ignition TOYOTA AURIS 2012 (in English) Service Manual

6217-2. Steps to take in an emergency
UK_AURIS/AURIS_HV_EE (OM12E33E)
7
When trouble arises
Once
The driver’s door
was opened and
closed with the
engine switch
turned off and
then the engine
switch was put in
ACCESSORY or
IGNITION ON
mode twice with-
out the engine
being started.
Press the
engine
switch
while
depress-
ing the
clutch
pedal.
During an engine
starting proce-
dure in the event
that the electronic
key was not func-
tioning properly
(P. 6 7 1 ) , t h e
engine switch was
touched with the
electronic key.
Press the
engine
switch
while
depress-
ing the
clutch
pedal
within 10
seconds of
the buzzer
sounding.
Interior
buzzerExterior
buzzerWarning messageDetailsCorrection
procedure
(Flashes)
(Vehicles with manual
transmission)
*1

6777-2. Steps to take in an emergency
UK_AURIS/AURIS_HV_EE (OM12E33E)
7
When trouble arises
Start the engine of the second vehicle. Increase the engine speed
slightly and maintain at that level for approximately 5 minutes to
recharge the 12-volt battery of your vehicle.
Open and close any of the doors of your vehicle with the engine
switch off.
Vehicles without a smart entry & start system:
Maintain the engine speed of the second vehicle and turn the
engine switch to the “ON” position, then start the vehicle's engine.
Vehicles with a smart entry & start system:
Maintain the engine speed of the second vehicle and turn the
engine switch to IGNITION ON mode, then start the vehicle's
engine.
Once the vehicle’s engine has started, remove the jumper cables in
the exact reverse order from which they were connected.
Once the engine starts, have the vehicle inspected at any authorized
Toyota dealer or repairer, or another duly qualified and equipped pro-
fessional as soon as possible.
Starting the engine when the 12-volt battery is discharged
The engine cannot be started by push-starting.
To prevent 12-volt battery discharge
Turn off the headlights and the audio system while the engine is off.
Turn off any unnecessary electrical components when the vehicle is running
at a low speed for an extended period, such as in heavy traffic.
When the 12-volt battery is removed or discharged (vehicles with an
alarm)
Make sure that the key is not inside the vehicle when recharging or replacing
the battery. The key may be locked in the vehicle if the alarm is activated.
(P. 105)
Charging the 12-volt battery
The electricity stored in the 12-volt battery will discharge gradually even when
the vehicle is not in use, due to natural discharge and the draining effects of
certain electrical appliances. If the vehicle is left for a long time, the 12-volt
battery may discharge, and the engine may be unable to start. (The 12-volt
battery recharges automatically during driving.)
4
5
6
7

7108-1. Specifications
UK_AURIS/AURIS_HV_EE (OM12E33E)
Hybrid model
Capacity (reference)
Gasoline engine
With an exhaust heat
recovery system
Without an exhaust heat
recovery system
Power control unit
7.2 L (7.6 qt., 6.3 Imp. qt.)
6.5 L (6.9 qt., 5.7 Imp. qt.)
2.1 L (2.2 qt., 1.8 Imp. qt.)
Coolant typeUse either of the following.
• “Toyota Super Long Life Coolant”
• Similar high-quality ethylene glycol-
based non-silicate, non-amine, non-
nitrite, and non-borate coolant with long-
life hybrid organic acid technology
Do not use plain water alone.
Ignition system (gasoline engine)
Spark plug
MakeDENSO SC20HR11
Gap1.1 mm (0.043 in.)
NOTICE
Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark plug gap.

726
UK_AURIS/AURIS_HV_EE (OM12E33E)
What to do if... (Troubleshooting)
What to do if... (Troubleshooting)
If you lose your keys or mechanical keys, new genuine keys or
mechanical keys can be made by any authorized Toyota dealer or
repairer, or another duly qualified and equipped professional.
(P. 149)
If you lose your keys or electronic keys, the risk of vehicle theft
increases significantly. Contact any authorized Toyota dealer or
repairer, or another duly qualified and equipped professional
immediately. (P. 150)
Is the key battery weak or depleted? (P. 529)
Vehicles with a smart entry & start system (except hybrid model):
Is the engine switch in IGNITION ON mode?
When locking the doors, turn the engine switch off. (P. 261)
Vehicles with smart entry & start system (hybrid model):
Is the power switch in ON mode?
When locking the doors, turn the power switch off. (P. 270)
Vehicles with a smart entry & start system:
Is the electronic key left inside the vehicle?
When locking the doors, make sure that you have the electronic
key on your person.
The function may not operate properly due to the condition of the
radio wave. (P. 158)
If you have a problem, check the following before contacting any
authorized Toyota dealer or repairer, or another duly qualified
and equipped professional.
The doors cannot be locked, unlocked, opened or closed
You lose your keys
The doors cannot be locked or unlocked

