engine SMART FORTWO COUPE ELECTRIC DRIVE 2015 Owners Manual

Driving and parking
Safety notes ............................. 76
Driving safety systems .................... 46
ABS ....................................... .46
ESP ®
....................................... 47
Hydraulic brake assistant ........... 47 E
ECO indicator ............................... 86
Electrical system
Improper work on or modifica-
tions ....................................... 16
Power outlet ............................ 110
Electronic immobilizer .................. 48
Electronic Power Steering
see EPS
Electronic Stability Program
see ESP ®
Emergency Tensioning Device see ETD
Emergency, in case of
Hazard warning flashe r.......... 48, 68
Roadside Assistance ................... 15
Emission control
Information label ..................... 214
System warranties ...................... 13
Engine
Electronics ............................. 212
Starting .................................. 76
Turning off .............................. 79
EPS (Electronic Power Steering)
Warning lamp .......................... 170
ESP ®
(Electronic Stability Program) ... 47
Warning lamp .......................... 170
ETD (Emergency Tensioning Device) ... 33
Safety guidelines ...................... 35
Exterior lamp switch ...................... 64
Exterior lighting
Overview ................................ 180
Exterior rear view mirrors .............. 61F
Flat tire ..................................... 187
Fluids
Capacities .............................. 218
Fog lamps ................................ 67, 180 Front air bags
see Air bags
Front compartment ........................ 123
Front lamps
Overview ................................ 180
Fuse chart ................................... 208
Fuses ......................................... 205 G
GAWR (Gross Axle Weight Rating) ...... 144
Global locking/unlocking ................ 53
Glove box .................................... 106
Gross Axle Weight Rating
see GAWR
Gross Vehicle Weight
see GVW
Gross Vehicle Weight Rating
see GVWR
GVW (Gross Vehicle Weight) ............. 144
GVWR (Gross Vehicle Weight Rating) .. 144 H
Halogen headlamps see Headlamps
Hazard warning flasher .................... 68
Head-thorax air bags ...................... 37
Headlamps
Automatic headlamp mode ............ 64
Daytime running lamp mode ......... 65
High-beam flasher ..................... 66
High-beam headlamps ................. 66
Low-beam headlamps .................. 64
Switch ..................................... 64
Heated exterior rear view mirrors ..... 61
Height adjustment
Seats ...................................... 59
High-beam flasher ......................... 66
High-beam headlamps ................ 66, 180
Indicator lamp ......................... 171
High-mounted brake lamp ............... 181
High-voltage battery
Battery care ............................ 113
Charge level gauge ..................... 81
Charging (AC power socket )......... 114
Charging (control system) ........... 92
Charging (private wallbox) ......... 115 6
Index

Opening and closing the rear
soft top ............................... 56, 72
Opening and closing the
retractable soft top ............... 55, 71
Removing the side rails .............. 73
Storing the side rails ................ 74
Sound package ............................... 97
SRS (Supplemental Restraint Sys-
tem)
Indicator lamp ........................ 169
Standing water, driving through ...... 152
Starter switch positions .................. 57
Starting the engine ........................ 76
Steering wheel paddle shifters .........79
Storage compartments .................... 106
Coin holder ............................. 106
Door pockets ........................... 106
Drawer ................................... 107
Glove box ................................ 106
in the tailgate ........................ .107
Parcel nets ............................ .107
Storage tray in center console .... 107
Storage trays next to steering
wheel .................................... .106
Storing tires ............................... 138
Sun screen ................................... 109
Sun visors ................................... 109 T
Tail lamps ................................... 181
Tailgate
Closing ............................... 55, 57
Opening .............................. 54, 56
Technical data
Brake fluid ............................ .218
Coolant ................................. .219
Dimensions and weights ............ .215
Identification labels ............... .214
Rims and tires ........................ .216
Service fluids and capacities ..... 217
Windshield/rear window washer
system ................................... 218
Temperature
Coolant ................................. .152
Interior temperature ................ 101
Outside ................................... 87 Tether anchorage points
see Children in the vehicle
Thorax-pelvis side air bags ............. 37
Tightening torque
Wheels ................................... 139
TIN (Tire Identification Num-
ber) ...................................... 142, 145
Tire and Loading Information plac-
ard ............................................ 133
Tire and loading terminology .......... 143
Tire Identification Number
see TIN
Tire inflation pressure
Checking ................................ 130
Important notes on .................... 129
Placard on driver’s door B-pil-
lar ........................................ 133
Tire labeling ...............................1 39
Tire load rating ........................... 145
Tire ply composition and material
used ........................................... 145
Tire Pressure Monitoring System
(TPMS) ........................................ 130
Tire repair kit ....................... 160, 187
Tire speed rating .................... 141, 145
Tires .................................... 127, 216
Air pressure ........................... 128
Care and maintenance ................ 137
Cleaning ................................ 138
Direction of rotation, spinning .. 137
Driving instructions ................ 150
Flat tire ................................. 187
Important notes on tire infla-
tion pressure .......................... 129
Inflation pressure .............. 129, 130
Information placard ................. 133
Inspection .............................. 137
Labeling ................................ 139
Load rating ............................. 145
Ply composition and material
used ...................................... 145
Problems under-/overinflation ... 129
Retreads ................................. 127
Rims and tires (technical data) ... 216
Rotation ................................. 139
Service life ............................ 137
Sizes ..................................... 216 10
Index

Snow chains ...........................
