check engine Seat Cordoba 2005 User Guide

138Your vehicle and the environment
Suggestion 3. Avoid driving at maximum speed
Try not to drive at maximum speed. The increase of fuel
consumption, exhaust pollution and noise is disproportionate at
high speeds.
The illustration shows the relation between consumption (l/100
km) and speed (km/h)
⇒fig. 101.
If only about 3 quarters of top speed is utilized, the fuel
consumption will be reduced by about half.
Suggestion 4. Decrease idling
It is worth switching off1)the engine in traffic jams, at railroad
crossings and at traffic lights with a long red light. The savings in
fuel after 30-40 seconds with the engine switched off is higher
than the fuel used to switch the engine on again.
K
Suggestion 5. Periodic revisions
Your fuel savings are guaranteed even before going on a trip with
periodic revisions by your Technical Service Centre. Proper engine
maintenance is not only a safety and maintenance issue but also a
fuel consumption issue.
Poor fine tuning of the engine may increase fuel consumption by
up to 10%.
Check the oil level every time you fill up. The oil consumption
depends largely on the engine load. Depending on the driving
style, the oil consumption can be up to 1.0 l/1000 km.
Another suggestion: You can also lower oil consumption by using
synthetic oils.
K
km/h
max
l/100km
B45-355PFig. 101
1)Statutory regulations must be respected.
D Dr
ri
iv
vi
in
ng
g aat
t hhi
ig
gh
h ssp
pe
ee
ed
ds
s dde
ec
cr
re
ea
as
se
es
s rro
oa
ad
d ssa
af
fe
et
ty
y.
.
K
W WA
AR
RN
NI
IN
NG
G

139 Your vehicle and the environment
Safety FirstControls and equipment Tips and Maintenance Technical Data
Suggestion 6. Avoid short drives
The engine and the catalytic converter must reach its optimum
functioning temperature in order to effectively reduce consumption
and toxic gas emissions.
The fuel consumption of a cold engine of a normal vehicle right
after the start is about 30-40 liters per 100 km. After about one
kilometer the consumption decreases to 20 liters. After about
f fo
ou
ur
r
kilometers the engine has warmed up and the consumption is
normal. For this reason, it is important to avoid short drives and
heating the vehicle’s engine when the vehicle is not moving. Drive
on quickly!
The ambient temperature also counts. The illustration shows the
difference in consumption (l/100km) for the same distance (km) at
+20°C and –10°C. Your vehicle’s consumption is higher in the
summer than in the winter
⇒fig. 102.K
Suggestion 7. Check the tyre pressure
Make sure that the tyres have always adequate pressure. Even half
a bar less increases the level of fuel consumption by 5 percent. If
the pressure is not correct, the tyres wear out faster due to an
excessive deformation and overheating which, in turn, will
decrease the driving performance.
Always check the tyre pressure when the tyre is cold.
In addition, do not drive year round with winter tyres. They make
more noise and increase fuel consumption by 10 percent. Change
to summer tyres on time.
K
Suggestion 8. Avoid unnecessary weight
Apart from driving habits and periodic revisions of your vehicle,
there are other ways to reduce fuel consumption:
A Av
vo
oi
id
d uun
nn
ne
ec
ce
es
ss
sa
ar
ry
y wwe
ei
ig
gh
ht
t
Every kilogram increases fuel consumption. For this reason, it is
worth checking your boot to avoid unnecessary weight.
Frequently, the roof rack will stay on the roof even though it is no
longer needed. Due to greater air resistance, an unloaded roof
rack at a speed of 100-120 km/h increases the consumption by
approx. 12%.
K
5+20°C –10°C
15 25km
30
l/100km
B45-356PFig. 102

140Your vehicle and the environment
Suggestion 9. Save electricity
The alternator generates electricity while driving. The more
electricity is used, the higher the fuel consumption.
The heated rear window, extra lights, the heater fan and air
conditioning* use a large amount of energy. The heated rear
window creates a consumption of approx. one liter for every 10
hours.
For this reason, disconnect electrical consumers as soon as they
are no longer needed. The alternator generates electricity when the
engine is running.
