air condition Seat Ibiza 5D 2006 Maintenance programme

SEAT maintenance program
8SEAT maintenance programUsing these instructionsThis programme will indicate the work that should be pe riodically carried out
on your vehicle in order to maintain the safety, reliability and lifetime condi-
tions required.
Using the “vehicle identification” data or the data in this document, the
correct spare parts for your vehicle will be specified in ca se of repairs; even
many years following the initial purchase.
We recommend that you keep this maintenance programme with the vehicle
documents. The Proof of service is one of the fundamental r equirements for
warranty rights.
The maintenance programme shows the date of delive ry and this indicates
the beginning of the vehicle guarantee.Maintenance ProgramThe SEAT maintenance programme is composed of di fferent inspection serv-
ices carried out according to the time since the vehi cle purchase or the
mileage.
Each Inspection Service as well as an y required additional operation already
has a pre-established work time. This will allow you to know the total cost of
the service beforehand.
. The SEAT Service Centre network is equipped with modern technology and
well-trained specialists. Many SEAT Service Centres offer different value
service packages
Adverse weather conditionsThe Service Centre “service consultant” will inform you of any necessary addi-
tional work within the intervals defined by the Inspection Ser vice depending
on the conditions and the environment in which the vehicle is used. For
example, for an oil change where the vehicle is use d only for frequent short
journeys or is subject to extreme temperatures. Likewis e, when the vehicle is
used in dusty conditions the air, dust and pollen filter cartridges must be
changed more often and the timing belt checked.Diesel fuelThe Service Centre “service consultant” can provide inf ormation about which
countries use fuel with a high sulphur content. In th ese cases, the oil must be
changed every 7,500 km / 4,650 miles.
Caution
•
Vehicles with the label “UNSUITABLE FOR BIODIESEL” on th e fuel cover
cannot be driven using biodiesel.
•
To be certain if your vehicle can be used with biodiesel according to the
DIN EN 14214 (FAME) standard consult your Serv ice Centre.
•
DIN is a German abbreviation for “Deutsches Institut für Normug e.V.”, the
German standards institute.
•
EN means European Norm.
•
FAME is the English abbreviation “F atty Acid Methyl Ester”
dsfsd Seite 8 Mittwoch, 3. Mai 2006 5:05 17

Inspection Service general programme
12•
Test drive: Check brake operation, handbrake, gearbo x operation,
steering system operation, kick-down (for autom atic gearbox), air condi-
tioning and sliding roof.
•
Interior and glove compartment lighti ng, lighter/socket, warning lights
and horn: Check operation.
•
Tyres, including the spare wheel: Check the profile, tread wear indicator
and pressure.
•
Headlights: Check adjustment.
•
Windscreen and headlights washer system: Check operation and for
possible damage, top up.
•
Sun roof: Check operation, clean drains and grease guides.
•
Service interval indicator on the instrument panel: Re set.
•
Door and tailgate hinges: Lubricate.
•
Undercarriage protection: Visual damage inspection
•
Steering servo: Check oil level.
Additional workIn addition to the Inspection Service, additional maint enance jobs may have
to be carried out, depending on the conditions in which y our vehicle is used
and depending on the equipment level of your vehicle. Th is additional work
should be carried out in accordance with time/dista nce travelled to ensure
your vehicle remains reliable. Your Serv ice Centre will provide detailed infor-
mation about the additional work that may be neces sary. These can be done
independently of the obligatory services, taking int o account the notes in the
Maintenance Programme (or the label: Next service). Your SEAT Service
Centre will be happy to advise you and quote the p rices for this additional work. Additional jobs completed are marked on the w
orkshop sheet with the
receipt.
Every 7,500 km•
Engine oil and oil filter: Replacement (engines using high sulphur content
diesel).
Every 30,000 km•
Air filter: Clean the housing and replace the filter element (Ibiz a Cupra
only).
•
Fuel filter: Clean.
•
Fuel filter: Replacement (only diesel engines using biodi esel, or using fuel
that does not comply to the DIN EN 590 standard)
•
Dust and pollen filter for the passenger compartment : Replacement.
•
Manual gearbox: Check the oil level (for cases of perme ability).
Every 60,000 km•
Automatic gearbox (Gearbox): Check the ATF level.
•
Fuel filter: Replacement (only diesel engines using fuel conforming to the
DIN EN 590 standard)
•
Air filter: Clean the housing and replace the filter element.
dsfsd Seite 12 Mittwoch, 3. Mai 2006 5:05 17

