catalytic converter Seat Cordoba 2005 Owner's Manual

120Driving
S
St
ta
ar
rt
ti
in
ng
g tth
he
e een
ng
gi
in
ne
e
General notes
• Before starting, move gear lever to neutral (with automatic
gearbox, selector lever in “P” or “N” position) and apply handbrake
firmly.
• On vehicles with a manual gearbox depress the clutch pedal
when operating starter so that starter only has to turn engine.
• As soon as engine starts, release the ignition key so that starter
can disengage.
• After starting a cold engine it may sound noisy for a moment or
two because the oil pressure has to build up in the hydraulic
tappets first. This is normal and no cause for alarm.
F Fo
or
r tth
he
e ssa
ak
ke
e oof
f tth
he
e een
nv
vi
ir
ro
on
nm
me
en
nt
t
Do not warm the engine up by running it when the vehicle is stationary.
Begin driving the vehicle as soon as possible.
C Ca
au
ut
ti
io
on
n
• Do not over-rev or use full throttle until the engine has reached the normal
operating temperature.
• On vehicles with a catalytic converter the engine must not be started by
towing the vehicle in excess of 50 m. Otherwise unburned fuel can pass into
the converter and lead to damage.
• Before trying to start the engine by towing, an attempt should be made, if
possible, to use the battery of another vehicle
⇒"Emergency starting"
chapter.K
Petrol engines
The engine is equipped with a fuel injection system that
automatically supplies the correct air/fuel mixture.
When engine i is
s cco
ol
ld
d oor
r aat
t oop
pe
er
ra
at
ti
in
ng
g tte
em
mp
pe
er
ra
at
tu
ur
re
e
do n no
ot
t
accelerate
before or during the starting procedure.
If the engine does not start at once, stop using the starter after 10
seconds. Wait about half a minute and then try again.
If the engine still does not start, the electric fuel pump fuse may
have blown
⇒ "Fuses" chapter".
When the engine i is
s vve
er
ry
y hho
ot
t
it may be necessary to accelerate
slightly after the engine has started.
K
W Wh
he
en
n rru
un
nn
ni
in
ng
g tth
he
e een
ng
gi
in
ne
e iin
n cco
on
nf
fi
in
ne
ed
d ssp
pa
ac
ce
es
s tth
he
er
re
e iis
s aa dda
an
ng
ge
er
r oof
f
p po
oi
is
so
on
ni
in
ng
g.
.
W
WA
AR
RN
NI
IN
NG
G

122Driving
Valid for all versions with catalytic converter*
C
Ca
au
ut
ti
io
on
n
Do not switch off the ignition while the vehicle is in motion with a gear
engaged; otherwise unburned fuel may go into the converter, where it
would burn and cause overheating, which would damage the converter.
K
C
Cr
ru
ui
is
se
e cco
on
nt
tr
ro
ol
l ssy
ys
st
te
em
m*
*
Description
To relieve the foot on the accelerator pedal this system can hold
any speed above around 30 km/h constant, so far as this is
permitted by engine output.
C Ca
au
ut
ti
io
on
n
When the system is switched on do not move into neutral without de-
pressing the clutch pedal, otherwise the engine will race and can, under
certain circumstances, become damaged.
N No
ot
te
e
On vehicles with an automatic gearbox, the Cruise Control System isonly
active when the gear selector is in position D D, 3
3or 2
2. If any other position
(P P, N
N, R
Ror 1
1) is selected while driving, the last speed to be stored is deleted
and the system is switched off.K
– – tth
he
e cco
oo
ol
la
an
nt
t tte
em
mp
pe
er
ra
at
tu
ur
re
e iin
nc
cr
re
ea
as
se
es
s ddu
ue
e tto
o hhe
ea
at
t bbu
ui
il
ld
d-
-u
up
p
– – wwh
he
en
n tth
he
e een
ng
gi
in
ne
e iis
s hho
ot
t aan
nd
d tth
he
e een
ng
gi
in
ne
e cco
om
mp
pa
ar
rt
tm
me
en
nt
t iis
s hhe
ea
at
te
ed
d
a ad
dd
di
it
ti
io
on
na
al
ll
ly
y bby
y sst
tr
ro
on
ng
g ssu
un
nl
li
ig
gh
ht
t.
