light TATA SAFARI 2015 Owner's Guide
[x] Cancel search | Manufacturer: TATA, Model Year: 2015, Model line: SAFARI, Model: TATA SAFARI 2015Pages: 161, PDF Size: 2.55 MB
Page 116 of 161
116
POWER STEERING POWER STEERINGPOWER STEERING POWER STEERING
POWER STEERING
Procedure for Oil Filling and Bleeding of Power Procedure for Oil Filling and Bleeding of PowerProcedure for Oil Filling and Bleeding of Power Procedure for Oil Filling and Bleeding of Power
Procedure for Oil Filling and Bleeding of Power
Steering SteeringSteering Steering
Steering (Ensure that Power Steering fluid reservoir is totally
clean before starting the work)
1 . Fill the reservoir nearly full. Crank the engine for 10
seconds without allowing it to start (if possible). If engine
does start, shut the engine immediately. Check & refill
the reservoir repeat atleast three times, each time
checking & refilling the reservoir.
2 . Check for leakage in the system and if noticed take
corrective action.
3 . Start the engine and steer the vehicle from full left to full
right turns 3-4 times.
4 . Add fluid if necessary to maintain the level upto filter top.
NOTICE NOTICENOTICE NOTICE
NOTICE
Do not force the wheel against lock position either
extreme left or right. The power steering pump may get
damaged. Hold it lightly.
5 . When the engine is at steady speed, check for bubble
or foaming in the oil. If present it indicates that air is
getting sucked into the systems. Check the suction
line/fittings and correct if necessary.
6 . Once the system is bled properly and free from foaming
there should not be any appreciable change in oil level
in the reservoir, when the engine is started or stopped
repeatedly.
7 . Now the system is ready for driving.
Final oil level should be at ‘H’ mark on dip stick.
NOTICE NOTICENOTICE NOTICE
NOTICE
* Do not allow fluid level to drop significantly or run out
of the reservoir during the above operation. This may
induce air to the system.
* Do not start the engine without oil in the power steering
system. This will result in serious damage to the
pump. In case of emergency disconnect the pump belt
and then start the engine.
* Always use recommended oil from closed containers.
Any dirty oil poured in the system will result in damage
to pump and gear box.
M A I N T E N A N C E
ProCarManuals.com
Page 126 of 161
126
VEHICLE C VEHICLE CVEHICLE C VEHICLE C
VEHICLE C
ARE AREARE ARE
ARE
Polishes : Polishes :Polishes : Polishes :
Polishes :
Polishes and cleaners can restore shine to the painted surface
that has oxidised and become dull. They normally contain mild
abrasives and solvents that remove the top layer of the finish
coat. Polish your car if the finish does not regain its original shine
after using wax.
Cleaning of Carpets : Cleaning of Carpets :Cleaning of Carpets : Cleaning of Carpets :
Cleaning of Carpets :
Vacuum clean the carpet regularly to remove dirt. Dirt will make
the carpet wear out faster. Periodically shampoo the carpet to
keep it looking new.
Use carpet cleaners (preferably foam type). Follow the
instructions that come with the cleaner, applying it with a
sponge or soft brush. Keep the carpeting as dry as possible
by not adding water to the foam.
Cleaning of Windows, Front & Rear Glasses : Cleaning of Windows, Front & Rear Glasses :Cleaning of Windows, Front & Rear Glasses : Cleaning of Windows, Front & Rear Glasses :
Cleaning of Windows, Front & Rear Glasses :
Clean the windows inside and outside with commercially
available glass cleaners.
This will remove the haze that builds up on the inside of
windows. Use a soft cloth or paper towels to clean all glass and
plastic surfaces.VEHICLE CARE : VEHICLE CARE :VEHICLE CARE : VEHICLE CARE :
VEHICLE CARE :
The car is subjected to many external influences such as climate,
road conditions, industrial pollution and proximity to the sea.
These conditions demand regular care of the car body. Dirt,
insects, bird droppings, oil, grease, fuel and stone chippings should
be removed as soon as possible.
W WW W
W
ashing : ashing :ashing : ashing :
ashing :
Do not wash the car in direct sunlight, wash in shade. Spray the
car thoroughly with a cold water jet (car on a washing pit or
hoist). Mix car shampoo in the wash water. No solvent (fuel,
thinners) need be used.
