wheel torque Seat Toledo 2015 Owner's manual
[x] Cancel search | Manufacturer: SEAT, Model Year: 2015, Model line: Toledo, Model: Seat Toledo 2015Pages: 248, PDF Size: 5.06 MB
Page 49 of 248
The essentials
Wheel bolt caps Fig. 60
Pull off the wheel bolt cap. Removing
● Fit the plastic clip (vehicle tools) over the
c ap u
nti
l it clicks into place ››› Fig. 60.
● Remove the cap with the plastic clip.
Fitting
● Inser
t the caps as far as they will go over
the wheel bolts.
The wheel
bolt caps are stored in a box on
the spare wheel or in the spare wheel well. Anti-theft wheel bolts*
Fig. 61
Anti-theft wheel bolt with adapter. Anti-theft wheel bolts (one bolt per wheel)
c
an on
ly
be loosened or tightened using a
factory-supplied adapter.
● Pull off the hub cap or bolt cover.
● Insert the adapter B
› ›
› Fig. 61
with its
toothed side as far as it will go on the interior
toothing of the anti-theft wheel bolt A so
th at
on
ly the outer hexagonal is protruding.
● Fit the box spanner as far as it will go over
adapt
er B .
● Loosen or firmly tighten the wheel bolt
› ›
›
page 47.
● After removing the adapter, replace the hub
cap or the anti-theft
wheel bolt cover. ●
Check the
tightening torque as soon as
possible with a torque wrench.
Note down the code number stamped on the
front of the adapter or of the anti-theft wheel
bolt. You will need this number to obtain a
spare adapter from the SEAT original acces-
sories programme.
You should always have a wheel bolt adapter
as part of your vehicle tools.
Loosening and tightening wheel bolts Fig. 62
Changing a wheel: loosen the wheel
bo lts. Loosening wheel bolts
● Insert the box spanner onto the wheel bolt
a s
f
ar as it will go 1)
. »1)
The corresponding adapter is required to unscrew
or tighten the anti-thef t
wheel bolts ››› page 47. 47
Page 51 of 248
The essentials
● Adju s
t
the jack so that its claw surrounds
the jacking point on the door sill ››› Fig. 64 - B
underneath the stamp.
● Make sure that the base of the jack is en-
tirely s
upported on a flat surface and that it is
vertical ››› Fig. 64 to the point where the claw
surrounds the jacking point on the door sill.
● Continue to wind up the jack using the
crank
handle until the defective wheel is
clear off the ground.
Removing and fitting a wheel Change the wheel after loosening the wheel
bo
lts
and r
aising the vehicle with the jack.
Taking off the wheel
● Unscrew the wheel bolts using the box
spanner and p
lace them on a clean surface.
● Take off the wheel.
Putting on the s
pare wheel
When fitting tyres with a compulsory rotation
direction, observe the instructions in
››› page 49.
● Mount the wheel.
● Screw on the wheel bolts in position and
tighten them loosely
with a box spanner.
● Carefully lower the vehicle using the jack*. ●
Tighten the wheel bo
lts in diagonal pairs
using the wheel brace.
The wheel bolts should be clean and turn
easily. Before fitting the spare wheel, inspect
the wheel condition and hub mounting surfa-
ces. These surfaces must be clean before fit-
ting the wheel.
Tyres with compulsory direction of ro-
tation A directional tread pattern can be identified
b
y
the arr
ows on the sidewall that point in
the direction of rotation. Always observe the
direction of rotation indicated when fitting
the wheel to guarantee optimum properties
of this type of tyres with regard to grip,
noises, wear and aquaplaning.
If it is absolutely necessary to fit the spare
tyre* against the direction of rotation, drive
with care as this means the tyre does not of-
fer optimum driving properties. This is of par-
ticular importance when the road surface is
wet.
Replace the punctured tyre as soon as possi-
ble and restore the obligatory and correct di-
rection of rotation of all tyres. Subsequent work ●
Alloy wheels: repl
ace the wheel bolt caps.
● Plate wheels: repl
ace the wheel hubcap
››› page 46.
● Return all tools to their proper storing loca-
tion.
● If the replaced wheel does not fit in the
spar
e wheel housing, store it safely in the
luggage compartment ›››
page 141.
● Check the tyre pressure of the newly moun-
ted tyr
e as soon as possible.
● In vehicles fitted with a tyre pressure indi-
cat or
, adjust the pressure and store it in
memory ›››
page 219.