.
S Sp
pe
ec
ci
ia
al
l cca
ar
re
e mmu
us
st
t tth
he
er
re
ef
fo
or
re
e bbe
e tta
ak
ke
en
n wwh
he
en
n wwo
or
rk
ki
in
ng
g iin
n tth
he
e een
ng
gi
in
ne
e
c co
om
mp
pa
ar
rt
tm
me
en
nt
t.
.
K
W WA
AR
RN
NI
IN
NG
G ((c
co
on
nt
ti
in
nu
ue
ed
d)
)
T Th
he
e ccr
ru
ui
is
se
e cco
on
nt
tr
ro
ol
l ssy
ys
st
te
em
m ssh
ho
ou
ul
ld
d nno
ot
t bbe
e uus
se
ed
d iin
n dde
en
ns
se
e ttr
ra
af
ff
fi
ic
c aan
nd
d ppo
oo
or
r rro
oa
ad
d
c co
on
nd
di
it
ti
io
on
ns
s ((s
sl
li
ip
pp
pe
er
ry
y ssu
ur
rf
fa
ac
ce
es
s,
, aaq
qu
ua
ap
pl
la
an
ni
in
ng
g,
, ggr
ra
av
ve
el
l)
).
.
W
WA
AR
RN
NI
IN
NG
G

127 Refuelling
Safety FirstControls and equipment Tips and Maintenance Technical Data
T
Ti
ip
ps
s aan
nd
d MMa
ai
in
nt
te
en
na
an
nc
ce
e
R
Re
ef
fu
ue
el
ll
li
in
ng
g
F
Fi
il
ll
li
in
ng
g tth
he
e tta
an
nk
k
General notes
The filler neck is located in the rear right-side panel.
The fuel tank cap turns freely to prevent it’s opening without a key.
Open the cover, hold the cap with one hand and next introduce the
key in the lock and turn it 180° to the left. At this moment the cap
should unscrew in a counter-clockwise direction.To close, screw the cap to the right until you hear a "click". Turn the
key without releasing the cap clockwise 180°. Remove the key and
close the cover.
The tank holds about 45 liters.
F Fo
or
r tth
he
e ssa
ak
ke
e oof
f tth
he
e een
nv
vi
ir
ro
on
nm
me
en
nt
t
As soon as the automatic nozzle, correctly operated, disconnects for the
first time, the tank is full. Do not continue filling since the expansion space
would be occupied. If it heats up the fuel could overflow.
After filling the tank, screw cap and close tank flap until it engages.
The cap is tied to an anti-loss cord.
N No
ot
te
e
Any fuel spillage should be wiped off the paint finish immediately, as the
paint could otherwise be damaged, especially if it is RME (“biodiesel”) fuel.
C
Ca
au
ut
ti
io
on
n
On vehicles with a catalytic converter, never drive until the fueltank is
completely empty. The irregular fuel supply can cause misfiring. This allows
unburnt fuel into the exhaust system, which can cause overheating and
damage to the catalyst.
K
CON-009Fig. 99

128Refuelling
P
Pe
et
tr
ro
ol
l
In the chapter “Technical Data” and on the inside of the tank flap
you will find information on the correct octane rating for your
engine.
K
General notes
•Unleaded petrol must comply with DIN EN1)228 and leaded
petrol with
DIN 51 600.
•If, in an emergency, the octane rating of the available petrol is
lower than that required by the engine, only drive with medium
engine speeds and low engine loading. H Hi
ig
gh
h een
ng
gi
in
ne
e llo
oa
ad
di
in
ng
g wwi
it
th
h
f fu
ul
ll
l tth
hr
ro
ot
tt
tl
le
e oor
r hhi
ig
gh
h rre
ev
vs
s cca
an
n cca
au
us
se
e een
ng
gi
in
ne
e dda
am
ma
ag
ge
e.
