maintenance Seat Altea 2011 Owner's Guide

Checking and refilling levels245
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Brake fluidChecking the brake fluid level
The brake fluid is checked at the intervals given in the service
schedule.– Read off the fluid level at the transparent brake fluid reservoir. It
should always be between the “MIN” and “MAX” marks.The position of the brake fluid reservoir is shown in the corresponding engine
compartment illustration ⇒page 291. The brake fluid reservoir has a black
and yellow cap.
The brake fluid level drops slightly when the vehicle is being used as the
brake pads are automatically adjusted as they wear. However, if the level goes down noticeably in a short time, or drops below the
“MIN” mark, there may be a leak in the brake system. A display on the instru-
ment panel will warn you if the brake fluid level is too low
⇒page 77.
WARNING
Before opening the bonnet to check the brake fluid level, read and observe
the warnings ⇒page 232.Changing the brake fluid
The Maintenance Programme indicates the brake fluid
change intervals.We recommend that you have the brake fluid changed by an Authorised
Service Centre.
Before opening the bonnet, please read and follow the warnings ⇒ in
“Safety instructions on working in the engine compartment” on page 232 in
section “Safety notes for working in the engine compartment”.
Brake fluid absorbs moisture. In the course of time, it will absorb water from
the ambient air. If the water content in the brake fluid is too high, the brake
system could corrode. This also considerably reduces the boiling point of the
brake fluid. Heavy use of the brakes may then cause a vapour lock which
could impair the braking effect.
It is important that you use only brake fluid compliant with US standard
FMVSS 116 DOT 4. We recommend the use of Genuine SEAT brake fluid.
WARNING
Brake fluid is poisonous. Old brake fluid impairs the braking effect.
Fig. 171 In the engine
compartment: Brake fluid
reservoir cover
Altea_EN.book Seite 245 Donnerstag, 2. September 2010 2:00 14

Checking and refilling levels
246•Before opening the bonnet to check the brake fluid level, read and
observe the warnings ⇒page 232.•Brake fluid should be stored in the closed original container in a safe
place out of reach of children. There is a toxic risk.•Complete the brake fluid change according to the Maintenance
Programme. Heavy use of the brakes may cause a vapour lock if the brake
fluid is left in the system for too long. This would seriously affect the effi-
ciency of the brakes and the safety of the vehicle. This may cause an acci-
dent.Caution
Brake fluid could damage the paintwork. Wipe off any brake fluid from the
paintwork immediately.
For the sake of the environment
The brake pads and fluid must be collected and disposed of according the
applicable regulations. The SEAT service network has the necessary equip-
ment and qualified personnel for collecting and disposing of this waste
material.
Vehicle batteryWarnings on handling the battery
WARNING
Always be aware of the danger of injury and chemical burns as well as the
risk of accident or fire when working on the battery and the electrical
system:•Wear eye protection. Protect your eyes, skin and clothing from acid and
particles containing lead.•Battery acid is very corrosive and caustic. Wear protective gloves and
eye protection. Do not tilt the batteries. This could spill acid through the
vents. Rinse battery acid from eyes immediately for several minutes with
clear water. Then seek medical care immediately. Neutralise any acid
splashes on the skin or clothing with a soapy solution, and rinse off with
plenty of water. If acid is swallowed by mistake, consult a doctor immedi-
ately.•Fires, sparks, open flames and smoking are prohibited. When handling
cables and electrical equipment, av oid causing sparks and electrostatic
WARNING (continued)

Wear eye protection

Battery acid is very corrosive and caustic. Wear protec-
tive gloves and eye protection!
Ž
Fires, sparks, open flames and smoking are prohibited!
Ÿ
A highly explosive mixture of gases is released when the
battery is under charge.

Keep children away from acid and batteries!
Altea_EN.book Seite 246 Donnerstag, 2. September 2010 2:00 14

Checking and refilling levels
248Charging and changing the vehicle battery
The battery is maintenance-free and is checked during the
inspection service. All work on the vehicle battery requires
specialist knowledge.If you often drive short distances or if the vehicle is not driven for long
periods, the battery should be checked by a specialised workshop between
the scheduled services.
If the battery has discharged and you have problems starting the vehicle, the
battery might be damaged. If this happens, we recommend you have the
vehicle battery checked by an Authorised Service Centre where it will be re-
charged or replaced.
Charging the battery
The vehicle battery should be charged by a specialised workshop only, as
batteries using special technology have been installed and they must be
charged in a controlled environment.
Replacing a vehicle battery
The battery has been developed to suit the conditions of its location and has
special safety features.
Genuine SEAT batteries fulfil the maintenance, performance and safety spec-
ifications of your vehicle.
WARNING
•We recommend you use only maintenance-free or cycle free leak-proof
batteries which comply with standards T 825 06 and VW 7 50 73. This
standard applies as of 2001.•Before starting any work on the batteries, you must read and observe
the warnings ⇒ in “Warnings on handling the battery” on page 246.
For the sake of the environment
Batteries contain toxic substances such as sulphuric acid and lead. They
m ust b e d isp ose d of app ro pr iate ly a nd m ust no t b e disp ose d of wit h or di na r y
household waste.
Altea_EN.book Seite 248 Donnerstag, 2. September 2010 2:00 14