NOTICE NOTICENOTICE NOTICE
NOTICE
Avoid wiping of painted surface in dry condition as it may
leave scratches on the painted surface.
Use a soft bristle brush, sponge or soft cloth and rinse it
frequently while washing. When you have washed the whole
exterior, dry it with a chamois or soft cloth. After drying the car,
inspect it for chips and scratches that could allow corrosion to
start. Apply touch up paint where necessary.
For vehicles with Rear View Camera : Use cover for camera For vehicles with Rear View Camera : Use cover for cameraFor vehicles with Rear View Camera : Use cover for camera For vehicles with Rear View Camera : Use cover for camera
For vehicles with Rear View Camera : Use cover for camera
during washing. during washing.during washing. during washing.
during washing.
M A I N T E N A N C E
ProCarManuals.com
Page 127 of 161
127
Maintaining the car when not in extended use : Maintaining the car when not in extended use :Maintaining the car when not in extended use : Maintaining the car when not in extended use :
Maintaining the car when not in extended use :
Park the car in covered, dry and if possible well-ventilated
premises.
Engage a gear.
Remove the cables from the battery terminals (first remove
the cable from the negative terminal).
Make sure the handbrake is not engaged.
Clean and protect the painted parts using protective wax.
Clean and protect the shiny metal parts using commercially
available special compounds.
Sprinkle talcum powder on the rubber windscreen wiper and
rear window wiper blades and lift them off the glass.
Slightly open the windows.
Cover the car with a cloth or perforated plastic sheet. Do
not use sheets of imperforated plastic as they do not allow
moisture on the car body to evaporate.
Inflate the tyres to 0.5 bar above the normal specified
pressure and check it at regular intervals.
Check the battery charge every six weeks.
Do not drain the engine cooling system.
VEHICLE C VEHICLE CVEHICLE C VEHICLE C
VEHICLE C
ARE AREARE ARE
ARE
Wiper Care : Wiper Care :Wiper Care : Wiper Care :
Wiper Care :
Wiper blade attack angle on windshield glass should be 90
0
i.e. perpendicular.
Remove wiper blade and root wiper arm on windshield glass
in the centre position. Check the gap between arm strip
and glass.
Adjust by twisting wiper arm as shown in the figure.
OK OKOK OK
OK FOR CHA FOR CHAFOR CHA FOR CHA
FOR CHA
T TT T
T
TERING & NOISY PR TERING & NOISY PRTERING & NOISY PR TERING & NOISY PR
TERING & NOISY PR
OBLEMS OBLEMSOBLEMS OBLEMS
OBLEMS
NO NONO NO
NO
T OK T OKT OK T OK
T OK Windshield
GlassVIE VIEVIE VIE
VIE
W W W W
W
WITHOUT WITHOUT WITHOUT WITHOUT
WITHOUT
WIPER BL WIPER BLWIPER BL WIPER BL
WIPER BL
ADE ADEADE ADE
ADE
M A I N T E N A N C E
ProCarManuals.com
Page 128 of 161
128
VEHICLE C VEHICLE CVEHICLE C VEHICLE C
VEHICLE C
ARE AREARE ARE
ARE
FOLL FOLLFOLL FOLL
FOLL
O OO O
O
WING GUIDELINES WING GUIDELINES WING GUIDELINES WING GUIDELINES
WING GUIDELINES
WILL HELP WILL HELP WILL HELP WILL HELP
WILL HELP
Y YY Y
Y
OU OU OU OU
OU
T TT T
T
O BET O BETO BET O BET
O BET
TER TERTER TER
TER
PROTECT YOUR VEHICLE FROM CORROSION PROTECT YOUR VEHICLE FROM CORROSIONPROTECT YOUR VEHICLE FROM CORROSION PROTECT YOUR VEHICLE FROM CORROSION
PROTECT YOUR VEHICLE FROM CORROSION
PROPER CLEANING : PROPER CLEANING :PROPER CLEANING : PROPER CLEANING :
PROPER CLEANING :
In order to protect your vehicle from corrosion it is recommended
that you wash your vehicle thoroughly and frequently in case :
1. There is an heavy accumulation of dirt and mud especially on
the underbody.
