tow SUBARU OUTBACK 2000 3.G Owner's Manual

8-8and otherwise similar to on-road d riving c ond itions
. Op erating it und er
other than those c ond itions c ould sub jec t the vehic le to exc essive
stress whic h mig ht result in d amag e not elig ib le fo r rep air und er war-
ranty. If you d o take your SUBARU off road , you sho uld review the
c ommon sense p rec autions in the next sec tion (ap p li c ab le to the
OUTBACK) for g eneral g uid anc e. But p lease keep in m ind that your
vehic le ’s off-road c ap ab ilities are more limited than those of the OUT-
BACK.
Never attemp t to d rive throug h p ools and p ud d les, o r road s flood ed
with water. Water entering the eng ine air intake or the exhaust p ip e or
water sp lashing onto elec tric al p arts may d amag e yo ur vehic le and
may c ause it to stall. OUTBACK
Bec ause of the AWD feature and hig her g round c leara nc e, your
Sub aru c an b e d riven on ord inary road s or off-road . But p lease keep
in mind that an AWD Sub aru is a p asseng er c ar and i s neither a c on-
ventional off-road vehic le nor an all-terrain vehic le. If you d o take your
Sub aru off-road , c ertain c ommon sense p rec autions s uc h as the fol-
lowing should b e taken: Make c ertain that you and all of your p asseng ers ar e wearing seat
b elts. Carry some emerg enc y eq uip ment, suc h as a towing ro p e or
c hain, a shovel, wheel b loc ks, first aid kit and p o rtab le p hone or c iti-
zens b and rad io. Drive c arefully. Do not take unnec essary risks b y d riving in d ang er-
ous areas or over roug h terrain. Slow d own and emp loy extra c aution at all times. Wh en d riving off-
road , you will not have the b enefit of marked traff ic lanes, b anked
c urves, traffic sig ns and the like. Do not d rive ac ross steep slop es. Instead , d rive ei ther straig ht up
or straig ht d own the slop es. A vehic le c an muc h mor e easily tip over
sid eways than it c an end over end . Avoid d riving st raig ht up or d own
slop es that are too steep . Avoid sharp turning maneuvers, esp ec ially at hig her sp eed s.
Do not g rip the insid e or sp okes of the steering wh eel. A b ad

8-20n
To remove the crossbar
1. Loosen and remove the T –30 torx head sc rew from the top of
eac h c rossb ar end sup p ort.
2. Rotate the lower c lamp on the b ottom of eac h end sup p ort d own-
ward ap p roximately 90 .
3. Carefully raise the c rossb ar from roof rails. n To install the crossbar
Front crossbar:
Front c rossb ar has 100 LBS. Load Lab el on left-hand sid e.
HB1011BC
1. Before p lac ing the c rossb ar on the roof rails, ma ke sure that the
T-30 torx head sc rew is removed from the top of eac h c rossb a r end
sup p ort.
2. Rotate the lower c lamp on the b ottom of eac h end sup p ort d own-
ward ap p roximately 90 .
3. With the front d irec tion arrow lab el on the top r ig ht sid e of the
c rossb ar p ointing toward the front of the vehic le, c arefully p lac e the
c rossb ar ac ross the top of the vehic le so that the c rossb ar end sup -
p orts rest on the top of the roof rails ap p roximate ly 6 inc hes (152 mm)
rearward from the seam (joint) b etween the front ro of rail sup p ort and
the roof rail.
4. Rotate (raise) the lower c lamp up to the b ottom o f the roof rail and
loosely tig hten the T-30 torx head sc rew with the torx wrenc h p ro-
vid ed , throug h the top of the end sup p ort and into the thread ed insert
in the lower c lamp on eac h end of the c rossb ar.

8-22Trailer hitch (if equipped)
WARNING
Never exceed the maximum weight specified for the trailer
hitch. Exceeding the maximum weight could cause an accident resulting in serious personal injuries. Permissible trailer weight
changes depending on the situation. Refer to the next section“ Trailer towing ” for possible recommendations and limitations.
Trailer brakes are required when the towing load exceeds
1,000 lbs. (453 kg). Be sure your trailer has safety chains and that
each chain will hold the trailer ’s maximum gross weight. Towing
trailers without safety chains could create a traffic safety hazardif the trailer separates from the hitch due to coupling damage orhitch ball damage. Be sure to check the hitch pin and safety pin for positive lock-
ing placement before towing a trailer. If the ball mount comes off
the hitch receiver, the trailer could get loose and create a trafficsafety hazard. Use only the ball mount supplied with this hitch. Use the hitch
only as a weight carrying hitch. Do not use with any type ofweight distributing hitch.
The trailer hitc h is d esig ned to tow a Class 1 rate d load . A maximum of
2,000 lbs. (906 kg) g ross trailer weig ht and a maximum of 200 lbs. (90
kg) g ross tong ue weig ht are p ermissib le for the traile r hitc h.
When you tow a trailer, follow the instruc tions in the next sec tion “Trailer
towing ”.

