(Balance/Fade)............................3-44, 3-47, 3-52
Air Bag
Readiness Light..........................................3-28
Air Bag Systems.............................................1-62
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-72
How Does an Air Bag Restrain?....................1-68
Servicing Your Air Bag-Equipped Vehicle.........1-71
What Makes an Air Bag Inate?....................1-68
What Will You See After an Air Bag Inates?......1-69
When Should an Air Bag Inate?...................1-67
Where Are the Air Bags?..............................1-64
Air Cleaner/Filter, Engine.................................5-20
Airbag Sensing and Diagnostic Module (SDM)...... 7-8
AM ...............................................................3-71
AM-FM Radio.................................................3-42
Antenna, Fixed Mast.......................................3-73
Anti-lock Brake System (ABS)............................ 4-7
Anti-Lock Brake, System Warning Light..............3-31
Appearance Care............................................5-82
Care of Safety Belts....................................5-85
Chemical Paint Spotting...............................5-88Appearance Care (cont.)
Cleaning the Inside of Your Vehicle................5-82
Cleaning the Outside of Your Vehicle..............5-85
Finish Damage............................................5-88
Sheet Metal Damage...................................5-87
Underbody Maintenance...............................5-88
Vehicle Care/Appearance Materials................5-89
Weatherstrips..............................................5-85
Ashtrays........................................................3-17
Assist Handles...............................................2-41
Audio Output..................................................3-61
Audio System(s).............................................3-41
AM-FM Radio.............................................3-42
Care of Your Cassette Tape Player................3-72
Care of Your CD and DVD Player..................3-73
Care of Your CDs and DVDs........................3-73
Fixed Mast Antenna.....................................3-73
Radio with Cassette and CD.........................3-50
Radio with CD............................................3-45
Setting the Time..........................................3-41
Theft-Deterrent Feature................................3-69
Understanding Radio Reception.....................3-71
Automatic Climate Control System.....................3-20
Automatic Dimming Mirror Operation..........2-35, 2-37
Automatic Headlamp System............................3-14
Automatic Operation........................................3-21
Automatic Transaxle........................................2-21
Fluid..........................................................5-23
Operation...................................................2-23
1
ProCarManuals.com

B
Backing Up....................................................4-44
Battery..........................................................5-39
Battery Replacement......................................... 2-7
Battery Run-Down Protection............................3-16
Battery Warning Light......................................3-29
Before Leaving on a Long Trip.........................4-23
Before You Drive............................................3-59
Brake
Parking......................................................2-27
System Warning Light..................................3-30
Brake Fluid....................................................5-36
Brake Wear...................................................5-38
Brakes..........................................................5-36
Braking........................................................... 4-6
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-19
Bulb Replacement...........................................5-46
Center High-Mounted
Stoplamp (CHMSL)..........................5-49, 5-50
Fog Lamps.................................................5-49
Halogen Bulbs............................................5-46
Headlamps, Front Turn Signal, Sidemarker,
and Parking Lamps..................................5-47
Replacement Bulbs......................................5-52
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps................................5-50, 5-52
Buying New Tires...........................................5-64
C
California Fuel.................................................. 5-6
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Capacities and Specications............................5-98
Carbon Monoxide...................4-26, 4-40, 2-13, 2-31
Care of
Safety Belts................................................5-85
Your Cassette Tape Player............................3-72
Your CD and DVD Player.............................3-73
Your CDs and DVDs....................................3-73
Cargo Cover..................................................2-43
Cassette Tape Messages.................................3-54
Cassette Tape Player Service............................. 6-9
CD Adapter Kits.............................................3-54
CD Messages........................................3-49, 3-58
Center Console Storage Area...........................2-41
Center High-Mounted Stoplamp (CHMSL)....5-49, 5-50
Center Rear Passenger Position (Wagon)...........1-31
Chains, Tires..................................................5-68
Check
Engine Light...............................................3-34
Checking Coolant............................................5-25
Checking Engine Oil........................................5-16
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-88
2
ProCarManuals.com

Customer Assistance Information
Customer Assistance for Text Telephone (TTY)
Users....................................................... 7-5
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
Reporting Safety Defects to Saturn................7-10
Reporting Safety Defects to the Canadian
Government............................................7-10
Reporting Safety Defects to the United States
Government.............................................. 7-9
Roadside Assistance Program......................... 7-6
Service Publications Ordering Information........7-10
D
Daytime Running Lamps..................................3-13
Daytime Running Lamps Indicator Light.............3-39
Defensive Driving............................................. 4-2
Defogging and Defrosting.........................3-19, 3-23
Delayed Locking.............................................2-10
Dinghy Towing................................................4-33
Disabling the Theft-Deterrent Feature.................3-71
Doing Your Own Service Work........................... 5-4
Dolly Towing..................................................4-34
Dome Lamp...................................................3-15
Door
Delayed Locking..........................................2-10
Locks.......................................................... 2-9Door (cont.)
Power Door Locks.......................................2-10
Programmable Automatic Door Locks.............2-11
Rear Door Security Locks.............................2-11
Driver
Position, Safety Belt.....................................1-16
Seat Height Adjuster...................................... 1-3
Six-Way Power Seat...................................... 1-4
Driving
At Night.....................................................4-15
City...........................................................4-20
Defensive..................................................... 4-2
Drunken....................................................... 4-2
Freeway.....................................................4-21
Hill and Mountain Roads..............................4-24
In Rain and on Wet Roads...........................4-17
Winter........................................................4-26
Driving on Grades...........................................4-45
Driving on Snow or Ice....................................4-27
Driving Through Deep Standing Water...............4-19
Driving Through Flowing Water.........................4-19
Driving with a Trailer.......................................4-44
DVD
Rear Seat Entertainment System...................3-59
DVD Display Error Messages...........................3-67
DVD Distortion...............................................3-68
DVD Radio....................................................3-62
DVD Radio Error Messages.............................3-68
4
ProCarManuals.com