● Have the tightening torque of the wheel
bolts c
hecked as soon as possible with a tor-
que wrench (it should be 120 Nm). Mean-
while, drive carefully.
● Have the flat tyre replaced as quickly as
poss
ible.
Snow chains Use Snow chains should only be used on the
fr
on
t
wheels. » 49
Page 78 of 248
Emergencies
distance. Observe applicable local legal regu-
lation
s.
This is for your own safety and that of
other drivers.
● If you have a flat tyre, stop the vehicle as
far aw
ay as possible from moving traffic. Stop
on flat, solid ground.
● If you have to change the tyre on a gradi-
ent, block
the wheel opposite the wheel be-
ing changed by placing a stone or similar ob-
ject under it to prevent the vehicle from roll-
ing away unexpectedly.
● If the vehicle has been fitted with tyres or
allo
ys that are different to those fitted in
manufacture, the instructions ››› page 217,
New tyres or wheels must be followed.
● Always raise the vehicle with the doors
closed.
● Nev
er place parts of your body, e.g. arms
and leg
s, underneath the vehicle when it is
supported only by the jack.
● Secure the base of the jack with suitable
suppor
ts so that it cannot slip. The jack could
slide if the ground below it is soft and slip-
pery and the vehicle could slip off it. There-
fore, place the jack on a firm surface or use a
large, stable base. On a slippery surface, e.g.
tile, use a non-slip base such as a rubber
mat.
● Never start the engine when the vehicle is
jack
ed. Risk of injury.
● The jack should only be used in the correct
jack
ing points. CAUTION
● The pre s
cribed tightening torque for wheel
bolts on steel and alloy wheels is 120 Nm.
● If the anti-theft wheel bolt is overly tight-
ened, this c
ould damage the bolt and the
adapter. Note
● The set of anti-thef
t wheel bolts or the
adapter are available from authorised SEAT
dealers.
● Please observe the relevant local legal reg-
ulation
s when changing the wheel. Wheel bolts
The wheel
bolts
ar
e m
atched to the rims.
When installing different wheels, e.g. to fit
light alloy wheels or wheels with winter tyres,
it is important to use the correct wheel bolts
with the right length and correctly shaped
bolt heads. This is essential for a secure fit of
the wheels and for proper operation of the
brake system. Note
● Never gr e
ase or oil the wheel bolts!
● If the wheel bolt is very tight, it may be
poss
ible to loosen it by pushing down the
end of the box spanner carefully with your foot. Hold on to the vehicle for support and
tak
e c
are not to slip.
● If you notice that the wheel bolts are rusty
and difficult
to turn when changing a wheel,
they must be replaced before having the
tightening torque checked. Tyre repairs
TMS Anti-p
uncture kit (Tyre Mobility
System)* Read the additional information carefully
› ›
›
page 45
The Tyre Mobility System is stored in a box
under the carpet in the boot.
Using the Tyre Mobility System you can relia-
bly seal tyres damaged by foreign bodies,
provided that cuts or punctures are no larger
than approx. 4 mm in diameter. Do not re-
move the foreign bodies, e.g. bolts or nails,
from the tyre!
The tyre must be repaired immediately.
The repair made using the Tyre Mobility Sys-
tem under no circumstances replaces perma-
nent tyre repair and should only be used to
drive to the nearest official service.
76
Page 217 of 248
Wheels and tyres
Wheels and tyres
Wheel s
Intr oduction WARNING
● Durin g the fir
st 500 km, new tyres do not
give maximum grip, therefore you should
drive carefully. Risk of accident!
● Never drive with damaged tyres. Risk of ac-
cident!
● Only
use wheels and tyres that been au-
thorised by
SEAT or your vehicle model. Fail-
ure to do so could impair road safety. Risk of
accident!
● Never exceed the maximum speed permit-
ted for
your tyres. Risk of accident due to tyre
damage and loss of vehicle control!
● Under-inflated tyres are submitted to great-
er rol
ling resistance. This means that they
can overheat at high speeds. This can cause
tread separation and even tyre blow-out.
● For driving safety, tyres should be replaced
at le
ast in pairs according to the axle and not
individually. The tyres with the deepest tread
should always be used on the front wheels.
● Never fit used tyres of an unknown age or
prior use.
● Ty
res must be immediately changed at the
very
latest when they have worn down to the
tread wear indicators. ●
Worn ty r
es reduce the necessary grip at
high speeds on damp surfaces. This could
lead to “aquaplaning” (uncontrolled vehicle
movement – “skidding” on damp surfaces).