Driving tips8-25
–
CONTINUED –
8. Connec t the hitc h wire harness
’s b lac k four –p in wire c onnec tor to
the towing trailer ’s wire harness
HB8021BB
9. Confirm p rop er func tion of the hitc h wire harness b y ind ivid ually
ac tivating the b rake, rig ht turn sig nal, left turn sig nal, stop , and p ark-
ing lig hts on the trailer. NOTE Always disconnect the trailer wire harness before launching or retrieving a watercraft. When you do not tow a trailer
Remove the b all mount from the hitc h rec eiver tub e and insert the
rec eiver c over onto the hitc h rec eiver tub e. Plac e the d ust c ap over the four –p in c onnec tor of the hitc h wire
harness to p rotec t ag ainst p ossib le d amag e. Oc c asionally lub ric ate terminals of the four –p in c onnec tor using
the terminal g rease.

8-26Trailer towing
Your c ar is d esig ned and intend ed to b e used p rimar
ily as a p asseng er-
c arrying vehic le. Towing a trailer p uts ad d itional load s on your c ar’s en-
g ine, d rivetrain, b rakes, tires and susp ension and has an ad verse effec t
on fuel ec onomy.
If you d o d ec id e to tow a trailer, your safety and satisfac tion d ep end
up on p rop er use of c orrec t eq uip ment and c autious o p eration of your ve-
hic le. Seek the ad vic e of your SUBARU d ealer to ass ist you in p urc has-
ing a hitc h and other nec essary towing eq uip ment ap p rop riate for your
vehic le. In ad d ition, b e sure to follow the instruc tions on c orrec t installa-
tion and use p rovid ed b y the trailer and other towi ng eq uip ment
manufac turers.
SUBARU assumes no resp onsib ility for injuries or ve hic le d amag e that
result from trailer towing eq uip ment, or from any e rrors or omissions in
the instruc tions ac c omp anying suc h eq uip ment or for your failure to fol-
low the p rop er instruc tions.
Warranties and maintenance
SUBARU warranties d o not ap p ly to vehic le d amag e or malfunc tion
c aused b y trailer towing . If you use your vehic le t o tow a trailer, more
freq uent maintenanc e will b e req uired d ue to the ad d itional load .
(Refer to “Maintenanc e sc hed ule und er severe d riving c ond ition s” in
the “Warranty and Maintenanc e Booklet ”.)
Und er no c irc umstanc es should a trailer b e towed wi th a new vehic le
or a vehic le with any new p owertrain c omp onent (eng ine, transmis-
sion, d ifferential, wheel b earing s, etc .) for the f irst 1,000 miles (1,600
km) of d riving . Maximum load limits
WARNING
Never exceed the maximum load limits explained below. Exceed- ing the maximum load limits could cause personal injury and/or
vehicle damage.

Driving tips8-27
–
CONTINUED –
CAUTION
Adequate size trailer brakes are required when the trailer and
its cargo exceed 1,000 lbs (453 kg) total weight. Before towing a trailer, check the trailer total weight, GVW,
GAWs and tongue load. Make sure the load and its distribution inyour vehicle and trailer are acceptable.
n Total trailer weight
The total trailer weig ht (trailer weig ht p lus its c arg o load ) must never
exc eed the maximum weig ht shown b elow.
Model
ConditionsMaximum totaltrailer weight
MT modelsWhen towing a trailer without brakes.1,000 lbs (453 kg)
When towing a trailer with brakes.2,000 lbs (906 kg)
AT modelsWhen towing a trailer without brakes.1,000 lbs (453 kg)
When towing a trailer with brakes.2,000 lbs (906 kg)
When towing a trailer on a long uphill grade continuously for over 5 miles (8 km) with an outside temperature of 104 F
(40 C) or above.1,000 lbs (453 kg)
OM-H2781
Total trailer weight

Driving tips8-29
–
CONTINUED –
HBF019BB
Gross Axle Weight
OM-H2784
To c hec k b oth GVWR and GAWR and to c onfirm that the total weig ht
and weig ht d istrib ution are within safe d riving lim its, you should have
your vehic le and trailer weig hed at a c ommerc ial we ig hing station.
Be sure that all c arg o is firmly sec ured to p revent a c hang e in weig ht
d istrib ution while d riving . n Tongue load
WARNING
If the trailer is loaded with more weight in the back of trailer ’s
axle than in the front, the load is taken off the rear axle of the tow- ing vehicle. This may cause the rear wheels to skid, especiallyduring braking or when vehicle speed is reduced during corner-
ing, resulting in over-steer, spin out and/or jackknifing.
Ensure that the trailer tong ue load is from 8 to 11 p erc ent of the total
trailer weig ht and d oes not exc eed the maximum valu e of 200 lb s (90
kg ).
The tong ue load c an b e weig hed with a b athroom sc al e as shown in
the illustration b elow. When weig hing the tong ue lo ad , b e sure to p osi-
tion the towing c oup ler at the heig ht at whic h it w ould b e d uring
ac tual towing , using a jac k as shown.

