oil pressure SUZUKI GRAND VITARA 2022 Owners Manual

54P00-01E
SERVICE STATION GUIDE
1. Fuel (see section 1)
2. Engine hood (see section 5)
3. Tire changing tools (see section 8)
4. Engine oil dipstick
(see section 7)
5. Engine coolant (see section 7)
6. Windshield washer fluid
(see section 7)
7. Battery (see section 7)
8. Tire pressure (see tire information
label on driver’s door lock pillar)
9. Spare tire (see section 7) / Flat tire
repair kit (see section 8)
54P000002
LHD: Left Hand Drive
RHD: Right Hand Drive
24
7
6
(LHD)1
9
(RHD)
3
8 8
55
1(RHD) 2
1(LHD)
2
(D16AA Diesel engine)

2-73
BEFORE DRIVING
54P00-01E
Door lock (Door lock setting)
You can choose either once or twice oper-
ation(s) to unlock all doors (including the
tailgate) or release the dead lock system (if
equipped) by turning the key, or operating
the keyless entry system transmitter, key-
less push start system remote controller or
request switch.
You can also turn off or on the buzzer
sound when the door(s) is(are) locked or
unlocked.
Lights (Light setting)
(Footwell light setting) (if equipped)
The footwell lights can be programmed for
interlocked operation with either lighting
control or door operation and for no light-
ing.
Lane change (Turn signal light setting)
The turn signal and its indicator can be set
whether they flash three times even if you
return the turn signal control lever immedi-
ately after moving it.Antitheft (Theft deterrent alarm system
setting) (if equipped)
You can switch the theft deterrent alarm
system from the enabled state to the dis-
abled state, and vice versa.
The state of the theft deterrent alarm sys-
tem is shown on the information display as
follows:
• Mode A: Disabled state
• Mode D: Enabled state
NOTE:
For the theft deterrent alarm system of
Mexico and South Africa models, refer to
“For European countries, Mexico and
South Africa” in “SUPPLEMENT” section.Oil change (Oil life monitoring system
reset setting) (if equipped for gasoline
engine model)
The oil life monitoring system must be
reset after changing the engine oil and oil
filter.
TPMS (Tire pressure monitoring system
setting) (if equipped)
• You can check the current tire inflation
pressure on the information display.
• You can set one of the initial values of
tire pressure below that are indicated on
the tire information label.
– Comfort Mode
–Eco Mode
– Load Mode
Refer to “Tire pressure monitoring system
(TPMS) (if equipped)” in “OPERATING
YOUR VEHICLE” section for details.

2-92
BEFORE DRIVING
54P00-01E
ESP® OFF indicator light
57L30045
When the ignition switch is turned to “ON”
position or the engine switch is pressed to
change the ignition mode to “ON”, this light
comes on briefly so you can check that the
light is working.
When the ESP
® OFF switch is pushed to
turn off the ESP® systems (other than
ABS), the ESP® OFF indicator light comes
on and stays on.
For details of the ESP
® systems, refer to
“Electronic stability program (ESP®)” in
“OPERATING YOUR VEHICLE” section.
Hill descent control indicator light (if equipped)
79K050
When the ignition switch is turned to “ON”
position or the engine switch is pressed to
change the ignition mode to “ON”, this light
comes on briefly so you can check that the
light is working.
When you push the hill descent control
switch and the hill descent control operat-
ing conditions are fulfilled, the hill descent
control indicator comes on. If the hill
descent control indicator blinks, the hill
descent control will not be activated.
For details of the hill descent control sys-
tem, refer to “Hill descent control system (if
equipped)” in “OPERATING YOUR VEHI-
CLE” section.
Oil pressure light
50G051
When the ignition switch is turned to “ON”
position or the engine switch is pressed to
change the ignition mode to “ON”, this light
comes on. When the engine is started, the
light goes out. The light will come on and
remain on if there is insufficient oil pres-
sure. If the light comes on when driving,
pull off the road as soon as you can and
stop the engine.
Check the oil level and add oil if necessary.
If there is enough oil, the lubrication sys-
tem should be inspected by your SUZUKI
dealer before you drive the vehicle again.
NOTICE
• If you operate the engine with this
light on, severe engine damage can
result.
• Do not rely on the oil pressure light
to indicate the need to add oil. Peri-
odically check the engine oil level.