.146
Speed rating ................ 141, 145, 151
Storing .................................. 138
Temperature ......................1 29, 139
Terminology ........................... .143
Tire Identification Number .. 142, 145
Tire Pressure Monitoring Sys-
tem (TPMS) .............................. 130
Traction ..................... 138, 145, 150
Tread ..................................... 145
Tread depth ....................... 137, 146
Treadwear indicators .......... 137, 146
Vehicle maximum load on ........... 146
Wheel change ........................... 195
Winter tires ......................1 46, 216
Top tether
see Children in the vehicle
Total load limit ........................... 145
Tow-away alarm .............................49
Towing ....................................... 203
Traction ................................ 145, 150
Transmission
Driving tips ............................. 81
Hill-start assist system .............. 81
Shifting procedure .................... 79
Transmission position indicator ...... 84
Transmitting power values .............. 213
Traveling abroad .......................... 153
Tread (tires) ................................ 145
Tread depth (tires) .................. 137, 146
Treadwear indicators (tires) ..... 137, 146
Turn signal lamps .........................1 80
Turn signals ................................. 66
Indicator lamps ....................... 172
Turning off the engine .................... 79U
Uniform Tire Quality Grading
Standards .............................. 138, 146
Unlocking the vehicle ..................... 52
Manually ................................. 177
USB socket .................................... 96 V
Vehicle Bulbs .................................... .179 Care ...................................... 153
Data acquisition ....................... 19
Identification Number (VIN) ....... 215
Locking/unlocking .................... 52
Modifications and alterations,
Operating safety ....................... 16
Towing ................................... 203
Unlocking/locking manually ....... 177
Vehicle Homepage
Data protection ........................ 121
Functions ............................... 121
General information .................1 20
Internet connection .................. 122
Personal area .......................... 121
Vehicle Identification Number
(VIN) .......................................... 215
Vehicle lighting ........................... .64
Vehicle loading
Instructions ............................ 108
Load limit .............................. 134
Roof rack ................................ 108
Terminology ............................ 143
Vehicle maximum load on the tire .... 146
Vehicle specification ................... 215
Vehicle washing
see Vehicle care W
Warning signals Brake pads .............................. 177
Door ...................................... 176
Lighting ................................. 176
Parking .................................. 177
Parking brake .......................... 176
Seat belt reminder system .... 168, 176
Warranty coverage ......................... 212
Warranty information ......................13
Washer fluid
Mixing ratio ........................... 218
Refilling ................................ 126
Wiping .................................... 70
Washer jet nozzles .........................187
Washing the vehicle ......................153
Wheel change ...............................1 95
Wheels, sizes ............................... 216
Wheels, Tires and .......................... 127 Index
11

Operating safety
G
WARNING
Some safety systems only function while the drive system is switched on. You should
therefore never switch off the drive system
while driving. G
WARNING
Work improperly carried out on electronic
components and associated software could
cause them to cease functioning. Because
the vehicle’s electronic components are
interconnected, any modifications made
may produce an undesired effect on other
systems. Electronic malfunctions could
seriously impair the operating safety of
your vehicle.
