air condition TOYOTA AURIS HYBRID 2017 Repair Manual

5628-2. Steps to take in an emergency
AURIS Touring Sports_EE (12L13E)
■System warning light
In the following situation, the master warning light will not come on or flash.
Instead, a separate system warning light will come on along with a message
displayed on the multi-information display.
●Malfunction of the brake system
The brake system warning light will come on. (P. 545)
■Warning buzzer
In some cases, the buzzer may not be heard because of noisy place or an
audio sound.
■Engine oil change reminder message comes on (1ND-TV engine only)
Replace the engine oil filter when the engine oil change reminder message
does not come on even if you have driven over 15000 km (9300 miles) after
the engine oil was changed.
There is a possibility that the “Oil maintenance required.” message has been
displayed when you have driven less than 15000 km (9300 miles) based on a
usage or driving condition.
WARNING
■When driving to clean the DPF catalytic converter (diesel engine)
When driving, pay sufficient attention to weather, road conditions, terrain
and traffic conditions, and be sure to observe traffic laws and/or regulations.
Failure to do so may cause an unexpected accident, resulting in death or
serious injury.
NOTICE
■When the DPF system warning message comes on (diesel engine)
If the DPF system warning message is left on without performing cleaning,
after an additional 100 to 300 km (62 to 187 miles), the malfunction indicator
lamp may come on. If this happens, have the vehicle inspected by any
authorized Toyota dealer or repairer, or another duly qualified and equipped
professional immediately.
■If the fuel filter warning message comes on (diesel engine)
Never drive the vehicle with the warning message is shown. Continued driv-
ing with water accumulated in the fuel filter will damage the fuel injection
pump.
AURIS Touring Sports_OM_Europe_OM12L13E.book 562 ページ ２０１６年６月２７日　月曜日　午後５時２１分

5908-2. Steps to take in an emergency
AURIS Touring Sports_EE (12L13E)
WARNING
■When fixing the flat tire
●After inflation of the tire has completed, the sealant may splatter when the
hose is disconnected or some air is let out of the tire.
●Follow the operation procedure to repair the tire. If the procedures not fol-
lowed, the sealant may spray out.
●Keep back from the tire while it is being repaired, as there is a chance of it
bursting while the repair operation is being performed. If you notice any
cracks or deformation of the tire, turn off the compressor switch and stop
the repair operation immediately.
●The repair kit may overheat if operated for a long period of time. Do not
operate the repair kit continuously for more than 40 minutes.
●Parts of the repair kit become hot during operation. Be careful when han-
dling the repair kit during and after operation. Do not touch the metal part
around the connecting area between the bottle and compressor. It will be
extremely hot.
●Do not attach the vehicle speed warning sticker to an area other than the
one indicated. If the sticker is attached to an area where an SRS airbag is
located, such as the pad of the steering wheel, it may prevent the SRS
airbag from operating properly.
■Driving to spread the liquid sealant evenly
Observe the following precautions to reduce the risk of accidents.
Failing to do so may result in a loss of vehicle control and cause death or
serious injury.
●Drive the vehicle carefully at a low speed. Be especially careful when turn-
ing and cornering.
●If the vehicle does not drive straight or you feel a pull through the steering
wheel, stop the vehicle and check the following.
• Tire condition. The tire may have separated from the wheel.
• Tire inflation pressure. If the tire inflation pressure is 130 kPa (1.3
kgf/cm
2 or bar, 19 psi) or less, the tire may be severely damaged.
AURIS Touring Sports_OM_Europe_OM12L13E.book 590 ページ ２０１６年６月２７日　月曜日　午後５時２１分

