belt SATURN OUTLOOK 2007 Manual PDF

Instrument Panel, Vinyl, and Other
Plastic Surfaces
A soft cloth dampened with water may be used to
remove dust. If a more thorough cleaning is
necessary, a clean soft cloth dampened with a
mild soap solution can be used to gently remove
dust and dirt. Never use spot lifters or removers
on plastic surfaces. Many commercial cleaners and
coatings that are sold to preserve and protect
soft plastic surfaces may permanently change the
appearance and feel of your interior and are
not recommended. Do not use silicone or
wax-based products, or those containing organic
solvents to clean your vehicle’s interior because
they can alter the appearance by increasing
the gloss in a non-uniform manner.
Some commercial products may increase gloss on
your instrument panel. The increase in gloss
may cause annoying reections in the windshield
and even make it difficult to see through the
windshield under certain conditions.
Care of Safety Belts
Keep belts clean and dry.
{CAUTION:
Do not bleach or dye safety belts. If you
do, it may severely weaken them. In a
crash, they might not be able to provide
adequate protection. Clean safety belts
only with mild soap and lukewarm water.
Weatherstrips
Silicone grease on weatherstrips will make them
last longer, seal better, and not stick or squeak.
Apply silicone grease with a clean cloth. During
very cold, damp weather frequent application may
be required. SeeRecommended Fluids and
Lubricants on page 497.
467
ProCarManuals.com

Maintenance Schedule................................ 486
Introduction............................................... 486
Maintenance Requirements........................ 486
Your Vehicle and the Environment............ 486
Using the Maintenance Schedule............... 486
Scheduled Maintenance............................. 488
Additional Required Services..................... 491
Maintenance Footnotes.............................. 492Owner Checks and Services..................... 493
At Each Fuel Fill....................................... 494
At Least Once a Month............................. 494
At Least Once a Year............................... 495
Recommended Fluids and Lubricants........ 497
Normal Maintenance Replacement Parts..... 498
Engine Drive Belt Routing......................... 499
Maintenance Record.................................. 500
Section 6 Maintenance Schedule
485
ProCarManuals.com

Additional Required Services
The following services should be performed at the rst maintenance service (IorII) after the indicated
miles (kilometers) shown for each item.
Additional Required Services
Service and Miles (Kilometers)25,000
(40 000)50,000
(80 000)75,000
(120 000)100,000
(160 000)125,000
(200 000)150,000
(240 000)
Inspect fuel system for damage or leaks.• •••••
Inspect exhaust system for loose or
damaged components.• •••••
Replace engine air cleaner lter. See
Engine Air Cleaner/Filter on page 392.•••
Change automatic transmission uid
(severe service).See footnote (h).•••
Change automatic transmission uid
(normal service).•
Replace spark plugs and inspect spark
plug wires.An Emission Control Service.•
Engine cooling system service (or every
ve years, whichever occurs rst).
An Emission Control Service.
See footnote (i).•
Inspect engine accessory drive belt.
An Emission Control Service.
See footnote (k).•
491
ProCarManuals.com

Maintenance Footnotes
(a)Visually inspect brake lines and hoses for
proper hook-up, binding, leaks, cracks, chafing,
etc. Inspect disc brake pads for wear and rotors
for surface condition. Inspect other brake
parts, including calipers, parking brake, etc.
Check parking brake adjustment.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose, or missing
parts or signs of wear. Inspect power steering lines
and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
(c)Visually inspect hoses and have them replaced
if they are cracked, swollen, or deteriorated.
Inspect all pipes, fittings and clamps; replace
with genuine parts as needed. To help ensure
proper operation, a pressure test of the cooling
system and pressure cap and cleaning the outside
of the radiator and air conditioning condenser is
recommended at least once a year.
(d)Inspect wiper blades for wear, cracking,
or contamination. Clean the windshield and wiper
blades, if contaminated. Replace wiper bladesthat are worn or damaged. See Windshield Wiper
Blade Replacement on page 424 and Windshield,
Backglass, and Wiper Blades on page 469 for
more information.
(e)Make sure the safety belt reminder light and
all belts, buckles, latch plates, retractors, and
anchorages are working properly. Look for
any other loose or damaged safety belt system
parts. If you see anything that might keep a safety
belt system from doing its job, have it repaired.
Have any torn or frayed safety belts replaced.
Also look for any opened or broken airbag
coverings, and have them repaired or replaced.
The airbag system does not need regular
maintenance.
(f)Lubricate all key lock cylinders, hood latch
assemblies, secondary latches, pivots, spring
anchor and release pawl, hood and door hinges,
rear folding seats, and liftgate hinges. More
frequent lubrication may be required when
exposed to a corrosive environment. Applying
silicone grease on weatherstrips with a clean cloth
will make them last longer, seal better, and not stick
or squeak.
492
ProCarManuals.com

