belt SATURN VUE 2009 Repair Manual

Additional Required Services (cont’d)
Service and Miles (Kilometers)25,000
(40 000) 50,000
(80 000) 75,000
(120 000) 100,000
(160 000) 125,000
(200 000) 150,000
(240 000)
Change transfer case uid (severe
service). See footnote (h). •••
Change transfer case uid (normal
service). See footnote (m). •
Engine cooling system service (or
every ve years, whichever occurs
rst). An Emission Control Service. See
footnote (i). •
Inspect engine accessory drive belt.
An Emission Control Service. See
footnote (n). •
Maintenance Schedule 6-7
ProCarManuals.com

Maintenance Footnotes
†The U.S. Environmental Protection
Agency or the California Air
Resources Board has determined
that the failure to perform this
maintenance item will not nullify the
emission warranty or limit recall
liability prior to the completion of the
vehicle’s useful life. We, however,
urge that all recommended
maintenance services be performed
at the indicated intervals and the
maintenance be recorded.
(a)Visually inspect brake lines and
hoses for proper hook-up, binding,
leaks, cracks, chafing, etc.
Inspect disc brake pads for wear
and rotors for surface condition.
Inspect other brake parts, including
calipers, parking brake, etc.
(b)Visually inspect front and rear
suspension and steering system for
damaged, loose, or missing parts
or signs of wear.(c)Visually inspect hoses and have
them replaced if they are cracked,
swollen, or deteriorated. Inspect
all pipes, fittings, and clamps;
replace with genuine parts as
needed. To help ensure proper
operation, a pressure test of
the cooling system and pressure
cap and cleaning the outside of the
radiator and air conditioning
condenser is recommended at least
once a year.
(d)Inspect wiper blades for wear,
cracking, or contamination.
Clean the windshield and wiper
blades, if contaminated. Replace
wiper blades that are worn or
damaged. See Windshield Wiper
Blade Replacement on page 5-42
and Windshield and Wiper
Blades on page 5-76 for more
information.(e)Make sure the safety belt
reminder light and safety belt
assemblies are working properly.
Look for any other loose or
damaged safety belt system parts. If
you see anything that might keep
a safety belt system from doing
its job, have it repaired. Have any
torn or frayed safety belts replaced.
Also see Checking the Restraint
Systems on page 1-58.
(f)Lubricate all key lock cylinders,
door hinges and latches, hood
hinges and latches, glove box
hinges, sunroof (if equipped), and
any folding seat hardware. More
frequent lubrication may be required
when exposed to a corrosive
environment. Applying silicone
grease on weatherstrips with a clean
cloth will make them last longer,
seal better, and not stick or squeak.
6-8 Maintenance Schedule
ProCarManuals.com

(g)Check system for interference or
binding and for damaged or missing
parts. Replace parts as needed.
Replace any components that have
high effort or excessive wear.
(h)Severe service is when the
vehicle is mainly driven under one
or more of these conditions:
In heavy city traffic where the
outside temperature regularly
reaches 90°F (32°C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer
towing.
Uses such as found in taxi,
police, or delivery service.(i)Drain, flush, and refill cooling
system. This service can be
complex; you should have your
dealer/retailer perform this service.
See Engine Coolant on page 5-22 for
what to use. Inspect hoses. Clean
radiator, condenser, pressure cap,
and filler neck. Pressure test the
cooling system and pressure cap.
(j)A fluid loss in any vehicle system
could indicate a problem. Have
the system inspected and repaired
and the fluid level checked. Add
fluid if needed.
(k)Or every 12 months, whichever
occurs first. If you drive regularly
under dusty conditions, the filter may
require replacement more often.(l)If driving regularly under dusty
conditions, inspect the filter at each
engine oil change.
(m)Change the fluid the first
time the vehicle is serviced after
100,000 miles (166 000 km) and
when the vehicle is serviced after
each subsequent 50,000 miles
(83 000 km).
(n)Visually inspect belt for fraying,
excessive cracks, or obvious
damage. Replace belt if necessary.
Maintenance Schedule 6-9
ProCarManuals.com

Engine Drive Belt
Routing
2.4L L4 (LE5) Engine
3.5L V6 (LZ4) Engine
3.6L V6 (LY7) Engine
6-16 Maintenance Schedule
ProCarManuals.com