6038-2. Steps to take in an emergency
AURIS Touring Sports_EE (12L13E)
8
When trouble arises
●Vehicles with a 3-ring meter: The high engine coolant temperature
warning light (P. 545) comes on or a loss of engine power is
experienced (for example, the vehicle speed does not increase).
Vehicles with a 2-ring meter: The engine coolant temperature
gauge (P. 98) enters the red zone or a loss of engine power is
experienced (for example, the vehicle speed does not increase).
●Steam comes out from under the hood.
Stop the vehicle in a safe place and turn off the air conditioning sys-
tem, and then stop the engine.
If you see steam:
Carefully lift the hood after the steam subsides.
If you do not see steam:
Carefully lift the hood.
Except 8NR-FTS and 1WW engines
After the engine has cooled
down sufficiently, inspect the
hoses and radiator core (radia-
tor) for any leaks.
Radiator
Cooling fan
If a large amount of coolant
leaks, immediately contact any
authorized Toyota dealer or
repairer, or another duly quali-
fied and equipped professional.
If your vehicle overheats
The following may indicate that your vehicle is overheating.
Correction procedures
1
2
3
1
2
AURIS Touring Sports_OM_Europe_OM12L13E.book 603 ページ ２０１６年６月２７日　月曜日　午後５時２１分

6058-2. Steps to take in an emergency
AURIS Touring Sports_EE (12L13E)
8
When trouble arises
Add coolant if necessary.
Water can be used in an emergency if coolant is unavailable.
Start the engine and turn the air conditioning system on to check
that the radiator cooling fan operates and to check for coolant leaks
from the radiator or hoses.
The fan operates when the air conditioning system is turned on immedi-
ately after a cold start. Confirm that the fan is operating by checking the fan
sound and air flow. If it is difficult to check these, turn the air conditioning
system on and off repeatedly. (The fan may not operate in freezing tem-
peratures.)
If the fan is not operating:
Stop the engine immediately and contact any authorized Toyota
dealer or repairer, or another duly qualified and equipped profes-
sional.
If the fan is operating:
Have the vehicle inspected at the nearest authorized Toyota dealer
or repairer, or another duly qualified and equipped professional.
5
Except 8NR-FTS engine8NR-FTS engine
6
7
AURIS Touring Sports_OM_Europe_OM12L13E.book 605 ページ ２０１６年６月２７日　月曜日　午後５時２１分

6169-1. Specifications
AURIS Touring Sports_EE (12L13E)
1NR-FE and 1ZR-FAE engines
Engine
Model1NR-FE, 1ZR-FAE
Ty p e4-cylinder in line, 4-cycle, gasoline
Bore and stroke
1NR-FE engine
72.5  80.5 mm (2.85  3.17 in.)
1ZR-FAE engine
80.5  78.5 mm (3.17  3.09 in.)
Displacement
1NR-FE engine
1329 cm
3 (81.1 cu. in.)
1ZR-FAE engine
1598 cm
3 (97.5 cu. in.)
Valve clearance
(engine cold)Automatic adjustment
Drive belt tension
1NR-FE engine
Automatic adjustment
1ZR-FAE engine
7.6 10.0 mm (0.30 0.39 in.)
*
*
: Drive belt deflection with 98 N (10 kgf, 22 lbf) thumb
force (used belt)
Generator
Water pump
Air
conditioning
compressorCrankshaft
AURIS Touring Sports_OM_Europe_OM12L13E.book 616 ページ ２０１６年６月２７日　月曜日　午後５時２１分

6409-2. Customization
AURIS Touring Sports_EE (12L13E)■
Stop & Start system* (P. 286)
*: If equipped
■
Toyota parking assist-sensor*1 (P. 308)
*1: If equipped
*2: Vehicles with a navigation/multimedia system
*3: When Toyota parking assist-sensor is operating.
■
Automatic air conditioning system* (P. 409)
*: If equipped
FunctionDefault settingCustomized set-
ting
Change the Stop & Start
system duration when the
A/C is on
NormalLong—O—
123
FunctionDefault settingCustomized set-
ting
Toyota parking assist-
sensor systemOnOff—O—
Detection distance of the
front center sensors
*2FarNearO—O
Detection distance of the
rear center sensors
*2FarNearO—O
Buzzer volume*251 to 4O—O
Display setting*2, 3All sensors dis-
playedDisplay offO—O
123
FunctionDefault settingCustomized set-
ting
Switching between out-
side air and recirculated
air mode linked to
“AUTO” switch operation
OnOffO—O
A/C auto switch operationOnOff——O
123
AURIS Touring Sports_OM_Europe_OM12L13E.book 640 ページ ２０１６年６月２７日　月曜日　午後５時２１分

