sunroof SSANGYONG TURISMO 2013 Service Manual

06-98510-00
Center fascia switch
Passenger’s Window Switch
(same with rear window
switches)
Overhead console switch
Auto light sensor
Cigarette lighter
Power outlet socket
Driver’s seat
warmer switch
Rear fog lamp
switchESP OFF switch
Defogger switch
Passenger’s seat
warmer switch Front fog lamp switch
Front room lamp switch
Sunroof switch
Door coupled room lamp switch
Hazard warning
flasher switch

04-4
2. CAUTIONS WHEN WORKING
Wear clean work clothes and gloves.
Any unauthorized modification or operational test is not allowed since the sunroof motor and control
unit are preset at the factory.
Pay attention not to drop the sunroof assembly when removing it and do not keep it right up. -
-
-
Even though the sunroof can be operated when the engine is not running, operating the sunroof
repeatedly with the engine turned off will run down the battery. Operate the sunroof while the engine
is running.
When the sunroof operation is completed, release the switch. Keeping pressing the switch can result
in malfunction.
Especially in winter, never operate the sunroof if operation areas are iced. Wait until melted.
To prevent a theft, make sure that the sunroof is completely closed when leaving the vehicle. In
addition, rain or snow can get into the vehicle through the open sunroof.
When the sunroof is fully open, wind buffeting symptom can be worse. In this case, try to adjust the
sunroof position manually or open the sunroof until the wind buffeting is disappeared
Parts of the body can be trapped in the sunroof and can be struck by passing objects. Do not stick
hands, head or anything else out of the openings.
Remove any dirt and foreign material stuck on the edge of the sunroof glass periodically. -
-
-
-
-
-
-
4. MAJOR CHANGES
Sunroof drain rear hose
Sunroof drain rear hose route changed due to rear quarter panel change
3. CAUTIONS FOR OPERATION

04-57340-00
1. OVERVIEW
The sunroof is fitted to the roof panel. It consists of the sunroof switch, sunroof control unit, sunroof
motor, sunroof glass and drain hose.
The sunroof motor is operated by the sunroof control unit according to the operating signal from the
sunroof switch, which results in opening and closing of the sunroof glass.
2. LAYOUT
Sunroof motor
Sunroof control unit
Sunroof switchSunroof assembly

04-6
3. COMPONENTS OF SUNROOF
Sunroof assy
Motor assy-sunroof
Unit-control sunroof
Glass assy-sunroof
Welt-sunroof
Screw
BRKT-sunroof SUPT
Hose-sunroof drain FRT
Grommet-sunroof drain hose FRT 1.
2.
3.
4.
5.
6.
7.
8.
9.Hose-sunroof drain RR
Grommet-sunroof drain hose RR
Cover-sunroof tooling hole
PNL ASSY-sunroof sunshade
Cover-side INR
Cover-side OTR
Wind deflector ASSY-sunroof 10.
11.
12.
14.
15.
16.
17.

04-8
5. SUNROOF OPERATION
1) Tilting
Push the front side of the button when the glass is
closed then, motor actuate the operating
cable to lift up the glass.
Push the rear side of the button to put down the
glass.
Motor actuates the operating cable
Mechanical equipment lifts up & down the glass