729What to do if... (Troubleshooting)
UK_AURIS/AURIS_HV_EE (OM12E33E)
Vehicles without a smart entry & start system:
Is the engine switch in the “ON” position?
If you cannot release the shift lever by depressing the brake pedal
with the engine switch in the “ON” position. (P. 668)
Vehicles with a smart entry & start system:
Is the engine switch in IGNITION ON mode?
If you cannot release the shift lever by depressing the brake pedal
with the engine switch in IGNITION ON mode. (P. 668)
Vehicles without a smart entry & start system:
It is locked to prevent theft of the vehicle if the key is pulled from
the engine switch. (P. 256)
Vehicles with a smart entry & start system:
It is locked automatically to prevent theft of the vehicle. (P. 264)
Is the window lock switch pressed?
The power window except for the one at the driver’s seat cannot
be operated if the window lock switch is pressed. (P. 220)
The shift lever cannot be shifted from P even if you
depress the brake pedal (vehicles with a multidrive)
The steering wheel cannot be turned after the engine is
stopped (except hybrid model)
The windows do not open or close by operating the power
window switches

730What to do if... (Troubleshooting)
UK_AURIS/AURIS_HV_EE (OM12E33E)
The auto power off function will be operated if the vehicle is left in
ACCESSORY or IGNITION ON mode (the engine is not running)
for a period of time. (P. 264)
The auto power off function will be operated if the vehicle is left in
ACCESSORY or ON mode (the hybrid system is not operating) for
a period of time. (P. 271)
The seat belt reminder light is flashing
Are the driver and the front passenger wearing the seat belts?
(P. 590)
The parking brake indicator is on
Is the parking brake released? (P. 298)
Depending on the situation, other types of warning buzzer may also
sound. (P. 585, 599)
The engine switch is turned off automatically (vehicles
with smart entry & start system) (except hybrid model)
The power switch is turned off automatically
(hybrid model)
A warning buzzer sounds during driving

731What to do if... (Troubleshooting)
UK_AURIS/AURIS_HV_EE (OM12E33E)

Did anyone inside the vehicle open a door or anything move inside
the vehicle
* during setting the alarm?
The sensor detects them and the alarm sounds. (P. 103)
*: If the vehicle is equipped with intrusion sensor.
Vehicles without a smart entry & start system (except hybrid model):
To stop the alarm, turn the engine switch to the “ON” position or start
the engine.
Vehicles with a smart entry & start system (except hybrid model):
To stop the alarm, turn the engine switch to IGNITION ON mode or
start the engine.
Hybrid model:
To stop the alarm, turn the power switch to ON mode or start the
hybrid system.
Is the electronic key left inside the vehicle?
Vehicles with a multi-information display: Check the message on
the multi-information display. (P. 599)
When a warning light turns on, refer to P. 585.
An alarm is activated and the horn sounds
(vehicles with an alarm)
A warning buzzer sounds when leaving the vehicle
(vehicles with a smart entry & start system)
A warning light turns on
(vehicles with a drive monitor display)

736Alphabetical index
UK_AURIS/AURIS_HV_EE (OM12E33E)
Eco drive mode ........................ 292
Eco Driving Indicator............... 138
Electric Power Steering
(EPS) ....................................... 356
Function ................................ 356
Warning light ......................... 588
Electronic key .......................... 148
Battery-saving function ......... 157
If the electronic key does not
operate properly ................. 670
Replacing the battery ............ 529
Emergency, in case of
If the 12-volt battery is
discharged .......................... 680
If the battery is discharged .... 674
If the electronic key does
not operate properly ........... 670
If the engine will not start ...... 664
If the hybrid system
will not start......................... 670
If the shift lever cannot be
shifted from P ..................... 668
If the warning buzzer
sounds ................................ 585
If the warning light turns on ... 585
If the warning message is
displayed ............................ 599
If you have a flat tire...... 626, 638
If you think something is
wrong .................................. 583
If your vehicle becomes
stuck ................................... 692
If your vehicle has to be stopped
in an emergency ................. 573
If your vehicle needs to be
towed .................................. 575
If your vehicle
overheats .................... 685, 687Emergency brake signal ......... 357
Emergency flashers ................ 572
Emergency tire puncture
repair kit ................................. 638
Engine....................................... 701
Accessory mode ................... 261
Compartment ........................ 492
Engine switch................ 254, 258
Hood ..................................... 488
How to start the
engine......................... 254, 258
How to start the hybrid
system ................................ 268
Identification number ............ 700
If the engine will not start ...... 664
If the hybrid system
will not start ........................ 670
Ignition switch
(engine switch) ........... 254, 258
Ignition switch
(power switch) .................... 268
Overheating .................. 685, 687
Power switch......................... 268
Engine coolant ......................... 505
Capacity ................................ 709
Checking ............................... 505
Preparing and checking
before winter....................... 368
Engine coolant temperature
gauge...................................... 122
Engine immobilizer system ...... 91
E