.
Fill tank with
petrol of the correct octane rating as soon as possible.
•Fuel with a higher octane rating than that required by the engine
can be used without limitation. There are, however, no advantages
regarding output and consumption.
F Fo
or
r tth
he
e ssa
ak
ke
e oof
f tth
he
e een
nv
vi
ir
ro
on
nm
me
en
nt
t
Even one tankful of leaded petrol will detract from the efficiency ofthe
catalytic converter.
N No
ot
te
e
See chapter “Filling the tank”.K
Petrol additives
The quality of the fuel has a decisive influence upon the running
behavior, performance and service life of the engine. The additives
which are mixed into the petrol are of particular significance. Itis
therefore advisable only to use good q qu
ua
al
li
it
ty
y ppe
et
tr
ro
ol
l cco
on
nt
ta
ai
in
ni
in
ng
g
a ad
dd
di
it
ti
iv
ve
es
s.
.
K
D
Di
ie
es
se
el
l
Diesel
Diesel fuel must correspond to DIN EN1)590.
C
CZ
Z2
2)
)n
no
o llo
ow
we
er
r tth
ha
an
n 449
9.
.K
RME fuel (“diester”)
According to norm DIN 51 6063).
Vehicles with diesel engines can also run on
R RM
ME
E ffu
ue
el
l (Rapeseed
Methyl Ester).
Ask your Technical Service Centre or automobile club where
biodiesel is available.
See chapter "Filling the tank".
K
1)European norm2)Cetan-Zahl (Cetane Number). Measure of diesel fuel ignitability.3)DIN preliminary Norm

136Your vehicle and the environment
After the running-in period
•On vehicles with a rev counter* the maximum permissible engine
speed is shown by the beginning of the red zone on the rev
counter scale. The needle of the counter must not move into this
zone.
Extremely high engine revs will be automatically governed.
K
C Cl
le
ea
an
ni
in
ng
g tth
he
e eex
xh
ha
au
us
st
t ffu
um
me
es
s
Description
T
Th
he
e ppe
er
rf
fe
ec
ct
t ffu
un
nc
ct
ti
io
on
ni
in
ng
g oof
f tth
he
e ccl
le
ea
an
ni
in
ng
g ssy
ys
st
te
em
m ffo
or
r eex
xh
ha
au
us
st
t ffu
um
me
es
s
is of great importance for the environment-friendly functioning of
your vehicle.
Therefore, keep in mind the following points:
•Versions with a catalytic converter must only use unleaded fuel
⇒"Filling the tank" chapter.
•In vehicles with a catalytic converter never drive until the fuel
tank is completely empty. Irregular fuel supply can cause misfiring,
thus allowing unburned fuel into the exhaust system which can
cause overheating and damage to the catalyst.
•If you experience starting difficulties, loss of power or engine
problems while driving, the cause could be a failure in the ignition.
In this case, fuel may be entering the exhaust system withoutburning and, in this way being released into the atmosphere.
Furthermore, the catalyst could deteriorate due to overheating.
Reduce speed immediately. Have this problem fixed at the nearest
Technical Service Centre.
•Do not overload the engine with oil
⇒"Engine oil" chapter.
•Do not towstartthe vehicle for more than 50 m
⇒"Tow
start/towing" chapter.
N No
ot
te
e
Even when the cleaning system for exhaust fumes is in perfect working
order, under certain circumstances, the fumes may smell like sulfur.
This depends on the percentage of sulfur in the fuel.
Often it is sufficient to change brands or buy super unleaded.
