maintenance Seat Ibiza SC 2011 Owner's Guide

199
Checking and refilling levels
Engine oil specification ⇒ page 197.
WARNING
Oil is highly inflammable! Ensure that no oil comes into contact with hot
engine components when topping up.
CAUTION
If the oil level is above the area A do not start the engine. This could result
in damage to the engine and catalytic converter. Contact a specialised work-
shop.
For the sake of the environment
The oil level must never be above area A. Otherwise oil can be drawn in
through the crankcase breather and escape into the atmosphere via the ex-
haust system. 
Changing engine oil
The engine oil must be changed at the intervals given in the
service schedule. We recommend that you have the engine oil changed by an Authorised
Service Centre.
The oil change intervals are shown in the Maintenance Programme.
WARNING
Only change the oil yourself if you have the specialist knowledge re-
quired!
● Before opening the bonnet, read and observe the warnings
⇒ page 193, Safety instructions on working in the engine compartment.
● Wait for the engine to cool down. Hot oil may cause burn injuries.
● Wear eye protection to avoid injuries caused by splashes of oil.
● When removing the oil drain plug with your fingers, keep your arm
horizontal to help prevent oil from running down your arm.
● Wash your skin thoroughly if it comes into contact with engine oil.
● Engine oil is poisonous! Used oil must be stored in a safe place out of
the reach of children.
CAUTION
No additives should be used with engine oil. This could result in engine
damage. Any damage caused by the use of such additives would not be
covered by the factory warranty.
For the sake of the environment
● Because of the disposal problems, the necessary special tools and spe-
cialist knowledge required, we recommend that you have the engine oil and
filter changed by an Authorised Service Centre.
● Never pour oil down drains or into the ground.
● Use a suitable container when draining the used oil. It must be large
enough to hold all the engine oil. 
Safety FirstOperating InstructionsPractical TipsTechnical Specifications

206Checking and refilling levels
WARNING
Before opening the bonnet to check the brake fluid level, read and ob-
serve the warnings ⇒ page 193.

Changing the brake fluid
The Maintenance Programme indicates the brake fluid
change intervals. We recommend that you have the brake fluid changed by an Authorised
Service Centre.
Before opening the bonnet, please read and follow the warnings ⇒ 
in
Safety instructions on working in the engine compartment on page 193 in
section “Safety notes for working in the engine compartment”.
Brake fluid absorbs moisture. In the course of time, it will absorb water from
the ambient air. If the water content in the brake fluid is too high, the brake
system could corrode. This also considerably reduces the boiling point of
the brake fluid. Heavy use of the brakes may then cause a vapour lock
which could impair the braking effect.
It is important that you use only brake fluid compliant with US standard
FMVSS 116 DOT 4. We recommend the use of Genuine SEAT brake fluid.
WARNING
Brake fluid is poisonous. Old brake fluid impairs the braking effect.
● Before opening the bonnet to check the brake fluid level, read and ob-
serve the warnings ⇒ page 193.
WARNING (Continued)
● Brake fluid should be stored in the closed original container in a safe
place out of reach of children. There is a toxic risk.
● Complete the brake fluid change according to the Maintenance Pro-
gramme. Heavy use of the brakes may cause a vapour lock if the brake
fluid is left in the system for too long. This would seriously affect the effi-
ciency of the brakes and the safety of the vehicle. This may cause an ac-
cident.
CAUTION
Brake fluid could damage the paintwork. Wipe off any brake fluid from the
paintwork immediately.
For the sake of the environment
The brake pads and fluid must be collected and disposed of according the
applicable regulations. The SEAT Technical Service network has the neces-
sary equipment and qualified personnel for collecting and disposing of this
waste material. 