2. It is driven in areas having high atmosphere pollution due to
smoke, soot, dust, iron dust & other chemical pollutants.
3. It is driven in coastal areas.
4. The underbody must be thoroughly pressure washed after
every three months.
In addition to regularly washing your vehicle, the following
precautions need to be taken.
PERIODIC INSPECTION : PERIODIC INSPECTION :PERIODIC INSPECTION : PERIODIC INSPECTION :
PERIODIC INSPECTION :
1 . Regularly inspect your vehicle for any damage in the paint
film such as deep scratches and immediately get them
repaired from an authorised service center, as these defects
tend to accelerate corrosion.
2 . Inspect mud liners for damages.
3 . Keep all drain holes clear from clogging.PR PRPR PR
PR
OPER P OPER POPER P OPER P
OPER P
ARKING : ARKING :ARKING : ARKING :
ARKING :
Always park your vehicle in shade to protect it from harsh sunlight
or in a well-ventilated garage so that there is no dampness on
any part of the vehicle.
W WW W
W
ASHING ASHING ASHING ASHING
ASHING
Y YY Y
Y
OUR OUR OUR OUR
OUR
VEHICLE : VEHICLE :VEHICLE : VEHICLE :
VEHICLE :
Follow these tips while washing your vehicle. Follow these tips while washing your vehicle.Follow these tips while washing your vehicle. Follow these tips while washing your vehicle.
Follow these tips while washing your vehicle.
HAND HAND HAND HAND
HAND
W WW W
W
ASH : ASH :ASH : ASH :
ASH :
1 . Always wash your vehicle in shade and when the surface
is at room temperature.
2. Wash with mild car wash soap like "Car Shampoo" and use
a soft 100% cotton cloth to avoid scratches. Please take help
of your dealer to buy the right products.
3. Please be sure that you remove your wristwatch and wear
soft gloves to avoid scratches due to finger rings or nails.
4. To remove stubborn stains and contaminants like tar, use
turpentine or cleaners like "Stain Remover" which is safe
for painted surfaces. Again your dealer can help you in
selecting the right product.
5. Avoid substances like petrol, diesel, kerosene, benzene or
other solvents that cause damage to paint.
6. Dry your vehicle thoroughly to prevent any damp spots.
7. Rinse all surfaces thoroughly to prevent any traces of soap
and other cleaners as this may lead to the formation of
stains on the painted surface later.
M A I N T E N A N C E
ProCarManuals.com
Page 129 of 161
129
VEHICLE C VEHICLE CVEHICLE C VEHICLE C
VEHICLE C
ARE AREARE ARE
ARE
W WW W
W
A AA A
A
XING : XING :XING : XING :
XING :
Waxing and polishing is recommended to maintain the gloss
and wet-look appearance of your paint finish.
1. Use a good quality polish and wax for your vehicle.
2. Re-wax your vehicle when the water does not slip off the
surface and collects over the surface in patches.
Further tips for the care of your new vehicle finish : Further tips for the care of your new vehicle finish :Further tips for the care of your new vehicle finish : Further tips for the care of your new vehicle finish :
Further tips for the care of your new vehicle finish :
If your vehicle is washed in an automatic car wash, please
remember that the paint can be scratched by type of brushes,
unfiltered washing water or the washing process itself.
Scratching reduces paint durability and gloss, especially on
darker colours. It is suggested to wash the vehicle by hand with
cool and clean water using a soft cloth or sponge. Please do not
use soap but a car shampoo recommended by your dealer.
Please take the following precautions : Please take the following precautions :Please take the following precautions : Please take the following precautions :
Please take the following precautions :
1. Always wash your vehicle in shade, avoiding direct exposure
to sunlight during washing.
2. Dry wiping your vehicle may lead to the formation of
scratches and hence always use a soft cloth and clean water
while wiping your vehicle.
3. Always keep your vehicle parked in a well ventilated shade.
Exposure to heat with entrapped moisture promotes corrosion.4. Avoid driving on gravel roads, as the possibility of paint
chip off due to the impact of stones is high. If you are
driving on freshly tarred road, check immediately
afterwards for any stains & clean them.