K
Suggestion 10. Written check-up
If you wish to reduce fuel consumption keep a trip book. It is not
much work and is worth while since it allows you to detect possible
consumption variations (positive or negative) on time and
intervene, if necessary. If you detect an increase in consumption
you should examine the driving conditions since the last filling.
K
T Tr
ra
ai
il
le
er
r tto
ow
wi
in
ng
g
What do you need to bear in mind when towing a trailer?
The vehicle is designed mainly to carry people and luggage.
However it may also be used to tow a trailer, as long as you fit it
with the technically appropriate equipment and you do not
exceed the maximum authorised weights
⇒“Technical Data”
chapter.Towing a trailer not only demands more from the car, but from the
driver too.
You should therefore strictly adhere to the service and running-in
instructions on the following pages.
T Te
ec
ch
hn
ni
ic
ca
al
l rre
eq
qu
ui
ir
re
em
me
en
nt
ts
s
•If the trailer to be towed has a 7-pin plug, an adapter cable can
be used which may be obtained in any Technical Service Centre.
Installation of a towing bracket at a later stage should be carried
out according to the instructions of the towing bracket
manufacturer.
I If
f aa ttr
ra
ai
il
le
er
r iis
s ffi
it
tt
te
ed
d aat
t aa lla
at
te
er
r sst
ta
ag
ge
e,
, yyo
ou
u ssh
ho
ou
ul
ld
d uus
se
e tth
he
e bbo
od
dy
y rre
ei
in
nf
fo
or
rc
ce
em
me
en
nt
t
s se
et
t dde
es
si
ig
gn
ne
ed
d bby
y SSE
EA
AT
T.
.
O Ot
th
he
er
rw
wi
is
se
e yyo
ou
u mma
ay
y sse
er
ri
io
ou
us
sl
ly
y dda
am
ma
ag
ge
e tth
he
e bbo
od
dy
y wwo
or
rk
k.
.
D Da
an
ng
ge
er
r oof
f aac
cc
ci
id
de
en
nt
t!
!
T To
o iin
ns
st
ta
al
ll
l tth
he
e tto
ow
w jjo
oi
in
nt
t,
, wwe
e rre
ec
co
om
mm
me
en
nd
d tth
ha
at
t yyo
ou
u vvi
is
si
it
t aa TTe
ec
ch
hn
ni
ic
ca
al
l SSe
er
rv
vi
ic
ce
e
C Ce
en
nt
tr
re
e.
.
K
W WA
AR
RN
NI
IN
NG
G

142Your vehicle and the environment
•In vehicles without air conditioning, the cooling system should
be reinforced if a towing device is fitted at a later stage.
Failure to do so will submit the engine to greater stress (steep
slopes, high temperatures, heavy towing loads, etc.) and result in
overheating of the engine. For more information, contact a
Technical Service Centre.
•When using a trailer on mountain routes you must bear in mind
that the tow loads given in the “Technical data” chapter are only
applicable for slopes of 10% to 12%. If you do not use the full tow
load you may drive up steeper slopes.
•The given trailer weights are only applicable for altitudes up
to 1000 m above sea level. As the engine output drops due to
the decreasing air density, the climbing ability must also be
reduced by 10% for each further 1000 m.
•Where possible make full use of the maximum permissible
drawbar weight on the ball of the towing bracket but do not exceed
it
⇒chapter “Technical Data”.
•While observing the permissible trailer and drawbar weight,
distribute the load in the trailer so that heavy objects are as near
as possible to the axle. The objects must also be secured so that
they cannot slip about.
•The tyre pressures on the towing vehicle must be adjusted for full
load conditions, and also check the pressures on the trailer.
•Headlight settings should be checked, with the trailer attached,
before beginning the journey and adjusted as necessary.
On vehicles with headlight beam control it is only necessary to turn
the knurled disc on the dash board in the appropriate direction.D Dr
ri
iv
vi
in
ng
g iin
ns
st
tr
ru
uc
ct
ti
io
on
ns
s
To obtain the best possible handling of vehicle and trailer, the
following should be noted:
• Try to avoid driving with an unladen vehicle and a loaded trailer.
If this cannot be avoided, only drive slowly to allow for the
unfavourable weight distribution.
