lock TOYOTA AVALON 1997 Manual PDF

177
Tire surface and wheel nuts
Check the tires carefully
for cuts, damage
or excessive wear. See Chapter 7-2 for
additional information. When checking
the tires, make sure no nuts are missing,
and check the nuts for looseness. T ighten
them if necessary.
Tire rotation
Rotate the tires every 12000 km (7500
miles). See Chapter 7-2 for additional in-
formation.
Fluid leaks
Check underneath for leaking fuel, oil, wa-
ter or other fluid after the vehicle has been
parked for a while. If you smell fuel fumes
or notice any leak, have the cause found
and corrected immediately.
Doors and engine hood
Check that all doors including trunk lid op-
erate smoothly and all latches lock se-
curely. M ake sure the engine hood secon-
dary latch secures the hood from opening
when the primary latch is released.
INSIDE THE VEHICLE
Items listed below should be checked
regularly, e.g. while performing peri-
odic services, cleaning the vehicle,
etc. Lights
Make sure the headlights, stop lights, tail
lights, turn signal lights, and other lights
are all working. Check headlight aim.
Service reminder indicators and
warn-
ing buzzers
Check that all service reminder indicators
and warning buzzers function properly.
Steering wheel
Check that it has the specified freeplay.
Be alert for changes in steering condition,
such as hard steering or strange noise.
Seats
Check that all front seat controls such as
seat adjusters, seatback recliner, etc. op-
erate smoothly and that all latches lock
securely in any position. Check that the
head restraints move up and down
smoothly and that the locks hold securely
in any latched position.
Seat belts
Check that the seat belt system such as
buckles, retractors and anchors operate
properly and smoothly. Make sure the belt
webbing is not cut, frayed, worn or dam-
aged.
Accelerator pedal
Check the pedal for smooth operation and
uneven pedal effort or catching. Brake pedal
Check
the pedal for smooth operation and
that the pedal has the proper clearance.
Check the brake booster function.
Brakes
At a safe place, check that the brakes do
not pull to one side when applied.
Parking brake
Check that the pedal has the proper travel
and that, on a safe incline, your vehicle is
held securely with only the parking brake
applied.
Automatic transmission Parkº mech-
anism
Check the lock release button of the se-
lector lever for proper and smooth opera-
tion. On a safe incline, check that your ve-
hicle is held securely with the selector
lever in ºPº position and all brakes re-
leased.
IN THE ENGINE COMPARTMENT
Items listed below should be checked
from time to time, e.g. each time when
refueling.
Washer fluid
Make sure there is sufficient fluid in the
tank. See Chapter 7-3 for additional infor-
mation.ProCarManuals.com

1801. Engine coolant reservoir
2. Power steering fluid reservoir
3. Engine oil filler cap
4. Brake fluid reservoir
5. Fuse blocks
6. Battery
7. Engine cooling fans
8. Engine oil level dipstick
9. Windshield washer and headlight
cleaner fluid tank
Engine compartment overview
ProCarManuals.com

188If the level is low, add SAE J1703 or
FMVSS No. 116 DOT 3 brake fluid to the
brake reservoir.
Remove and replace the reservoir cover
by hand. Fill the brake fluid to the dotted
line.
This brings the fluid to the correct lev-
el when you put the cover back on.
Use only newly opened brake fluid. Once
opened, brake fluid absorbs moisture
from the air, and excess moisture can
cause a dangerous loss of braking.
CAUTION
Take care when filling the reservoir
because brake fluid can harm your
eyes and damage painted surfaces. If
fluid gets in your eyes, flush your
eyes with clean water.!
If you spill the fluid, be sure to wash it off with water to prevent it from
damaging the parts or paint.
NOTICE
Check the fluid level through the reser-
voir. If necessary, add automatic trans-
mission fluid DEXRON
[II or -III.
If the vehicle has been driven around 80
km/h (50 mph) for 20 minutes (a little more
in frigid temperatures), the fluid is hot
(60 C ' 80 C or 140 F ' 175 F). You
may also check the level when the fluid is
cold (about room temperature, 10 C '
30 C or 50 F ' 85 F) if the engine has
not been run for about five hours. Clean all dirt from outside of the reservoir
tank and look at the fluid level. If the fluid
is cold, the level should be in the COLDº
range. Similarly, if it is hot, the fluid level
should be in the HOTº range. If the level
is at the low side of either range, add auto-
matic transmission fluid DEXRON
[-II or
-III to bring the level within range.
To remove the filler cap, turn it counter-
clockwise and lift up. To reinstall it, turn it
clockwise. After replacing the filler cap,
visually check the steering box case, vane
pump and hose connections for leaks or
damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.!
Avoid overfilling, or the power steering could be damaged.
NOTICE
Checking power steering fluid
ProCarManuals.com