644
AURIS Touring Sports_EE (12L13E)
What to do if... (Troubleshooting)
What to do if... (Troubleshooting)
●If you lose your keys or mechanical keys, new genuine keys or mechanical
keys can be made by any authorized Toyota dealer or repairer, or another
duly qualified and equipped professional. (P. 124)
●If you lose your keys or electronic keys, the risk of vehicle theft increases
significantly. Contact any authorized Toyota dealer or repairer, or another
duly qualified and equipped professional immediately. (P. 133)
●Is the key battery weak or depleted? (P. 511)
●Vehicles with a smart entry & start system:
Is the engine switch in IGNITION ON mode?
When locking the doors, turn the engine switch off. (P. 216)
●Vehicles with a smart entry & start system:
Is the electronic key left inside the vehicle?
When locking the doors, make sure that you have the electronic key on
your person.
●The function may not operate properly due to the condition of the radio
wave. (P. 125, 148)
●Is the child-protector lock set?
The rear door cannot be opened from inside the vehicle when the lock is
set. Open the rear door from outside and then unlock the child-protector
lock. (P. 138)
If you have a problem, check the following before contacting any
authorized Toyota dealer or repairer, or another duly qualified
and equipped professional.
The doors cannot be locked, unlocked, opened or closed
You lose your keys
The doors cannot be locked or unlocked
The rear door cannot be opened
AURIS Touring Sports_OM_Europe_OM12L13E.book 644 ページ ２０１６年６月２７日　月曜日　午後５時２１分

649
AURIS Touring Sports_EE (12L13E)
Alphabetical index
Alphabetical index
A/C............................................. 409
Air conditioning filter.............. 509
ABS
(Anti-lock Brake System) ...... 331
Warning light ......................... 546
Air conditioning filter .............. 509
Air conditioning
system .................................... 409
Air conditioning filter.............. 509
Airbag manual on-off system ... 52
Airbags ....................................... 42
Airbag manual on-off
system .................................. 52
Airbag operating conditions .... 48
Airbag precautions for
your child .............................. 44
Correct driving posture............ 36
Curtain shield airbag
operating conditions ............. 48
Curtain shield airbag
precautions ........................... 46
General airbag precautions..... 44
Locations of airbags ................ 42
Modification and
disposal of airbags................ 47
Side airbag operating
conditions ............................. 48
Side airbag precautions .......... 44
Side and curtain shield airbags
operating conditions ............. 48
Side and curtain shield airbags
precautions ........................... 44
SRS airbags ............................ 42
SRS warning light ................. 546Alarm .......................................... 87
Warning buzzer............. 545, 557
Anchor brackets ........................ 64
Antennas (smart entry &
start system) .......................... 145
Anti-lock Brake
System (ABS) ........................ 331
Warning light ......................... 546
Armrest ..................................... 446
Ashtrays ................................... 444
Assist grips .............................. 447
Audio input
*............................ 344
Audio system
*......................... 342
Audio input ............................ 344
AUX port/USB port................ 344
Bluetooth
® audio................... 374
CD player .............................. 350
iPod....................................... 358
MP3/WMA disc ..................... 350
Optimal use........................... 345
Portable music player ........... 373
Radio .................................... 347
Steering wheel audio
switch ................................. 343
USB memory ........................ 366
Automatic headlight leveling
system .................................... 240
Automatic High Beam ............. 276
Automatic light control
system .................................... 235
AUX port
*................................. 373
Auxiliary boxes ................ 429, 435
A
*: For vehicles with navigation/multimedia system, refer to
“Navigation and multimedia system Owner’s manual”.
AURIS Touring Sports_OM_Europe_OM12L13E.book 649 ページ ２０１６年６月２７日　月曜日　午後５時２１分