• As driving stability of vehicle and trailer decreaseswhen the
speed increases do not drive at the maximum permissible top
speed in unfavourable road, weather or wind conditions –
particularly when going downhill.
In any case the speed must be reduced as soon as the trailer
shows the slightest sign of snaking. On no account try to stop the
snaking by accelerating.
• • FFo
or
r ssa
af
fe
et
ty
y rre
ea
as
so
on
ns
s oon
ne
e ssh
ho
ou
ul
ld
d nno
ot
t ddr
ri
iv
ve
e ffa
as
st
te
er
r tth
ha
an
n 880
0 kkm
m/
/h
h
( (5
50
0 mmp
ph
h)
).
. TTh
hi
is
s aal
ls
so
o aap
pp
pl
li
ie
es
s iin
n cco
ou
un
nt
tr
ri
ie
es
s wwh
he
er
re
e hhi
ig
gh
he
er
r ssp
pe
ee
ed
ds
s aar
re
e
p pe
er
rm
mi
it
tt
te
ed
d.
.
• Always brake in good time. If the trailer has an overrun brake,
apply the brakes gently at first then firmly. This will avoid the
jerking caused by the trailer wheels locking.
Change down before going down a steep hill so that the engine
can act as a brake.
• When a long climb in a low gear with extremely high engine revs
must be negotiated at exceptionally high ambient temperatures
the coolant temperature gauge must be observed. When the gauge
needle moves to the right end of the scale, the road speed must be
reduced immediately.
• The cooling effect of the radiator fan cannot be increased by
changing down, because the speed of the fan is not dependent on


154Care and maintenance
If the engine compartment is cleaned at any time with grease
removing solutions1)or if one has the engine washed, the anti-
corrosion compound is nearly always removed as well. It is
therefore essential to ask for durable preservation of all surfaces,
seams, joints and components in the engine compartment to be
carried out. This applies also when corrosion protected parts are
renewed.
F Fo
or
r tth
he
e ssa
ak
ke
e oof
f tth
he
e een
nv
vi
ir
ro
on
nm
me
en
nt
t
Because when washing the engine petrol, grease and oil deposits are
washed off, the dirty water must be cleaned by an oil separator. For this
reason engine washing should only be carried out in a workshop or filling
station.
K
Undercoating
The underside of the vehicle is coated with a special compound to
protect it from corrosion and damage.
However, as this protective layer becomes damaged when the
vehicle is in use, the protective coating under the body and on the
running gear should be examined at defined intervals – preferably
before and after the winter season – and any damage made good.N No
ot
te
e ffo
or
r vve
eh
hi
ic
cl
le
es
s wwi
it
th
h aa cca
at
ta
al
ly
yt
ti
ic
c cco
on
nv
ve
er
rt
te
er
r
Due to the high temperatures which occur in the afterburning
process, additional heat shields are fitted over the catalytic
converter. Underbody sealant must not be applied to these
shields, the catalytic converter or the exhaust pipes. Removal of
the heat shields is also not permissible.
K
Cavity preservation
All cavities on the vehicle which could be susceptible to corrosion
are given permanent protection at the factory.
This coating does not need checking or any subsequent treatment.
Should a small amount of wax run out of the cavities at high
ambient temperatures it can be removed with a plastic scraper and
some white spirit.
F Fo
or
r tth
he
e ssa
ak
ke
e oof
f tth
he
e een
nv
vi
ir
ro
on
nm
me
en
nt
t
If the wax which has run out is removed with clean petrol, heed the
environmental protection regulations.K
1)Only the correct cleaning solutions should be used – on no accountpetrol or Diesel.
N
Ne
ev
ve
er
r uus
se
e aad
dd
di
it
ti
io
on
na
al
l uun
nd
de
er
r ffl
lo
oo
or
r ppr
ro
ot
te
ec
ct
ti
io
on
n oor
r aan
nt
ti
i-
-c
co
or
rr
ro
os
si
io
on
n aag
ge
en
nt
ts
sf
fo
or
r
t th
he
e eex
xh
ha
au
us
st
t ssi
il
le
en
nc
ce
er
r,
, eex
xh
ha
au
us
st
t ppi
ip
pe
e,
, cca
at
ta
al
ly
ys
st
ts
s oor
r hhe
ea
at
t ssh
hi
ie
el
ld
ds
s.