See an authorized electric drive smart cen- ter for repairs or modifications to elec-
tronic components.
Improper work or modifications on other
vehicle systems could also have a negative
impact on the operating safety of the vehi-cle. G
WARNING
Heavy blows against the vehicle underbody
or tires/wheels, for example when running
over an obstacle, road debris or a pothole,
may cause serious damage and impair the
operating safety of your vehicle.
If you feel a sudden significant vibration
or ride disturbance, or you suspect that
damage to your vehicle has occurred, you
should turn on your hazard warning flash-
ers, carefully slow down, and drive with
caution to an area which is a safe distance from the road.
Inspect the vehicle underbody and tires/
wheels for possible damage. If the vehicle
appears unsafe, have it towed to the nearest
authorized electric drive smart center or
other maintenance or repair facility that
is qualified to work on smart electric vehi-
cles for further inspection or repairs. G
WARNING
A vehicle with an electric motor produces
significantly lower noise levels than a
vehicle with a combustion engine. Other
motorists or pedestrians, especially those who are visually or hearing impaired, may
be unable to hear your vehicle while it is in
motion. This is particularly true when
driving at lower speeds and during parking
maneuvers. At all times, it is the respon-
sibility of the driver to be aware of their
surroundings, especially in these low
speed situations. Otherwise other road
users could be seriously or fatally injured.
Vehicles equipped with an Acoustic Vehi-
cle Indication* emit a certain noise. Thus,
your vehicle will be better noticed by other
road users at low speeds (Y page 48). Danger of electric shock
The components of the drive system are
indicated by yellow warning labels to make
you aware of high voltage.
High‑voltage cables are orange‑colored. G
WARNING
Due to the high-voltage technology, elec-
trical leads under high voltage are instal- led in the vehicle. For this reason, work on
the vehicle may only be carried out by spe-
cially trained technicians.
For safety reasons, smart recommends all
work to be carried out by a smart service 16
>> Introduction. * optional

partner which is qualified for smart elec-
tric drive.
Particular care should be taken involving
all areas which are in the vicinity of high
voltage parts, e.g. parts in the engine com-
partment. Orange-colored cables and their respective sockets carry high voltage and
must not be damaged.
Serious injury or death can result if you:
R remove the covers of components which
are labeled with a warning sticker.
R handle components of the high-voltage
vehicle electrical system.
R open the housing.
R disconnect plug connectors.
R come into contact with components or
orange-colored cables of the high-volt-
age vehicle electrical system following
an accident.
R come into contact with orange-colored
cables or their damaged plug connectors.
R come into contact with damaged compo-
nents of the high-voltage vehicle elec-
trical system.
Have the damaged orange-colored cables or their damaged plug connectors replaced
immediately at an authorized electric
drive smart center. The service partner
must have the required knowledge and tools
to carry out the necessary work. For safety
reasons, smart recommends using a smart
center which is qualified for smart elec-
tric drive. Particularly for safety-rele-
vant work and work on safety-relevant vehi- cle systems, servicing by an authorized
electric drive smart center is essential.
Do not remove the high-voltage battery of
the high-voltage vehicle electrical sys-
tem. Have the required work carried out by
an authorized electric drive smart center.
smart recommends that you use an author-
ized electric drive smart center. G
WARNING
The high‑voltage battery of the drive sys-
tem is located under the vehicle’s under-
body. When the pressure inside the
high‑voltage battery exceeds a certain
value, for example in case of a vehicle fire, inflammable gas will escape via a duct. Theinflammable gas escapes to an area under
the vehicle. This prevents the high‑voltage
battery from exploding.
Stay away from this area of the vehicle.
When you carry out common works like
replacing bulbs or checking coolant level,
make sure that
R the ignition is switched off
R the charging cable for the high-voltage
battery is disconnected. Automatic switch-off of the high-volt-
age system
The high-voltage system will be automati- cally switched off, in the event:
R of an accident in which the restraint
systems are triggered
R of a short circuit in the high-voltage
system is detected
R that an electric connection in the high-
voltage system has been disconnected
This helps to avoid that you get in contact
with high-voltage. High-voltage battery
G
WARNING
The high‑voltage battery of the drive sys-
tem is located under the vehicle’s under-
body. When the pressure inside the
high‑voltage battery exceeds a certain
value, for example in case of a vehicle fire, inflammable gas will escape via a duct. Theinflammable gas escapes to an area under >> Introduction.
