fuel Seat Ibiza ST 2010 Maintenance programme

Service information5
First serviceYour Official SEAT Service will place a cros s on the service that your vehicle requires.Vehicle delivery documentation from the Of ficial SEAT Service
If diesel with a high sulphur content is used, the fuel filter and the oil should
be changed every 7,500 km (5,000 miles) ⇒ page 8. Your Official SEAT
S e r v i ce wi ll b e a b l e t o t e ll y o u w h i ch co u n t r i e s ha v e d i e s e l wi t h a h i g h s u l p h u r
content.
Before delivery, your vehicle was inspected a ccording to factory guidelines.
This ensures that driving will be a pleasure from the very beginning.
The agent will provide you with the following in formation when the vehicle is
delivered:•Running-in
•Changing the brake fluid•Service intervals, in particular information on what constitutes severe
operating conditions ⇒page 7Note
•Using diesel fuel with a high sulphur conten t may significantly reduce the
useful life of the diesel particulate filter.
c
LongLife Service (PR no. QG1)
c
Service dependent on time/
distance travelled (PR no.:QG0 or QG2)
Interval Service
According to flexible service interval displ ay
(after 2 years at the latest). Oil Change Service
According to service interval display (every 15,000 km/10,000 miles
or every year - whichever comes first)
Delivery inspection carried out:
Date: Official SEAT Service stamp
Prog Manto Ibizas-Alteas_EN.book Seite 5 Dienstag, 14. September 2010 11:40 11

Service information
6•If LongLife engine oil is not used, th e service dependent on time/distance
travelled then applies. In this case, an oil c hange service will have to be
carried out every 15,000 km (10,000 miles) or every year.Importance of the Maintenance ProgrammeThe Maintenance Programme confirms the date of deliv ery of
your vehicle and thus the beginning of its warranty cover.The vehicle data that appears in the Maintenance Programme guarantees
that the appropriate Genuine SEAT
® Parts are installed. This data helps
ensure that your car can be repaired without difficulty even after many years
of use.
The Maintenance Programme also informs you of which service should be
carried out when, and the work this entails.
Your Official SEAT Service will note down in this booklet the services carried
out.
Your Maintenance Programme should be kept in the vehicle with the on-
board documentation so that it is at han d whenever you need it.
Please remember to give the Maintenanc e Programme to the new owner if
you sell your car.
The SEAT Service Centre network is equ ipped with modern workshop tech-
nology and well-trained specialists. Many S EAT Service Centres offer different
service packages at special prices
Safety notesAll fluids and consumables , such as timing belts, tyres, coolant liquid, en gine
oil, spark plugs and vehicle batteries are cont inuously being developed.
Therefore, we recommend you take the veh icle to a qualified workshop to
have fluids or consumables changed. The Official SE AT Services receive
regular up-to-date information about mo difications. This is why SEAT recom-
mends you have fluids and other consumables replaced by an Official SEAT
Service.
Unless the vehicle is regularly and correctly s erviced as required in the
service plan, the vehicle could breakdown wh ile driving, leading to serious
accident and injury.•S e r v i c e s s h o u l d b e c a r r i e d o u t b y a q u a l i f i e d w o r k s h o p i n a c c o r d a n ce w i t h
the Maintenance Programme.•Please observe the instructions for use.Note
•Only use suitable fluids. Fluids should nev er be mixed up. This could
result in serious faults and engine dama ge.•SEAT is not responsible for damage to the v ehicle as a result of the use of
poor quality fuel, inadequate servicing o r non-availability of original spare
parts.•Spilt brake fluid may pollute the environme nt. If fluids leak or are spilt,
they should be collected and disposed of a ccordingly.•Regular servicing of your vehicle not only helps to ensure it remains in
good working order but also contributes to road safety. Therefore, we recom-
mend work is carried out in accordance with the Maintenance Programme.
Prog Manto Ibizas-Alteas_EN.book Seite 6 Dienstag, 14. September 2010 11:40 11