192If wheel covers are used, they will be
scratched by the chain band, so remove
the covers before putting on the chains.


Do not exceed 50 km/h (30 mph) or
the chain manufacturer's recom-
mended speed limit, whichever is
lower.

Drive carefully avoiding bumps,
holes, and sharp turns, which may
cause the vehicle to bounce.

Avoid sharp turns or locked-wheel
braking, as use of chains may ad-
versely affect vehicle handling.
CAUTION!
WHEN TO REPLACE YOUR WHEELS
If you have wheel damage such as
bending, cracks or heavy corrosion,
the wheel should be replaced.
If you fail to replace damaged wheels, the
tire may slip off the wheel or they may
cause loss of handling control.
WHEEL SELECTION
When replacing wheels, care should
be taken to ensure that the wheels are
replaced by ones with the same load
capacity, diameter, rim width, and off-
set.
Correct replacement wheels are available
at your Toyota dealer.
A wheel of a different size or type may ad-
versely affect handling, wheel and bear-
ing life, brake cooling, speedometer/
odometer calibration, stopping ability,
headlight aim, bumper height, vehicle
ground clearance, and tire or snow chain
clearance to the body and chassis. Replacement
with used wheels is not rec-
ommended as they may have been sub-
jected to rough treatment or high mileage
and could fail without warning. Also, bent
wheels which have been straightened
may have structural damage and there-
fore should not be used. Never use an in-
ner tube in a leaking wheel which is de-
signed for a tubeless tire.
Replacing wheels
ProCarManuals.com

201
The following illustrations show how to
gain access to the bulbs. When replacing
a bulb, make sure the ignition switch and
light switch are off. Use bulbs with the
wattage ratings given in the table.
Halogen bulbs have pressurized
gas inside and require special
handling. They can burst or shatter
if scratched or dropped. Hold a bulb
only by its plastic or metal case. Do
not touch the glass part of a bulb
with bare hands.
CAUTION
!
NOTICE
Only use a bulb of the listed type.
Light bulbsBulb
No.WType
Headlight
(low beam)900655A
Headlight
(high beam)900565B
Parking lights1685D
Front turn signal lights115627C
Front side marker
lights1943.8D
Rear turn signal ligths115627C
Stop and tail lights115727/8C
Back-up lights115627C
License plate light1685D
High mounted stop
light92118D
Interior lightÐ8E
Front personal lightÐ8C
Rear personal lightÐ8C
Glovebox lightÐ1.2D
Door courtesy lights1945D
Trunk lightÐ3E
A: HB4 halogen bulbs
B: HB3 halogen bulbs
C: Single end bulbs
D: Wedge base bulbs
E: Double end bulbs
1. Unplug the connector while de-
pressing the lock release
If the connector is tight, wiggle it.
ÐHeadlights
Replacing light bulbsÐ
ProCarManuals.com

