key SMART FORTWO COUPE 2008 Workshop Manual

Rear window defroster
154
>> Controls. The rear window defroster serves to de
ice
the rear window quickly and clear the view if
the rear window is fogged.
The rear window defroster uses a large
amount of power. To keep battery drain to a
minimum, switch off the defroster as soon as
the rear window is clear. The defroster is
automatically deactivated after approximately
10 minutes of operation.
1
Rear window defroster switch>Make sure that the key in the starter switch
is turned to position1.
> Switching on: Press button
1.
The indicator lamp on the switch comes on.
>Switching off: Press button1 once more.
The indicator lamp on the switch goes out.
P83.20
2349
31

Loading and storing
>> Controls.
161
> Opening: Pull on glove box lid release
2
and fold down the glove box lid.
>Closing: Lift up the glove box lid with a bit
of force until it engages.
>Locking: Insert the key into glove box
lock
1 and turn counterclockwise.
> Unlocking: Insert the key into glove box
lock1 and turn clockwise.Storage compartment in the tailgate
1
You can store small objects in the storage
compartment in the tailgate.1
Handle
>Open the tailgates.
>Pull handle
1 on the inside of the tailgate
backward.
>Lift up the storage compartment cover.
Loading instructions
1 coupé only.
G
Warning!
Transport heavy or hard objects in the
cargo compartment, not in the passenger
compartment.
Always fasten items being carried as
securely as possible using fastening ma

terials appropriate for the weight and
size of the load.
In an accident, during hard braking or
sudden maneuvers, loose items may be
thrown around inside the vehicle, causing
injury to vehicle occupants.

Useful features
>> Controls.
165
The auxiliary power outlet is located in the
lower center console.1
Auxiliary power outlet
>Turn the key in the starter switch to
position1 (

page 91).
!
Please observe the safety instructions
given in the respective operating instruc

tions.Please note that:
• if using the auxiliary power outlet the max

imum current drawn does not exceed 5 A,
• the electric air pump can be connected to
the auxiliary power outlet for the time it
takes to inflate the tire without any prob

lem,
• the vehicle battery will discharge when
current is drawn.
Wheel trim cap*1
Wheel trim cap aperture
2
Valve> Mounting: Position wheel trim cap aperture
1 so the valve
2 fits through.
>Push the wheel trim cap evenly onto the
wheel rim with both hands.
>Check that the wheel trim cap is fixed se

curely to the wheel rim.
>Removing: Carefully remove the wheel trim
cap from the wheel rim with both hands. P68.00
4797
31

At the gas station
>> Operation
169 Refueling
!
Do not put diesel in vehicles with gasoline
engines. Do not mix gasoline with diesel. Even
small quantities of diesel will damage the in

jection system. Damage caused by adding die

sel will not be covered by the smart Limited
Warranty.
If diesel has mixed with gasoline, do not start
the engine. Otherwise the catalytic converter
will be irreparably damaged.
Contact an authorized smart center or Road

side Assistance immediately and have the ve

hicle towed.
!
Damage resulting from mixing gasoline
with diesel fuel is not covered by the smart
Limited Warranty.
The fuel filler flap is located on the passenger
side towards the rear.
Locking/unlocking the vehicle with the key
automatically locks/unlocks the fuel filler flap.
i
In case the central locking system does
not release the fuel filler flap, or the opening
mechanisms is clamping, contact Roadside As

sistance or an authorized smart center.
1
Opening the fuel filler flap
2
Tether
3
Fuel type label
G
Warning!
Gasoline is highly flammable and poison

ous. It burns violently and can cause
serious personal injury.
Never allow sparks, flame or smoking
materials near gasoline!
Turn off the engine before refueling.
Never allow fire, sparks, flame, or com

bustible materials near gasoline!
Direct skin contact with gasoline and the
inhalation of gasoline vapors are damag

ing to your health.

