cooling TOYOTA AURIS HYBRID 2017 User Guide

6028-2. Steps to take in an emergency
AURIS Touring Sports_EE (12L13E)
WARNING
■Battery precautions
The battery contains poisonous and corrosive acidic electrolyte, while
related parts contain lead and lead compounds. Observe the following pre-
cautions when handling the battery:
●When working with the battery, always wear safety glasses and take care
not to allow any battery fluids (acid) to come into contact with skin, clothing
or the vehicle body.
●Do not lean over the battery.
●In the event that battery fluid comes into contact with the skin or eyes,
immediately wash the affected area with water and seek medical attention.
Place a wet sponge or cloth over the affected area until medical attention
can be received.
●Always wash your hands after handling the battery support, terminals, and
other battery-related parts.
●Do not allow children near the battery.
NOTICE
■When handling jumper cables
When connecting the jumper cables, ensure that they do not become entan-
gled in the cooling fans or engine drive belt.
AURIS Touring Sports_OM_Europe_OM12L13E.book 602 ページ ２０１６年６月２７日　月曜日　午後５時２１分

6038-2. Steps to take in an emergency
AURIS Touring Sports_EE (12L13E)
8
When trouble arises
●Vehicles with a 3-ring meter: The high engine coolant temperature
warning light (P. 545) comes on or a loss of engine power is
experienced (for example, the vehicle speed does not increase).
Vehicles with a 2-ring meter: The engine coolant temperature
gauge (P. 98) enters the red zone or a loss of engine power is
experienced (for example, the vehicle speed does not increase).
●Steam comes out from under the hood.
Stop the vehicle in a safe place and turn off the air conditioning sys-
tem, and then stop the engine.
If you see steam:
Carefully lift the hood after the steam subsides.
If you do not see steam:
Carefully lift the hood.
Except 8NR-FTS and 1WW engines
After the engine has cooled
down sufficiently, inspect the
hoses and radiator core (radia-
tor) for any leaks.
Radiator
Cooling fan
If a large amount of coolant
leaks, immediately contact any
authorized Toyota dealer or
repairer, or another duly quali-
fied and equipped professional.
If your vehicle overheats
The following may indicate that your vehicle is overheating.
Correction procedures
1
2
3
1
2
AURIS Touring Sports_OM_Europe_OM12L13E.book 603 ページ ２０１６年６月２７日　月曜日　午後５時２１分

6048-2. Steps to take in an emergency
AURIS Touring Sports_EE (12L13E)
8NR-FTS and 1WW engines
After the engine has cooled
down sufficiently, inspect the
hoses and radiator core (radia-
tor) for any leaks.
Radiator
Cooling fans
If a large amount of coolant
leaks, immediately contact any
authorized Toyota dealer or
repairer, or another duly quali-
fied and equipped professional.
The coolant level is satisfactory if it is between the “FULL” and
“LOW” lines on the reservoir.
Reservoir
“FULL”
“LOW”
3
1
2
4
1
2
3
Except 8NR-FTS and 1WW
engines8NR-FTS engine
1WW engine
AURIS Touring Sports_OM_Europe_OM12L13E.book 604 ページ ２０１６年６月２７日　月曜日　午後５時２１分

6058-2. Steps to take in an emergency
AURIS Touring Sports_EE (12L13E)
8
When trouble arises
Add coolant if necessary.
Water can be used in an emergency if coolant is unavailable.
Start the engine and turn the air conditioning system on to check
that the radiator cooling fan operates and to check for coolant leaks
from the radiator or hoses.
The fan operates when the air conditioning system is turned on immedi-
ately after a cold start. Confirm that the fan is operating by checking the fan
sound and air flow. If it is difficult to check these, turn the air conditioning
system on and off repeatedly. (The fan may not operate in freezing tem-
peratures.)
If the fan is not operating:
Stop the engine immediately and contact any authorized Toyota
dealer or repairer, or another duly qualified and equipped profes-
sional.
If the fan is operating:
Have the vehicle inspected at the nearest authorized Toyota dealer
or repairer, or another duly qualified and equipped professional.
5
Except 8NR-FTS engine8NR-FTS engine
6
7
AURIS Touring Sports_OM_Europe_OM12L13E.book 605 ページ ２０１６年６月２７日　月曜日　午後５時２１分

