parking brake TOYOTA AVENSIS 1999 Supplement

IN–36
– INTRODUCTIONTERMS
PKB
Parking Brake
PPSProgressive Power Steering
PSPower Steering
PTOPower Take–Off
RAMRandom Access Memory
R/BRelay Block
RBSRecirculating Ball Type Steering
R/FReinforcement
RFSRigid Front Suspension
RHRight–Hand
RHDRight–Hand Drive
RLYRelay
ROMRead Only Memory
RrRear
RRRear–Engine Rear–Wheel Drive
RRSRigid Rear Suspension
RWDRear–Wheel Drive
SDNSedan
SENSensor
SICSStarting Injection Control System
SPECSpecification
SRSSupplemental Restraint System
SSMSpecial Service Materials
SSTSpecial Service Tools
STDStandard
SWSwitch
SYSSystem
T/ATransaxle
TACHTachometer
TDCTop Dead Center
TEMP.Temperature
TEMSTOYOTA Electronic Modulated Suspension
TFTToyota Free–Tronic
T/MTransmission
TMCTOYOTA Motor Corporation
TRCTraction Control System
U/DUnderdrive
VENTVentilator
VINVehicle Identification Number
VSCVehicle Skid Control Vehicle Stability Control
VSVVacuum Switching Valve
w/With
WGNWagon
W/HWire Harness
w/oWithout
1stFirst

MX09C–01
D06624
Air Cleaner Case
Assembly
with Air Hose
Air Flow Meter
Connector
D06625
Shift Lever Assembly
12 (120, 9)
Transmission Control Cable Bracket
Clip
WasherShift Cable Grommet
Retainer Shift Cable Grommet Select Control Cable
Shift Control CableConsole Box Assembly
Shift Lever Knob
Clip
Clip
Washer
WasherClip Front Ash Receptacle
Parking Brake Cover
Cap Cap
Air Duct
4.9 (50, 43 in.·lbf)Clip
4.9 (50, 43 in.·lbf)
N·m (kgf·cm, ft·lbf): Specified torque MX–48
– MANUAL TRANSAXLE (E251)SHIFT LEVER AND CONTROL CABLE
SHIFT LEVER AND CONTROL CABLE
COMPONENTS

H11621
Instrument Panel
Column CoverNo.1 Register
Steering Wheel Combination Meter
Steering Wheel PadHeater Control Assembly
Cluster Finish Panel
Glove Compartment DoorFront Ash Receptacle
Lower Finish Panel
Rear Console Box No.1 Under Cover
Shift Knob
Parking Brake Hole Cover Combination Switch
Center Cluster Finish Panel
78 (790, 58)
N·m (kgf·cm, ft·lbf) : Specified torque
Cowl Side Panel
18 (184, 13)
Cover
Cover
– SUPPLEMENTAL RESTRAINT SYSTEMCURTAIN SHIELD AIRBAG ASSEMBLY
RS–21

No.
AGround (Power)
Tacho Pick–UP Sensor
EFI ECU (3S–FE, 2C–TE Engine)
EGR (2C–T Engine)
Vehicle Speed Sensor
EFI ECU
Water Temperature Sender Gauge (2C–T Engine)
Ground (Engine)
Ground
Outside Temperature Sender Gauge
Ground (Fuel)
Fuel Sender Gauge
Ground (Power)
Ground (Speed)
Turn Signal Switch (Right)
Other Parts
Oil Level Warning Switch
O/D OFF Switch
ECT ECU (Gasoline Engine)
Fuel Filter Warning Switch (Diesel Engine)
Glow Plug Timer (Diesel Engine)
EFI ECU (Gasoline Engine)
ECT Pattern Select Switch
ABS ECU
Rear Fog Light Switch 1
3
5
6
7
8
9
10
11
12
14
15
17
18
19
21
22
23
24
25
26Wire Harness Side
1
2
3
4
5
6
7
9
11
13
14
15
16
17
18
19
20
22
24
26Turn Signal Switch (Left)
H–LP Fuse
Front Fog Light Switch
Alternator L Terminal
Brake Fluid Level Warning Switch
Parking Brake Switch
ECU+B Fuse
Taillight Relay
GAUGE Fuse
Ground (Signal)
DOOR Fuse
EFI ECU (Gasoline Engine)
EGR ECU (Diesel Engine)
Headlight Dimmer Switch
Low Oil Pressure Warning Switch
IGN Fuse
Door Courtesy Switch
Airbag ECU
Taillight Relay
GAUGE Fuse
Ground (Signal)
DOOR Fuse
B
– BODY ELECTRICALCOMBINATION METER
BE–5

