belt SATURN OUTLOOK 2008 Manual PDF

(i)Drain, flush, and refill cooling system. This service
can be complex; you should have your dealer/retailer
perform this service. See Engine Coolant on page 5-20
for what to use. Inspect hoses. Clean radiator,
condenser, pressure cap, and filler neck. Pressure
test the cooling system and pressure cap.
(j)Check system for interference or binding and for
damaged or missing parts. Replace parts as needed.
Replace any components that have high effort or
excessive wear. Do not lubricate accelerator or
cruise control cables.
(k)Visually inspect belt for fraying, excessive cracks, or
obvious damage. Replace belt if necessary.
(l)If you drive regularly under dusty conditions, inspect
the filter at each engine oil change.
Owner Checks and Services
These owner checks and services should be performed
at the intervals specied to help ensure vehicle safety,
dependability, and emission control performance. Your
dealer/retailer can assist with these checks and services.
Be sure any necessary repairs are completed at once.
Whenever any uids or lubricants are added to the
vehicle, make sure they are the proper ones, as shown
inRecommended Fluids and Lubricants on page 6-11.
At Each Fuel Fill
It is important to perform these underhood checks at
each fuel fill.
Engine Oil Level Check
Notice:It is important to check the engine oil
regularly and keep it at the proper level. Failure to
keep the engine oil at the proper level can cause
damage to the engine not covered by the vehicle
warranty.
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-13.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOL®
coolant mixture if necessary. SeeEngine Coolant
on page 5-20.
Windshield Washer Fluid Level Check
Check the windshield washer uid level in the windshield
washer uid reservoir and add the proper uid if
necessary.
6-8
ProCarManuals.com

Engine Drive Belt Routing
3.6L V6 Engine
6-14
ProCarManuals.com

Vehicle Data Recording and
Privacy
Your Saturn vehicle has a number of sophisticated
computers that record information about the vehicle’s
performance and how it is driven. For example,
your vehicle uses computer modules to monitor and
control engine and transmission performance, to monitor
the conditions for airbag deployment and deploy
airbags in a crash and, if so equipped, to provide
antilock braking to help the driver control the vehicle.
These modules may store data to help your
dealer/retailer technician service your vehicle. Some
modules may also store data about how you operate the
vehicle, such as rate of fuel consumption or average
speed. These modules may also retain the owner’s
personal preferences, such as radio pre-sets, seat
positions, and temperature settings.
Event Data Recorders
This vehicle has an Event Data Recorder (EDR). The
main purpose of an EDR is to record, in certain crash or
near crash-like situations, such as an airbag deployment
or hitting a road obstacle, data that will assist in
understanding how a vehicle’s systems performed.
The EDR is designed to record data related to vehicle
dynamics and safety systems for a short period of time,
typically 30 seconds or less. The EDR in this vehicle
is designed to record such data as:
How various systems in your vehicle were operating
Whether or not the driver and passenger safety
belts were buckled/fastened
How far, if at all, the driver was pressing the
accelerator and/or brake pedal
How fast the vehicle was traveling
This data can help provide a better understanding of the
circumstances in which crashes and injuries occur.
7-18
ProCarManuals.com

A
Accessories and Modications............................ 5-3
Accessory Power Outlets.................................3-21
Adding Equipment to Your Airbag-Equipped
Vehicle.......................................................1-78
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment...........................5-110
Air Cleaner/Filter, Engine.................................5-18
Air Conditioning......................................3-23, 3-26
Airbag
Passenger Status Indicator...........................3-41
Readiness Light..........................................3-40
Airbag System................................................1-64
Adding Equipment to Your Airbag-Equipped
Vehicle...................................................1-78
How Does an Airbag Restrain?......................1-71
Passenger Sensing System...........................1-73
Servicing Your Airbag-Equipped Vehicle..........1-78
What Makes an Airbag Inate?......................1-71
What Will You See After an Airbag Inates?........1-72
When Should an Airbag Inate?....................1-69
Where Are the Airbags?...............................1-66
All-Wheel Drive...............................................5-43
All-Wheel-Drive (AWD) System........................... 4-9
Antilock Brake System (ABS)............................. 4-5
Anti-lock Brake, System Warning Light...............3-46Appearance Care
Aluminum or Chrome-Plated Wheels.............5-106
Care of Safety Belts...................................5-103
Chemical Paint Spotting..............................5-107
Cleaning Exterior Lamps/Lenses..................5-104
Fabric/Carpet............................................5-102
Finish Care...............................................5-104
Finish Damage..........................................5-107
Instrument Panel, Vinyl, and Other Plastic
Surfaces...............................................5-103
Interior Cleaning........................................5-100
Leather....................................................5-102
Sheet Metal Damage..................................5-107
Tires
........................................................5-106
Underbody Maintenance.............................5-107
Vehicle Care/Appearance Materials...............5-108
Washing Your Vehicle.................................5-104
Weatherstrips............................................5-103
Windshield, Backglass, and Wiper Blades......5-105
Appointments, Scheduling Service.....................7-10
Assist Handles...............................................2-57
Audio System.................................................3-82
Audio Steering Wheel Controls....................3-126
Navigation/Radio System,
see Navigation Manual............................3-115
Radio Reception........................................3-127
1
ProCarManuals.com