OPERATING YOUR VEHICLE
3
54P00-01E
60G408
OPERATING YOUR VEHICLE
Exhaust gas warning .......................................................... 3-1
Daily inspection checklist .................................................. 3-1
Engine oil consumption ..................................................... 3-2
Ignition switch
(vehicle without keyless push start system) .................... 3-3
Engine switch
(vehicle with keyless push start system) .......................... 3-5
Keyless push start system (if equipped) .......................... 3-6
Parking brake lever ............................................................. 3-10
Pedal ..................................................................................... 3-11
Starting engine
(vehicle without keyless push start system) .................... 3-12
Starting engine
(vehicle with keyless push start system) .......................... 3-14
Using transaxle ................................................................... 3-19
Gearshift indicator .............................................................. 3-21
Four-mode 4WD system (if equipped) .............................. 3-23
ENG A-STOP system
(engine auto stop start system) (if equipped) .................. 3-29
Adaptive cruise control system (if equipped) .................. 3-32
Cruise control (if equipped) ............................................... 3-42
Speed limiter (if equipped) ................................................. 3-45
Radar brake support system (if equipped) ....................... 3-47
Emergency stop signal (ESS) (if equipped) ...................... 3-63
Parking sensors (if equipped) ............................................ 3-64
Rearview camera (if equipped) .......................................... 3-71
Braking ................................................................................. 3-74
Electronic stability program (ESP®) ................................. 3-76
Tire pressure monitoring system (TPMS) (if equipped) .. 3-83

3-2
OPERATING YOUR VEHICLE
54P00-01E
NOTE:
It is normal for water to drip from the air
conditioning system after use.
4) Check that the hood is fully closed and
latched.
5) Check the headlights, turn signal lights,
brake lights and horn for proper opera-
tion.
6) Adjust the seat and head restraint.
7) Check the brake pedal and the parking
brake lever.
8) Adjust the mirrors.
9) Check that you and all passengers
have properly fastened your seat belts.
10)Check that all warning lights come on
as the ignition switch is turned to “ON”
position or the engine switch is pressed
to change the ignition mode to “ON”.
11)Check all gauges.
12)Check that the brake system warning
light turns off when the parking brake is
released.
Once a week, or each time you fill your fuel
tank, perform the following under-hood
checks:
1) Engine oil level
2) Coolant level
3) Brake fluid level
4) Battery solution level
5) Windshield washer fluid level
6) Hood latch operation
Pull the hood release handle inside the
vehicle. Check that you cannot openthe hood all the way without releasing
the secondary latch. Close the hood
securely after checking for proper latch
operation. See the item “All latches,
hinges and locks” of “Chassis, body
and others” in “Maintenance schedule”
in “INSPECTION AND MAINTE-
NANCE” section for lubrication sched-
ule.
Once a month, or each time you fill your
fuel tank, check the tire pressure using a
tire pressure gauge. Also check the tire
pressure of the spare tire.Engine oil consumption
It is normal for the engine to consume
some engine oil during normal vehicle
operation.
The amount of engine oil consumption
depends on viscosity and quality of the oil
and your driving conditions.
More oil is consumed during high-speed
driving and when there is frequent acceler-
ation and deceleration. Under high loads,
your engine also will consume more oil.
A new engine also consumes more oil,
since its pistons, piston rings and cylinder
walls have not yet become conditioned.
New engines reach the normal level of oil
consumption only after approximately
5000 km (3000 miles) driving.
Oil consumption:
Max. 1.0 L per 1000 km
(1 Qt. per 600 miles)
When judging the amount of oil consump-
tion, note that the oil may become diluted
and it is difficult to judge the accurate oil
level.
As an example, if a vehicle is used for
repeated short trips, and consumes a nor-
mal amount of oil, the dipstick may not
show any drop in the oil level at all, even
after 1000 km (600 miles) or more of driv-
ing. This is because the oil gradually
becomes diluted with fuel or moisture,
WA R N I N G
Check that the hood is fully closed
and latched before driving. If it is not,
it can fly up unexpectedly during
driving, obstructing your view and
resulting in an accident.