K
•D Du
ue
e tto
o ppo
os
ss
si
ib
bl
le
e hhi
ig
gh
h tte
em
mp
pe
er
ra
at
tu
ur
re
es
s oof
f tth
he
e cca
at
ta
al
ly
ys
st
t,
, ddo
o nno
ot
t ppa
ar
rk
k iin
n
p pl
la
ac
ce
es
s wwh
he
er
re
e tth
he
e cca
at
ta
al
ly
ys
st
t iis
s eea
as
si
il
ly
y eex
xp
po
os
se
ed
d tto
o iin
nf
fl
la
am
mm
ma
ab
bl
le
e mma
at
te
er
ri
ia
al
l.
.
•D
Do
o nno
ot
t uus
se
e aad
dd
di
it
ti
io
on
na
al
l ppr
ro
ot
te
ec
ct
ti
io
on
n ffo
or
r tth
he
e bbo
od
dy
y oor
r aan
nt
ti
ic
co
or
rr
ro
os
si
iv
ve
e ppr
ro
od
du
uc
ct
ts
s ffo
or
r
s su
um
mp
ps
s aan
nd
d eex
xh
ha
au
us
st
t ppi
ip
pe
es
s,
, c
ca
at
ta
al
ly
yt
ti
ic
c cco
on
nv
ve
er
rt
te
er
rs
s oor
r hhe
ea
at
t ssh
hi
ie
el
ld
ds
s.
.T
Th
he
e
a ab
bo
ov
ve
e mme
en
nt
ti
io
on
ne
ed
d mma
at
te
er
ri
ia
al
l cco
ou
ul
ld
d iig
gn
ni
it
te
e wwh
hi
il
le
e ddr
ri
iv
vi
in
ng
g.
.
W
WA
AR
RN
NI
IN
NG
G

139 Your vehicle and the environment
Safety FirstControls and equipment Tips and Maintenance Technical Data
Suggestion 6. Avoid short drives
The engine and the catalytic converter must reach its optimum
functioning temperature in order to effectively reduce consumption
and toxic gas emissions.
The fuel consumption of a cold engine of a normal vehicle right
after the start is about 30-40 liters per 100 km. After about one
kilometer the consumption decreases to 20 liters. After about
f fo
ou
ur
r
kilometers the engine has warmed up and the consumption is
normal. For this reason, it is important to avoid short drives and
heating the vehicle’s engine when the vehicle is not moving. Drive
on quickly!
The ambient temperature also counts. The illustration shows the
difference in consumption (l/100km) for the same distance (km) at
+20°C and –10°C. Your vehicle’s consumption is higher in the
summer than in the winter
⇒fig. 102.K
Suggestion 7. Check the tyre pressure
Make sure that the tyres have always adequate pressure. Even half
a bar less increases the level of fuel consumption by 5 percent. If
the pressure is not correct, the tyres wear out faster due to an
excessive deformation and overheating which, in turn, will
decrease the driving performance.
Always check the tyre pressure when the tyre is cold.
In addition, do not drive year round with winter tyres. They make
more noise and increase fuel consumption by 10 percent. Change
to summer tyres on time.
K
Suggestion 8. Avoid unnecessary weight
Apart from driving habits and periodic revisions of your vehicle,
there are other ways to reduce fuel consumption:
A Av
vo
oi
id
d uun
nn
ne
ec
ce
es
ss
sa
ar
ry
y wwe
ei
ig
gh
ht
t
Every kilogram increases fuel consumption. For this reason, it is
worth checking your boot to avoid unnecessary weight.
Frequently, the roof rack will stay on the roof even though it is no
longer needed. Due to greater air resistance, an unloaded roof
rack at a speed of 100-120 km/h increases the consumption by
approx. 12%.
K
5+20°C –10°C
15 25km
30
l/100km
B45-356PFig. 102

143 Your vehicle and the environment
Safety FirstControls and equipment Tips and Maintenance Technical Data
the engine speed. One should therefore not change down even
when towing a trailer as long as the engine can cope without the
vehicle speed dropping too much.