208Checking and refilling levels
CAUTION
● Never disconnect the battery if the ignition is switched on or if the en-
gine is running. This could damage the electrical system or electronic com-
ponents.
● Do not expose the battery to direct sunlight over a long period of time,
as the intense ultraviolet radiation can damage the battery housing.
● If the vehicle is left standing in cold conditions for a long period, protect
the battery from freezing. If it freezes it will be damaged. 
Checking the electrolyte level
The electrolyte level should be checked regularly in high-
mileage vehicles, in hot countries and in older batteries. – Open the engine bonnet and the battery cover ⇒ 
in Safety in-
structions on working in the engine compartment on page 194
⇒ 
in Warnings on handling the battery on page 207. For vehi-
cles with the battery under the spare wheel, open the tailgate
and lift the floor covering. The battery is located next to the
spare wheel.
– Check the colour display in the "magic eye" on the top of the
battery.
– If there are air bubbles in the window, tap the window gently
until they disperse.
The position of the battery is shown in the corresponding engine compart-
ment diagram ⇒ page 250. The location of the battery in the luggage com-
partment can be seen in ⇒ fig. 175.
The “magic eye” indicator, located on the top of the battery changes colour,
depending on the charge state and electrolyte level of the battery. There are two different colours:
●
Black: correct charge status.
● Transparent/clear yellow: the battery must be replaced. Contact a spe-
cialist workshop. 
Charging and changing the vehicle battery
The battery is maintenance-free and is checked during the
inspection service. All work on the vehicle battery requires
specialist knowledge.
If you often drive short distances or if the vehicle is not driven for long peri-
ods, the battery should be checked by a specialised workshop between the
scheduled services.
If the battery has discharged and you have problems starting the vehicle,
the battery might be damaged. If this happens, we recommend you have
the vehicle battery checked by an Authorised Service Centre where it will be
re-charged or replaced.
Charging the battery
The vehicle battery should be charged by a specialised workshop only, as
batteries using special technology have been installed and they must be
charged in a controlled environment.
Replacing a vehicle battery
The battery has been developed to suit the conditions of its location and
has special safety features.
Genuine SEAT batteries fulfil the maintenance, performance and safety
specifications of your vehicle. 

209
Checking and refilling levels
WARNING
● We recommend you use only maintenance-free or cycle free leak-proof
batteries which comply with standards T 825 06 and VW 7 50 73. This
standard applies as of 2001.
● Before starting any work on the batteries, you must read and observe
the warnings ⇒ 
in Warnings on handling the battery on page 207.
For the sake of the environment
Batteries contain toxic substances such as sulphuric acid and lead. They
must be disposed of appropriately and must not be disposed of with ordi-
nary household waste. 
Wheels
General notes
Avoiding damage
– If you have to drive over a kerb or similar obstacle, drive very
slowly and at a right angle.
– Keep grease, oil and fuel off the tyres.
– Inspect the tyres regularly for damage (cuts, cracks or blisters,
etc.). Remove any foreign objects embedded in the treads.
Storing tyres
– When you remove the tyres, mark them in order to maintain the
same direction of rotation when they are installed again. –
When removed, the wheels and/or tyres should be stored in a
cool, dry and preferably dark location.
– Store tyres in a vertical position if they are not fitted on wheel
rims.
New tyres
New tyres must be run in ⇒ page 166.
The tread depth of new tyres may vary, according to the type and make of
tyre and the tread pattern.
Concealed damage
Damage to tyres and rims is often not readily visible. If you notice unusual
vibrations or the vehicle pulling to one side, this may indicate that one of
the tyres is damaged. The tyres should be checked immediately by an Au-
thorised Service Centre.
Tyres with directional tread pattern
An arrow on the tyre sidewall indicates the direction of rotation on tyres with
directional tread. Always observe the direction of rotation indicated when
fitting the wheel. This guarantees optimum grip and helps to avoid aqua-
planing, excessive noise and wear.
WARNING
● New tyres do not have maximum grip during the first 500 km. Drive
particularly carefully to avoid possible accidents.
● Never drive with damaged tyres. This may cause an accident.
● If you notice unusual vibrations or if the vehicle pulls to one side
when driving, stop the vehicle immediately and check the tyres for dam-
age.

Safety FirstOperating InstructionsPractical TipsTechnical Specifications

246Description of specifications
Technical Specifications
Description of specifications
Important information
Important
The information in the vehicle documentation always has
precedence. All technical specifications provided in this manual are valid for the stand-
ard model in Spain. The vehicle data card included in the Maintenance Pro-
gramme or the vehicle registration documents shows which engine is instal-
led in the vehicle.
The figures may be different depending on if additional equipment is fitted,
for different models, for special vehicles and for other countries.
Abbreviations used in the Technical Specifications section
Abbrevia- tionMeaning
kWKilowatt, engine power measurement.
PSPferdestärke (horsepower), formerly used to denote engine
power.
rpmRevolutions per minute - engine speed.NmNewton metres, unit of engine torque.l/100 kmFuel consumption in litres per 100 km.g/kmCarbon dioxide emissions in grams per km travelled.CO2Carbon dioxide
Abbrevia-
tionMeaning
CNCetane number, indication of the diesel combustion power.
RONResearch octane number, indication of the knock resistance
of petrol.