Vehicle Data
Recording and
Privacy
Your Saturn vehicle has a number
of sophisticated computers that
record information about the
vehicle’s performance and how it is
driven. For example, your vehicle
uses computer modules to monitor
and control engine and transmission
performance, to monitor the
conditions for airbag deployment
and deploy airbags in a crash and,
if so equipped, to provide antilock
braking to help the driver control the
vehicle. These modules may
store data to help your
dealer/retailer technician service
your vehicle. Some modules
may also store data about how you
operate the vehicle, such as rate
of fuel consumption or average
speed. These modules may
also retain the owner’s personal
preferences, such as radio pre-sets,
seat positions, and temperature
settings.
Event Data Recorders
This vehicle has an Event
Data Recorder (EDR). The main
purpose of an EDR is to record, in
certain crash or near crash-like
situations, such as an airbag
deployment or hitting a road
obstacle, data that will assist in
understanding how a vehicle’s
systems performed. The EDR is
designed to record data related to
vehicle dynamics and safety
systems for a short period of time,
typically 30 seconds or less.
The EDR in this vehicle is designed
to record such data as:
How various systems in your
vehicle were operating
Whether or not the driver and
passenger safety belts were
buckled/fastened
How far, if at all, the driver was
pressing the accelerator and/or
brake pedal
How fast the vehicle was
travelingThis data can help provide a better
understanding of the circumstances
in which crashes and injuries
occur.
Important:EDR data is recorded
by your vehicle only if a non-trivial
crash situation occurs; no data
is recorded by the EDR under
normal driving conditions and no
personal data (e.g., name, gender,
age, and crash location) is
recorded. However, other parties,
such as law enforcement, could
combine the EDR data with the type
of personally identifying data
routinely acquired during a crash
investigation.
To read data recorded by an EDR,
special equipment is required,
and access to the vehicle or the
EDR is needed. In addition to
the vehicle manufacturer, other
parties, such as law enforcement,
that have the special equipment, can
read the information if they have
access to the vehicle or the EDR.
7-16 Customer Assistance Information
ProCarManuals.com

A
About Driving Your Vehicle......... ii
Accessories and
Modications...................... 5-3
Accessory Power.................2-17
Accessory Power Outlets......3-16
Adding Equipment to Your
Airbag-Equipped Vehicle....1-57
Additional Required Services,
Scheduled Maintenance....... 6-6
Additives, Fuel...................... 5-6
Add-On Electrical
Equipment.......................5-79
Adjustment
Chime Level....................3-93
Air Cleaner/Filter, Engine.......5-17
Air Conditioning...................3-17
Air Filter, Passenger
Compartment...................3-24
Airbag
Readiness Light................3-29
Airbag System.....................1-42
Adding Equipment to
Your Airbag-Equipped
Vehicle........................1-57
How Does an Airbag
Restrain?.....................1-49Airbag System (cont.)
Passenger Sensing
System........................1-51
Servicing Your
Airbag-Equipped
Vehicle........................1-56
What Makes an Airbag
Inate?........................1-49
What Will You See After
an Airbag Inates?........1-50
When Should an Airbag
Inate?........................1-47
Where Are the Airbags?.....1-45
Airbags
Passenger Status
Indicator.......................3-30
All-Wheel Drive....................5-35
All-Wheel Drive Disabled
Light...............................3-40
All-Wheel-Drive (AWD)
System............................. 4-9
Antenna
Fixed Mast......................3-93
Antenna, XM™ Satellite
Radio Antenna System......3-93
Antilock Brake
System (ABS).................... 4-6
Warning Light...................3-32Appearance Care
Aluminum Wheels.............5-77
Care of Safety Belts..........5-74
Chemical Paint Spotting.....5-78
Cleaning Exterior Lamps/
Lenses........................5-75
Fabric/Carpet...................5-73
Finish Care......................5-76
Finish Damage.................5-78
Instrument Panel, Vinyl,
and Other Plastic
Surfaces......................5-74
Interior Cleaning...............5-72
Leather...........................5-74
Sheet Metal Damage........5-78
Tires...............................5-77
Underbody Maintenance....5-78
Washing Your Vehicle........5-75
Weatherstrips...................5-75
Windshield and Wiper
Blades.........................5-76
Assistance Program,
Roadside.......................... 7-6
Audio System......................3-64
Audio Steering Wheel
Controls.......................3-92
Navigation/Radio System,
see Navigation Manual . . . 3-81
INDEX i-1
ProCarManuals.com