17 Z

the vehicle. This prevents the high‑voltage
battery from exploding.
Stay away from this area of the vehicle. High-voltage disconnect device
Your vehicle is equipped with a high-volt-
age disconnect device :to disable the
vehicle’s high-voltage system.
! The high-voltage system must only be
switched off at vehicle standstill by
specially trained service engineers.
Otherwise the high-voltage system may
be damaged. Proper use of the vehicle
Proper use of the vehicle requires that you
are familiar with the following informa-
tion and rules:
R the safety precautions in this manual
R the “Technical data” section in this man-
ual
R traffic rules and regulations
R motor vehicle laws and safety standards G
WARNING
Various warning labels are attached to your vehicle. These warning labels are intended
to make you and others aware of various
risks. You should not remove any of these
warning labels unless explicitly instruc-
ted to do so by information on the label
itself. Removal of any of these labels may cause you and others to be unaware of cer-
tain risks which may result in an accident
and/or personal injury. Problems with your vehicle
If you should experience a problem with
your vehicle, particularly one that you
believe may affect its safe operation, we
urge you to immediately contact an author-
ized electric drive smart center to have the problem diagnosed and corrected if
required. Do not drive the vehicle if you
believe it may not be safely operated. If the
matter is not handled to your satisfaction, please discuss the problem with the smart
center management, or if necessary contact
us at one of the following addresses:
In the USA:
Mercedes-Benz USA LLC
One Mercedes Drive
Montvale, NJ 07645
In Canada:
Customer Relations Department
98 Vanderhoof Avenue
Mercedes-Benz Canada, Inc.
Toronto, Ontario, M4G 4C9 Reporting safety defects
For the USA only: The following text is pub- lished as required of manufacturers under
Title 49, Code of U.S. Federal Regulations, Part 575 pursuant to the National Traffic
and Motor Vehicle Safety Act of 1966.
If you believe that your vehicle has a defect
which could cause a crash or could cause
injury or death, you should immediately
inform the National Highway Traffic Safety
Administration (NHTSA) in addition to
notifying Mercedes-Benz USA LLC.
If NHTSA receives similar complaints, it
may open an investigation, and if it finds 18
>> Introduction.

that a safety defect exists in a group of
vehicles, it may order a recall and remedy
campaign. However, NHTSA cannot become
involved in individual problems between
you, your dealer, or Mercedes-Benz USA
LLC.
To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327-4236
(TTY: 1-800-424-9153); go to
http://www.safercar.gov ; or write to:
Administrator, NHTSA Headquarters, 1200
New Jersey Avenue, SE, West Building,
Washington, DC 20590. You can also obtain
other information about motor vehicle
safety from http://www.safercar.gov. Vehicle data recording
Data recording
This vehicle is capable of recording diag-
nostic information relating to vehicle
operation, malfunctions, and user set-
tings. This may include information about
the performance or status of various sys-
tems, including but not limited to, engine, throttle, steering or brake systems, that isstored and can be read out with suitable
devices, particularly when the vehicle is
serviced. The data obtained is used to
properly diagnose and service your vehi-
cle or to further optimize and develop
vehicle functions. Event data recorders
This vehicle is equipped with an event data
recorder (EDR). The main purpose of an EDR is to record data that will assist in under- standing how a vehicle’s systems performed
in certain crash or near crash-like situa-
tions, such as during air bag deployment or when hitting a road obstacle. The EDR is
designed to record data related to vehicle
dynamics and safety systems for a short
period of time, typically 30 seconds or
less. The EDR in this vehicle is designed to
record such data as:
R how various systems in your vehicle are
operating
R whether or not the driver and passenger
seat belts are fastened
R how far (if at all) the driver is depress-
ing the accelerator and/or brake pedal
and
R how fast the vehicle is traveling
This data can help provide a better under-
standing of the circumstances in which
crashes and injuries occur. NOTE: EDR data
is recorded by your vehicle only if a non-
trivial crash situation occurs; no data is
recorded by the EDR under normal driving
conditions and no personal data (e.g.,
name, gender, age, and crash location) are
recorded. However, other parties, such as
law enforcement, can combine the EDR data with the type of personal identification
data routinely acquired during a crash
investigation.