Audio System (cont.)
Rear Seat Audio (RSA)...............................3-124
Setting the Clock.........................................3-84
Theft-Deterrent Feature...............................3-126
Audio System(s).............................................3-86
Automatic Transmission
Fluid..........................................................5-20
Operation...................................................2-30
B
Battery..........................................................5-37
Electric Power Management..........................3-20
Run-Down Protection...................................3-21
Brake
Emergencies................................................ 4-6
Brakes..........................................................5-34
System Warning Light..................................3-45
Braking........................................................... 4-4
Braking in Emergencies..................................... 4-6
Break-In, New Vehicle.....................................2-25
Bulb Replacement...........................................5-45
Halogen Bulbs............................................5-45
Headlamp Aiming........................................5-44
High Intensity Discharge (HID) Lighting...........5-45
License Plate Lamps....................................5-47Bulb Replacement (cont.)
Replacement Bulbs......................................5-47
Taillamps, Turn Signal, Stoplamps and
Sidemarker Lamps...................................5-46
Buying New Tires...........................................5-65
C
Calibration.....................................................2-39
California Fuel.................................................. 5-6
California Perchlorate Materials Requirements....... 5-4
California Proposition 65 Warning....................... 5-4
Canadian Owners................................................ ii
Capacities and Specications..........................5-120
Carbon Monoxide...........................2-14, 2-37, 4-17
Care of
Safety Belts..............................................5-103
Cargo Cover..................................................2-59
Cargo Management System.............................2-59
Cargo Tie Downs............................................2-59
CD, MP3 ............................................3-104, 3-108
Center Console Storage Area...........................2-56
Chains, Tire...................................................5-71
Charging System Light....................................3-43
Check
Engine Light...............................................3-48
2
ProCarManuals.com

E
EDR .............................................................7-18
Electrical System
Add-On Equipment.....................................5-110
Fuses and Circuit Breakers.........................5-111
Instrument Panel Fuse Block.......................5-111
Power Windows and Other Power Options.......5-111
Underhood Fuse Block...............................5-115
Windshield Wiper Fuses.............................5-110
Electronic Immobilizer
PASS-Key
®III+...........................................2-23
Electronic Immobilizer Operation
PASS-Key
®III+...........................................2-24
Engine
Air Cleaner/Filter.........................................5-18
Check and Service Engine Soon Light............3-48
Coolant......................................................5-20
Coolant Heater............................................2-29
Coolant Temperature Gage...........................3-47
Coolant Temperature Warning Light................3-47
Drive Belt Routing.......................................6-14
Engine Compartment Overview......................5-12
Exhaust.....................................................2-37
Oil .............................................................5-13
Oil Life System...........................................5-16Engine (cont.)
Overheated Protection Operating Mode...........5-25
Overheating................................................5-23
Starting......................................................2-27
Entry Lighting.................................................3-18
Event Data Recorders.....................................7-18
Extender, Safety Belt.......................................1-38
Exterior Lamps...............................................3-15
F
Filter
Engine Air Cleaner......................................5-18
Finish Damage.............................................5-107
Flashers, Hazard Warning.................................. 3-6
Flash-to-Pass.................................................3-10
Flat Tire........................................................5-72
Flat Tire, Changing.........................................5-84
Flat Tire, Storing.............................................5-96
Floor Mats.....................................................2-57
Fluid
Automatic Transmission................................5-20
Power Steering...........................................5-32
Windshield Washer......................................5-33
Fog Lamp
Fog ...........................................................3-17
5
ProCarManuals.com