Inspection Service general programme13
•
Spark plugs: Replacement.
Every 90,000 km / 55,800 Miles (the first
time around) then, every 30,000 km / 18,600 miles•
Camshaft timing belt: Check condition and replace if necessary (petrol
engines only).
Every 120,000 km•
particulate filter: Veri fy (1.9 TDI engines)
•
Camshaft timing belt: Replacement (T DI engines with injector pump).
Every 150,000 km•
particulate filter: Verify (1.4 TDI engines)
•
Camshaft timing belt: Replacement (TDI and SDI engin es).
Every 180,000 km•
Camshaft timing belt: Replacement (4 cylinder petrol en gines 20
valves).
Every 240,000 km•
Tension roller for the camshaft timing belt: Replacement (TDI engines with
injector pump).
Every 2 years•
Brake fluid: Replace
•
Dust and pollen filter for the passenger compartment: R eplace (only for
vehicles with less than 30,000 km).
Every 4 years•
Air filter: Clean the housing and replace the filter element (only f or vehi-
cles with less than 60,000 km).
•
Puncture repair kit: Check the expiry date on the sealing c ompound and
replace if necessary.
•
Spark plugs: Replace (only for vehicles with less than 60, 000 km).
dsfsd Seite 13 Mittwoch, 3. Mai 2006 5:05 17

Warranty
16WarrantyFault-free operation warrantyAccording to the clauses of the guarantee applied to SEAT vehicles in the
sales contract, a A fault-free operation guarantee of 2 years in accor dance
with legal requirements is provided.
2) 3)
We must insist that it is understood that natural wear a s well as damage
caused by the abuse of the vehicle benefits by inap propriate use or by unac-
ceptable modifications are excluded from the w arranty. The warranty is no
longer valid, also when the vehicle is damaged by th e use of parts and acces-
sories that are not SEAT approved or damage due to ignoring the mainte-
nance and repair requirements.Paintwork and body warrantyAuthorised Service Centres provide a warranty on bodywork
and paintwork for vehicles sold in the EU.In addition to the warranty conditions for brand new S EAT vehicles (as
detailed in the purchase contract), a defined period warranty i s also provided
covering paintwork and body through-rusting:•
3 year paintwork warranty following delivery date (ex cept the Alhambra
model).
•
12 years from the date of delivery against bodywork thr ough-rusting (6
years for the Alhambra).
I f , h o w e v e r , t h i s t y p e o f d a m a g e s h o u l d o c c u r, i t w i l l b e r e p a i r e d f r e e o f c h a r g e
including parts and labour by any SEAT Authorised Servic e Centre in Europe.
Warranty claims will not be accepted in the follow ing circumstances:
•
if damage is caused by external influence or careless ness, or
•
damage to the body or paintwork is not repaired promptly and appropri-
ately in accordance with the manufacturer's instructio ns using genuine,
approved spare parts and materials, or
•
if perforation rusting is caused by the use of non-genuine p arts and mate-
rials for body repairs and if these repair s were not carried out in accordance
with the manufacturer's instructions.
If the bodywork is repaired or painted, your Authorise d Service Centre will
confirm your warranty against throug h-rusting for the repaired sections.
Approved SEAT spare partsThe approved spare parts, according to the manufact urer specifications,
represent an additional available service and facilitating the replacement of
entire assemblies, in general: lighte r engine, gearbox, cylinder heads,
control units, electric elements, etc.
Of course these are Approved parts and, as they have the same class as the
manufacturer parts, they avail of the same SEAT approve d spare parts
warranty.
2)The warranty is not available for all export mark ets. For information, please ask for in-
formation at the SEAT Authorised Service Centre.3)As well as the legally required guarantee, SEA T offers an extended guarantee to their
clients in some European countries. The specific c onditions of this extended guaran-
tee are detailed in the vehicle sales contract .
dsfsd Seite 16 Mittwoch, 3. Mai 2006 5:05 17