(g)A fluid loss in any vehicle system could
indicate a problem. Have the system inspected
and repaired and the fluid level checked. Add fluid
if needed.
(h)Change automatic transmission fluid if the
vehicle is mainly driven under one or more
of these conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C)
or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police, or delivery
service.
(i)Drain, flush, and refill cooling system.
This service can be complex; you should have
your dealer/retailer perform this service. See
Engine Coolant on page 396 for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap, and filler neck. Pressure test
the cooling system and pressure cap.(j)Check system for interference or binding and
for damaged or missing parts. Replace parts
as needed. Replace any components that have
high effort or excessive wear. Do not lubricate
accelerator or cruise control cables.
(k)Visually inspect belt for fraying, excessive
cracks, or obvious damage. Replace belt if
necessary.
(l)If you drive regularly under dusty conditions,
inspect the filter at each engine oil change.
Owner Checks and Services
These owner checks and services should be
performed at the intervals specied to help ensure
the safety, dependability, and emission control
performance of your vehicle. Your dealer/retailer
can assist you with these checks and services.
Be sure any necessary repairs are completed at
once. Whenever any uids or lubricants are added
to your vehicle, make sure they are the proper
ones, as shown inRecommended Fluids and
Lubricants on page 497.
493
ProCarManuals.com

Engine Drive Belt Routing
3.6L V6 Engine
499
ProCarManuals.com

Event Data Recorders
This vehicle has an Event Data Recorder (EDR).
The main purpose of an EDR is to record, in
certain crash or near crash-like situations, such as
an air bag deployment or hitting a road obstacle,
data that will assist in understanding how a
vehicle’s systems performed. The EDR is designed
to record data related to vehicle dynamics and
safety systems for a short period of time, typically
30 seconds or less. The EDR in this vehicle is
designed to record such data as:
How various systems in your vehicle were
operating
Whether or not the driver and passenger
safety belts were buckled/fastened
How far, if at all, the driver was depressing
the accelerator and/or brake pedal
How fast the vehicle was traveling
This data can help provide a better understanding
of the circumstances in which crashes and
injuries occur.
Important:EDR data is recorded by your vehicle
only if a non-trivial crash situation occurs; no
data is recorded by the EDR under normal drivingconditions and no personal data (e.g., name,
gender, age, and crash location) is recorded.
However, other parties, such as law enforcement,
could combine the EDR data with the type of
personally identifying data routinely acquired
during a crash investigation.
To read data recorded by an EDR, special
equipment is required, and access to the vehicle
or the EDR is needed. In addition to the vehicle
manufacturer, other parties, such as law
enforcement, that have the special equipment,
can read the information if they have access to
the vehicle or the EDR.
Saturn will not access this data or share it with
others except: with the consent of the vehicle
owner or, if the vehicle is leased, with the consent
of the lessee; in response to an official request
of police or similar government office; as part
of Saturn’s defense of litigation through the
discovery process; or, as required by law.
Data that Saturn collects or receives may
also be used for Saturn research needs or
may be made available to others for research
purposes, where a need is shown and the data
is not tied to a specic vehicle or vehicle owner.
520
ProCarManuals.com