Description of specifications287
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Technical SpecificationsDescription of specificationsImportant informationImportant
The information in the vehicle documentation always has
precedence.All technical specifications provided in this manual are valid for the standard
model in Spain. The vehicle data card included in the Maintenance
Programme or the vehicle registration documents shows which engine is
installed in the vehicle.
The figures may be different depending on if additional equipment is fitted,
for different models, for special vehicles and for other countries. Abbreviations used in the Technical Specifications section
Abbrevia-
tion
Meaning
kW
Kilowatt, engine power measurement.
PS
Pferdestärke (horsepower), formerly used to denote engine
power.
rpm
Revolutions per minute - engine speed.
Nm
Newton metres, unit of engine torque.
l/100 km
Fuel consumption in litres per 100 km.
g/km
Carbon dioxide emissions in grams per km travelled.
CO2
Carbon dioxide
CN
Cetane number, indication of the diesel combustion power.
RON
Research octane number, indication of the knock resistance
of petrol.
Altea_EN.book Seite 287 Donnerstag, 2. September 2010 2:00 14

Description of specifications
288Vehicle identification data
The most important information is given on the identification
plate and the vehicle data sticker.Vehicles for certain export countries do not have an identification plate.
Identification plate
The identification plate is located on the left rib inside the engine compart-
ment.
Vehicle identification number
The vehicle identification number (chassis number) can be read from outside
the vehicle through a viewer in the windscreen. This is located on the left-
hand side of the vehicle in the lower area of the windscreen. It is also located
on the right hand side of the engine compartment. Vehicle data
The data sticker is placed on the inside of the spare wheel recess in the
luggage compartment.
The following information is provided on the vehicle data sticker:
⇒fig. 207
These data are also provided in the Maintenance Programme. Production control number
Vehicle identification number (chassis number)
Model code number
Model designation / engine power output
Engine and gearbox code letters
Paintwork number / interior trim code
Optional equipment codes
Consumption values
CO
2 emissions values
Data from 2 to 9 are also provided in the Maintenance Programme.
Consumption figures and CO
2
Consumption (litres/100 km) / CO
2 emissions (g/km) urban
Consumption (litres/100 km) / CO2 emissions (g/km) motorway
Consumption (litres/100 km) / CO2 emissions (g/km) mixed
Fig. 207 Vehicle data
sticker (luggage compart-
ment)
A1A2A3A4A5A6A7A8A9AAABAC
Altea_EN.book Seite 288 Donnerstag, 2. September 2010 2:00 14