Audio System (cont.)
Setting the Clock..............3-65
XM™ Satellite Radio
Antenna System............3-93
Audio System(s)..................3-67
Audio Systems
Radio Reception...............3-92
Theft-Deterrent Feature......3-91
Automatic Climate Control
System...........................3-20
Automatic Door Lock.............. 2-8
Automatic Door Unlock........... 2-8
Automatic Headlamp
System...........................3-13
Automatic Transmission
Fluid...............................5-18
Operation................2-19, 2-22
B
Battery...............................5-30
Electric Power
Management.................3-15
Run-Down Protection.........3-16
Belt Routing, Engine.............6-16
Bluetooth
®..........................3-81
Brake
Emergencies...................... 4-6
Brake Fluid.........................5-28Brakes...............................5-28
Antilock............................. 4-6
Parking...........................2-24
System Warning Light.......3-31
Braking................................ 4-5
Braking in Emergencies.......... 4-6
Break-In, New Vehicle..........2-15
Bulb Replacement................5-41
Fog Lamp ........................3-14
Front Turn Signal and
Parking Lamps..............5-40
Halogen Bulbs..................5-39
Headlamp Aiming..............5-36
Headlamps......................5-39
License Plate Lamps.........5-41
Taillamps, Turn Signal,
Stoplamps and Back-up
Lamps .........................5-40
Buying New Tires.................5-58
C
Calibration..........................3-47
California
Perchlorate Materials
Requirements................. 5-4
California Fuel....................... 5-6
California Proposition 65
Warning............................ 5-4Camera, Rear Vision............2-31
Canadian Owners..................... ii
Capacities and
Specications...................5-86
Carbon Monoxide
Engine Exhaust................2-28
Liftgate............................. 2-9
Winter Driving..................4-25
Care of
Safety Belts.....................5-74
Cargo
Tie Downs .......................2-44
Cargo Cover.......................2-44
Cargo Management System . . . 2-44
CD, MP3 ............................3-75
Center Console Storage........2-42
Chains, Tire........................5-62
Charging System Light..........3-31
Check
Engine Lamp...................3-35
Checking Things Under
the Hood .........................5-10
Chemical Paint Spotting........5-78
Child Restraints
Infants and Young
Children.......................1-26
Lower Anchors and
Tethers for Children.......1-31
i-2 INDEX
ProCarManuals.com

Door
Ajar Light........................3-40
Automatic Door Lock.......... 2-8
Automatic Door Unlock........ 2-8
Delayed Locking................. 2-8
Locks............................... 2-7
Power Door Locks.............. 2-8
Rear Door Security Locks.... 2-8
Drive Systems
All-Wheel Drive................5-35
Driver
Seat Height Adjuster........... 1-4
Driver Behavior..................... 4-2
Driver Information
Center (DIC)....................3-42
DIC Operation and
Displays.......................3-42
DIC Vehicle
Customization...............3-57
DIC Warnings and
Messages....................3-49
Driving
At Night..........................4-22
Before a Long Trip............4-24
Defensive.......................... 4-3
Drunk............................... 4-4
Environment...................... 4-2
Highway Hypnosis............4-24
Hill and Mountain Roads....4-24Driving (cont.)
In Rain and on Wet
Roads.........................4-23
Loss of Control................4-12
Off-Road .........................4-13
Off-Road Recovery...........4-11
Rocking Your Vehicle to
Get it Out ....................4-27
Winter.............................4-25
Driving for Better Fuel
Economy........................... 4-3
E
EDR ..................................7-16
Electrical Equipment
Add-On Equipment............5-79
Electrical System
Fuses and Circuit
Breakers......................5-80
Instrument Panel Fuse
Block...........................5-80
Power Windows and
Other Power Options.....5-80
Underhood Fuse Block......5-82
Windshield Wiper Fuses....5-80
Electronic Immobilizer
PASS-Key
®III+................2-13Electronic Immobilizer
Operation
PASS-Key
®III+................2-14
Engine
Air Cleaner/Filter...............5-17
Change Engine Oil Light....3-38
Check and Service
Engine Soon Lamp........3-35
Compartment Overview......5-12
Coolant...........................5-22
Coolant Heater.................2-18
Coolant Temperature
Warning Light...............3-34
Cooling System................5-19
Drive Belt Routing.............6-16
Exhaust...........................2-28
Oil ..................................5-14
Oil Life System.................5-16
Overheating.....................5-25
Reduced Power Light........3-39
Starting...........................2-17
Entry Lighting......................3-14
Reporting Safety Defects
to the United States
Government.....................7-14
Event Data Recorders..........7-16
Extender, Safety Belt............1-23
Exterior Lamps....................3-12
i-4 INDEX
ProCarManuals.com

