steering SUBARU LEGACY 2005 4.G Service Manual

11 -4 1
Maintenance and service
– CONTINUED –
Power steering fluid !Checking the fluid level
Be careful not to burn yourself because the flu-
id may be hot.
"When power steering fluid is being added,
use only clean fluid, and be careful not to allow any dirt into the tank. And never use different
brands together.
"
Avoid spilling fluid when adding it in the tank.
The power steering fluid expands greatly as its tem-
perature rises; the fluid level differs according to fluid
temperature. Therefore, the reservoir tank has two dif-
ferent checking ranges for hot and cold fluids.
Check the power steering fluid level monthly.
1. Park the vehicle on a level surface, and stop the en-
gine.
2. Check the fluid level of the reservoir tank.
When the fluid is hot after the vehicle has been run:
Check that the oil level is between “HOT MIN” and
“HOT MAX” on the surface of the reservoir tank.
When the fluid is cool before the vehicle is run: Check
that the oil level is between “COLD MIN” and “COLD
MAX” on the surface of the reservoir tank.
3. If the fluid level is lower than the applicable “MIN”
line, add the recommended fluid as necessary to bring
the level between the “MIN” and “MAX” line.
If the fluid level is extreme low, it may indicate possible
leakage. Consult your SUBARU dealer for an inspec-
tion.
HOT MAX COLD MAXHOT MIN
COLD MIN
UBB519BB

11 -5 3
Maintenance and service
– CONTINUED –
Incorrect tire pressures detract from controllability and
ride comfort, and they cause the tires to wear abnor-
mally. "Correct tire pressure (tread worn evenly)
Roadholding is good, and steering is responsive. Roll-
ing resistance is low, so fuel consumption is also low-er. "
Abnormally low tire pressure (tread worn at
shoulders)
Rolling resistance is high, so fuel consumption is also
higher.
HSB052AA
HSB053AA

11 - 5 4
Maintenance and service
"
Abnormally high tire pressure (tread worn in cen-
ter)
Ride comfort is poor. Also, the tire magnifies the ef-
fects of road-surface bumps and dips, possibly result-
ing in vehicle damage.
Driving at high speeds with excessively low tire
pressures can cause the tires to deform severe-
ly and to rapidly become hot. A sharp increase
in temperature could cause tread separation,
and destruction of the tires. The resulting loss
of vehicle control could lead to an accident.
! Wheel balance
Each wheel was correctly balanced when your vehicle
was new, but the wheels will become unbalanced as
the tires become worn during use. Wheel imbalance
causes the steering wheel to vibrate slightly at certain
vehicle speeds and detracts from the vehicle’s
straight-line stability. It can also cause steering and
suspension system problems and abnormal tire wear.
If you suspect that the wheels are not correctly bal-
anced, have them checked and adjusted by your SUB-
ARU dealer. Also have them adjusted after tire repairs
and after tire rotation.
NOTE
Loss of correct wheel alignment* causes the tires
to wear on one side and reduces the vehicle’s run-
ning stability. Contact your SUBARU dealer if you
notice abnormal tire wear.
*: The suspension system is designed to hold each wheel at
a certain alignment (relative to the other wheels and to the
road) for optimum straight-line stability and cornering perfor-
mance.
HSB054AA

12-4
Specifications !
Capacities
Fuel tank16.9 US gal (64 liters, 14.1 Imp gal)
Engine oil2.5-liter models4.2 US qt (4.0 liters, 3.5 Imp qt)
3.0-liter models5.8 US qt (5.5 liters, 4.8 Imp qt)
Transmission oil (MT)3.7 US qt (3.5 liters, 3.1 Imp qt)
Transmission fluid (AT)2.5-liter non-turbo models10.0 US qt (9.5 liters, 8.4 Imp qt)
2.5-liter turbo models10.4 US qt (9.8 liters, 8.6 Imp qt)
3.0-liter models10.3 US qt (9.8 liters, 8.6 Imp qt)
AT differential gear oil2.5-liter non-turbo models1.3 US qt (1.2 liters, 1.1 Imp qt)
2.5-liter turbo and 3.0-liter models1.5 US qt (1.4 liters, 1.2 Imp qt)
Rear differential gear oil0.8 US qt (0.8 liter, 0.7 Imp qt)
Power steering gear fluid0.7 US qt (0.7 liter, 0.6 Imp qt)
Engine coolant2.5-liter non-turbo
modelsMT6.8 US qt (6.4 liters, 5.6 Imp qt)
AT6.7 US qt (6.3 liters, 5.5 Imp qt)
2.5-liter turbo mod- elsMT7.7 US qt (7.3 liters, 6.4 Imp qt)
AT7.6 US qt (7.2 liters, 6.3 Imp qt)
3.0-liter models7.6 US qt (7.2 liters, 6.3 Imp qt)