5. External contamination in the form of sap or industrial
fall-out may mar or develop spots on a new finish. Hence
avoid parking your vehicle near trees, which are known
to drop sap, or near factories, which give out heavy smoke.
6. The acid content in bird droppings may damage the newly
painted finish and hence any bird dropping must be
immediately washed off.
7. The paint finish is susceptible to damage in case petrol,
brake fluid, liquid from car battery, oil, antifreeze,
transmission fluid or windshield solvent spills onto the
painted surface. In case of such a spillage immediately
rinse the affected area with water. Avoid wiping the area
far as possible, however if wiping is required, ensure that
you wipe the area gently with soft cotton cloth.
8. Avoid using sharp objects to scrap off tar or mud from a
painted surface as it may develop scratches or may peel
off the paint.
M A I N T E N A N C E
ProCarManuals.com
Page 134 of 161
134
AIR CONDITIONING AIR CONDITIONING AIR CONDITIONING AIR CONDITIONING
AIR CONDITIONING
Air Conditioning Air ConditioningAir Conditioning Air Conditioning
Air Conditioning
The Air Conditioning is a sealed system. Any major maintenance
should be done by Authorised Workshop.
There are couple of things which can be done by you to ensure proper
working of Air conditioning / Heating.
Periodically check the engine’s radiator and air conditioning
condensers for leaves, insects and dirt stuck in front surface.
These block the air flow and reduce the cooling efficiency. Use a light
water spray from a hose or a soft brush to remove them.
NO NONO NO
NO
TICE TICETICE TICE
TICE
Use only low pressure spray or soft bristle brush to clean condenser
and radiator fins.
Run the air conditioning at least once a week during winter season.
Run it at least for ten minutes with vehicle at steady speed and engine
at normal operating condition. This circulates lubrication oil in the
compressor.
For any complaint on A.C. and Heating get it attended at Authorised
Workshop.
NO NONO NO
NO
TICE TICETICE TICE
TICE
The system is charged with R 134 (a) - ‘Non C.F.C.’ refrigerant. Do
not top up with any other refrigerant.
M A I N T E N A N C E
ProCarManuals.com
Page 141 of 161
141
PRELIMINAR PRELIMINARPRELIMINAR PRELIMINAR
PRELIMINAR
Y Y Y Y
Y
TR TRTR TR
TR
OUBLE SHOO OUBLE SHOOOUBLE SHOO OUBLE SHOO
OUBLE SHOO
TING TINGTING TING
TING
SR. NO. SR. NO.SR. NO. SR. NO.
SR. NO.
PROBLEM OBSERVED PROBLEM OBSERVEDPROBLEM OBSERVED PROBLEM OBSERVED
PROBLEM OBSERVED
PROBABLE CAUSE PROBABLE CAUSEPROBABLE CAUSE PROBABLE CAUSE
PROBABLE CAUSE
A AA A
A
CTION CTION CTION CTION
CTION
T TT T
T
O BE O BE O BE O BE
O BE
T TT T
T
AKEN AKENAKEN AKEN
AKEN
STEERING SYSTEM STEERING SYSTEMSTEERING SYSTEM STEERING SYSTEM
STEERING SYSTEM
1. Hard steeringLess fluid in the power steering • Get the fluid topped up to
tankcorrect level
Air in the system • Get the air removed by bleeding
the system
Loose pump belt • Get the belt correctly adjusted
ELECTRICAL ELECTRICALELECTRICAL ELECTRICAL
ELECTRICAL
1. No lights on the dash board after Battery terminal got disconnected• Get the battery properly
turning on the ignition key Battery completely dead connected
• Get the battery charged
• Get the alternator & charging
circuit checked
• Check for parking lamp fuse
2. Non functioning electricalBlown fuse in the circuit • Replace the fuse if blown