6068-2. Steps to take in an emergency
AURIS Touring Sports_EE (12L13E)
WARNING
■When inspecting under the hood of your vehicle
Observe the following precautions.
Failure to do so may result in serious injury such as burns.
●If steam is seen coming from under the hood, do not open the hood until
the steam has subsided. The engine compartment may be very hot.
●Keep hands and clothing (especially a tie, a scarf or a muffler) away from
the fan and belts. Failure to do so may cause the hands or clothing to be
caught, resulting in serious injury.
●Do not loosen the coolant reservoir cap while the engine and radiator are
hot.
High temperature steam or coolant could spray out.
NOTICE
■When adding coolant
Add coolant slowly after the engine has cooled down sufficiently. Adding
cool coolant to a hot engine too quickly can cause damage to the engine.
■To prevent damage to the cooling system
Observe the following precautions:
●Avoid contaminating the coolant with foreign matter (such as sand or dust
etc.).
●Do not use any coolant additive.
AURIS Touring Sports_OM_Europe_OM12L13E.book 606 ページ ２０１６年６月２７日　月曜日　午後５時２１分

6259-1. Specifications
AURIS Touring Sports_EE (12L13E)
9
Vehicle specifications
1NR-FE, 1ZR-FAE and 1ND-TV engines
8NR-FTS engine
Cooling system
Capacity
(Refer-
ence)
1NR-FE engine
With exhaust heat recirculation system
5.7 L (6.0 qt., 5.0 Imp. qt.)
Without exhaust heat recirculation system
4.7 L (5.0 qt., 4.1 Imp. qt.)
1ZR-FAE engine
Vehicles with a Multidrive
5.8 L (6.1 qt., 5.1 Imp. qt.)
Vehicles with a manual transmission
5.6 L (5.9 qt., 4.9 Imp. qt.)
1ND-TV engine
With power heater
6.0 L (6.3 qt., 5.3 Imp. qt.)
Without power heater
5.6 L (5.9 qt., 4.9 Imp. qt.)
Coolant typeUse either of the following:
• “Toyota Super Long Life Coolant”
• Similar high-quality ethylene glycol-
based non-silicate, non-amine, non-
nitrite, and non-borate coolant with
long-life hybrid organic acid technology
Do not use plain water alone.
Capacity (reference)
Gasoline engine
IntercoolerVehicles with a Multidrive
6.4 L (6.8 qt., 5.6 Imp. qt.)
Vehicles with a manual transmission
6.2 L (6.6 qt., 5.5 Imp. qt.)
2.1 L (2.2 qt., 1.8 Imp. qt.)
Coolant typeUse either of the following:
• “Toyota Super Long Life Coolant”
• Similar high-quality ethylene glycol-
based non-silicate, non-amine, non-
nitrite, and non-borate coolant with
long-life hybrid organic acid technology
Do not use plain water alone.
AURIS Touring Sports_OM_Europe_OM12L13E.book 625 ページ ２０１６年６月２７日　月曜日　午後５時２１分

651Alphabetical index
AURIS Touring Sports_EE (12L13E)
Child-protectors ....................... 138
Cleaning............................ 452, 456
Aluminum wheels .................. 453
Exterior.................................. 452
Interior ................................... 456
Seat belts .............................. 457
Clock ......................................... 444
Coat hooks ............................... 447
Condenser ................................ 483
Console box ............................. 426
Cooling system ........................ 481
Engine overheating ............... 603
Cruise control .......................... 299
Cup holders .............................. 428
Curtain shield airbags ............... 42
Customizable features ............ 635
Daytime running light
system .................................... 239
Deck board ............................... 432
Defogger
Outside rear view
mirrors ........................ 406, 413
Rear window ................. 406, 413
Windshield .................... 406, 413
Dimensions .............................. 612
Display
Multi-information
display ........................ 101, 107
Warning message ................ 557Do-it-yourself maintenance .... 462
Door lock
Back door.............................. 140
Side doors............................. 134
Smart entry &
start system ................ 134, 140
Wireless remote
control......................... 134, 140
Doors
Back door.............................. 140
Door lock....................... 134, 140
Door windows ....................... 181
Double locking system ............ 90
Open door warning
buzzer......................... 138, 141
Open door warning light........ 549
Outside rear view mirrors...... 178
Rear door child-protector ...... 138
Side doors............................. 134
Double locking system ............. 90
DPF
Diesel Particulate Filter
system ................................ 329
Warning light ......................... 548
Drive information ..................... 111
Driving ...................................... 186
Break-in tips .......................... 189
Correct driving posture ........... 36
Procedures ........................... 186
Winter drive tips .................... 337
D
*: For vehicles with navigation/multimedia system, refer to
“Navigation and multimedia system Owner’s manual”.
AURIS Touring Sports_OM_Europe_OM12L13E.book 651 ページ ２０１６年６月２７日　月曜日　午後５時２１分