247
Description of specifications
Vehicle identification data
The most important information is given on the identifica-
tion plate and the vehicle data sticker.
Fig. 173 Vehicle data
sticker (luggage compart-
ment)
Vehicles for certain export countries do not have an identification plate.
Identification plate
The identification plate is located on the left rib inside the engine compart-
ment.
Vehicle identification number
The vehicle identification number (chassis number) can be read from out-
side the vehicle through a viewer in the windscreen. This is located on the left-hand side of the vehicle in the lower area of the windscreen. It is also
located on the right hand side of the engine compartment.
Vehicle data
The data sticker is placed on the inside of the spare wheel well, in the lug-
gage compartment and on the rear cover of the Maintenance Programme.
The following information is provided on the vehicle data sticker:
⇒ fig. 173
Production control number
Vehicle identification number (chassis number)
Model code number
Model designation / engine power output
Engine and gearbox code letters
Paintwork number / interior trim code
Optional equipment codes
Consumption values
CO 2 emissions values
At the end of the data sticker, in points 8 and 9, you can see the con-
sumption and emission information.
Information on consumption and emissions 1)
Urban consumption (l/100 km)
Urban CO 2 emissions (g/km)
Extra-urban consumption (l/100 km)
Extra-urban CO 2 emissions (g/km)
Combined consumption (l/100 km)
Combined CO 2 emissions (g/km)

1
23456789
A
B
C
1)
The values are not valid for certain countries. In such cases, the fields are marked with “X”.
Safety FirstOperating InstructionsPractical TipsTechnical Specifications

248Description of specifications
Information on fuel consumption
Fuel consumption
The consumption and emission details shown on the vehicle
data sticker differ from one vehicle to another.
The vehicle's fuel consumption and CO 2 emissions can be consulted on the
vehicle data sticker in the spare wheel well, inside the luggage compart-
ment and on the rear cover of the Maintenance Programme.
The fuel consumption and CO 2 emission values refer to the weight category
assigned to your vehicle according to the engine and gearbox combination,
as well as the specific equipment fitted, and is only used to compare be-
tween the different models.
The fuel consumption and CO 2 emissions do not depend only on the per-
formance of the vehicle, they can also differ from the established values de-
pending on other factors such as driving style, road conditions, traffic con-
ditions, environmental conditions, load and number of passengers.
Calculation of fuel consumption
The consumption values have been calculated based on measurements per-
formed or supervised by certified CE laboratories according to the latest ver-
sion of directives 715/2007/EC and 80/1268/CEE (for more information
consult the European Union Publications Office at EUR-Lex: © European Un-
ion, http://eur-lex.europa.eu/en/index.htm) and are valid for the kerb
weight indicated for the vehicle.
Note
In practice, and considering all the factors mentioned here, consumption
values can differ from those calculated in the current European regulations. Weights
Kerb weight refers to the basic model with a fuel tank filled to 90% capacity
and without optional extras. The figure quoted includes 75 kg to allow for
the weight of the driver.
For special versions and optional equipment fittings or for the addition of
accessories, the weight of the vehicle will increase
⇒ 
.
WARNING
● Please note that the centre of gravity may shift when transporting
heavy objects; this may affect the vehicle's handling and lead to an acci-
dent. Always adjust your speed and driving style to suit road conditions
and requirements.
● Never exceed the gross axle weight rating or the gross vehicle weight
rating. If the allowed axle load or the allowed total weight is exceeded,
the driving characteristics of the vehicle may change, leading to acci-
dents, injuries and damage to the vehicle.

Towing a trailer Trailer weights
Trailer weight
The trailer weights and drawbar loads approved are selected in intensive tri-
als according to precisely defined criteria. The approved trailer weights are
valid for vehicles in the EU for maximum speeds of 80 km/h (in certain cir-
cumstances up to 100 km/h). The figures may be different in other coun-
tries. All data in the official vehicle documents take precedence over these
data ⇒ 
. 