To read data recorded by an EDR, special
equipment is required, and access to the
vehicle or the EDR is needed. In addition to
the vehicle manufacturer, other parties
that have the special equipment, such as
law enforcement, can read the information
by accessing the vehicle or the EDR.
EDR data may be used in civil and criminal
matters as a tool in accident reconstruc-
tion, accident claims, and vehicle safety.
Since the Crash Data Retrieval CDR tool
that is used to extract data from the EDR is commercially available, Mercedes-Benz
USA, LLC ("MBUSA") expressly disclaims
any and all liability arising from the
extraction of this information by unau-
thorized Mercedes-Benz personnel.
MBUSA will not share EDR data with others
without the consent of the vehicle owners
or, if the vehicle is leased, without the
consent of the lessee. Exceptions to this
representation include responses to sub-
poenas by law enforcement; by federal, >> Introduction.
19 Z

Occupant safety
Introduction
The smart vehicle is equipped with seat
belts and dual stage air bags to protect you
in a crash. However, children can be killed or seriously injured by an inflating air
bag. Indeed, there is a stronger risk of
serious death or bodily injury when an air
bag deploys on a child positioned in a
rear-facing child seat in the passenger
seat. Because this vehicle has only two
front seats and no backseat, it is limited as are other two-seat vehicles, in the extent
to which it may restrain children traveling
in the passenger front seat. Many states
have laws against placing children of cer- tain ages in the front seat of a vehicle that
has both front and back seats. Those laws
make exceptions to permit children to be
restrained in the front seat of two seat
vehicles. Special instructions and warn-
ings are provided below about when and if
you may restrain a child in the passenger
seat of the smart vehicle. Under certain
circumstances, it is appropriate for the
passenger air bag not to operate when a
child is restrained in a car seat in the
passenger seat, and this vehicle is equip- ped with technology to accomplish this.
Please pay very close attention to the
instructions and warnings below, particu-
larly as they relate to children.
In this section you will learn the most
important facts about the restraint system components of the vehicle.
The restraint systems are:
R Seat belts (Y page 31)
R Child restraints (Y page 42) Additional protection potential is provi-
ded by:
R Supplemental RestraintSystem (SRS)
with
- Air bags (Y page 33)
- Air bag control unit (with crash sen-
sors)
- Emergency Tensioning Devices and
seat belt force limiters (Y page 33)
R Air bag system components with
- Passenger front air bag off indicator
lamp (Y page 41)
- Passenger seat with OccupantClassi-
fication System (OCS) (Y page 39)
Although independent systems, their pro-
tective functions work in conjunction with each other.
i For information on infants and chil-
dren traveling with you in the vehicle
and restraint systems for infants and
children, see “Children in the vehicle”
(Y page 42).
The SRS system conducts a self-test when
the ignition is switched on and in regular intervals while the engine is running. This facilitates detection of malfunctions. The
SRS indicator lamp 6in the instrument
cluster comes on when the ignition is
switched on and goes out after approx-
imately four seconds.
The SRS components are in operational
readiness if the SRS indicator lamp 6
is not lit when the engine is running.
A malfunction in the system has been detec- ted if the SRS indicator lamp 6
R fails to go out after approximately 4 sec-
onds after the ignition was switched on
R does not come on at all
R comes on after the engine was started or
while driving G
WARNING
Modifications to or work improperly con-
ducted on restraint systems (such as seat 30
Occupant safety>> Safety.

assistant automatically provides full
brake boost, thereby potentially reducing
the braking distance.
X Apply continuous full braking pressure
until the emergency braking situation is
over.
The ABS will prevent the wheels from
locking.
