battery TOYOTA AURIS TOURING SPORTS 2017 Service Manual

4707-3. Do-it-yourself maintenance
AURIS Touring Sports_EE (12L13E)■
8NR-FTS engine
Engine coolant reservoir
(P. 481)
Intercooler coolant reservoir
(P. 482)
Engine oil filler cap
(P. 476)
Engine oil level dipstick
(P. 473)Battery (P. 484)
Fuse box (P. 514)
Radiator (P. 483)
Condenser (P. 483)
Electric cooling fans
Intercooler
Washer fluid tank (P. 487)1
2
3
4
5
6
7
8
9
10
11
AURIS Touring Sports_OM_Europe_OM12L13E.book 470 ページ ２０１６年６月２７日　月曜日　午後５時２１分

4717-3. Do-it-yourself maintenance
AURIS Touring Sports_EE (12L13E)
7
Maintenance and care
■1ND-TV engine
Washer fluid tank
(P. 487)
Engine coolant reservoir
(P. 481)
Engine oil filler cap
(P. 476)
Engine oil level dipstick
(P. 473)Fuel filter (P. 488)
Battery (P. 484)
Fuse box (P. 514)
Radiator (P. 483)
Electric cooling fan
Condenser (P. 483)
Intercooler (P. 483)1
2
3
4
5
6
7
8
9
10
11
AURIS Touring Sports_OM_Europe_OM12L13E.book 471 ページ ２０１６年６月２７日　月曜日　午後５時２１分

4727-3. Do-it-yourself maintenance
AURIS Touring Sports_EE (12L13E)■
1WW engine
Washer fluid tank
(P. 487)
Engine coolant reservoir
(P. 481)
Engine oil filler cap
(P. 476)
Engine oil level dipstick
(P. 473)Fuel filter (P. 489)
Fuse box (P. 514)
Battery (P. 484)
Condenser (P. 483)
Electric cooling fans
Intercooler (P. 483)
Radiator (P. 483)1
2
3
4
5
6
7
8
9
10
11
AURIS Touring Sports_OM_Europe_OM12L13E.book 472 ページ ２０１６年６月２７日　月曜日　午後５時２１分

4847-3. Do-it-yourself maintenance
AURIS Touring Sports_EE (12L13E)
Check the battery as follows.
■Caution symbols
The meanings of each caution symbol on the top of the battery are
as follows:
■Battery exterior
Make sure that the battery terminals are not corroded and that
there are no loose connections, cracks, or loose clamps.
Terminals
Hold-down clamp
■Before recharging
When recharging, the battery produces hydrogen gas which is flammable and
explosive. Therefore, observe the following before recharging:
●If recharging with the battery installed on the vehicle, be sure to disconnect
the ground cable.
●Make sure the power switch on the charger is off when connecting and dis-
connecting the charger cables to the battery.
Battery
No smoking, no naked
flames, no sparksBattery acid
Shield eyesNote operating
instructions
Keep away from chil-
drenExplosive gas
1
2
AURIS Touring Sports_OM_Europe_OM12L13E.book 484 ページ ２０１６年６月２７日　月曜日　午後５時２１分

4857-3. Do-it-yourself maintenance
AURIS Touring Sports_EE (12L13E)
7
Maintenance and care
■After recharging/reconnecting the battery (vehicles with a smart entry &
start system)
●Unlocking the doors using the smart entry & start system may not be possi-
ble immediately after reconnecting the battery. If this happens, use the wire-
less remote control or the mechanical key to lock/unlock the doors.
●Start the engine with the engine switch in ACCESSORY mode. The engine
may not start with the engine switch turned off. However, the engine will
operate normally from the second attempt.
●The engine switch mode is recorded by the vehicle. If the battery is recon-
nected, the vehicle will return the engine switch mode to the status it was in
before the battery was disconnected. Make sure to turn off the engine
before disconnecting the battery. Take extra care when connecting the bat-
tery if the engine switch mode prior to discharge is unknown.
If the system will not start even after multiple attempts, contact any authorized
Toyota dealer or repairer, or another duly qualified and equipped professional.
WARNING
■Chemicals in the battery
Batteries contain poisonous and corrosive sulfuric acid and may produce
hydrogen gas which is flammable and explosive. To reduce the risk of death
or serious injury, take the following precautions while working on or near the
battery:
●Do not cause sparks by touching the battery terminals with tools.
●Do not smoke or light a match near the battery.
●Avoid contact with eyes, skin and clothes.
●Never inhale or swallow electrolyte.
●Wear protective safety glasses when working near the battery.
●Keep children away from the battery.
AURIS Touring Sports_OM_Europe_OM12L13E.book 485 ページ ２０１６年６月２７日　月曜日　午後５時２１分