738Alphabetical index
UK_AURIS/AURIS_HV_EE (OM12E33E)
Hands-free system
(for cellular phone)*
Head restraints......................... 212
Headlights ................................ 300
Adaptive Front-lighting
System (AFS) ..................... 303
Automatic High Beam
system ................................ 306
Discharge headlights
precautions ......................... 570
Follow me home system ....... 302
Light switch ........................... 300
Replacing light bulbs ............. 555
Wattage................................. 716
Heaters
Heater system ....................... 374
Outside rear view mirrors ...... 398
Seat heaters.......................... 465
Hill-start assist control ............ 362
Hood.......................................... 488
Open ..................................... 488
Hooks
Cargo hooks.......................... 451
Coat hooks ............................ 469
Retaining hooks (floor mat) ..... 38
Horn .......................................... 299
Hybrid battery
(traction battery) ...................... 84
Hybrid battery
(traction battery) air vents ...... 85Hybrid system ............................ 80
Emergency shut off system .... 85
Energy monitor/
consumption screen ........... 142
EV drive mode ...................... 274
High voltage components ....... 84
Hybrid System Indicator........ 136
Hybrid system precautions ..... 84
Hybrid vehicle driving tips ..... 366
If the hybrid system
will not start ........................ 670
Overheating .......................... 687
Power (ignition) switch .......... 268
Starting the hybrid system .... 268
Hybrid System Indicator ......... 136
Hybrid transmission ................ 289
Identification ............................ 699
Engine................................... 700
Vehicle .................................. 699
Ignition switch
(engine switch) .............. 254, 258
Ignition switch
(power switch) ....................... 268
Illuminated entry system ........ 444
Immobilizer system ............. 91, 99
Indicators ................................. 119
Initialization
Power windows ..................... 222
Inside rear view mirror ............ 215
Intercooler ................................ 507
Interior lights............................ 441
Intrusion sensor ...................... 107
ISOFIX rigid anchors ................. 68
H
I

743Alphabetical index
UK_AURIS/AURIS_HV_EE (OM12E33E)
Specifications .......................... 696
Speech command system*
Speed limiter ............................ 327
Speedometer .................... 122, 126
Sport mode ............................... 277
Steering lock
Column lock release ..... 256, 265
Steering lock system
warning message ............... 611
Steering wheel ......................... 214
Adjustment ............................ 214
Audio switches ...................... 438
Stop & Start cancel switch...... 351
Stop & Start system................. 350
Stop & Start system
operation time........................ 124
Stop & Start system total
operation time........................ 124
Stop lights
Emergency brake signal ....... 357
Replacing light bulbs ............. 555
Storage feature ........................ 445
Stuck
If the vehicle becomes
stuck ................................... 692
Sun visors ................................ 458
Sunshade
Panoramic roof...................... 471Switches
AFS OFF switch.................... 303
Airbag manual on-off
switch ................................... 56
Audio remote control
switches.............................. 438
Cruise control switch............. 322
“DISP” button ........ 123, 127, 129
Door lock switches ................ 200
Emergency flashers switch ... 572
Engine switch................ 254, 258
“ES” switch............................ 282
Fog light switch ..................... 310
Ignition switch ............... 254, 258
Toyota parking assist-sensor
switch ................................. 330
Light switches ....................... 300
Outside rear view mirror
switches.............................. 217
Paddle shift switches .... 278, 282
Power door lock switch ......... 200
Power switch......................... 268
Power window switches ........ 220
“SPORT” switch .................... 277
Stop & Start cancel switch .... 350
Rear window and outside
rear view mirror defoggers
switch ................................. 398
Seat heater switches ............ 465
Talk switch*
Telephone switches*
VSC OFF switch ................... 358
Window lock switch............... 220
Windshield wiper and
washer switch ..................... 312
*: Refer to ““touch screen” Owner’s manual”