SEAT maintenance programme7
SEAT maintenance programmeService intervalsGeneral informationTo ensure that you have each service carrie d out on time and that none are
forgotten, there is a reminder sticker on the dr iver side door pillar and a
reminder will also be shown via the serv ice interval display on the instrument
panel.
The service intervals quoted are for vehicles used under normal operating
conditions .
However, if the vehicle is used in adverse conditions, it may require work
before the next established service int erval or even between service inter-
vals.
Adverse conditions include:•the use of fuel with a high sulphur content•frequent short journeys•leaving the engine idling for long periods o f time (as occurs with taxis)•driving on dusty roads or in dusty areas•frequently using the vehicle for towing•mainly driving in the city, in heavy traffic whe re it is necessary to continu-
ously brake and start, and•using the vehicle mainly in the winter
This particularly affects:•the air filter
•the timing belt•the engine oil and•the diesel particulate filter
In some countries diesel fuel has a high sulp hur content; in these cases the
fuel filter and the oil should be changed every 7 ,500 km (5,000 miles)
⇒ page 8. Your Official SEAT Service will b e able to tell you which countries
have diesel with a high sulphur content.
The service advisor at your Official SEAT Ser vice will advise you on the need
to carry out additional work on your vehicle, t aking into account the usage
conditions of the vehicle.
A list of the work to be carried out at the SEAT services is given on the
following pages. These services are valid at the time of printing and can be
subject to further modifications for technical reaso ns. Your Official SEAT
Service always has the latest available in formation and will be able to tell
you if your vehicle requires any other additio nal inspections established by
law.
The cost of the SEAT service may vary, depen ding on the vehicle type, equip-
ment fitted, additional work and statutor y inspections. Your Official SEAT
Service will tell you how much the SEAT serv ice will cost (labour and parts).
Prog Manto Ibizas-Alteas_EN.book Seite 7 Dienstag, 14. September 2010 11:40 11

SEAT maintenance programme
8IntervalsPlease see the oil specifications given in th e Instruction Manual.
In ⇒ page 9, “General Service Programme” you wil l find the work corre-
sponding to each service.
LongLife Service
Thanks to the technology used at SEAT, with the LongLife Service, an Interval
Service only has to be carried out when it is necessary.
The length of the service intervals is also deter mined by factors such as
conditions under which the vehicle is used and personal driving style.
If LongLife engine oil is not used, the service depende nt on time/distance
travelled then applies . In this case, an oil change service will have to be carried out every 15,000 km (10,000 miles)
or every year. This also applies
if you reprogramme the vehicle to the ser vice dependent on time/distance
travelled
Note
In addition to the Inspection and Interval Se rvices, additional work should be
carried out according to the time/distance trav elled ⇒page 11.
Service
Service type
LongLife Service (PR no. QG1) Service dependent on time/
distance travelled (PR no.:QG0 or QG2)
Oil Change Service
a)
a)Under certain circumstances differen t services can be carried out at the same time (Oil Change and In terval Services in combination with the Inspection Service). This w ay, any work
quoted twice will only be billed o nce.
See ⇒page 8, “LongLife Service” According to service interval display
(every year or
every 15,000 km/10,000 miles)
b)c)
b)If diesel with a high sulphur content is used, the fuel filter and the oil should be changed every 7,500 km (5,000 miles). Yo u r O f f ic ia l S E AT S e r vi ce w i ll b e abl e t o te l l y o u w h i ch co u n t r i e s
have diesel with a high sulphur content.c)Whichever comes first.Interval service
a)
According to flexible service
interval display
( maximum after 2 years)
b)
Every 2 years or
every 30,000 km (20,000 miles)
b) c)
Inspection Service
a)
First service after 3 years or at 60,000 km (4 0,000 miles)
c), and then every 2 years
c)/60.000 km (40,000 miles)
Changing the brake fluid First change after 3 years, then every 2 years (we recommend using only genuine SEAT brake fluid)
Prog Manto Ibizas-Alteas_EN.book Seite 8 Dienstag, 14. September 2010 11:40 11