14-4
Index
Cup holder
Front passenger’s ......................................... 6-12
Rear passenger’s ......................................... 6-13
D
Daytime running light system ............................ 3-46
Differential gear oil Front ........................................................... 11-35
Rear ............................................................ 11-37
Dimensions ........................................................ 12-2
Disarming the system ........................................ 2-26
Disc brake pad wear warning indicators ............ 7-38
Dome light ................................................ 6-2, 11-82
Door locks ........................................................... 2-6
Door open warning light .................................... 3-31
Drive belts ....................................................... 11-30
Driving All-wheel drive vehicle .................................. 3-31
Car phone/mobile phone ................................. 10
Drinking ............................................................. 9
Drugs ................................................................. 9
Foreign countries ............................................ 8-7
Pets ................................................................. 11
Snowy and icy roads .................................... 8-13
Tips ..................................... 7-15, 7-23, 7-33, 8-7
Tired or sleepy ................................................. 10 E
Electrical system ............................................... 12-3
Electronic Brake Force Distribution (EBD)
system ........................................................... 7-41
Emergency Locking Retractor (ELR) ................ 1-18
Engine
Compartment overview ................................ 11-8
Coolant ....................................................... 11-19
Exhaust gas (Carbon monoxide) ................ 8, 8-3
Hood ............................................................. 11-5
Oil ............................................................... 11-12
Overheating .................................................. 9-20
Starting ......................................................... 7-10
Stopping ....................................................... 7-12
Exterior care ...................................................... 10-2 F
Flat tires .............................................................. 9-5
Floor mat ........................................................... 6-22
Fluid level
Automatic transmission .............................. 11-33
Brake .......................................................... 11-42
Clutch ......................................................... 11-43
Power steering ........................................... 11-41
Fog light switch ................................................. 3-50
Front
Differential gear oil ..................................... 11-35

14-7
Index
Oil pressure warning light .................................. 3-26
Outside mirrors .................................................. 3-61
Outside temperature indicator ........................... 3-37
Overheating engine ........................................... 9-20 P
Parking
Brake stroke ............................................... 11-48
Light switch ................................................... 3-49
Periodic inspection .............................................. 8-6 Power Door locking switches ................................... 2-10
Seat ................................................................ 1-5
Steering fluid ............................................... 11-41
Windows ....................................................... 2-31
Precautions against vehicle modification .. 1-37, 1-92
Preparing to drive .............................................. 7-10
Printed antenna ................................................... 5-2 R
Rear Combination lights ...................................... 11-76
Differential gear oil ...................................... 11-37
Gate .............................................................. 2-39
Seats ............................................................ 1-11
Rear seat
Folding down (Station wagon) ...................... 1-12 Rear window
Defogger button ............................................ 3-57
Wiper and washer switch .............................. 3-55
Recommended
Automatic transmission fluid ....................... 11-35
Brake fluid ................................................... 11-43
Clutch fluid .................................................. 11-44
OIL grade and viscosity ....... 11-16, 11-17, 11-32, 11-36, 11-40
Power steering fluid .................................... 11-42
Spark plugs ................................................. 11-29
Remote keyless entry system ........................... 2-12
Replacement Brake pad and lining ................................... 11-47
Wiper blades ............................................... 11-60
Replacing
Air cleaner element ..................................... 11-24
Battery (remote keyless entry system) ......... 2-16
Lost transmitters (keyless entry system) ...... 2-17
Replacing bulbs ............................................... 11-73 Cargo area light .......................................... 11-85
Dome light .................................................. 11-82
Door step light ............................................ 11-84
Front fog light .............................................. 11-76
Front turn signal light .................................. 11-76
Headlight .................................................... 11-74
High mount stop light .................................. 11-86