Driving tips8-31
–
CONTINUED –

Trailer hitches
WARNING
Never drill the frame or under-body of your vehicle to install a
commercial trailer hitch. If you do, dangerous exhaust gas, wateror mud may enter the passenger compartment through the drilledhole. Exhaust gas contains carbon monoxide, a colorless andodorless gas which is dangerous, or even lethal, if inhaled. Also,drilling the frame or under-body of your vehicle could cause dete-rioration of strength of your vehicle and cause corrosion aroundthe drilled hole.
CAUTION
Do not modify the vehicle exhaust system, brake system, or
other systems when installing a hitch or other trailer towingequipment. Do not use axle-mounted hitches as they can cause damage to
the axle housing, wheel bearings, wheels or tires.
Choose a p rop er hitc h for your vehic le and trailer. OUTBACK wagon
The use of a g enuine SUBARU trailer hitc h is rec omm end ed . A g enu-
ine SUBARU hitc h is availab le from your SUBARU d eal er.
If use of a non-g enuine hitc h is unavoid ab le, b e su re the hitc h is
suited to your vehic le and trailer. Consult with a p rofessional hitc h
sup p lier to assist you in c hoosing an ap p rop riate h itc h for your
vehic le. Be sure to follow all of the hitc h manufac turer’s instruc tions for
installation and use.
Never use a hitc h that mounts only to the rear b ump er. The b ump er is
not d esig ned to hand le that typ e of load .
For all typ es of hitc hes, reg ularly c hec k that the hitc h mounting b olts
and nuts are tig ht.

8-32
All vehicles except OUTBACK wagon
SUBARU d oes not offer ac c essory trailer hitc hes. Co nsult with a p ro-
fessional hitc h sup p lier to assist you in c hoosing an ap p rop riate hitc h
for your vehic le. Be sure to follow all of the hitc h manufac turer’s
instruc tions for installation and use.
Never use a hitc h that mounts only to the rear b ump er. The b ump er is
not d esig ned to hand le that typ e of load .
Reg ularly c hec k that the hitc h mounting b olts and n uts are tig ht.
Connecting a trailer
n Trailer brakes
WARNING
Adequate size trailer brakes are required when the trailer and
its cargo exceed 1,000 lbs (453 kg) total weight. Do not directly connect your trailer ’s hydraulic brake system
to the hydraulic brake system in your vehicle. Direct connectionwould cause the vehicle ’s brake performance to deteriorate and
could lead to an accident.
If your trailer ’s total weig ht (trailer weig ht p lus its c arg o weig h t)
exc eed s 1,000 lb s (453 kg ), the trailer is req uired to b e eq uip p ed with
its own b rake system. Elec tric b rakes or surg e b rak es are rec om-
mend ed , and must b e installed p rop erly. Chec k that your trailer’s
b rakes c onform with Fed eral, state/p rovinc e and /or other ap p lic ab le
reg ulations. Your SUBARU ’s b rake system is not d esig ned to b e
tap p ed into the trailer ’s hyd raulic b rake system. Please ask your
SUBARU d ealer and p rofessional trailer sup p lier for more information
ab out the trailer ’s b rake system.
n Trailer safety chains
WARNING
Always use safety chains between your vehicle and the trailer.
Towing trailer without safety chains could create a traffic safetyhazard if the trailer separates from the hitch due to coupling dam-age or hitch ball damage.

Driving tips8-33
–
CONTINUED –
In c ase the trailer hitc h c onnec tor or hitc h b all s
hould b reak or
b ec ome d isc onnec ted , the trailer c ould g et loose an d c reate a traffic
safety hazard .
For safety, always c onnec t the towing vehic le and t railer with trailer
safety c hains. Pass the c hains c rossing eac h other und er the trailer
tong ue to p revent the trailer from d rop p ing onto th e g round in c ase
the trailer tong ue should d isc onnec t from the hitc h b all. Allow suffi-
c ient slac k in the c hains taking tig ht-turn situati ons into ac c ount; how-
ever, b e c areful not to let them d rag on the g round .
For more information ab out the safety c hain c onnec t ion, refer to the
instruc tions for your hitc h and trailer. n Side mirrors
After hitc hing a trailer to your vehic le, c hec k tha t the stand ard sid e
mirrors p rovid e a g ood rearward field of view witho ut sig nific ant b lind
sp ots. If sig nific ant b lind sp ots oc c ur with the ve hic le’s stand ard sid e
mirrors, use towing mirrors that c onform with Fed er al, state/p rovinc e
and /or other ap p lic ab le reg ulations.
HB0085
n Trailer lights CAUTION
Direct splicing or other improper connection of trailer lights may
damage your vehicle ’s electrical system and cause a malfunction
of your vehicle ’s lighting system.