K
General notes
• • DDu
ur
ri
in
ng
g tth
he
e rru
un
nn
ni
in
ng
g iin
n ppe
er
ri
io
od
d yyo
ou
u ssh
ho
ou
ul
ld
d aav
vo
oi
id
d tto
ow
wi
in
ng
g aa ttr
ra
ai
il
le
er
r iif
f
p po
os
ss
si
ib
bl
le
e.
.
• • IIt
t iis
s aad
dv
vi
is
sa
ab
bl
le
e tto
o hha
av
ve
e tth
he
e vve
eh
hi
ic
cl
le
e sse
er
rv
vi
ic
ce
ed
d bbe
et
tw
we
ee
en
n tth
he
e
I In
ns
sp
pe
ec
ct
ti
io
on
n iin
nt
te
er
rv
va
al
ls
s iif
f iit
t iis
s uus
se
ed
d ffr
re
eq
qu
ue
en
nt
tl
ly
y ffo
or
r tto
ow
wi
in
ng
g aa ttr
ra
ai
il
le
er
r.
.
• The trailer and drawbar load figures on the data plate of the
towing bracket are for test certification only. The correct figuresfor
the vehicle, which may be lower than the above figures, are given
in the vehicle documents and in this manual.
• When using the towing device the car’s empty weight is reduced,
and as a result its effective load is decreased.
• Observe all statutory requirements regarding the use of a
trailer.
K
D Dr
ri
iv
vi
in
ng
g aab
br
ro
oa
ad
d
Observations
If the vehicle is to be taken abroad, the following must also be
borne in mind:
• If the vehicle has a petrol engine and catalytic converter, one
must ensure that unleaded petrol will be available during the
journey
⇒"Filling the tank" chapter. The automobile clubs offer
information about the unleaded filling station network.
•In some countries it is possible that a vehicle model is sold under
conditions where some spare parts are not available or that the
Technical Services may only carry out limited repairs.
SEAT importers and distributors will gladly provide information
about the technical preparation of your vehicle in addition to
necessary maintenance and repair possibilities.
K
Cover headlights
When the vehicle is used in a country which drives on the opposite
side of the road to the home country, the asymmetric dipped
headlights will dazzle oncoming traffic.
To prevent this, the areas of the headlight lenses shown in the
illustration must be covered with an opaque adhesive strip.
When using a sharp object (i.e. a razor blade) to cut the tape, do
not do this directly on the headlights as you may scratch them.


154Care and maintenance
If the engine compartment is cleaned at any time with grease
removing solutions1)or if one has the engine washed, the anti-
corrosion compound is nearly always removed as well. It is
therefore essential to ask for durable preservation of all surfaces,
seams, joints and components in the engine compartment to be
carried out. This applies also when corrosion protected parts are
renewed.
F Fo
or
r tth
he
e ssa
ak
ke
e oof
f tth
he
e een
nv
vi
ir
ro
on
nm
me
en
nt
t
Because when washing the engine petrol, grease and oil deposits are
washed off, the dirty water must be cleaned by an oil separator. For this
reason engine washing should only be carried out in a workshop or filling
station.
K
Undercoating
The underside of the vehicle is coated with a special compound to
protect it from corrosion and damage.
However, as this protective layer becomes damaged when the
vehicle is in use, the protective coating under the body and on the
running gear should be examined at defined intervals – preferably
before and after the winter season – and any damage made good.N No
ot
te
e ffo
or
r vve
eh
hi
ic
cl
le
es
s wwi
it
th
h aa cca
at
ta
al
ly
yt
ti
ic
c cco
on
nv
ve
er
rt
te
er
r
Due to the high temperatures which occur in the afterburning
process, additional heat shields are fitted over the catalytic
converter. Underbody sealant must not be applied to these
shields, the catalytic converter or the exhaust pipes. Removal of
the heat shields is also not permissible.
K
Cavity preservation
All cavities on the vehicle which could be susceptible to corrosion
are given permanent protection at the factory.
This coating does not need checking or any subsequent treatment.