At the gas station
170
>> Operation >Turn off the engine.
>Remove the key from the starter switch.
>Open the fuel filler flap by pulling at the
point indicated by arrow
1.
>Turn the fuel filler cap counterclockwise
and hold on to it until possible pressure is
released.
>Take off the fuel filler cap.
!
The fuel filler cap is tethered to the fuel
filler flap. Do not drop the fuel filler cap. It
could damage the vehicle paint finish.
>To prevent gasoline vapors from escaping
into open air, fully insert filler nozzle unit.
>Only fill your tank until the filler nozzle unit
cuts out
do not top off or overfill.>Replace the fuel filler cap.
>Turn the fuel filler cap clockwise until the
handle grip overturns.
i
Make sure to close the fuel filler flap be

fore locking the vehicle as the fuel filler flap
locking pin prevents closing after you have
locked the vehicle.
>Close the fuel filler flap.
You should hear the latch close shut.
i
Only use premium unleaded gasoline with a
minimum Posted Octane Rating of 91 (average
of 96 RON/86 MON). Information on gasoline
quality can normally be found on the fuel
pump. Please contact gas station personnel in
case labels on the pump cannot be found.
For more information on gasoline, see
"Premium unleaded gasoline" (

page 306),
see "Fuel requirements" (

page 306), and
the, or contact an authorized smart center.
G
Warning!
Overfilling of the fuel tank may create
pressure in the system which could cause
a gas discharge. This could cause the gas
to spray back out when removing the fuel
pump nozzle, which could cause personal
injury.

Front compartment
176
>> Operation
Service flapYou can remove the service flap and hang it on
the front of the vehicle so that it does not get
damaged or dirty.
!
Check the fill levels at regular intervals.
!
Carefully remove ice, snow, and any other
deposits from the air intake grilles above the
service flap to ensure air intake at all times.>Park the vehicle on level ground.
>Turn off the engine.
>Set the parking brake.
1
Lever
2
Service flap
>Removing: Fold both levers
1 outwards in
the direction of the arrows.
Service flap
2 is unlocked.
>Lift service flap2 at the front.
>Remove service flap2.
G
Warning!
Always turn key in starter switch to
position0 and remove the key from the
starter switch before opening the ser

vice flap.
If the windshield wipers should inadvert

ently be switched on, you could be seri

ously injured by the wiper washer drive,
which is located just below the service
flap.
G
Warning!
Make sure that the service flap is locked
while driving. Otherwise, the service flap
could become detached and pose a haz

ard to you or others.G
Warning!
To help prevent personal injury, stay
clear of moving parts when the service
flap is open.
The radiator fan may continue to run for
approximately 30 seconds or may even
restart after the engine has been turned
off. Stay clear of fan blades.

Driving instructions
212
>> Operation
BrakesRefer to the description of the hydraulic
brake assistant (

page 75).
!
Because the ESP
® operates automatically,
the engine must be shut off (key in starter
switch position0) when
• the parking brake is being tested on a
brake test dynamometer
• the vehicle is being towed with the front
axle raised
Active braking action through the
ESP
® may
otherwise seriously damage the brake system
which is not covered by the smart Limited
Warranty.Brake pad wear or a leak in the brake system
may be the reason for low brake fluid level in
the brake fluid reservoir.
The brake fluid level in the brake fluid
reservoir may be too low if the brake warning
lamp in the instrument cluster comes on
(

page 34) although the parking brake is
released.
Have the brake system inspected immediately.
Contact an authorized smart center.
All checks and service work on the brake
system should be carried out by qualified
technicians only. Contact an authorized smart
center.
Only install brake pads and use brake fluid
recommended by smart.Inclines
!
When driving down long and steep grades,
relieve the load on the brakes by shifting into
a lower gear to use the engine’s braking
power. This helps prevent overheating of the
brakes and reduces brake pad wear.
When using the engine’s braking power, a
drive wheel may not spin for an extended pe

riod of time, e.g. on slippery road surfaces.
This may cause serious damage to the drive

train which is not covered by the smart
Limited Warranty.
G
Warning!
Make sure not to endanger any other
road users when carrying out braking
maneuvers.