K
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
L
Leather cleaning . . . . . . . . . . . . . . . . . . . . . . . . 181
Leaving Home function . . . . . . . . . . . . . . . . . . . 97
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Load compartment in the luggage compart- ment
see Loading the luggage compartment . . . 16
Loading the luggage compartment . . . . . . . . . . 16
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 178
LPG . . . . . . . . . . . . . . . . . . . . . . . . . . 54, 140, 189
LPG system Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Filler neck adapter . . . . . . . . . . . . . . . . . . . 190
Level indicator . . . . . . . . . . . . . . . . . . . . . . . 54
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . 189
Luggage compartment . . . . . . . . . . . . . . . . . . . 123 see also Loading the luggage compartment . .16
Luggage compartment light . . . . . . . . . . . . . . 240
Luggage compartment light* . . . . . . . . . . . . . 102
M
Main beam . . . . . . . . . . . . . . . . . . . . . . . . . 94, 100
Main beam headlights Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . 71
Maintenance Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 Maintenance and cleaning . . . . . . . . . . . . . . . 174
Manual gearbox . . . . . . . . . . . . . . . . . . . . . . . . 144
Manual heating . . . . . . . . . . . . . . . . . . . . . . . . 126
controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Manual heating system Defrosting the windscreen . . . . . . . . . . . . . 126
Demisting the windscreen and side win-dows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
MFI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Mirrors Exterior mirrors . . . . . . . . . . . . . . . . . . . . . . 108
Interior mirror . . . . . . . . . . . . . . . . . . . . . . . 106
vanity mirror . . . . . . . . . . . . . . . . . . . . . . . . 103
Mobile phone . . . . . . . . . . . . . . . . . . . . . . . . . . 184
Multifunction display . . . . . . . . . . . . . . . . . . . . . 57
N
Number of seats . . . . . . . . . . . . . . . . . . . . . . . . . 18
O
Observations . . . . . . . . . . . . . . . . . . . . . . . . . . 171
Octane number . . . . . . . . . . . . . . . . . . . . . . . . . 192
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Oil change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 199
Oil properties . . . . . . . . . . . . . . . . . . . . . . . . . . 197
One-touch opening and closing Electric windows . . . . . . . . . . . . . . . . . . . . . . 90
Opening and locking . . . . . . . . . . . . . . . . . . . . . 87 Operation when a fault occurs
Panorama/ tilting sunroof . . . . . . . . . . . . . . 93
Outside temperature display . . . . . . . . . . . . 56, 58
Overview Control lamps . . . . . . . . . . . . . . . . . . . . . . . . 61
Dash panel . . . . . . . . . . . . . . . . . . . . . . . . . . 51
Indicator lamps . . . . . . . . . . . . . . . . . . . . . . 64
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . 53
Warning lamps . . . . . . . . . . . . . . . . . . . . 61, 64
P
Paintwork Polishing . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
Panorama sunroof . . . . . . . . . . . . . . . . . . . . . . . 91
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 153
Parking lights . . . . . . . . . . . . . . . . . . . . . . . . . . 100
Passenger see Correct sitting position . . . . . . . 10, 11, 12
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192 Driving abroad . . . . . . . . . . . . . . . . . . . . . . 171
Petrol additives . . . . . . . . . . . . . . . . . . . . . . . . 192
Physical principles of a frontal collision . . . . . . 20
Plastic parts . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
Plastic parts cleaning . . . . . . . . . . . . . . . . . . . . 180
Pollen filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 133
Pollution filter . . . . . . . . . . . . . . . . . . . . . . . . . . 133
Products for vehicle maintenance . . . . . . . . . . 174
271
Index

Vehicle interior heating or cooling system . . . 129
Vehicle modifications . . . . . . . . . . . . . . . . . . . 183
Vehicle paintworkMaintenance . . . . . . . . . . . . . . . . . . . . . . . . 177
Products for vehicle maintenance . . . . . . . 174
Vehicle tools Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . 215
Vehicle washing . . . . . . . . . . . . . . . . . . . . . . . . 175
Ventilation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
Ventilation slits . . . . . . . . . . . . . . . . . . . . . . . . . 17
W Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Warning lamps . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Warning reports Red . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Yellow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Warning symbols . . . . . . . . . . . . . . . . . . . . . . . . 64
Warning triangle . . . . . . . . . . . . . . . . . . . . . . . . 122
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . 202
Washing by hand . . . . . . . . . . . . . . . . . . . . . . . 175
Washing the vehicle . . . . . . . . . . . . . . . . . . . . . 175
Washing tunnel . . . . . . . . . . . . . . . . . . . . . . . . 175
Washing with high pressure cleaners . . . . . . . 176
Water in the windscreen washer tank . . . . . . . 202
Wear indicators . . . . . . . . . . . . . . . . . . . . . . . . 211
Wearing suitable shoes . . . . . . . . . . . . . . . . . . . 16
Wheel bolts . . . . . . . . . . . . . . . . . . . . . . . . 218, 249 Tightening torque . . . . . . . . . . . . . . . . . . . . 213
Wheel change . . . . . . . . . . . . . . . . . . . . . . . . . . 216 Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . 209, 249
Why assume the correct sitting position? . . . . . 29
Why should head restraints be correctly adjus-
ted? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Why wear seat belts? . . . . . . . . . . . . . . . 18, 20, 29
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Windscreen defrosting . . . . . . . . . . . . . . . . . . . 126
Windscreen washer fluid Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 67
Windscreen wiper blades Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . 178
Windscreen wipers . . . . . . . . . . . . . . . . . . . . . . 103 Changing blades . . . . . . . . . . . . . . . . . . . . 203
Changing the rear wiper blade . . . . . . . . . 204
Winter driving Diesel engine . . . . . . . . . . . . . . . . . . . . . . . 193
Winter tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Wooden trim cleaning . . . . . . . . . . . . . . . . . . . 181
Working in the engine compartment . . . . . . . 193
274 Index