Highway Hypnosis................4-24
Hill and Mountain Roads.......4-24
Hood
Checking Things Under.....5-10
Release..........................5-11
Horn .................................... 3-5
How to Wear Safety Belts
Properly..........................1-14
I
Ignition Positions..................2-16
Infants and Young Children,
Restraints........................1-26
Ination - Tire Pressure.........5-49
Instrument Panel
Brightness.......................3-14
Cluster............................3-27
Overview........................... 3-4
Storage Area....................2-42
Introduction........................... 6-1
J
Jump Starting......................5-31
K
Keyless Entry, Remote
Operation.......................... 2-4
Keyless Entry System............ 2-3
Keys.................................... 2-2
L
Labeling, Tire Sidewall..........5-44
Lamp
Malfunction Indicator.........3-35
Lamps
Daytime Running (DRL).....3-13
Dome .............................3-14
Front Turn Signal and
Parking Lamps..............5-40
License Plate...................5-41
Reading..........................3-15
Lap-Shoulder Belt................1-19
LATCH System for Child
Restraints........................1-31
Liftgate
Carbon Monoxide............... 2-9
Lighting
Entry..............................3-14Lights
Airbag Readiness.............3-29
All-Wheel Drive Disabled....3-40
Antilock Brake System
(ABS) Warning..............3-32
Brake System Warning......3-31
Change Engine Oil...........3-38
Charging System..............3-31
Cruise Control..................3-38
Daytime Running Lamps
Indicator.......................3-39
Door Ajar.........................3-40
Engine Coolant
Temperature Warning.....3-34
Exterior Lamps.................3-12
Flash-to-Pass..................... 3-7
Fog Lamp ........................3-38
Gate Ajar.........................3-40
Highbeam On...................3-39
High/Low Beam Changer..... 3-7
Low Fuel Warning.............3-41
Low Washer Fluid
Warning.......................3-40
Oil Pressure.....................3-37
Passenger Airbag Status
Indicator.......................3-30
i-6 INDEX
ProCarManuals.com

Lights (cont.)
Reduced Engine Power.....3-39
Safety Belt Reminders.......3-28
Security...........................3-38
Service Vehicle Soon........3-40
StabiliTrak
®Indicator.........3-33
Tire Pressure...................3-34
Traction Control System
(TCS) Warning..............3-33
Warning, Power Steering . . . 3-33
Loading Your Vehicle............4-28
Locks
Automatic Door Lock.......... 2-8
Automatic Door Unlock........ 2-8
Delayed Locking................. 2-8
Door ................................. 2-7
Lockout Protection.............. 2-8
Power Door ....................... 2-8
Rear Door Security Locks.... 2-8
Loss of Control....................4-12
Low Fuel Warning Light........3-41
Low Washer Fluid Warning
Light...............................3-40
Lower Anchors and Tethers
for Children......................1-31
Luggage Carrier...................2-43
Lumbar
Manual Controls................. 1-5
M
Maintenance
Footnotes.......................... 6-8
Maintenance Schedule
Additional Required
Services........................ 6-6
At Each Fuel Fill..............6-10
At Least Once a Month.....6-10
At Least Once a Year.......6-11
Maintenance Record.........6-17
Maintenance Replacement
Parts...........................6-15
Maintenance Requirements . . . 6-1
Owner Checks and
Services.......................6-10
Recommended Fluids and
Lubricants....................6-13
Scheduled Maintenance....... 6-3
Using............................... 6-2
Your Vehicle and the
Environment................... 6-1
Malfunction Indicator Lamp....3-35
Manual Lumbar Controls......... 1-5
Manual Seats........................ 1-3
Message
DIC Warnings and
Messages....................3-49Mirrors
Automatic Dimming
Rearview......................2-29
Manual Rearview Mirror.....2-29
Outside Convex Mirror.......2-30
Outside Heated Mirrors......2-30
Outside Power Mirrors.......2-29
MP3 ...................................3-75
N
Navigation System, Privacy . . . 7-17
Navigation/Radio System,
see Navigation Manual......3-81
Net
Convenience....................2-44
New Vehicle Break-In...........2-15
O
Odometer...........................3-28
Odometer, Trip.....................3-28
Off-Road .............................4-13
Driving............................4-13
Recovery.........................4-11
INDEX i-7
ProCarManuals.com