Should a small amount of wax run out of the cavities at high
ambient temperatures it can be removed with a plastic scraper and
some white spirit.
F Fo
or
r tth
he
e ssa
ak
ke
e oof
f tth
he
e een
nv
vi
ir
ro
on
nm
me
en
nt
t
If the wax which has run out is removed with clean petrol, heed the
environmental protection regulations.K
1)Only the correct cleaning solutions should be used – on no accountpetrol or Diesel.
N
Ne
ev
ve
er
r uus
se
e aad
dd
di
it
ti
io
on
na
al
l uun
nd
de
er
r ffl
lo
oo
or
r ppr
ro
ot
te
ec
ct
ti
io
on
n oor
r aan
nt
ti
i-
-c
co
or
rr
ro
os
si
io
on
n aag
ge
en
nt
ts
sf
fo
or
r
t th
he
e eex
xh
ha
au
us
st
t ssi
il
le
en
nc
ce
er
r,
, eex
xh
ha
au
us
st
t ppi
ip
pe
e,
, cca
at
ta
al
ly
ys
st
ts
s oor
r hhe
ea
at
t ssh
hi
ie
el
ld
ds
s.
. TTh
he
es
se
e
s su
ub
bs
st
ta
an
nc
ce
es
s cco
ou
ul
ld
d iig
gn
ni
it
te
e wwh
hi
il
ls
st
t tth
he
e vve
eh
hi
ic
cl
le
e iis
s iin
n mmo
ot
ti
io
on
n.
.
W
WA
AR
RN
NI
IN
NG
G

239 General index
Topping up engine oil . . . . . . . . . . . . . . . . . . . 160
Tow loads . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208
Tow start/towing . . . . . . . . . . . . . . . . . . . . . . .202
Traction Control System (TCS)* . 51, 77, 131, 134
Trailer indicators* . . . . . . . . . . . . . . . . . . . . . 53
Trailer towing . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Trolley jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . 204
Turn signal bulb . . . . . . . . . . . . . . . . . . . . . . . 193
Tyre life . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 176
Tyre pressure . . . . . . . . . . . . . . . . . . . . . . . . . . 208
U
U
Undercoating . . . . . . . . . . . . . . . . . . . . . . . . .154
Up to 1,000 kilometres . . . . . . . . . . . . . . . . . . 135
Upholstery cloth and textile trim . . . . . . . . . . 152
Using air conditioner economically . . . . . . . . 108
Using the handbrake . . . . . . . . . . . . . . . . . . . 118
V V
Valid for all versions with catalytic
converter* . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Vehicle hoist . . . . . . . . . . . . . . . . . . . . . . . . . . 204
Vehicle identification data . . . . . . . . . . . . . . . 210
Vehicle tools . . . . . . . . . . . . . . . . . . . . . . . . . . 173
Vents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Visibility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Volumetric sensor* . . . . . . . . . . . . . . . . . . . . . 64
W W
Warning lamps . . . . . . . . . . . . . . . . . . . . . . . . 47
Warnings on handling the battery . . . . . . . . . 165
Washing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 149
Washing the vehicle by hand . . . . . . . . . . . . . 150
Washing vehicle with high pressure cleaner . 150Ways to secure a child seat . . . . . . . . . . . . . . 26
Weights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208
What can have a negative effect on the
brakes? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
What do you need to bear in mind when
towing a trailer? . . . . . . . . . . . . . . . . . . . . . . . 140
Wheel bolts . . . . . . . . . . . . . . . . . . . . . . . . . . . 179
Wheel trims . . . . . . . . . . . . . . . . . . . . . . . . . . . 181
Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 175
When are the Air Bags activated? . . . . . . . . . 19
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 151
Windscreen washer . . . . . . . . . . . . . . . . . 80, 169
Winter tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . 179
Wiper blades . . . . . . . . . . . . . . . . . . . . . . . . . .81
Y
Y
Your vehicle and the environment . . . . . . . . . 135