. TTh
he
es
se
e
s su
ub
bs
st
ta
an
nc
ce
es
s cco
ou
ul
ld
d iig
gn
ni
it
te
e wwh
hi
il
ls
st
t tth
he
e vve
eh
hi
ic
cl
le
e iis
s iin
n mmo
ot
ti
io
on
n.
.
W
WA
AR
RN
NI
IN
NG
G

156Checking and refilling
Engine compartment
C
Ca
au
ut
ti
io
on
n
When topping up fluids do not confuse them with each other under any
circumstances, otherwise serious functional defects may occur.
F Fo
or
r tth
he
e ssa
ak
ke
e oof
f tth
he
e een
nv
vi
ir
ro
on
nm
me
en
nt
t
The ground underneath the vehicle should be checked regularly. If spots
caused by oil or other fluids can be seen, the vehicle should be taken to a
Technical Service Centre for checking.
K
•F Fo
or
r ssa
af
fe
et
ty
y rre
ea
as
so
on
ns
s tth
he
e bbo
on
nn
ne
et
t mmu
us
st
t aal
lw
wa
ay
ys
s bbe
e ppr
ro
op
pe
er
rl
ly
y ccl
lo
os
se
ed
d wwh
he
en
n tth
he
e
v ve
eh
hi
ic
cl
le
e iis
s mmo
ov
vi
in
ng
g.
. AAl
lw
wa
ay
ys
s cch
he
ec
ck
k tth
he
er
re
ef
fo
or
re
e aaf
ft
te
er
r ccl
lo
os
si
in
ng
g tth
he
e bbo
on
nn
ne
et
t tth
ha
at
t tth
he
e
l lo
oc
ck
k iis
s een
ng
ga
ag
ge
ed
d.
. TTh
hi
is
s iis
s tth
he
e cca
as
se
e wwh
he
en
n tth
he
e bbo
on
nn
ne
et
t iis
s ffl
lu
us
sh
h wwi
it
th
h tth
he
e
a ad
dj
ja
ac
ce
en
nt
t bbo
od
dy
y ppa
an
ne
el
ls
s.
.
•I
If
f yyo
ou
u ssh
ho
ou
ul
ld
d nno
ot
ti
ic
ce
e tth
ha
at
t tth
he
e llo
oc
ck
k iis
s nno
ot
t een
ng
ga
ag
ge
ed
d,
, sst
to
op
p tth
he
e vve
eh
hi
ic
cl
le
e
i im
mm
me
ed
di
ia
at
te
el
ly
y aan
nd
d ccl
lo
os
se
e tth
he
e bbo
on
nn
ne
et
t.
.
•G
Gi
iv
ve
en
n tth
he
e tty
yp
pe
e oof
f llo
oc
ck
k,
, tta
al
ll
l ppe
eo
op
pl
le
e mma
ay
y bbe
e iin
nj
ju
ur
re
ed
d.
.
K
W WA
AR
RN
NI
IN
NG
G
P Pa
ar
rt
ti
ic
cu
ul
la
ar
r cca
ar
re
e ssh
ho
ou
ul
ld
d bbe
e tta
ak
ke
en
n wwh
he
en
n wwo
or
rk
ki
in
ng
g iin
n tth
he
e een
ng
gi
in
ne
e cco
om
mp
pa
ar
rt
tm
me
en
nt
t!
!
•S
Sw
wi
it
tc
ch
h oof
ff
f een
ng
gi
in
ne
e,
, rre
em
mo
ov
ve
e iig
gn
ni
it
ti
io
on
n kke
ey
y.
.
•P
Pu
ul
ll
l hha
an
nd
db
br
ra
ak
ke
e oon
n ffi
ir
rm
ml
ly
y.
.
•M
Mo
ov
ve
e gge
ea
ar
r lle
ev
ve
er
r iin
nt
to
o nne
eu
ut
tr
ra
al
l oor
r,
, iin
n aau
ut
to
om
ma
at
ti
ic
c gge
ea
ar
rb
bo
ox
xe
es
s,
, iin
n ““P
P”
” ppo
os
si
it
ti
io
on
n.