Height Adjuster, Driver Seat............................... 1-3
High Voltage Devices and Wiring.....................5-110
Highbeam On Light.........................................3-52
Highway Hypnosis...........................................4-16
Hill and Mountain Roads..................................4-16
Hood
Checking Things Under................................5-11
Release.....................................................5-11
Horn ............................................................... 3-7
How to Wear Safety Belts Properly...................1-23
I
Ignition Positions.............................................2-26
Infants and Young Children, Restraints...............1-42
Ination - Tire Pressure...................................5-56
Inator Kit, Tire...............................................5-73
Instrument Panel
Brightness..................................................3-17
Cluster.......................................................3-38
Overview..................................................... 3-4
Storage Area..............................................2-55
J
Jump Starting.................................................5-38
K
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
L
Labeling, Tire Sidewall.....................................5-50
Lamps
Courtesy....................................................3-17
Dome ........................................................3-18
Dome Lamp Override...................................3-18
Reading.....................................................3-20
Lap-Shoulder Belt...........................................1-32
LATCH System
Child Restraints...........................................1-49
License Plate Lamps.......................................5-47
Liftgate
Carbon Monoxide........................................2-13
Liftgate, Power...............................................2-14
Light
Airbag Readiness........................................3-40
Anti-lock Brake System (ABS) Warning...........3-46
Brake System Warning.................................3-45
Charging System.........................................3-43
Cruise Control.............................................3-52
Engine Coolant Temperature Warning.............3-47
7
ProCarManuals.com

Light (cont.)
Fog Lamp ..................................................3-52
Highbeam On.............................................3-52
Malfunction Indicator....................................3-48
Oil Pressure...............................................3-51
Passenger Airbag Status Indicator..................3-41
Safety Belt Reminders..................................3-39
Security.....................................................3-51
StabiliTrak
®Indicator....................................3-46
Tire Pressure..............................................3-48
Tow/Haul Mode ...........................................3-52
Lighting
Delayed Entry.............................................3-19
Delayed Exit...............................................3-19
Entry.........................................................3-18
Parade Dimming..........................................3-19
Lights
Exterior Lamps............................................3-15
Flash-to-Pass..............................................3-10
High/Low Beam Changer................................ 3-9
Loading Your Vehicle.......................................4-22
Lockout Protection..........................................2-12
Locks
Delayed Locking..........................................2-11
Door ..........................................................2-10
Lockout Protection.......................................2-12
Power Door ................................................2-11
Programmable Automatic Door Locks.............2-11
Rear Door Security Locks.............................2-12Loss of Control...............................................4-12
Luggage Carrier..............................................2-58
Lumbar
Manual Controls............................................ 1-4
Power Controls............................................. 1-5M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-8
At Least Once a Month.................................. 6-9
At Least Once a Year.................................... 6-9
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-7
Maintenance Record....................................6-15
Maintenance Replacement Parts....................6-13
Maintenance Requirements............................. 6-2
Owner Checks and Services........................... 6-8
Recommended Fluids and Lubricants.............6-11
Scheduled Maintenance................................. 6-4
Using.......................................................... 6-2
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Light................................3-48
Manual Lumbar Controls.................................... 1-4
Manual Seats................................................... 1-2
Manual, Using.................................................... iii
Memory Seat and Mirrors.................................. 1-6
8
ProCarManuals.com

Recommended Fluids and Lubricants.................6-11
Recreational Vehicle Towing.............................4-27
Remote Keyless Entry (RKE) System.................. 2-4
Remote Keyless Entry (RKE) System,
Operation..................................................... 2-5
Remote Vehicle Start........................................ 2-7
Removing the Flat Tire and Installing the
Spare Tire..................................................5-88
Removing the Spare Tire and Tools...................5-85
Replacement Bulbs.........................................5-47
Replacement Parts, Maintenance......................6-13
Reporting Safety Defects
Canadian Government..................................7-15
Saturn.......................................................7-16
United States Government............................7-15
Restraint System Check
Checking the Restraint Systems....................1-80
Replacing Restraint System Parts
After a Crash..........................................1-81
Retained Accessory Power (RAP)......................2-27
Roadside
Assistance Program....................................... 7-7
Rocking Your Vehicle to Get it Out....................4-22
Routing, Engine Drive Belt...............................6-14
Running Out of Fuel........................................2-38S
Safety Belt
Reminder Light............................................3-39
Safety Belts
Care of ....................................................5-103
How to Wear Safety Belts Properly................1-23
Lap-Shoulder Belt........................................1-32
Safety Belt Extender....................................1-38
Safety Belt Use During Pregnancy.................1-38
Safety Belts Are for Everyone.......................1-18
Safety Warnings and Symbols.............................. iii
Scheduled Maintenance..................................... 6-4
Seats
Driver Seat Height Adjuster............................. 1-3
Head Restraints..........................................1-11
Heated Seats............................................... 1-5
Manual Lumbar............................................. 1-4
Memory, Mirrors............................................ 1-6
Power Lumbar .............................................. 1-5
Power Seats................................................. 1-3
Rear Seat Operation....................................1-12
Reclining Seatbacks...................................... 1-8
Third Row Seat...........................................1-14
Second Row Center Console............................2-56
Secondary Latch System.................................5-93
11
ProCarManuals.com