4867-3. Do-it-yourself maintenance
AURIS Touring Sports_EE (12L13E)
WARNING
■Where to safely charge the battery
Always charge the battery in an open area. Do not charge the battery in a
garage or closed room where there is insufficient ventilation.
■How to recharge the battery
Only perform a slow charge (5 A or less). The battery may explode if
charged at a quicker rate.
■Emergency measures regarding electrolyte
●If electrolyte gets in your eyes
Flush your eyes with clean water for at least 15 minutes and get immedi-
ate medical attention. If possible, continue to apply water with a sponge or
cloth while traveling to the nearest medical facility.
●If electrolyte gets on your skin
Wash the affected area thoroughly. If you feel pain or burning, get medical
attention immediately.
●If electrolyte gets on your clothes
It can soak through clothing on to your skin. Immediately take off the cloth-
ing and follow the procedure above if necessary.
●If you accidentally swallow electrolyte
Drink a large quantity of water or milk. Get emergency medical attention
immediately.
NOTICE
■When recharging the battery
Never recharge the battery while the engine is operating. Also, be sure all
accessories are turned off.
AURIS Touring Sports_OM_Europe_OM12L13E.book 486 ページ ２０１６年６月２７日　月曜日　午後５時２１分

5117-3. Do-it-yourself maintenance
AURIS Touring Sports_EE (12L13E)
7
Maintenance and care
●Flathead screwdriver
●Small flathead screwdriver
●Lithium battery CR2016 (vehicles without a smart entry & start sys-
tem), or CR2032 (vehicles with a smart entry & start system)
Vehicles without a smart entry & start system
Remove the cover.
To prevent damage to the key,
cover the tip of the screwdriver with
a rag.
Remove the depleted battery.
Insert a new battery with the “+”
terminal facing up.
Wireless remote control/electronic key
battery
Replace the battery with a new one if it is depleted or “Key bat-
tery low.” is displayed on the multi-information display (vehicles
with a 2-ring meter only).
You will need the following items:
Replacing the battery
1
2
AURIS Touring Sports_OM_Europe_OM12L13E.book 511 ページ ２０１６年６月２７日　月曜日　午後５時２１分

5127-3. Do-it-yourself maintenance
AURIS Touring Sports_EE (12L13E)
Vehicles with a smart entry & start system
Take out the mechanical key.
Remove the cover.
To prevent damage to the key,
cover the tip of the screwdriver with
a rag.
Remove the battery cover.
To prevent damage to the key,
cover the tip of the screwdriver with
a rag.
Remove the depleted battery.
Insert a new battery with the “+”
terminal facing up.
1
2
3
4
AURIS Touring Sports_OM_Europe_OM12L13E.book 512 ページ ２０１６年６月２７日　月曜日　午後５時２１分

5137-3. Do-it-yourself maintenance
AURIS Touring Sports_EE (12L13E)
7
Maintenance and care
■Use a CR2016 (vehicles without a smart entry & start system) or CR2032
(vehicles with a smart entry & start system) lithium battery
●Batteries can be purchased at any authorized Toyota dealer or repairer, or
another duly qualified and equipped professional, local electrical appliance
shops or camera stores.
●Replace only with the same or equivalent type recommended by the manu-
facturer.
●Dispose of used batteries according to local laws.
■If the key battery is depleted
The following symptoms may occur:
●The smart entry & start system (if equipped) and wireless remote control will
not function properly.
●The operational range will be reduced.
WARNING
■Removed battery and other parts
These parts are small and if swallowed by a child, they can cause choking.
Keep away from children. Failure to do so could result in death or serious
injury.
■Certification for the lithium battery
CAUTION:
RISK OF EXPLOSION IF BATTERY IS REPLACED BY AN INCORRECT
TYPE. DISPOSE OF USED BATTERIES ACCORDING TO THE INSTRUC-
TIONS
NOTICE
■For normal operation after replacing the battery
Observe the following precautions to prevent accidents:
●Always work with dry hands.
Moisture may cause the battery to rust.
●Do not touch or move any other component inside the remote control.
●Do not bend either of the battery terminals.
AURIS Touring Sports_OM_Europe_OM12L13E.book 513 ページ ２０１６年６月２７日　月曜日　午後５時２１分

533
8When trouble arises
AURIS Touring Sports_EE (12L13E)8-1. Essential information
Emergency flashers ........... 534
If your vehicle has
to be stopped
in an emergency .............. 535
8-2. Steps to take
in an emergency
If your vehicle needs
to be towed ...................... 537
If you think something
is wrong ........................... 543
Fuel pump shut off
system ............................. 544
If a warning light turns on
or a warning buzzer
sounds ............................. 545
If a warning message
is displayed ...................... 557
If you have a flat tire
(vehicles with
a spare tire) ..................... 563
If you have a flat tire
(vehicles with
an emergency tire
puncture repair kit)........... 576If the engine will not
start.................................. 592
If the electronic key does
not operate properly ........ 594
If the vehicle battery
is discharged ................... 597
If your vehicle
overheats ......................... 603
If you run out of fuel
and the engine stalls........ 607
If the vehicle becomes
stuck ................................ 608
AURIS Touring Sports_OM_Europe_OM12L13E.book 533 ページ ２０１６年６月２７日　月曜日　午後５時２１分