.
•A
Al
ll
lo
ow
w een
ng
gi
in
ne
e tto
o cco
oo
ol
l oof
ff
f.
.
•A
As
s llo
on
ng
g aas
s tth
he
e een
ng
gi
in
ne
e iis
s aat
t oop
pe
er
ra
at
ti
in
ng
g tte
em
mp
pe
er
ra
at
tu
ur
re
e:
:
– –D
Do
o nno
ot
t ppu
ut
t yyo
ou
ur
r hha
an
nd
d iin
nt
to
o tth
he
e rra
ad
di
ia
at
to
or
r ffa
an
n,
, iit
t cco
ou
ul
ld
d ssw
wi
it
tc
ch
h oon
n ssu
ud
dd
de
en
nl
ly
y.
.
– –D
Do
o nno
ot
t oop
pe
en
n tth
he
e rra
ad
di
ia
at
to
or
r cca
ap
p bbe
ec
ca
au
us
se
e tth
he
e cco
oo
ol
li
in
ng
g ssy
ys
st
te
em
m iis
s uun
nd
de
er
r
p pr
re
es
ss
su
ur
re
e.
.
•N
Ne
ev
ve
er
r ssp
pi
il
ll
l aan
ny
y lli
iq
qu
ui
id
ds
s oov
ve
er
r tth
he
e hho
ot
t een
ng
gi
in
ne
e.
. TTh
he
es
se
e lli
iq
qu
ui
id
ds
s cco
ou
ul
ld
d iig
gn
ni
it
te
e.
.
W
WA
AR
RN
NI
IN
NG
G
•A Av
vo
oi
id
d cca
au
us
si
in
ng
g ssh
ho
or
rt
t cci
ir
rc
cu
ui
it
ts
s iin
n tth
he
e eel
le
ec
ct
tr
ri
ic
ca
al
l ssy
ys
st
te
em
m –– ppa
ar
rt
ti
ic
cu
ul
la
ar
rl
ly
y aat
t tth
he
e
b ba
at
tt
te
er
ry
y.
.
•I
If
f tte
es
st
ts
s hha
av
ve
e tto
o bbe
e cca
ar
rr
ri
ie
ed
d oou
ut
t wwi
it
th
h tth
he
e een
ng
gi
in
ne
e rru
un
nn
ni
in
ng
g,
, tta
ak
ke
e iin
nt
to
o aac
cc
co
ou
un
nt
t
t th
ha
at
t tth
he
er
re
e iis
s aan
n aad
dd
di
it
ti
io
on
na
al
l dda
an
ng
ge
er
r ppr
re
es
se
en
nt
t ffr
ro
om
m rro
ot
ta
at
ti
in
ng
g ppa
ar
rt
ts
s –– ee.
.g
g.
. rri
ib
bb
be
ed
d
b be
el
lt
ts
s,
, gge
en
ne
er
ra
at
to
or
r,
, rra
ad
di
ia
at
to
or
r ffa
an
n eet
tc
c.
. –– aan
nd
d ffr
ro
om
m tth
he
e hhi
ig
gh
h vvo
ol
lt
ta
ag
ge
e iig
gn
ni
it
ti
io
on
n
s sy
ys
st
te
em
m.
.
•I
If
f wwo
or
rk
k oon
n tth
he
e ffu
ue
el
l oor
r eel
le
ec
ct
tr
ri
ic
ca
al
l ssy
ys
st
te
em
m iis
s nne
ec
ce
es
ss
sa
ar
ry
y:
:
– –D
Di
is
sc
co
on
nn
ne
ec
ct
t tth
he
e bba
at
tt
te
er
ry
y ffr
ro
om
m tth
he
e vve
eh
hi
ic
cl
le
e eel
le
ec
ct
tr
ri
ic
cs
s
– –D
Do
o nno
ot
t ssm
mo
ok
ke
e
– –N
Ne
ev
ve
er
r wwo
or
rk
k nne
ea
ar
r nna
ak
ke
ed
d ffl
la
am
me
es
s
– –A
Al
lw
wa
ay
ys
s kke
ee
ep
p aa ffi
ir
re
e eex
xt
ti
in
ng
gu
ui
is
sh
he
er
r iin
n tth
he
e vvi
ic
ci
in
ni
it
ty
y.