213
Engine compartment (Canada)
6. HAZ 10 A: Turn signal lights, emer-gency flasher
7. DOME 7.5 A: Interior light, personal light, vanity mirror light, door courtesy
light, ignition switch light, trunk light,
power door lock control, locking with
wireless remote control system, theft
deterrent system, automatic light con-
trol system, daytime running light sys-
tem, service reminder indicators and
warning buzzer, clock
8. HEAD (LH) 15 A: Left-hand headlight
9. HEAD (RH) 15 A: Right-hand head- lightEngine compartment
10.HEAD HI (LH) 15 A: Left-hand head-
light (high beam)
11. HEAD HI (RH) 15 A: Right-hand headlight (high beam)
12.ALT-S 5 A: Charging system
13.AM2 30 A: Gauge and meters, SRS
airbag system, Multiport fuel injection
system/sequential multiport fuel injec-
tion system, starter system
14.ECU-B 5 A: Cruise control system, air conditioning control system
15.15 A: Spare fuse
16.30 A: Spare fuseEngine compartment (Canada only)
17.TEL 15 A: No circuit
18.HEAD LO (LH) 10 A: Left-hand head-
light (low beam)
19.HEAD LO (RH) 10 A: Right-hand headlight (low beam)
20.RAD NO.1 15 A: Audio system
21.FOG 15 A: No circuit
22.DRL 5 A: Daytime running light sys-
tem
23.SRS 5 A: SRS airbag system
24.IGN 5 A: Gauge and meters, SRS air- bag system, Multiport fuel injection
system/sequential multiport fuel injec-
tion system
ProCarManuals.com

214
Instrument panel
25.SEAT HEATER 20 A: Seat heater
26.TURN 7.5 A: Turn signal lights, emer-
gency flasher
27.ECU-IG 10 A: Cruise control system, anti-lock brake system, shift lock sys-
tem, power antenna, power door lock
system, electric cooling fan
28.WIPER 20 A: Windshield wipers and washer, headlight cleanerPassenger 's side kick panel
29.GAUGE 7.5 A: Gaugue and meter,
buck-up lights, interior lights, charging
system, electronically controlled auto-
matic transmission system, cruise
control system, power door lock sys-
tem, service reminder indicators and
warning buzzer, automatic light control
system, daytime running light system
30.TAIL 15 A: Parking lights, license plate lights, tail lights, front side mark-
er lights 31. STOP 15 A: Stop lights, cruise control
system, high mounted stoplight, anti/
lock brake system, shift lock system,
multiport fuel injection system/se-
quential multiport fuel injection system
32.PANEL 5 A: Gauge and meter, Audio
system, cigarette lighter, glovebox
light, clock, electronically controlled
automatic transmission system, air
conditioning control system, service
reminder indicators, turn signal lights,
emergency flasher, headlight cleaner,
seat heater
33.MIRROR HEATER 10 A: Mirror heat- ers
34.CIG/RADIO 15 A: Cigarette lighter,
interior lights, clock, SRS airbag sys-
tem, shift lock system, power antenna,
electronically controlled automatic
transmission sytstem, air conditioning
control system, ignition system, theft
deterrent system, outside rear view
mirror control system, Audio system,
service reminder indicators
35.HEATER 10 A: Air conditioning con- trol system, rear window defogger,
starter system
36.STARTER 5 A: Starter system
37. A.C 10 A: Air conditioning control sys- tem
ProCarManuals.com

215
Fuses (type B)
38.MAIN 40 A: HEAD (LH)º, HEAD HI
(LH)º, HEAD (RH)º and HEAD HI
(RH)º fuses
39.RDI 30 A: Electric cooling fan
40.CDS 30 A: Electric cooling fan
41.DOOR 30 A: Power door lock system,
power seat
42. RR DEF 40 A: Rear window defogger
43.POWER 30 A: Power window, electric moon roof
Fuses (type C)
44.ALT 120 A: RDI FANº, CDSº fuses
45.AM1 80 A: RR DEFº, DOORº,
POWERº, TAILº, PANELº, DEF I/
UPº, SEAT HEATERº, SRSº and
STOPº fuses
46.ABS 60 A: Anti-lock brake system
47.IG SW 40 A: CIG/RADIOº and GAUGEº fuses
48.48HTR 50 A: A.C.º fuseProCarManuals.com