7-28
INSPECTION AND MAINTENANCE
54P00-01E
If the coolant level is below “LOW” mark,
more coolant should be added. When the
engine is cool, remove the degassing tank
cap by turning it counterclockwise slowly to
release any pressure. And add coolant
until the degassing tank level reaches
“FULL” mark. Never fill the degassing tank
above “FULL” mark.
Coolant replacement
Since special procedures are required, ask
your authorized SUZUKI dealer for this job.
Air cleaner
If the air cleaner is clogged with dust, there
will be greater intake resistance, resulting
in decreased power output and increased
fuel consumption.
(For gasoline engine model)
61MM0B063
1) Remove the air cleaner inlet hose (1).
2) Remove the bolts (2), loosen the bolt
(3) and lift the air cleaner case (4)
directly above.
61MM0B064
3) Unclamp the side clamps, and remove
the element from the air cleaner case. If
it appears to be dirty, replace it with a
new one.
4) Clamp the side clamps or tighten the
bolts securely.
WA R N I N G
It is hazardous to remove the reser-
voir tank cap (degassing tank cap) for
a diesel engine when the water tem-
perature is high, because scalding
fluid and steam may be blown out
under pressure. Wait until the coolant
temperature has lowered before
removing the cap.
NOTICE
When lifting the air cleaner, check that
the air cleaner does not interfere with
the engine oil dipstick (5) to avoid
damage the dipstick.
(4)(5)
(1) (2)
(3)

8-12
EMERGENCY SERVICE
54P00-01E
Engine trouble: Overheating
The engine could overheat temporarily
under severe driving conditions. If the
engine coolant temperature gauge indi-
cates overheating during driving:
1) Turn off the air conditioner, if equipped.
2) Take the vehicle to a safe place and
park.
3) Run the engine at a normal idle speed
for a few minutes until the indicator is
within the normal, acceptable tempera-
ture range between “H” and “C”.If the temperature indication does not
come down to within the normal, accept-
able range:
1) Turn off the engine and check that the
water pump belt and pulleys are not
damaged or slipping. If any abnormality
is found, correct it.
2) Check the coolant level in the reservoir.
If it is found to be lower than “LOW”
line, check radiator, water pump, radia-
tor hoses and heater hoses for leakage.
If leakage that may cause overheating
is found, do not run the engine until
these problems have been corrected.
3) If leakage is not found, carefully add
coolant to the reservoir and then the
radiator, if necessary. (Refer to “Engine
coolant” in “INSPECTION AND MAIN-
TENANCE” section.)
NOTE:
If engine overheats and you are not sure
what to do, contact your SUZUKI dealer.
79J007
WA R N I N G
If you see or hear escaping steam,
stop the vehicle in a safe place and
immediately turn off the engine to
cool it. Do not open the hood when
steam is present. When the steam
can no longer be seen or heard, open
the hood to see if the coolant is still
boiling. If it is, you must wait until it
stops boiling before you proceed.WA R N I N G
• It is hazardous to remove the radia-
tor cap (or degassing tank cap for a
diesel engine) when the water tem-
perature is high, because scalding
fluid and steam may be blown out
under pressure. The cap should
only be taken off when the coolant
temperature has lowered.
• To help prevent personal injury,
keep hands, tools and clothing
away from the engine cooling fan
and air-conditioner fan (if
equipped). These electric fans can
automatically turn on without warn-
ing.