.
•A
At
tt
te
en
nt
ti
io
on
n mmu
us
st
t bbe
e ppa
ai
id
d tto
o tth
he
e wwa
ar
rn
ni
in
ng
gs
s ggi
iv
ve
en
n iin
n tth
hi
is
s MMa
an
nu
ua
al
l aan
nd
d tto
o tth
he
e
g ge
en
ne
er
ra
al
ll
ly
y aap
pp
pl
li
ic
ca
ab
bl
le
e ssa
af
fe
et
ty
y rre
eg
gu
ul
la
at
ti
io
on
ns
s.
.
W
WA
AR
RN
NI
IN
NG
G ((c
co
on
nt
ti
in
nu
ue
ed
d)
)

157 Checking and refilling
Safety FirstControls and equipment Tips and Maintenance Technical Data
Petrol engine
1Coolant surge tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
2Dipstick . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 160
3Oil filler hole . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 160
4Brake fluid reservoir . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
5Vehicle’s battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 165
6Windscreen washer container . . . . . . . . . . . . . . . . . . . . . 169
The components layout may change in relation to the engine.
N No
ot
te
e
Remember the previous page warnings.K
Diesel engine
1Coolant surge tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
2Dipstick . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 160
3Oil filler hole . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 160
4Brake fluid reservoir . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
5Vehicle’s battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 165
6Windscreen washer container . . . . . . . . . . . . . . . . . . . . . 169
The components layout may change in relation to the engine.
N No
ot
te
e
Remember the previous page warnings.K
142356
IBN-021
FirsCo
IBN-022Fig. 118Fig. 119

158Checking and refilling
E
En
ng
gi
in
ne
e ooi
il
l
Specifications
The engine comes with a special, high quality, multi grade oil that
can be used in all seasons of the year except for those regions
affected by extreme cold.
As the use of high quality oil is essential for the correct operation
of the engine and its long useful life, when topping up or
replacement is necessary use only those oils that conform to the
requirements of the VW standards.
If it is not possible to find oil conforming to the VW standards then
oil conforming to the ACEA or API standards with an appropriate
viscosity at atmospheric temperature should be used instead. The
use of this type of oil may have some repercussions on the
performance of the engine for example, long starting time,
increased consumption and a higher emission level.
If a top up is required then different oils may be mixed as long as
they all conform to the VW standards.
The specifications (VW standards) set out in the following page
should appear on the container of the service oil; the container will
display together the different standards for petrol and diesel
engines, the oil can be used for both types of engines.
K
Oil properties
V Vi
is
sc
co
os
si
it
ty
y
The viscosity class is selected according to the diagram above. If
atmospheric temperature falls outside of the described limits for
only a short period then an oil change is not necessary.
B1H-149Fig. 120


159 Checking and refilling
Safety FirstControls and equipment Tips and Maintenance Technical Data
P
Pe
et
tr
ro
ol
l een
ng
gi
in
ne
e
D Di
ie
es
se
el
l een
ng
gi
in
ne
eM Mo
on
no
o-
-g
gr
ra
ad
de
e ooi
il
l
Mono-grade oils cannot be used throughout the whole year due to
their limited range of viscosity
2).
These oils are only useful in a climate that is constantly very cold or
very warm.
E En
ng
gi
in
ne
e ooi
il
l aad
dd
di
it
ti
iv
ve
es
s
No type of additive should be mixed with the engine oil. The
deterioration caused by these additives is not covered by the
guarantee.
N No
ot
te
e
Before a long trip, we recommend finding an engine oil that conforms to the
corresponding VW specifications and keeping it in the vehicle. In this way
the required oil will be available if needed.