● Damaged wheels and tyres must be re-
plac
ed immediately.
● Do not use summer or winter tyres that are
more than 6 or 4
years old respectively.
● Wheel bolts should be clean and screw
eas
ily. However, they must never be treated
with grease or oil.
● If the tightening torque of the wheel bolts
is t
oo low, they could loosen while the vehi-
cle is moving. Risk of accident! If the tighten-
ing torque of the wheel bolts is too high, the
bolts and threads could be damaged, leading
to the permanent deforming of the rim sup-
port surfaces.
● Incorrectly handled wheel bolts could lead
to a wheel c
oming loose while the vehicle is
moving. Risk of accident!
● Observe the national legal requirements re-
gardin
g the use of snow tyres and chains. CAUTION
● Where a s p
are wheel that is not compatible
with the wheels fitted is used, follow the in-
structions ››› page 218.
● The prescribed tightening torque for wheel
bolts
on steel and alloy wheels is 120 Nm.
● Protect your tyres from coming into contact
with oil, gr
ease and fuel.
● Replace any lost valve caps immediately. For the sake of the environment
Under-inflated tyres increases fuel consump-
tion. Note
● We r ec
ommend having all work on tyres
and wheels carried out by an authorised SEAT
dealer.
● We recommend using wheels, tyres, hub
caps
and snow chains from the SEAT Original
Accessories programme. 215
Technical data
Advice
Operation
Emergencies
Safety
Page 226 of 248
Technical data
Drawbar loads
The maximum permitt ed dr
a
wbar load on the
ball joint of the towing bracket must not ex-
ceed 50 kg.
In the interest of road safety, we recommend
that you always tow approaching the maxi-
mum drawbar load. The response of the trail-
er on the road will be poor, if the drawbar
load is too small.
If the maximum permissible drawbar load
cannot be met (e.g. with small, empty and
light-weight single axle trailers or tandem
axle trailers with a wheelbase of less than 1
metre), a minimum of 4% of the actual trailer
weight is legally required for the drawbar
load. WARNING
● For s af
ety reasons, do not exceed the 80
km/h (50 mph) limit. This is also valid in
countries where higher speeds are permitted.
● Never exceed the maximum trailer weights
or the drawb
ar load. If the permissible axle
load or the permissible total weight is excee-
ded, the driving characteristics of the vehicle
may change, leading to accidents, injuries
and damage to the vehicle. Wheels
Ty
r
e pressure, snow chains, wheel
bolts Tyre pressures
The stic
k
er with the tyre pressure values can
be found on the inside of the fuel tank flap.
The tyre pressure values given there are for
cold tyres. Do not reduce the slightly raised
pressures of warm tyres ››› .
The pre s
sure for winter tyres is 0.2 bar
(2.9 psi / 20 kPa) higher than that of summer
tyres.
Snow chains
Snow chains may be fitted only to the front
wheels.
Consult the section “wheels” of this manual.
Wheel bolts
After the wheels have been changed, the
tightening torque of the wheel bolts should
be checked as soon as possible with a torque
wrench ››› . The tightening torque for steel
and al lo
y
wheels is 120 Nm. WARNING
● Check the ty
re pressure at least once per
month. Checking the tyre pressure is very im-
portant. If the tyre pressure is too high or too low, there is an increased danger of accidents
- par
tic
ularly at high speeds.
