warning light SKODA OCTAVIA 2010 2.G / (1Z) LPG Supplement

LPG fuel gauge
4
During the refuelling procedure, noises ge nerated through refuelling with LPG are not
critical.
WARNING
•
When refuelling with LPG, smoking and working with a naked flame are
prohibited - risk of explosion!
•
For vehicles with auxiliary heating: Switch of f the auxiliary heating.
•
Incorrect refuelling or improper handling of LPG can cause a fire, an explo-
sion and can lead to injuries.
•
LPG is highly explosive and highly fla mmable. It can cause severe burns and
other injuries.
•
Switch off the engine and switch off the ignition before you refuel with LPG.
•
Always switch off the mobile phone and the radio completely when you
refuel. Sparks could arise through electromagnetic waves which can trigger a
fire.
•
Do not enter the vehicle when refuelling with LPG. If in exceptional cases
you must enter the vehicle, close the do or when you exit the vehicle and touch
a metal surface before you take hold of the filling coupling. This prevents elec-
trostatic discharges, which may result in flying sparks. These in turn could
trigger a fire during the refuelling procedure with LPG.
•
A small quantity of LPG can escape after removing the filling piston. In case
of contact with the skin, there is a risk of frostbite.Note
The LPG filling pressure may vary within some countries for different refuelling
systems. If the filling pressure is too low, it can occur that the filling valve does not slam
closed when filling up. When the filling valv e does not close, a clearly audible clatter
can be heard from the tank area. In this ca se, refuelling with LPG must be finished
manually. This effect is not a fault of the LPG system of your vehicle.
LPG fuel gauge Fig. 4 Instrument clusterLPG gauge
The fuel gauge fig. 4 in the instrument cluster provides information about the
LPG remaining in the LPG fuel tank.
The warning light
 tells you that your vehicle is running in LPG mode.
If the LPG filling level reaches the reserve capacity level, the message Please refuel
with LPG appears in the display of the instrument cluster.
The vehicle automatically switches over to petrol mode when the LPG fuel tank is
empty.
Note
•
The LPG filling level in the LPG fuel tank can change through inertia forces while
driving. A different quantity of LPG in the fuel tank may be indicated temporarily.
•
If the vehicle is parked for a longer period of time immediately after refuelling, the
situation may arise in which the pointer of the fuel tank gauge fig. 4 does not
indicate exactly the same level as was the case immediately after refuelling when the
engine is restarted. This is not due to any system leakages but a drop in pressure in the
LPG fuel tank due to technical reasons after a cooling phase directly after refuelling.
AA
AB
AA
s5h8.8.book Page 4 Wednesda y, October 27, 2010 11:20 AM

Multi-functional indicator (onboard computer) 5
Multi-functional indicator (onboard computer)The following data for the multi-functional indicator only relate to the current oper-
ating mode (LPG/petrol):•
Current consumption,
•
average fuel consumption,
•
range.
Driving with LPGThe vehicles with LPG drive can be used wi th LPG which complies with the standard
EN 589 as well as unleaded petrol wh ich complies with the standard EN 228.
The LPG fuel tank is housed in the spare wheel well under the luggage compartment
cover.
Starting the engine
The engine always starts in petrol mode, ev en if the vehicle was parked in LPG mode.
Automatically switching over from petrol mode to LPG mode
Switching over from petrol mode to LPG mode is performed automatically after a
system check if the follo wing conditions are met:•
sufficient LPG in the LPG fuel tank,
•
the engine has reached its operating temperature (the warning light
 in the
instrument clus ter goes out),
•
The engine speed is higher than 1 200 rpm.
If these conditions are met, the system automatically switches to LPG mode.
The warning light
 in the instrument cluster then comes on.
Automatically switching over from LPG mode to petrol mode
When one of the conditions are met, the vehicle automatically switches over from LPG
mode to petrol mode:
•
when starting the engine,
•
when the LPG fuel tank is empty,
•
if the outside temperature is lower than -10 °C,
•
when there is a system fault in the LPG system.
The warning light
 in the instrument cluster goes out.
Manually switching over from petrol mode to LPG mode
Manually switching between LPG to petrol can be performed when the engine is
running by pressing the button even while the vehicle is in motion fig. 5 . When
the following conditions are met, the vehicl e switches over from petrol mode to LPG
mode:
•
The button is pressed,
•
sufficient LPG in the LPG fuel tank,
•
coolant temperature of the vehicle higher than +30 °C,
•
Engine speed when running higher than 1 200 rpm.
The warning light
 in the instrument cluster then comes on.
Manually switching over from LPG mode to petrol mode
Switching over is performed by pressing the button . The warning light
 in the
instrument cluster goes out.
Driving in petrol mode
If you drive mostly short distances at regular intervals, then use the petrol mode in
order to prevent any problems which may arise with the petrol system.
Fig. 5 LPG switch
GAS
GAS
GAS
s5h8.8.book Page 5 Wednesda y, October 27, 2010 11:20 AM

Coolant temperature 
6Caution
Because the engine always starts in petrol mode, there must be a sufficient quantity of
petrol in the petrol fuel tank at all times.
Note
For frequent short-haul traffic, especially at low outside temperatures, the vehicle is
driven more frequently in petrol mode than in LPG mode. This is why the petrol fuel
tank may run empty faster than the LPG fuel tank.Coolant temperature

The warning light
 lights up until the engine reache s its operating temperature. Avoid
running at high engine speeds, at full throttle and at severe engine loads.
Service workEvery 30,000 km•
Cover and filler tube for LPG (liquefied petroleum gas): Inspect condition, clean if
necessary, and check the O-rings.
•
Gas hoses: Visual inspection for signs of damage.
•
Fuel filter of the LPG system (liquefied petroleum gas system): replace.
Every 60,000 km
•
Oil and other impurities of the evaporator: check.
Every 90,000 km
•
Paper filter on the evaporator: replace.
Every 10 years
•
Replace LPG fuel tank.
Note
The conditions for replacing the LPG fuel tank are regulated by national statutory regu-
lations - find out about the latest status of these regulations in your country by
consulting a specialist gara ge or relevant importer.
s5h8.8.book Page 6 Wednesda y, October 27, 2010 11:20 AM