K
D De
en
no
om
mi
in
na
at
ti
io
on
nS
Sp
pe
ec
ci
if
fi
ic
ca
at
ti
io
on
nC
Co
om
mm
me
en
nt
ts
s
A – synthetic oilVW 502 00 /Dated after
VW 500 00 1-97
B –
mineral oilVW 501 01Dated after
1-97
A/B –
multi-grade oilACEA A2 ó A3 or Dated after
even API SH/SJ 1-97
D De
en
no
om
mi
in
na
at
ti
io
on
nS
Sp
pe
ec
ci
if
fi
ic
ca
at
ti
io
on
nC
Co
om
mm
me
en
nt
ts
s
A – synthetic oilVW 505 011)Dated after
1-97
B –
mineral oilVW 505 00Dated after
1-97
A/B –
multi-grade oilACEA A2 ó A3 or Dated after
even API CD/CF 1-97
1)Diesel engines that have fuel injection based on a fuel injector pump should use only
oil specification VW 505 01. Avoid the use of any other oil type than VW 505 01 for this
engine. Warning! Possible engine damage!
2)Viscosity: Oil density

160Checking and refilling
Checking oil level
Every engine uses a certain amount of oil. The oil consumption can
be up to 1.0 litres per 1000 km. The engine oil level must therefore
be checked at regular intervals, preferably when filling the tank
and before a long journey.
The location of the dipstick
Acan be determined from the
illustrations on page 157.
The vehicle must be on a level surface when checking the oil level.
After stopping engine wait a few minutes for the oil to drain backto
the sump.
Then pull the dipstick out, wipe it with a clean cloth and insert
again.
Then pull dipstick out again and check the oil level:
aOilm mu
us
st
tbe topped up. Afterwards it suffices when the oil level
is somewhere in area b.
bOilc ca
an
nbe topped up. It can then happen that the oil level is in
area c.
cOilm mu
us
st
t nno
ot
tbe topped up.
When the engine is working hard such as in sustained high-speed
motorway cruising in summer, when towing a trailer or when
climbing mountain passes, the oil level should be kept at area
c
– – nno
ot
t aab
bo
ov
ve
e.
.K
Topping up engine oil
Unscrew the cap from oil filler opening Band pour oil in 0.5 litres
at a time. Then check level with the dipstick.
O On
n nno
o aac
cc
co
ou
un
nt
t ssh
ho
ou
ul
ld
d tth
he
e ooi
il
l lle
ev
ve
el
l bbe
e aab
bo
ov
ve
e aar
re
ea
a
c.
. OOt
th
he
er
rw
wi
is
se
e ooi
il
l
c ca
an
n bbe
e ddr
ra
aw
wn
n iin
nt
to
o tth
he
e een
ng
gi
in
ne
e vvi
ia
a tth
he
e ccr
ra
an
nk
kc
ca
as
se
e bbr
re
ea
at
th
he
er
r aan
nd
d
e es
sc
ca
ap
pe
e iin
nt
to
o tth
he
e aat
tm
mo
os
sp
ph
he
er
re
e vvi
ia
a tth
he
e eex
xh
ha
au
us
st
t ssy
ys
st
te
em
m.
. OOn
n vve
eh
hi
ic
cl
le
es
s
f fi
it
tt
te
ed
d wwi
it
th
h aa cca
at
ta
al
ly
yt
ti
ic
c cco
on
nv
ve
er
rt
te
er
r,
, tth
he
e ooi
il
l cco
ou
ul
ld
d bbu
ur
rn
n iin
ns
si
id
de
e tth
he
e
c co
on
nv
ve
er
rt
te
er
r cca
au
us
si
in
ng
g iit
t tto
o bbe
ec
co
om
me
e dda
am
ma
ag
ge
ed
d.
.
Carefully close the filler cap and push the oil dipstick in as far as
possible, this will prevent oil spill when the engine is running.
K
AB c
b
aTO8-038AFig. 121
W Wh
he
en
n tto
op
pp
pi
in
ng
g uup
p tth
he
e ooi
il
l,
, ddo
o nno
ot
t ssp
pi
il
ll
l iit
t oon
nt
to
o hho
ot
t een
ng
gi
in
ne
e cco
om
mp
po
on
ne
en
nt
ts
s ––
d da
an
ng
ge
er
r oof
f ffi
ir
re
e.
.
W
WA
AR
RN
NI
IN
NG
G