General Service Programme9
General Service ProgrammeOil change serviceOperations to be carried out on your vehic le•Check the thickness of brake pads and the condition of front and rear
brake discs.•Change the engine oil and replace the oil f ilter.
1)
•The date of the next service is entered on th e service sticker which is
attached to the driver side door pillar•The service interval display is resetInterval serviceOperations to be performed on your vehicl e:•Check the battery.•Check the depth of the tyre tread (incl. the s pare wheel), that tread wear
is even, check the age and pressure of the ty res. Where applicable, adjust the
tyre pressure monitor.•Brake system inspected for leaks and dama ge.•Check the brake fluid level and wear of pads .•Check the thickness of brake pads and the condition of front and rear
brake discs.
•Check the correct operation of the front and rear lighting, the turn signals,
the hazard warning lights, the daytime dr iving lights, the static cornering
lights and the automatic dipped beam contr ol (where applicable) and the
horn.•Check if the windscreen is damaged.•Check the coolant and anti-freeze liquid an d top up as required.•Inspect the engine and components of the en gine compartment (from
above) for leaks and damage.•Inspect the engine and components of the en gine compartment, the
gearbox, the transmission, the final driv e (especially flanges) and the track
rod boots (from below) for leaks and damag e.•Change the engine oil and replace the oil filter
1).
•Check the expiry date of the puncture kit tyr e sealant (where applicable)
and record; check whether the bottle is d amaged and the level of the sealant.•Check the windscreen wipers and headligh t washers (where applicable)
operate correctly; check the blades, the res t position, the final position and
for possible damage, and top up the washe r fluid as required.•The headlight adjustment is checked•The date of the next service is entered on th e service sticker which is
attached to the driver side door pillar•The service interval display is reset.
1)If diesel with a high sulphur conten t is used, the fuel filter and the oil shoul d be
changed every 7,500 km (5,000 miles). Your Technical Service will be able to tell you
which countries have diesel with a h igh sulphur content.
Prog Manto Ibizas-Alteas_EN.book Seite 9 Dienstag, 14. September 2010 11:40 11

General Service Programme11
additional tasks. The service advisor at you r Official SEAT Service will advise
you accordingly.Additional tasksIn addition to the Inspection Service, addit ional maintenance jobs may have
to be carried out, depending on the conditions in which your vehicle is used
and on the equipment carried. This add itional work should be carried out in
accordance with time/distance travelled to ensure your vehicle remains reli-
able. Your Service Centre will provide de tailed information about the addi-
tional work that may be necessary. This can be done independently of the
obligatory services, taking into account the no tes on the Maintenance
Programme (or the label: Next service). Y our SEAT Service Centre will be
happy to advise you and quote the prices for th is additional work. Additional
jobs completed are marked on the work shop sheet with the receipt.Every 7,500 km (5,000 miles)•Replace the fuel filter in TDI
® diesel engines that use diesel with a sulphu r
content of more than 2,000 ppm.
Every 15,000 km (10,000 miles)•Replace the rubber bearings of the engine c over (only engines with
engine codes CDLA and CDLD).•LPG installation filter
2): Replace. Only engines with LPG (engine c ode
CHGA).
Every 30,000 km (20,000 miles)•Fuel filter: Replace in diesel engine vehicle s if the fuel does not comply
with the EN 590 standard.•Dust and pollen filter for the passenger com partment: Replace. (Only
models: Ibiza, Ibiza SC, Ibiza ST).•Gas hoses: inspect for damage: Only engin es with LPG
2) (engine code
CHGA).
•LPG filler neck and cap
2): Check condition and clean and inspect se als if
necessary. Only engines with LPG (engine cod e CHGA).
Every 60,000 km (40,000 miles)•Change oil and oil filter for DSG
® automatic gearboxes (where equipped)
- only 6-speed DSG
® gearboxes.
•Dust and pollen filter for the passenger com partment: Replace. (Only
models: Altea, Altea XL, Altea Freetrack and Leon)•Spark plugs : Replace (except 1.8 and 2.0 TFSI engines up to 147 kW).•Air filter: Clean casing and replace filter elemen t (only engines codes
CDLA and CDLD).•LPG evaporator: Check for traces of oil or o ther dirt. Only engines with
LPG2) (engine code CHGA).
2)LPG: Liquefied petroleum gas.
Prog Manto Ibizas-Alteas_EN.book Seite 11 Dienstag, 14. September 2010 11:40 11