A
Accessories and Modications..................... 377
Adding Equipment to Your
Airbag-Equipped Vehicle............................ 92
Additives, Fuel............................................ 380
Add-On Electrical Equipment....................... 475
Air Cleaner/Filter, Engine............................. 392
Air Conditioning..................................194, 198
Airbag
Passenger Status Indicator....................... 214
Readiness Light....................................... 212
Airbag System............................................... 76
What Will You See After an
Airbag Inates?...................................... 84
When Should an Airbag Inate?................. 82
Where Are the Airbags?............................. 79
Airbag Systems
Adding Equipment to Your
Airbag-Equipped Vehicle......................... 92
How Does an Airbag Restrain?.................. 84
Passenger Sensing System....................... 86
Servicing Your Airbag-Equipped Vehicle....... 91
What Makes an Airbag Inate?.................. 83
All-Wheel Drive........................................... 420
All-Wheel-Drive (AWD) System.................... 332Antilock Brake System (ABS)...................... 327
Antilock Brake, System Warning Light......... 218
Appearance Care
Aluminum or Chrome-Plated Wheels........ 470
Care of Safety Belts................................ 467
Chemical Paint Spotting........................... 472
Cleaning Exterior Lamps/Lenses.............. 468
Cleaning the Inside of Your Vehicle.......... 464
Fabric/Carpet........................................... 465
Finish Care.............................................. 468
Finish Damage......................................... 471
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 467
Leather.................................................... 466
Sheet Metal Damage............................... 471
Tires........................................................ 471
Underbody Maintenance........................... 472
Vehicle Care/Appearance Materials.......... 473
Washing Your Vehicle.............................. 468
Weatherstrips........................................... 467
Windshield, Backglass, and
Wiper Blades........................................ 469
Audio System.............................................. 260
Audio Steering Wheel Controls................. 317
Care of Your CD and DVD Player............ 320
Care of Your CDs and DVDs................... 320
523
ProCarManuals.com

Audio System (cont.)
Navigation/Radio System,
see Navigation Manual......................... 305
Radio with CD......................................... 263
Rear Seat Audio (RSA)............................ 315
Setting the Time...................................... 261
Theft-Deterrent Feature............................ 317
Understanding Radio Reception............... 318
Audio System(s)
Radio with CD and DVD.......................... 273
Automatic Transmission
Fluid........................................................ 394
Operation................................................. 129
B
Battery........................................................ 413
Electric Power Management..................... 187
Run-Down Protection............................... 188
Before Leaving on a Long Trip.................... 343
Brake
Emergencies............................................ 329
Brakes........................................................ 410
System Warning Light.............................. 217
Braking....................................................... 326Braking in Emergencies............................... 329
Break-In, New Vehicle................................. 123
Bulb Replacement....................................... 422
Halogen Bulbs......................................... 422
Headlamp Aiming..................................... 421
High Intensity Discharge (HID) Lighting...... 422
License Plate Lamps................................ 423
Replacement Bulbs.................................. 423
Buying New Tires........................................ 440
C
Calibration................................................... 139
California Fuel............................................. 380
California Proposition 65 Warning................ 378
Canadian Owners........................................... 3
Capacities and Specications...................... 483
Carbon Monoxide..............110, 137, 347, 362
Care of
Safety Belts............................................. 467
Your CD and DVD Player........................ 320
Your CDs and DVDs................................ 320
Cargo Cover............................................... 163
Cargo Management System........................ 164
Cargo Tie Downs........................................ 163
524
ProCarManuals.com

CD, MP3 ............................................290, 296
Center Console Storage Area...................... 161
Chains, Tire................................................. 445
Charging System Light................................ 216
Check
Engine Light............................................ 222
Checking Things Under the Hood................ 384
Chemical Paint Spotting.............................. 472
Child Restraints
Child Restraint Systems............................. 55
Infants and Young Children........................ 51
Lower Anchors and Tethers for Children....... 61
Older Children........................................... 48
Securing a Child Restraint in a
Rear Seat Position................................. 69
Securing a Child Restraint in the
Right Front Seat Position........................ 72
Where to Put the Restraint........................ 59
Cleaning
Aluminum or Chrome-Plated Wheels........ 470
Exterior Lamps/Lenses............................. 468
Fabric/Carpet........................................... 465
Finish Care.............................................. 468
Inside of Your Vehicle.............................. 464Cleaning (cont.)
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 467
Leather.................................................... 466
Tires........................................................ 471
Underbody Maintenance........................... 472
Washing Your Vehicle.............................. 468
Weatherstrips........................................... 467
Windshield, Backglass, and
Wiper Blades........................................ 469
Climate Control System............................... 194
Dual Automatic......................................... 198
Outlet Adjustment..................................... 205
Rear Air Conditioning and
Heating System.................................... 206
Rear Air Conditioning and Heating
System, Electronic................................ 207
Clock.......................................................... 261
Collision Damage Repair............................. 513
Comfort Guides, Rear Safety Belt................. 43
Compact Spare Tire.................................... 463
Compass..................................................... 139
Content Theft-Deterrent............................... 119
Control of a Vehicle..................................... 326
525
ProCarManuals.com