accessories such as powerLoose connectors • Get the connection properly
windows, head lamps, fueltightened
tank flap, wiper and washer etc. Circuit relay loose • Tighten the relay correctly
in the mounting
Defective components • Get the defective component
replaced from Authorised
Workshop
PRELIMINARY TROUBLE SHOOTING
ProCarManuals.com
Page 155 of 161
155
A L P H A B E T I C A L I N D E X ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX
ALPHABETIC INDEX
A AA A
A
Air Bags 2 2
Aggregate Numbers-Location 1 2
Air Conditioning52, 134
Air Filter & Filter Element 105
Analog Clock 66
Anti Lock Brake System 7 9
Ashtray 6 1
Audio Warning 2 1
Automatic Hub Lock 8 2
B BB B
B
Battery 118
Belt Tension 135
Bonnet Opening / Closing 7 0
Brake Fluid 115
Brakes 7 9
Branded Lubricants 9 5
C CC C
C
Catalytic Converter 132
Central Locking System 13
Child Lock 20
Cigarette Lighter 60
Clutch Fluid 115
Collapsible Steering column 2 1
Combi-Switch 33
Coolants 9 4
D DD D
D
Door Locks 20
Driving Controls 28
Driving in adverse conditions 85
Driving Safety 89
E
ECU 1 1 7
EGR System 132
Engine Compartment 104
Engine Coolant 73
Engine Cooling System 106
Engine oil 72
Engine Oil & Oil Filter 108
Environment Protection 8
F FF F
F
Flat tyre replacement 120
Follow Me Home Headlamp 64
Front & Rear Fog Lights 38
Front / Rear Axle Oil 112
Front Seat 56
Front Windshield / Door Glass Demister 5 4
Fuel 92
Fuel Economy 84
Fuel Gauge 50
Fuel level 72
Fuel Tank Flap Switch 38
Fuel Tank Flap 61
Fuses 130
G GG G
G
Gauges 4 7
Gear Box 78
Gear Box Oil 1 1 0
Gear Shift Lever 32
Glove Box 62
H HH H
H
Hazard Warning 39
Head Lamps & Headlamp Adjustment 113
Headlamp Leveling Switch 40
Headrest 57
Headrest adjustment 1 8
High mounted stop lamp 67
I II I
I
Ignition Switch 29
Immobiliser- Anti Theft Security System 31
Important Information 6,7
Indicators 43
Instrument Cluster 42
J JJ J
J
Jack & Tools 59
Jump Seats 59
ProCarManuals.com
Page 156 of 161
156
A L P H A B E T I C A L I N D E X ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX
ALPHABETIC INDEX
L LL L
L
Limited Slip Differential 82
Lubricants 9 3
Load consciouse pressure
reducing valve 117
M MM M
M
Middle Seat 57
Mirror (Inside) 63
Mirror (Motorised) 60
Mirror Demister 39
MP3/DVD player 67
Music System 66
O OO O
O
Odometer 47
Operating Switch 38
P PP P
P
Panel Lights 47
Parking Brake 32
Power Steering Fluid 115
Power Windows 55
Preparing to drive 77
Prior to driving – Check List 71
R RR R
R
Rear Seat 5 7
Rear Windshield Demister 39
Rear Windshield Wash & Wipe 39
Remote bypass valve 1 1 8
Relays 131
Reverse Guiding System 65
Roof Lights 63
Roof Mounted A.C. 54
Roof Rail 88
RPM Meter 49
Running in Period 77
S SS S
S
Seat Adjustment 58
Seat belt 1 6
Seat belt precautions 1 9
Service Schedule 144
Spare Wheel 1 2 5
Speedometer 4 8
Starting / Stopping the engine 7 6
Steering Lock 29
Steering Wheel Position Adjustment 38
Sunvisors 6 5
T TT T
T
Tail lamp 67
Technical Specifications 97
Temperature Gauge 50
Towing the vehicle 88
Transfer case 4X4 operation 82
Transfer case Electric Shift Switch 36
Transfer case oil 1 1 1
Trouble Shooting 136
Turbo Charger 133
Tyre 120,123
Tyre Rotation 124
V VV V
V
Vehicle Care 126
Vehicle Record Sheet 1 4 9
Vehicle Specifications 9 7
W WW W
W
Warranty-Terms & Condition 10
Wheels & Tyres 120
Wheel Alignment 123
Wheel Balancing 123
Wiper Care 127
ProCarManuals.com