When you release the brake pedal, the
brakes function again as normal. The
hydraulic brake assistant is then deacti-
vated. G
WARNING
When the hydraulic brake assistant is mal-
functioning, the brake system is still func- tioning normally, but without the addi-
tional brake boost that would normally be
provided during an emergency braking
maneuver. Therefore, the braking distance
may increase. G
WARNING
The hydraulic brake assistant cannot pre-
vent the natural laws of physics from acting on the vehicle, nor can it increase braking
efficiency beyond that afforded by the con-
dition of the vehicle brakes and tires or the traction afforded. The hydraulic brake
assistant cannot prevent accidents,
including those resulting from excessive
speed in turns, following another vehicle
too closely, or hydroplaning. Only a safe,
attentive, and skillful driver can prevent
accidents. The capabilities of a hydraulic
brake assistant equipped vehicle must
never be exploited in a reckless or dan-
gerous manner which could jeopardize the
user’s safety or the safety of others. Activating the hazard warning flasher
after an emergency braking maneuver
If you bring the vehicle to a complete stop
by strongly braking at a speed of more than
43 mph (70 km/h), the hazard warning
flasher comes on automatically as soon as the vehicle is at a standstill. The hazard
warning flasher will remain on until it is
switched off using the hazard warning
flasher switch (Y
page 68) or until the
speed of the vehicle has exceeded 6 mph
(10 km/h). Acoustic Vehicle Indication*
Vehicles with electric motors develop con-
siderably lower driving noises than vehi-
cles with combustion engines. Therefore
your vehicle in traffic might not be acous-
tically noticed by other road users in cer- tain situations.
In order to avoid this, a built-in sound
generator emits a certain noise (Acoustic
Vehicle Indication) within a speed range
between 0 to 20 mph (30 km/h). Thus, other
road users, especially pedestrians and
bicycle riders can notice your vehicle bet-
ter. Acoustic Vehicle Indication can also
be heard inside of the vehicle.
The volume of Acoustic Vehicle Indication depends on the current engine speed (rpm).The stronger you accelerate, the louder thenoise. At speed of more than 20 mph 30 km/h
the noise is switched off. From this speed
on the natural noises of the vehicle are
sufficient so that other road users can
notice the vehicle on time. Anti-theft systems
Electronic immobilizer
The electronic immobilizer prevents
unauthorized persons from starting your
vehicle.
When leaving the vehicle, always take the
key with you and lock the vehicle. The drive
system can be switched on by anyone with a
key that is left inside the vehicle. 48
Anti-theft systems>> Safety.
* optional

To minimize risk to you and to others, acti-
vate headlamps by turning exterior lamp
switch to position Lwhen driving or
when traffic and/or ambient lighting con-
ditions require you to do so.
In low ambient lighting conditions, only
switch from position ÃtoL with the
vehicle at a standstill in a safe location.
Switching from position ÃtoL will
briefly switch off the headlamps. Doing so
while driving in low ambient lighting con- ditions may result in an accident.
The automatic headlamp feature is only an
aid to the driver. The driver is responsible
for the operation of the vehicle’s lights at
all times.
X Turn the exterior lamp switch to position
Ã.
With the key in starter switch position 1,
the tail and parking lamps, the license
plate lamps, and the side marker lamps
will come on and go out automatically
depending on the brightness of the ambi-
ent light.
With the engine running, the low‑beam
headlamps, the tail and parking lamps,
the license plate lamps and the side
marker lamps will come on and go out
automatically depending on the bright-
ness of the ambient light.
Daytime running lamp mode* In USA, the daytime running lamp mode can
be deactivated.
In Canada, the daytime running lamp mode
is mandatory and therefore in a constant
mode.
Depending on the vehicle equipment, your
vehicle comes either with low-beam day-
time running lamps or with LED daytime
running lamps. Switching on:
X Start the drive system.
The daytime running lamps are switched
on.
On vehicles with low beam daytime run-
ning lamps the parking lamps also come
on.
Switching off - vehicles without rain-
light sensor*:
X Switch on the parking lamps Tor the
low‑beam headlamps M.
The daytime running lamps are switched
off.
Switching off - vehicles with rain-light
sensor*:
X Switch on the parking lamps Tor the
low‑beam headlamps M.
The daytime running lamps are switched
off.
or
X Turn the exterior lamp switch to position
Ã.
With the engine running, the low‑beam
headlamps, the tail and parking lamps,
the license plate lamps and the side
marker lamps will come on and go out
automatically depending on the bright-
ness of the ambient light.
Deactivating (USA only):
X Switch off the ignition.
X Remove the key from the starter switch.
X Switch on the high-beam flasher and
press button #on the key simultane-
ously.
An acoustic signal sounds.
The daytime running lamp mode is deac-
tivated. Lighting
65>> Controls.
* optional Z