service SSANGYONG NEW ACTYON SPORTS 2013 Owner's Guide

12-34610-01
1. SPECIFICATIONS
Description Specification
Steering wheel Type 4-spoke type
Gear box
(HPS)Type Rack and pinion type
Gear ratio 40.245
Steering angle Inner36.2˚
Outer32.4˚
Oil pump
(HPS)Type Vane type
Maximum pressure (kgf/cm2)90 ± 3
Pulley size (mm)Ø115
Operating temperature-40℃~150℃
Minimum turning radius (m) 5.8
Steering oil Type S-PSF-3
Capacity (L) Approx. 1.0
Service interval Daily check and add if necessary.
Steering column shaft Tilting angle-4.0/ 0° /+4.0° / +8.0°
This section describes the power steering pump and gear box based on the HPS (Hydraulic Power
Steering) system. For the information of the SSPS (Speed Sensing Power Steering) system, refer to
SSPS section under CHASSIS.

12-194610-01
Oil Pump Pressure Check ▶
Unscrew the pressure line fitting in power
steering pump.
Install the pressure gauge between the
power steering pump and the power steering
oil pressure line.
Place the shift lever to neutral position. Apply
the parking brake.
Open the valve in pressure gauge. Start the
engine and let it run at idle speed.
Turn the steering wheel several times so that
the oil temperature reaches to normal
operating level. 1.
2.
3.
4.
5.
Before checking the pressure, check the oil
level and belt tension. Prepare the empty
container to collect the spilled oil during the
service. Check the oil pump pressure to locate any
defect in oil pump.
Fully close the valve in pressure gauge and
measure the oil pressure. 6.
Relief pressure
90 ± 3 bar
Oil pump
Steering gear box
To prevent internal damage, do not close
the gauge valve over 10 seconds.
Keep the oil temperature at proper range. -
-

02-58810-01
3. GENERAL WARNINGS
Do not diagnose the circuit with a circuit tester or attempt to modify any air bag components including
the steering wheel, air bag mounting area and harness.
Incorrect inspection could cause a problem with an air bag and seat belt pretensioner, and they
cannot protect occupants properly. Inspection and repair service should be done only by a qualified
technician.
An infant or a child should not be seated on the front seat alone or on an adult's lap. An infant or a
child could be severely injured by air bag deployed.
A child restraint system should be placed on the rear seat which has the 3-point type seat
belt.
Never install a child restraint system on the front seat. Impact by the air bag inflation might cause
severe injury or even death.
When an occupant fastens the seat belt with unstable or inclined posture, the air bag cannot protect
the occupant properly. Moreover, the occupant may be injured by the air bag.
Do not incline toward the steering wheel while driving. If you hit the air bag before it is fully inflated,
brain or neck injury, or even death can occur.
Be careful not to strike the steering wheel, air bag mounting area, any air bag related component
(including wiring) and seat belt pretensioner. You might get severely injured by sudden deployment o
f
the air bag.
The air bag contains explosive materials, so handle it carefully when disposing or replacing it.
The air bag components will be very hot immediately after deployment. Do not touch them until they
cool down.
Once the air bag/seat belt pretentioner is triggered, it will not deploy again even if an additional impac
t
is applied to it. Once triggered air bag/seat belt pretensioner related components cannot be reused,
so they should be removed from the vehicle and the whole system should be replaced with a new
one.
Do not place any object or sticker on the air bag mounting area for correct and safe activation of the
air bag.
Do not bang the door. Otherwise, an air bag might operate erroneously.
Hold the outer rim of the steering so that the air bag can inflate without any hindrance.
Do not incline toward the steering wheel or hold the steering wheel with your hands
crossed. It will cause a problem with the air bag activation or severe injury when the air bag
inflates.
Never put your hands or feet on the dash board. You can severely injured when the air bag
inflates.
It is normal that a loud noise, dust and smoke occur when the air bag and seat belt pretensioner
operate.
The gas come out of air bag/seat belt pretensioner activation is non-toxic nitrogen gas. However, if
this gas occurs irritation to your skin, eyes, nose, and so on, wash it out with clean water. Seek
medical help if symptoms develop. -
-

-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-