E
Electrical System
Add-On Equipment......................................5-91
Fuses and Circuit Breakers...........................5-92
Power Windows and Other Power Options......5-92
Windshield Wiper Fuses...............................5-91
Emergency Trunk Release Handle (Sedan).........2-15
Emissions Inspection and Maintenance
Programs...................................................3-36
Engine
Air Cleaner/Filter.........................................5-20
Battery.......................................................5-39
Change Engine Oil Light...............................3-38
Check and Service Engine Soon Light............3-34
Coolant......................................................5-23
Coolant Heater............................................2-22
Coolant Temperature Gage...........................3-33
Coolant Temperature Warning Light................3-32
Drive Belt Routing.......................................6-14
Engine Compartment Overview......................5-12
Exhaust.....................................................2-31
Oil .............................................................5-16
Overheating................................................5-26
Reduced Power Light...................................3-38
Starting......................................................2-21
Engine Compartment Fuse Block......................5-95
Engine Cooling When Trailer Towing..................4-46
Engine Oil Additives........................................5-18
Entry Lighting.................................................3-15Event Data Recorders (EDR)............................. 7-8
Express-Down Window....................................2-17
Extender, Safety Belt.......................................1-35
Exterior Lamps...............................................3-13
F
Filter
Engine Air Cleaner......................................5-20
Finding a Station............................3-42, 3-45, 3-50
Finish Care....................................................5-86
Finish Damage...............................................5-88
Fixed Mast Antenna........................................3-73
Flash-to-Pass................................................... 3-7
Flat Tire........................................................5-69
Flat Tire, Changing.........................................5-70
Floor Console Fuse Blocks...............................5-92
Fluid
Automatic Transaxle.....................................5-23
Power Steering...........................................5-34
Windshield Washer......................................5-35
FM ...............................................................3-71
Fog Lamps....................................................3-14
Folding Rear Seat............................................ 1-8
Following Distance..........................................4-44
Fuel............................................................... 5-5
Additives...................................................... 5-7
California Fuel.............................................. 5-6
5
ProCarManuals.com

Fuel (cont.)
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-8
Fuels in Foreign Countries.............................. 5-7
Gage.........................................................3-40
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-6
Low Warning Light.......................................3-40
Fuses
Fuses and Circuit Breakers...........................5-92
Windshield Wiper.........................................5-91
G
Gage
Engine Coolant Temperature.........................3-33
Fuel..........................................................3-40
Speedometer..............................................3-27
Tachometer.................................................3-27
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-6
Glove Box.....................................................2-41
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hazard Warning Flashers................................... 3-4
Head Restraints............................................... 1-7
Headlamp High/Low-Beam Changer.................... 3-7
Headlamps..............................................3-7, 3-13
Bulb Replacement.......................................5-46
Halogen Bulbs............................................5-46
Headlamps, Front Turn Signal, Sidemarker,
and Parking Lamps..................................5-47
Headphones...................................................3-59
Heated Seats................................................... 1-5
Height Adjuster, Driver Seat............................... 1-3
Highway Hypnosis...........................................4-23
Hill and Mountain Roads..................................4-24
Hitches..........................................................4-43
Hood
Checking Things Under................................5-10
Release.....................................................5-10
Horn............................................................... 3-5
How to Add Coolant to the Coolant
Surge Tank.................................................5-31
How to Check................................................5-62
How to Check Power Steering Fluid..................5-34
How to Inspect the Engine Air Cleaner/Filter.......5-20
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-16
Hydroplaning..................................................4-19
6
ProCarManuals.com