13-4
INDEX
54P00-01E
Lap-shoulder belt with detachable connector .................. 2-31
License plate light ............................................................... 7-52
Light reminder buzzer ....................................................... 2-106
Lighting control lever ........................................................ 2-102
Lighting operation ............................................................. 2-102
Listening to a CD ................................................................. 5-57
Listening to an iPod
®.......................................................... 5-67
Listening to an MP3/WMA/AAC disc .................................. 5-60
Listening to files stored in a USB device .......................... 5-64
Listening to the radio ................................................. 5-50, 5-52
Low fuel warning light ......................................................... 2-95
Low tire pressure warning light ................................ 2-88, 3-83
Luggage compartment .......................................................... 5-7
Luggage compartment board ............................................. 5-18
Luggage compartment cover ............................................. 5-18
Luggage compartment hooks ............................................ 5-16
Luggage compartment pocket ........................................... 5-15
Luggage restraint loops ...................................................... 5-17
M
Main beam (high beam) indicator light .............................. 2-98
Maintenance schedule .......................................................... 7-2
Malfunction indicator light .................................................. 2-94
Manual heating and air conditioning system .................... 5-27
Manual transaxle.................................................................. 3-19
Manual transaxle oil ............................................................ 7-30
Master warning indicator light.......................................... 2-102
Mirrors .................................................................................. 2-20
O
Odometer .............................................................................. 2-71
Oil change request light ...................................................... 2-99
Oil filter replacement ........................................................... 7-24Oil level check ...................................................................... 7-21
Oil life .................................................................................... 2-67
Oil pressure light.................................................................. 2-92
Open door warning light...................................................... 2-94
Outside rearview mirror folding switch ............................. 2-21
Outside rearview mirrors..................................................... 2-20
Overhead console ................................................................ 5-12
P
Parking brake ....................................................................... 7-35
Parking brake lever .............................................................. 3-10
Parking sensors ................................................................... 3-64
Pedal...................................................................................... 3-11
Pinching prevention function ............................................. 2-19
Power-assisted brakes ........................................................ 3-74
R
Radar brake support system............................................... 3-47
Radar brake support system indicator light ...................... 2-96
Radar brake support system OFF indicator light.............. 2-96
Radio antenna ...................................................................... 5-38
RDS (Radio Data System).................................................... 5-54
Rear bottle holder ................................................................ 5-14
Rear combination light ........................................................ 7-50
Rear differential oil............................................................... 7-30
Rear fog light indicator light ............................................... 2-97
Rear seat belt guide ............................................................. 2-36
Rear seats ............................................................................. 2-24
Rear window wiper/washer switch ................................... 2-113
Rearview camera .................................................................. 3-71
Refill with oil and oil leakage check ................................... 7-26
Refilling ................................................................................. 7-22
Remote audio controls ........................................................ 5-81

13-5
INDEX
54P00-01E
Replacing tires and/or wheels ............................................ 3-91
Reversing light ..................................................................... 7-52
Roof rails or roof rack anchors .......................................... 5-19
Running-in .............................................................................. 4-1
S
Seat adjustment .......................................................... 2-21, 2-24
Seat belt inspection ............................................................. 2-37
Seat belt pretensioner system............................................ 2-48
Seat belt reminder ............................................................... 2-34
Seat belt warning ................................................................. 12-3
Seat belts and child restraint systems .............................. 2-28
Seat height adjustment lever .............................................. 2-22
Seat position adjustment lever........................................... 2-22
Seatback angle adjustment lever .............................. 2-22, 2-25
Selection of coolant............................................................. 7-26
Selection of ignition modes .................................................. 3-7
Setting mode ........................................................................ 2-71
Shopping hook..................................................................... 5-16
Shoulder anchor height adjuster ....................................... 2-36
Side air bags and side curtain air bags ............................. 2-55
Side door locks ...................................................................... 2-2
Side turn signal light ........................................................... 7-46
Spark plugs .......................................................................... 7-29
SPECIFICATIONS................................................................. 11-1
Specified oil................................................................. 7-20, 12-4
Speed limiter ........................................................................ 3-45
Speedometer ........................................................................ 2-64
Stability control system ...................................................... 3-77
Starting engine
(vehicle with keyless push start system) .......................... 3-14Starting engine
(vehicle without keyless push start system) ..................... 3-12
Steering ................................................................................. 7-35
Stuck vehicle .......................................................................... 4-5
Sun visor ................................................................................. 5-4
Sunroof ................................................................................... 5-9
Supplemental restraint system (air bags).......................... 2-50
T
Tachometer ........................................................................... 2-64
Tailgate.................................................................................... 2-5
Temperature gauge .............................................................. 2-65
Temporary-use spare tire (compact spare tire)................. 12-1
Theft deterrent alarm system .............................................. 12-5
Theft deterrent light ............................................................. 2-16
Thermometer ........................................................................ 2-67
Tilt/telescoping steering lock lever .................................. 2-114
Tire chains .............................................................................. 4-4
Tire changing tool .................................................................. 8-1
Tire inspection...................................................................... 7-36
Tire pressure monitoring system (TPMS) .......................... 3-83
Tire rotation .......................................................................... 7-38
Tires....................................................................................... 7-36
Towing................................................................................... 8-10
Traction control system ...................................................... 3-77
Trailer hitch installation points ............................................. 6-5
Trailer towing.......................................................................... 6-1
Transfer oil............................................................................ 7-30
Trip meter.............................................................................. 2-71
Turn signal control lever ................................................... 2-108
Turn signal indicators.......................................................... 2-98
Turn signal operation ........................................................ 2-109