What to do if ...
248
>> Practical hints. Flashes at double frequency:
• if one of the turn signals is malfunctioning.
>Replace the bulb as soon as possible
(
page 254).
or
>Have the turn signal checked at an autho

rized smart center as soon as possible.
EngineThe engine does not start:
>Check if
• the gear selector lever is in park
positionP,
• the brake pedal has been depressed,
• the transmission position indicator is on

or
.
The engine does not start within 4 seconds:
>Wait for a few seconds.
>Repeat the starting procedure.
Remember that extended starting attempts
can drain the vehicle battery.
The engine does not start after several
starting attempts:
>Set the parking brake when leaving the
vehicle.
>Contact Roadside Assistance or an autho

rized smart center.
Loss of keyIf you lose a key, you should do the following:
>Have the key deactivated at an authorized
smart center.
>Report the loss of the key to your car
insurance company immediately.
>If necessary have the mechanical lock
replaced.
Your authorized smart center will be glad to
supply you with a replacement following an
identity check.

What to do if ...
>> Practical hints.
249 Acoustic warning signals
Door warning
A warning signal sounds if the door is opened
while a gear is engaged with the engine run

ning and neither the brake nor accelerator
pedals are depressed.
In addition a warning signal sounds if you
open the driver’s door with the key in the
starter switch position 0 to remind you not to
leave the key in the vehicle.Anti
theft warning system*
Once the anti
theft warning system has been
armed, a visual and audible alarm is triggered
when someone opens
• a door or the tailgate,
• when the vehicle's interior is entered,
• if there is motion inside the vehicle,
• if the vehicle is raised.
The alarm is also triggered if the passenger
door is unlocked with the key (

page 250).
To cancel the alarm:
>Insert the key in the starter switch.
>Turn starter switch in Position 1
(

page 91).
or
>Press button
©
or
ª
on the key.Seat belt reminder system
If seat belts are not fastened when the engine
is started, a warning chime will sound, for de

tails see seat belt telltale (

page 245).
Mechanical/acoustic brake pad indicator
The vehicle is equipped with a mechanical/
acoustic brake pad indicator. If you can hear
a continuous noise from the front axle when
braking, have the brake pads checked at an
authorized smart center.

Unlocking/locking manually
250
>> Practical hints.
Unlocking the vehicleYou can unlock the driver’s door and the fuel
filler flap by unlocking the driver’s door using
the key. The lock cylinder is fitted with a cap.
>Press button
©
on the key.
The anti
theft warning system* is disarmed.
i
If the transmitter battery in the key is
discharged, the anti
theft warning system*
can no longer be disarmed with button
©
on
the key. For replacing the transmitter battery
(

page 253).
Unlocking the vehicle with the key and opening
a door or the tailgate will trigger the anti

theft warning system* (

page 77).
To cancel the alarm:
>Insert the key in the starter switch.
>Turn starter switch in Position 1
(

page 91).
1
Cap
2
Lock cylinder
>Remove cap
1 from lock cylinder
2.
>Unlock the driver’s door.
The driver’s door and the fuel filler flap are
unlocked.
i
To unlock the vehicle centrally press the
central unlocking switch in the upper center
console (

page 38).
Locking the vehicleIf you can no longer lock the vehicle using the
remote control and you do not have a spare
transmitter battery at hand, please proceed
as follows:
>Open the driver's door.
>Press the central locking switch
(

page 84).
The indicator lamp on central locking
switch
1 comes on, when the starter switch
is in position 1.
The indicator lamp on central locking
switch1 flashes, when the starter switch is
in Position 0.
>Remove the key from the starter switch,
take it with you, and close all doors.
The vehicle is now locked and the anti
theft
warning system* is armed. P72.10
3348
31