14-8
Index
License plate light ....................................... 11-80
Map light ..................................................... 11-83
Parking light ................................................ 11-76
Rear combination light ................................ 11-76
Trunk light ................................................... 11-86
Rocking the vehicle ........................................... 8-17
Roof rail and crossbar ....................................... 8-21 S Safety Precautions when driving .................................. 6
Symbol .............................................................. 3
Warnings ........................................................... 3
Seat Fabric ........................................................... 10-6
Heater ........................................................... 1-10
Seatbelt .................................................................. 6 Maintenance ................................................. 1-33
Pretensioners ............................................... 1-33
Safety tips ..................................................... 1-16
Warning light and chime ............................... 1-19
Seatbelts ........................................................... 1-16
Selector lever ........................................... 7-17, 7-26 Position indicator .......................................... 3-34
Shift lock release ...................................... 7-24, 7-35
Snow tires ......................................................... 8-15
Sounding a panic alarm ..................................... 2-15 Spark plugs ..................................................... 11-29
Specifications .................................................... 12-2
Speedometer ....................................................... 3-9 SRS
Curtain airbag ............................................... 1-80
Frontal airbag ............................................... 1-65
Side airbag ................................................... 1-80
SRS airbag (Supplemental Restraint System airbag) ....................................................... 6, 1-59
SRS airbag system warning light ...................... 3-24
Starting the engine ............................................ 7-10
State emission testing (U.S. only) ....................... 7-8
Steering wheel
Power ........................................................... 7-36
Tilt ................................................................. 3-63
Stopping the engine .......................................... 7-12
Storage compartment .......................................... 6-7
Sun shades ....................................................... 2-43
Sun visors ........................................................... 6-5
Supplemental Restraint System airbag (SRS) .. 1-59
Synthetic leather upholstery .............................. 10-6 T
Tachometer ....................................................... 3-11
Temperature gauge ........................................... 3-13
Temporary spare tire ........................................... 9-3
Tie-down hooks ................................................. 9-22

14-9
Index
Tilt steering wheel ............................................. 3-63 Tire
Chains .......................................................... 8-17
Inspection ................................................... 11-51
Pressures and wear .................................... 11-52
Replacement .............................................. 11-56
Rotation ...................................................... 11-55
Tires .................................................................. 12-5
Types .......................................................... 11-49
Tires and wheels ............................................. 11-49
Top tether anchorages ...................................... 1-55
Towing ............................................................... 9-21 All wheels on the ground .............................. 9-28
Flat-bed truck ................................................ 9-27
Tie-down hooks ............................................ 9-22
Weight .......................................................... 8-31
Trailer
Hitch ............................................................. 8-27
Hitches .......................................................... 8-37
Towing .......................................................... 8-31
Towing tips ................................................... 8-40
Trip meter ................................................. 3-10, 3-16
Trunk lid ............................................................. 2-35
Release handle ............................................. 2-37
Trunk light ........................................................ 11-86
Turn signal
Indicator lights .............................................. 3-34 Lever ............................................................. 3-47
U
Under-floor storage compartment ..................... 6-30 V
Valet mode ........................................................ 2-27
Vanity mirror ........................................................ 6-6
Vehicle Capacity weight ............................................ 8-19
Identification ............................................... 12-11
Vehicle Dynamics Control
OFF indicator light ........................................ 3-32
OFF switch ................................................... 7-48
Operation indicator light ................................ 3-31
System .......................................................... 7-43
Warning light ................................................. 3-32
Ventilator ............................................................. 4-2 W
Warning and indicator lights .............................. 3-20
Warning lights ABS .............................................................. 3-28
All-wheel drive .............................................. 3-31
Anti-lock Brake system ................................. 3-28
AT OIL TEMPerature .................................... 3-27