Index309
Heated rear window
2C-Climatronic . . . . . . . . . . . . . . . . . . . . . . . 166
Heating element wires . . . . . . . . . . . . . . . . 219
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 159
High pressure cleaners . . . . . . . . . . . . . . . . . . . 217
Hill-start aid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 188
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
How to jump start description . . . . . . . . . . . . . 282
Hydraulic Brake Assist . . . . . . . . . . . . . . . . . . . . 197IIdentification number . . . . . . . . . . . . . . . . . . . . 288
Identification plate . . . . . . . . . . . . . . . . . . . . . . 288
Ignition key . . . . . . . . . . . . . . . . . . . . . . . . . . . . 173
Ignition lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 173
Information in the multifunction display Memory displays . . . . . . . . . . . . . . . . . . . . . . 64
Information messages in the display . . . . . . . . . 66
Instrument and switch lighting . . . . . . . . . . . . . 122
Instrument lighting . . . . . . . . . . . . . . . . . . . . . . . 55
Instrument panel menus Configuration menu . . . . . . . . . . . . . . . . . . . . 74
Example of menu use . . . . . . . . . . . . . . . . . . 68
Lights and visibility menu . . . . . . . . . . . . . . . 76
Main menu . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
Vehicle status menu . . . . . . . . . . . . . . . . . . . 73
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Interior front light, type 1 . . . . . . . . . . . . . . . . . 126
Interior front light, type 2 . . . . . . . . . . . . . . . . . 127 Interior mirror . . . . . . . . . . . . . . . . . . . . . . . . . . . 134
Intermittent wipe, windscreen . . . . . . . . . . . . . 130
ISOFIX system . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
JJump leads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 281
Jump-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . 281KKeys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105LLeather cleaning . . . . . . . . . . . . . . . . . . . . . . . . 222
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Load compartment in the luggage compartment
See Loading the luggage compartment . . . . 17
Loading the luggage compartment . . . . . . . . . . 17
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 219
LPG . . . . . . . . . . . . . . . . . . . . . . . . . . . 60, 177, 227
LPG system Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
Filler neck adapter . . . . . . . . . . . . . . . . . . . . 229
Level indicator . . . . . . . . . . . . . . . . . . . . . . . . 60
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Luggage compartment . . . . . . . . . . . . . . . . . . . 156 See also Loading the luggage compartment 17
Luggage compartment net . . . . . . . . . . . . . . . . 147
MMain beam . . . . . . . . . . . . . . . . . . . . . . . . 118, 125
Main beam headlights Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 84
Main headlight bulbs . . . . . . . . . . . . . . . . . . . . 273
Maintenance Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Maintenance and cleaning . . . . . . . . . . . . . . . . 215
Manual gearbox . . . . . . . . . . . . . . . . . . . . . . . . . 181
Manual mode 2C-Climatronic . . . . . . . . . . . . . . . . . . . . . . . 168
MEDIA-IN connector . . . . . . . . . . . . . . . . . . . . . . 155
MFI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Mirrors Exterior mirrors . . . . . . . . . . . . . . . . . . . . . . 135
Interior mirror . . . . . . . . . . . . . . . . . . . . . . . . 134
Vanity mirrors . . . . . . . . . . . . . . . . . . . . . . . 129
Mobile phones and two-way radios . . . . . . . . . 225
Multifunction display . . . . . . . . . . . . . . . . . . . . . 63
Multi-purpose mobile storage compartment* . 151 Closing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 151
Fitting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 150
Opening . . . . . . . . . . . . . . . . . . . . . . . . . . . . 151
Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . 150
Uses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 151NNumber of seats . . . . . . . . . . . . . . . . . . . . . . . . . 19
Altea_EN.book Seite 309 Donnerstag, 2. September 2010 2:00 14

Index
310OObservations . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Octane number . . . . . . . . . . . . . . . . . . . . . . . . . 230
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
235
Oil change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
Oil properties . . . . . . . . . . . . . . . . . . . . . . . . . . . 236
One-touch opening and closing
Electric windows . . . . . . . . . . . . . . . . . . . . . 114
Opening and locking . . . . . . . . . . . . . . . . . . . . 111
Outside temperature display . . . . . . . . . . . . 65, 73
Overview Control lamps . . . . . . . . . . . . . . . . . . . . . . . . 77
Dash panel . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Indicator lamps . . . . . . . . . . . . . . . . . . . . . . . 80
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Warning lamps . . . . . . . . . . . . . . . . . . . . 77, 80PPaintworkPolishing . . . . . . . . . . . . . . . . . . . . . . . . . . . 218
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 187
Parking aid acoustic system . . . . . . . . . . . . . . . 189
Parking lights . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Parking system . . . . . . . . . . . . . . . . . . . . . . . . . 189
Parking system plus . . . . . . . . . . . . . . . . . . . . . 190
Passenger See Correct sitting position . . . . . . . . . . 11, 12
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 Petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Driving abroad . . . . . . . . . . . . . . . . . . . . . . . 210
Petrol additives . . . . . . . . . . . . . . . . . . . . . . . . . 231
Physical principles of a frontal collision . . . . . . 21
Plastic parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 218
Plastic parts cleaning . . . . . . . . . . . . . . . . . . . . 221
Pollen filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 169
Pollution filter . . . . . . . . . . . . . . . . . . . . . . . . . . 169
Power steering . . . . . . . . . . . . . . . . . . . . . . . . . . 203 Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 88
Products for vehicle maintenance . . . . . . . . . . 215
RRadio frequency remote control . . . . . . . . . . . . 107 Changing the battery . . . . . . . . . . . . . . . . . 108
Radio navigation controls on the steering wheel Audio + telephone version . . . . . . . . . . . . . . 96
Rain sensor* . . . . . . . . . . . . . . . . . . . . . . . . . . . 132
Rear drink holder* Armrest* . . . . . . . . . . . . . . . . . . . . . . . . . . . . 149
Rear fog light Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 83
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 118
Rear interior lights . . . . . . . . . . . . . . . . . . . . . . 128
Rear reading lights . . . . . . . . . . . . . . . . . . . . . . 128
Rear seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
Rear shelf Storage compartment . . . . . . . . . . . . . . . . . 157
Rear window automatic wiper/washer . . . . . . 133 Rear window wiper . . . . . . . . . . . . . . . . . . . . . . 133
Recommended gear display . . . . . . . . . . . . . . . . 62
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 226
Registration light . . . . . . . . . . . . . . . . . . . . . . . 280
Remote control key
Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107
Synchronising . . . . . . . . . . . . . . . . . . . . . . . 108
Removing and fitting the wheel . . . . . . . . . . . . 264
Repairs Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Replacement keys . . . . . . . . . . . . . . . . . . . . . . . 105
Replacement of parts . . . . . . . . . . . . . . . . . . . . 224
Rev counter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Reverse gear Manual gearbox . . . . . . . . . . . . . . . . . . . . . 181
Roll-back function Sliding/tilting sunroof . . . . . . . . . . . . . . . . 117
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Roof aerial . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Roof rack* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 157
Roof storage compartment* . . . . . . . . . . . . . . . 146
Rubber seals . . . . . . . . . . . . . . . . . . . . . . . . . . . 219
Run-flat tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . 252
Running in Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 205
SSafe driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Altea_EN.book Seite 310 Donnerstag, 2. September 2010 2:00 14