BO19J–02
I12662
Reinforcement
No.1 BraceFront Pillar Garnish
Instrument Panel
Front Door Opening Trim
Rear Door
Scuff Plate
Glove Compartment Door Heater Control
Assembly
No.1 Under Cover
Rear Console Box
Parking Brake Hole Cover Steering Wheel Pad Steering Wheel Combination Switch Column CoverLower Finish Panel Cluster Finish Panel Combination Meter No.1 Register
Center Cluster
Finish Panel
Front Door Scuff Plate Cowl Side Trim
Center Pillar Lower GarnishRear Door Opening Trim
B C
D
F G
A
A
B
CC
D
E
E
E
EE
E
E
EE
F
G
G
G
HHH
x 4Front Ash Receptacle
34 (350, 25)
18 (185, 13)
: Specified torqueN·m (kgf·cm, ft·lbf)
Curtain Shield Airbag
F
F
w/ Curtain shield air bag:
Front Pillar Garnish
– BODYINSTRUMENT PANEL
BO–13
INSTRUMENT PANEL
COMPONENTS

H03661
: 4 Clips
H03662
: 3 Clips
H03663
H03664
H03665
: 6 Clips
– BODYINSTRUMENT PANEL
BO–17
7. REMOVE NO.1 REGISTER
Using a screwdriver, remove the No.1 register.
HINT:
Tape the screwdriver tip before use.
8. REMOVE NO.1 UNDER COVER
Using a screwdriver, remove the No.1 under cover.
HINT:
Tape the screwdriver tip before use.
9. REMOVE GLOVE COMPARTMENT DOOR
Remove the 2 glove shaft and glove compartment door.
10. REMOVE PARKING BRAKE HOLE COVER
11. REMOVE REAR CONSOLE BOX
(a) M/T:
Remove the shift lever knob.
(b) Remove the 2 bolts, 4 caps, 4 screws and rear console
box.
12. REMOVE CENTER CLUSTER FINISH PANEL
Using a screwdriver, remove the panel, then disconnect the
connectors.
13. REMOVE HEATER CONTROL ASSEMBLY
(See Pub. No.RM599E on page AC–106)

BO2J4–01
H03666
H03665
H03664
H03663
– BODYINSTRUMENT PANEL
BO–19
INSTALLATION
1. INSTALL THESE PARTS:
(a) Install the reinforcement.
(b) Install the No.1 brace.
2. INSTALL INSTRUMENT PANEL
(a) Install the 6 screws and 3 nuts.
(b) Install the passenger airbag assembly with the 2 bolts.
Torque: 18 N·m (185 kgf·cm, 13 ft·lbf)
3. INSTALL HEATER CONTROL ASSEMBLY
(See Pub. No.RM599E on page AC–111)
4. INSTALL CENTER CLUSTER FINISH PANEL
Install the panel, then connect the connectors.
5. INSTALL REAR CONSOLE BOX
(a) Install the console box with the 2 bolts and 4 caps, 4
screws.
(b) M/T:
Install the shift lever knob.
6. INSTALL PARKING BRAKE HOLE COVER
7. INSTALL GLOVE COMPARTMENT DOOR
Install the glove compartment door with the 2 glove shaft.