● If the tightening torque of the wheel bolts
is t
oo low, they could loosen while the vehi-
cle is in motion. Risk of accident! If the tight-
ening torque is too high, the wheel bolts and
threads can be damaged. Note
We recommend that you ask your Technical
Ser vic
e for information about appropriate
wheel, tyre and snow chain size. 224
Page 242 of 248
Index
Speed warning device . . . . . . . . . . . . . . . . . . . . . . 29
St ar
t
-Stop system . . . . . . . . . . . . . . . . . . . . . . . . . 182
operating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 182
Starter button . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Starting the engine . . . . . . . . . . . . . . . . . . 153, 156
Starting the vehicle . . . . . . . . . . . . . . . . . . . . . . . . 17
Steering steering lock . . . . . . . . . . . . . . . . . . . . . . . . . . . 153
Steering wheel adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Steering wheel controls . . . . . . . . . . . . . . . . . . . . 105
Storage luggage compartment . . . . . . . . . . . . . . . . . . . 142
Storage compartments . . . . . . . . . . . . . . . . . . . . 135 for eyeglasses . . . . . . . . . . . . . . . . . . . . . . . . . . 139
front seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 136
in front door . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
in the centre console . . . . . . . . . . . . . . . . . . . . 140
in the luggage compartment . . . . . . . . . . . . . . 140
passenger side . . . . . . . . . . . . . . . . . . . . . . . . . 135
reflective vest . . . . . . . . . . . . . . . . . . . . . . . . . . 136
Sun visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
Switch hazard warning lights . . . . . . . . . . . . . . . . . . . 126
Switching off the engine with the key . . . . . . . . . . . . . . . . . . . . . . . . . . . . 156
Switching off the lights . . . . . . . . . . . . . . . . . . . . 121
Switching on the lights . . . . . . . . . . . . . . . . . . . . 121
Switching the ignition on and off . . . . . . . . . . . . 153
Symbols see Warning and indication lamps . . . . . . . 98, 99
System Easy Connect . . . . . . . . . . . . . . . . . . . . . . 104
T Tailgate locking time extension see Luggage compartment . . . . . . . . . . . . . . . 118 Technical specifications . . . . . . . . . . . . . . . . . . . . 221
Temperat
ure display
engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
outside temperature . . . . . . . . . . . . . . . . . . . . . . 24
Temperature selection heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148
Tightening torque of wheel bolts . . . . . . . . . . . . 224
Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 lap times . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
statistics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Tiptronic (automatic gearbox) . . . . . . . . . . 158, 161
Tiredness detection . . . . . . . . . . . . . . . . . . . . . . . 184
Top speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Top Tether system . . . . . . . . . . . . . . . . . . . . . . . . . 17
Tow-starting the engine . . . . . . . . . . . . . . . . . . 51, 78
Towing bracket device . . . . . . . . . . . . . . . . . . . . . 185
Towing the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 50
Towline anchorages . . . . . . . . . . . . . . . . . . . . . . . . 50 front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Traction Control . . . . . . . . . . . . . . . . . . . . . . . . . . 168
Traction control system . . . . . . . . . . . . . . . 100, 167
Trailer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 185 ball coupling . . . . . . . . . . . . . . . . . . . . . . . . . . . 190
correct placement . . . . . . . . . . . . . . . . . . . . . . . 191
driving with a trailer . . . . . . . . . . . . . . . . . . . . . 186
parking Aid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 173
service position . . . . . . . . . . . . . . . . . . . . . . . . 189
towing bracket device . . . . . . . . . . . . . . . . . . . 187
trailer weights . . . . . . . . . . . . . . . . . . . . . . . . . . 186
use and maintenance . . . . . . . . . . . . . . . . . . . . 192
Trailer weights . . . . . . . . . . . . . . . . . . . . . . . . . . . 223
Transporting children . . . . . . . . . . . . . . . . . . . . . . . 72
Transporting items carrier system . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Roof carrier . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Trip recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94 turn signals
contro l lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Tyre mobility set . . . . . . . . . . . . . . . . . . . . . . . . . . . 45 components . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
inflating a tyre . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
sealing a tyre . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Tyre Mobility System see Anti-puncture kit . . . . . . . . . . . . . . . . . . . . . 76
Tyre monitoring system . . . . . . . . . . . . . . . . . . . . 219
Tyre pressure control control lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Tyre pressures . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Tyre Profile . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 216
Tyre repair kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76 see also Anti-puncture kit . . . . . . . . . . . . . . . . . 76
Tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 215 changing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 217
new tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 217
useful life . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 216
wear indicators . . . . . . . . . . . . . . . . . . . . . . . . . 216
with compulsory direction of rotation . . . . . . . . 49
with directional tread pattern . . . . . . . . . . . . . 218
Tyre tread depth . . . . . . . . . . . . . . . . . . . . . . . . . . 216
Tyre wear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 216
U
Unfastening the seat belt . . . . . . . . . . . . . . . . . . . 12
Unlocking and locking . . . . . . . . . . . . . . . . . . . . . . . 9 central locking . . . . . . . . . . . . . . . . . . . . . . . . . 113
remote control . . . . . . . . . . . . . . . . . . . . . . . . . 109
with Keyless Access . . . . . . . . . . . . . . . . . . . . . 115
with the central locking switch . . . . . . . . . . . . 114
USB/AUX-IN input . . . . . . . . . . . . . . . . . . . . . . . . 109
240