Index
312Tank
Fuel level . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Reserve indicator . . . . . . . . . . . . . . . . . . . . . 58
Tank capacity . . . . . . . . . . . . . . . . . . . . . . . . . 58
TCS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 198
TCS (Traction control system) Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 89
Technical modifications . . . . . . . . . . . . . . . . . . 224
The danger of not using the seat belt . . . . . . . . 22
Tightening torque of wheel bolts . . . . . . . . . . . 290
Tilting sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . 115
Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 257
Top Tether system . . . . . . . . . . . . . . . . . . . . . . . . 52
Tow starting General notes . . . . . . . . . . . . . . . . . . . . . . . 284
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 284
Towing a trailer . . . . . . . . . . . . . . . . . . . . . . . . . 289
Towing bracket . . . . . . . . . . . . . . . . . . . . . . . . . 212
Towing bracket, fitting . . . . . . . . . . . . . . . . . . . 213
Towing eye . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 284
Towing eyes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 286
Tow-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 284
Traction control system Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 89
Trailer Trailer towing . . . . . . . . . . . . . . . . . . . . . . . . 211
Trailer turn signals Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 125
Trailer weights . . . . . . . . . . . . . . . . . . . . . . . . . . 289 Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 83
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 125
Tyre Mobility System (Tyre repair kit) . . . . . . . . 265
Tyre Mobility-System (Tyre repair kit) . . . . . . . 258
Tyre pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . 249 Loss . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Tyre pressure monitoring . . . . . . . . . . . . . . . . . 250
Tyre pressure warning lamp . . . . . . . . . . . . . . . . 85
Tyre pressures . . . . . . . . . . . . . . . . . . . . . . . . . . 290
Tyre repair kit . . . . . . . . . . . . . . . . . . . . . . . 258, 265
Tyres and wheels Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . 254
Tyres service life . . . . . . . . . . . . . . . . . . . . . . . . 251
Tyres tread depth . . . . . . . . . . . . . . . . . . . . . . . 252
Tyres with directional tread pattern . . . . . . . . . 249
UUnderbody protection . . . . . . . . . . . . . . . . . . . . 220
Unlocking and locking Personalisation . . . . . . . . . . . . . . . . . . . . . . 103VVehicle battery . . . . . . . . . . . . . . . . . . . . . . . . . 246
Vehicle data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 288
Vehicle identification data . . . . . . . . . . . . . . . . 288
Vehicle identification number . . . . . . . . . . . . . 288
Vehicle MaintenanceExterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 216 Vehicle modifications . . . . . . . . . . . . . . . . . . . . 224
Vehicle paintwork
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . 217
Products for vehicle maintenance . . . . . . . 215
Vehicle tools Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . 257
Vehicle washing . . . . . . . . . . . . . . . . . . . . . . . . 216
Ventilation slits . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Volumetric sensor* Activation . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Deactivation . . . . . . . . . . . . . . . . . . . . . . . . 109
WWarning lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Warning lamps . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Warning messages in the display . . . . . . . . . . . 66
Warning reportsRed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66, 80
Yellow . . . . . . . . . . . . . . . . . . . . . . . . . . . 66, 81
Warning symbols . . . . . . . . . . . . . . . . . . . . . . . . 80
Warning triangle . . . . . . . . . . . . . . . . . . . . . . . . 155
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . 241
Washing by hand . . . . . . . . . . . . . . . . . . . . . . . 216
Washing with high pressure cleaners . . . . . . . 217
Water Warning message . . . . . . . . . . . . . . . . . . . . . 67
Water in the windscreen washer tank . . . . . . . 241
Wear indicators . . . . . . . . . . . . . . . . . . . . . . . . . 252
Wearing suitable shoes . . . . . . . . . . . . . . . . . . . 16
Altea_EN.book Seite 312 Donnerstag, 2. September 2010 2:00 14