air condition Seat Ibiza ST 2011 Maintenance programme

6
SEAT maintenance programme
SEAT maintenance programme
Service intervals Gener al information To ensure that you have each service carried out on time and that none are
f

orgotten, there is a reminder sticker on the driver side door pillar and a re-
minder will also be shown via the service interval display on the instrument
panel.
The service intervals quoted are for vehicles used under normal operating
conditions.
However, if the vehicle is used in adverse conditions, it may require work
before the next established service interval or even between service inter-
vals.
Adverse conditions include:
● the use of fuel with a high sulphur content
● frequent short journeys
● leaving the engine idling for long periods of time (as occurs with taxis)
● driving on dusty roads or in dusty areas
● frequently using the vehicle for towing
● mainly driving in the city, in heavy traffic where it is necessary to contin-
uou
sly brake and start, and
● using the vehicle mainly in the winter This particularly affects:
●
the air filter
● the timing belt
● the engine oil and
● the diesel particulate filter
In some c
ountries diesel fuel has a high sulphur content; in these cases the
fuel filter and the oil should be changed every 7500 km (5000 miles)
⇒  page 7. Your Official SEAT Service will be able to tell you which coun-
tries have diesel with a high sulphur content.
The service advisor at your Official SEAT Service will advise you on the need
to carry out additional work on your vehicle, taking into account the usage
conditions of the vehicle.
A list of the work to be carried out at the SEAT services is given on the fol-
lowing pages. These services are valid at the time of printing and can be
subject to further modifications for technical reasons. Your Official SEAT
Service always has the latest available information and will be able to tell
you if your vehicle requires any other additional inspections established by
law.
The cost of the SEAT service may vary, depending on the vehicle type,
equipment fitted, additional work and statutory inspections. Your Official
SEAT Service will tell you how much the SEAT service will cost (labour and
parts). Ð

9
General Service Programme
● The headlight adjustment is checked
● The date of the next service is entered on the service sticker which is at-
t

ached to the driver side door pillar
● The service interval display is reset Ð
Inspection service Operations to be performed on your vehicle:
● The exhaust system is checked for leaks, damage and secure fitting
● ATF in the automatic gearbox: Check and, where necessary, top up with
fluid (e
xcept Exeo, Exeo ST and 09G gearbox in hot climates).
● Power steering hydraulic system: Check the seal and the fluid level, and
if

it is part of the equipment, if required, top up with hydraulic oil (only Exeo
and Exeo ST).
● Check the battery.
● Check the depth of the tyre tread (incl. the spare wheel, if applicable),
the ev
enness of the tread wear, the age and pressure of the tyres. Where
applicable, adjust the tyre pressure monitor.
● Check brake system and dampers for leaks and damage.
● Check the sunroof (where applicable) operates correctly and if necessary
c

lean and lubricate guides.
● Check the thickness of brake pads and the condition of front and rear
br

ake discs. ●
Chec
k the correct operation of the front and rear lighting, the turn sig-
nals, the hazard warning lights, the daytime driving lights, the static corner-
ing lights and the automatic dipped beam control (where applicable) and
the horn.
● Check if the windscreen is damaged.
● Check that the interior and glove box lighting, the cigarette lighter/pow-
er soc
ket, horn and warning lamps work correctly.
● Body: check for visible rust.
● Check the condition and, if required, the tension of the Poly V-belt.
● Check the coolant and anti-freeze liquid and top up as required.
● Inspect the engine and components of the engine compartment (from
abo
ve) for leaks and damage.
● Visually inspect (from below) the engine and components of the engine
c

ompartment, the gearbox, the end drive and the track rod boots for leaks
and damage.
● Check the engine oil level.
● Check the expiry date of the puncture kit tyre sealant (where applicable)
and r
ecord; check whether the bottle is damaged and the level of the seal-
ant.
● Take a test drive and check that the brakes, handbrake, steering, and air
c

onditioning operate correctly, and perform a kickdown.
● Check the windscreen wipers and headlight washers (where applicable)
oper
ate correctly; check the blades, the rest position, the final position and
for possible damage, and top up the washer fluid as required.
● The headlight adjustment is checked
● Coil spring (suspension) and bump stop, front and rear: visual check for
d