General Service Programme
12Every 90,000 km (60,000 miles)•Air filter: Clean casing and replace filter elemen t (except engine codes
CDLA and CDLD).•Fuel filter: Replacement (only diesel engines using fuel complying with
the DIN EN 590 standard)•Replace spark plugs – only vehicles driven o ver 90,000 km (60,000 miles)
in 6 years (only 1.8 TSI and 2.0 TSI
® engines up to 147 kW)
•LPG evaporator paper filter: Replace. Only engi nes with LPG
2) (engine
code CHGA).
At 90,000 km (60,000 miles) the first time, then every 30,000 km (20,000 miles)•Timing belt for camshaft: Check condit ion and replace if necessary (only
petrol engines, except 2.0 TFSI).At 120,000 km (80,000 miles) the first time, then every 30,000 km (20,000 miles)•Particulate filter: Check (only 125 kW TDI-PD e ngines).
At 150,000 km (90,000 miles) the first time, then every 30,000 km (20,000 miles)•Particulate filter: Check (TDI-PD engines, except 125 kW).Every 150,000 km (90,000 miles)•Timing belt for camshaft: Replace (only TDI-PD engines).At 180,000 km (120,000 miles) the first time, then every 30,000 km (20,000 miles)•Particulate filter: Check (TDI Common Rail e ngines).Every 210,000 km (130,000 miles)•Timing belt for camshaft: Replace (TDI Common Rail engines).•Camshaft timing belt tension roller: Replace (T DI Common Rail engines).Every 300,000 km (200,000 miles)•Camshaft timing belt tension roller: Replace (TDI-PD engines).
Prog Manto Ibizas-Alteas_EN.book Seite 12 Dienstag, 14. September 2010 11:40 11

Records19
Service records
Note
We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle. Sc rupulously following of the
Services (oil, interval, inspection) at an Offi cial SEAT Service will increase the
value of your vehicle.
LongLife Service:
YE S NO
Oil change
cc
Inspection
cc
Service dependent on time/distance travell ed: YES NO
Oil change
cc
Interval
cc
Inspection
cc
Additional jobs: YES NO YES NO
Brake fluid
cc
Air cleaner
cc
Spark plugs
cc
Fuel filter
cc
Dust and
pollen filters
cc
Timing belt
cc
DSG
®: oil and filter
cc

Date
Km/Miles:
Invoice number
Repair recommendation:
Service carried out by:
Official SEAT Service stamp
Next Service to be carried out:
Date:
Km/Miles: (whichever is first)
Prog Manto Ibizas-Alteas_EN.book Seite 19 Dienstag, 14. September 2010 11:40 11

Records
20Service records
Note
We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle. Sc rupulously following of the
Services (oil, interval, inspection) at an Offi cial SEAT Service will increase the
value of your vehicle.
LongLife Service:
YES NO
Oil change
cc
Inspection
cc
Service dependent on time/distance travel led: YES NO
Oil change
cc
Interval
cc
Inspection
cc
Additional jobs: YES NO YES NO
Brake fluid
cc
Air cleaner
cc
Spark plugs
cc
Fuel filter
cc
Dust and
pollen filters
cc
Timing belt
cc
DSG
®: oil and filter
cc

Date
Km/Miles:
Invoice number
Repair recommendation:
Service carried out by:
Official SEAT Service stamp
Next Service to be carried out:
Date:
Km/Miles: (whichever is first)
Prog Manto Ibizas-Alteas_EN.book Seite 20 Dienstag, 14. September 2010 11:40 11

Records21
Service records
Note
We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle. Sc rupulously following of the
Services (oil, interval, inspection) at an Offi cial SEAT Service will increase the
value of your vehicle.
LongLife Service:
YE S NO
Oil change
cc
Inspection
cc
Service dependent on time/distance travell ed: YES NO
Oil change
cc
Interval
cc
Inspection
cc
Additional jobs: YES NO YES NO
Brake fluid
cc
Air cleaner
cc
Spark plugs
cc
Fuel filter
cc
Dust and
pollen filters
cc
Timing belt
cc
DSG
®: oil and filter
cc

Date
Km/Miles:
Invoice number
Repair recommendation:
Service carried out by:
Official SEAT Service stamp
Next Service to be carried out:
Date:
Km/Miles: (whichever is first)
Prog Manto Ibizas-Alteas_EN.book Seite 21 Dienstag, 14. September 2010 11:40 11