I
If No Steam Is Coming From Your Engine..........5-28
If Steam Is Coming From Your Engine...............5-27
If the Light Is Flashing.....................................3-35
If the Light Is On Steady.................................3-35
If You Are Caught in a Blizzard.........................4-28
If You Are Stuck in Sand, Mud, Ice or Snow.......4-30
If You Do Decide to Pull a Trailer......................4-41
Ignition Positions.............................................2-20
Infants and Young Children, Restraints...............1-38
Ination - Tire Pressure...................................5-61
Installing the Cargo Shade...............................2-44
Instrument Panel
Cluster.......................................................3-26
Overview..................................................... 3-2
Instrument Panel Brightness.............................3-15
Interior Lamps................................................3-15
J
Jump Starting.................................................5-40
K
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
L
Lamps
Exterior......................................................3-13
Fog Lamps.................................................5-49
Interior.......................................................3-15
Lap Belt........................................................1-32
Lap-Shoulder Belt...........................1-17, 1-26, 1-29
LATCH System
Child Restraints...........................................1-50
Securing a Child Restraint Designed for the
LATCH System........................................1-52
Leaving Your Vehicle.......................................2-12
Leaving Your Vehicle With the
Engine Running..........................................2-29
Liftgate Release (Wagon).................................2-14
Liftgate/Trunk.................................................2-13
Light
Air Bag Readiness.......................................3-28
Anti-Lock Brake System Warning...................3-31
Battery Warning..........................................3-29
Brake System Warning.................................3-30
Change Engine Oil......................................3-38
Daytime Running Lamps Indicator..................3-39
Engine Coolant Temperature Warning.............3-32
Low Coolant Warning...................................3-33
Low Fuel Warning.......................................3-40
Low Washer Fluid Warning...........................3-39
7
ProCarManuals.com

Light (cont.)
Malfunction Indicator....................................3-34
Oil Pressure...............................................3-37
Reduced Engine Power................................3-38
Safety Belt Reminder...................................3-28
Security.....................................................3-38
Service Vehicle Soon...................................3-39
TCS Warning Light......................................3-32
Traction Control System (TCS) Warning..........3-32
Trunk Ajar..................................................3-39
Load Floor Storage Box...................................2-42
Loading Your Vehicle.......................................4-34
Lockout Protection..........................................2-12
Locks
Delayed Locking..........................................2-10
Door........................................................... 2-9
Leaving Your Vehicle....................................2-12
Lockout Protection.......................................2-12
Power Door................................................2-10
Programmable Automatic Door Locks.............2-11
Rear Door Security Locks.............................2-11
Loss of Control...............................................4-14
Low Coolant Warning Light..............................3-33
Low Fuel Warning Light...................................3-40
Low Washer Fluid Warning Light.......................3-39
Lumbar
Manual Controls............................................ 1-4M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-9
At Least Once a Month.................................. 6-9
At Least Once a Year..................................6-10
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-7
Maintenance Record....................................6-15
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-13
Owner Checks and Services........................... 6-9
Recommended Fluids and Lubricants.............6-12
Scheduled Maintenance................................. 6-4
Using Your................................................... 6-2
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-46
Making Turns.................................................4-44
Malfunction Indicator Light................................3-34
Manual Lumbar Controls.................................... 1-4
Manual Operation...........................................3-22
Manual Seats................................................... 1-3
Manual Windows............................................2-17
Map Lamps....................................................3-15
Matching Transmitter(s) to Your Vehicle............... 2-7
8
ProCarManuals.com

Playing the Radio...........................3-42, 3-45, 3-50
Playing the Single CD Player...........................3-54
Playing the Six–Disc CD Player........................3-56
Power............................................................. 1-4
Accessory Outlets........................................3-16
Door Locks.................................................2-10
Electrical System.........................................5-92
Reduced Engine Light..................................3-38
Steering Fluid.............................................5-34
Windows....................................................2-17
Power Steering...............................................4-10
Programmable Automatic Door Locks.................2-11
Q
Questions and Answers About Safety Belts.........1-15
R
Radios..........................................................3-41
AM-FM Radio.............................................3-42
Care of Your Cassette Tape Player................3-72
Care of Your CD and DVD Player..................3-73
Care of Your CDs and DVDs........................3-73
Radio with Cassette and CD.........................3-50
Radio with CD............................................3-45
Setting the Time..........................................3-41
Theft-Deterrent............................................3-69
Understanding Reception..............................3-71Rear Door Security Locks................................2-11
Rear Safety Belt Comfort Guides......................1-33
Rear Seat Entertainment System.......................3-59
Rear Seat Outside Passenger
Positions (Wagon).......................................1-28
Rear Seat Passenger Positions (Sedan).............1-25
Rear Seat Passengers, Safety Belts..................1-25
Rear Window Defogger............................3-20, 3-23
Rear Window Wiper/Washer (Wagon).................. 3-9
Rearview Mirror, Automatic Dimming with
Compass and Temperature Display................2-36
Rearview Mirror, Automatic Dimming with OnStar
®,
Compass and Temperature Display..................2-34
Rearview Mirror with OnStar
®...........................2-33
Rearview Mirrors.............................................2-33
Reclining Seatbacks.......................................... 1-5
Recommended Fluids and Lubricants.................6-12
Recreational Vehicle Towing.............................4-32
Reduced Engine Power Light............................3-38
Remote Control..............................................3-64
Remote Keyless Entry System............................ 2-4
Remote Keyless Entry System, Operation............ 2-5
Removing the Cargo Cover..............................2-44
Removing the Flat Tire and Installing the
Spare Tire..................................................5-74
Removing the Spare Tire and Tools (Sedan).......5-71
Removing the Spare Tire and Tools (Wagon)......5-72
Removing the Wheel.......................................5-74
Replacement Bulbs.........................................5-52
Replacing Brake System Parts..........................5-39
10
ProCarManuals.com