amage £

11
General Service Programme
Every 60 000 km (40 000 miles) ●
Change oil and oil filter for DSG ®
aut omatic gearboxes (only 6-speed
DSG ®
gearboxes).
● Change the automatic gearbox oil (only Exeo, Exeo ST and 09G gearbox
in hot
climates).
● Dust and pollen filter for the passenger compartment: Replace (only Al-
t

ea, Altea XL, Altea Freetrack, Leon and Alhambra).
● Spark plugs: Replace (except 1.8 and 2.0 TFSI engines up to 147 kW).
● Air filter: Clean casing and replace filter element (only engines codes
CDLA and CDLD and Die
sel engines in Exeo and Exeo ST).
● Fuel filter: Replace (only Exeo and Exeo ST, engine codes CAGA, CAGC,
CAHA).
● LPG evaporator: Check for traces of oil or other dirt (only engines with
L

GP) 1)
. Ð
Every 90 000 km (60 000 miles) ●
Air filter: Clean casing and replace filter element (except engines codes
CDLA and CDLD and Die
sel engines in Exeo and Exeo ST).
● Fuel filter: Replace (only Diesel engines which use fuel that complies
w

ith the EN 590 standard. In Exeo and Exeo ST, except engine codes CAGA,
CAGC, CAHA).
● Spark plugs: Replace (only 1.8 and 2.0 TFSI engines up to 147 kW). ●
LPG ev
aporator paper filter: Replace (only engines with LPG) 1)
. Ð
At 90 000 km (60 000 miles) the first time,
then ev
ery 30 000 km (20 000 miles) ●
Timing belt for camshaft: Check condition and replace if necessary (only
petr
ol engines, except 2.0 TFSI). Ð
Every 180 000 km (120 000 miles) ●
Timing belt for camshaft: Replace (only 2.0 TFSI engines in Exeo and Ex-
eo

ST). Ð
At 180 000 km (120 000 miles) the first time,
then ev
ery 30 000 km (20 000 miles) ●
Particulate filter: Check (TDI Common Rail engines). Ð
Every 210 000 km (130 000 miles) ●
Timing belt for camshaft: Replace (TDI Common Rail engines). £1)
LPG: Liquefied petroleum gas.

15
Warranty
Warranty Fault-free operation warranty According to the clauses of the warranty applied to SEAT vehicles in the
s ales contract, A fault-free operation warranty of 2 years in accordance with
legal requirements 1)2)
is provided from the date of delivery.
We hope that it is understood that natural wear as well as damage caused
by the abuse of vehicle performance through inappropriate use or by unac-
ceptable modifications are excluded from the warranty. The warranty is also
invalid when the vehicle is damaged by the use of parts and accessories
that are not SEAT approved or damage due to ignoring the maintenance and
repair requirements. Ð
Paintwork and body warranty Technical Services provide a warranty on bodywork and
pain

twork for vehicles sold in the EU.
In addition to the warranty conditions for brand new SEAT vehicles (as de-
tailed in the purchase contract), a defined period warranty is also provided
covering paintwork and bodywork rusting: ●
The a
dditional warranty on paint faults covers the first 3 years following
delivery
● Covered against perforation rusting on the body during the first 12 years
f

ollowing delivery.
If, however, this type of damage should occur, it will be repaired free of
charge including parts and labour by any SEAT Technical Service in Europe.
Warranty claims will not be accepted in the following circumstances:
● if damage is caused by external influence or carelessness, or
● if damage to the body is not repaired promptly and appropriately in ac-
c

ordance with the manufacturer's instructions using genuine, approved
spare parts and materials, or
● if perforation rusting is caused by the use of non-genuine parts and ma-
t

erials for body repairs and if these repairs were not carried out in accord-
ance with the manufacturer's instructions.
If the bodywork is repaired or painted, your Technical Service will certify
your warranty against through-rusting for the repaired sections. Ð
Approved SEAT exchange parts The approved SEAT exchange parts, conforming to the manufacturer's re-
quir
ements, constitute an additional service at your disposal, offering you £1)
The warranty is not available for all export markets. For more information, please ask your
Authori
sed SEAT Technical Service.
2) As well as the legally required warranty, SEAT offers an extended warranty to their clients in
some E
uropean countries. The specific conditions of this extended warranty are detailed in
the vehicle sales contract.