Fuel gauge TOYOTA CAMRY 1994 XV10 / 4.G Wiring Diagrams Workshop Manual

METER, ANALOG
Current flow activates a magnetic
coil which causes a needle to
move, thereby providing a relative
display against a background
calibration. LED (LIGHT EMITTING DIODE)
Upon current flow, these diodes
emit light without producing the
heat of a comparable light. IGNITION COIL
Converts low±voltage DC current
into high±voltage ignition current
for firing the spark plugs. 1. SINGLE
FILAMENT
GROUND
The point at which wiring attaches
to the Body, thereby providing a
return path for an electrical circuit;
without a ground, current cannot
flow.Current flow causes a headlight
filament to heat up and emit light.
A headlight may have either a
single (1) filament or a double (2)
filament. BATTERY
Stores chemical energy and
converts it into electrical energy.
Provides DC current for the auto's
various electrical circuits.
CAPACITOR (Condenser)
A small holding unit for temporary
storage of electrical voltage.
CIRCUIT BREAKER
Basically a reusable fuse, a circuit
breaker will heat and open if too
much current flows through it. Some
units automatically reset when cool,
others must be manually reset.
DIODE
A semiconductor which allows
current flow in only one direction.
DIODE, ZENER
A diode which allows current flow
in one direction but blocks reverse
flow only up to a specific voltage.
Above that potential, it passes the
excess voltage. This acts as a
simple voltage regulator.
FUSE
A thin metal strip which burns
through when too much current
flows through it, thereby stopping
current flow and protecting a
circuit from damage.
FUSIBLE LINK
A heavy±gauge wire placed in
high amperage circuits which
burns through on overloads,
thereby protecting the circuit.
The numbers indicate the cross±
section surface area of the wires.HORN
An electric device which sounds a
loud audible signal.
LIGHT
Current flow through a filament
causes the filament to heat up
and emit light.
METER, DIGITAL
Current flow activates one or
many LED's, LCD's, or fluorescent
displays, which provide a relative
or digital display.
MOTOR
A power unit which converts
electrical energy into mechanical
energy, especially rotary motion. CIGARETTE LIGHTER
An electric resistance heating
element.
DISTRIBUTOR, IIA
Channels high±voltage current
from the ignition coil to the
individual spark plugs.2. DOUBLE
FILAMENT HEADLIGHTS
FUEL
(for High Current Fuse or
Fusible Link.)
(for Medium Current Fuse)
M
16
GLOSSARY OF TERMS AND SYMBOLS

47
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
BW1REAR DOOR LH WIRE AND FLOOR NO. 1 WIRE (LEFT CENTER PILLAR)
BX1FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE (UNDER THE REAR SEAT CUSHION)
BY1REAR DOOR RH WIRE AND FLOOR NO. 2 WIRE (RIGHT CENTER PILLAR)
BZ1LUGGAGE ROOM NO. 1 WIRE AND FLOOR NO. 1 WIRE (LUGGAGE COMPARTMENT LEFT)
Ba1FLOOR NO. 1 WIRE AND LUGGAGE ROOM NO. 2 WIRE (LUGGAGE COMPARTMENT DOOR)

49
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
BX1FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE (UNDER THE REAR SEAT CUSHION)
BZ1LUGGAGE ROOM NO. 1 WIRE AND FLOOR NO. 1 WIRE (LUGGAGE COMPARTMENT LEFT)
Ba1FLOOR NO. 1 WIRE AND LUGGAGE ROOM NO. 2 WIRE (LUGGAGE COMPARTMENT DOOR)

51
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
BW1REAR DOOR LH WIRE AND FLOOR NO. 1 WIRE (LEFT CENTER PILLAR)
BX1FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE (UNDER THE REAR SEAT CUSHION)
BY1REAR DOOR RH WIRE AND FLOOR NO. 2 WIRE (RIGHT CENTER PILLAR)
Bb1LUGGAGE ROOM NO. 1 WIRE AND FLOOR NO. 1 WIRE (LUGGAGE COMPARTMENT LEFT)
Bc1
Bc2BACK DOOR NO. 1 (WIRE AND FLOOR NO. 1 WIRE (LEFT QUARTER TRIM INNER)
Bc3
BACK DOOR NO. 1 (WIRE AND FLOOR NO. 1 WIRE (LEFT QUARTER TRIM INNER)
Bd1
Bd2BACK DOOR NO. 1 WIRE AND BACK DOOR NO. 2 WIRE (BACK DOOR LEFT)
Bd3
BACK DOOR NO. 1 WIRE AND BACK DOOR NO. 2 WIRE (BACK DOOR LEFT)
Be1REAR WINDOW NO. 1 WIRE AND BACK DOOR NO. 2 WIRE (BACK DOOR LEFT)

85
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
C 832F16B28I2029
C 9A32H 9D33I2129
C10B32H1128J 133
C1728H1228J 233
C1828I 129J 639
D 128I 2A29J 733
D 332I 428K 129
D 632I 529K 229
D2432I 629M 629
E 128I 729N 129
E 428I 829T 129
E 7A32I 929V 129
E 8B32F15B29V 229
E 9C32I1629V 329
E10D32I1729V 429
F10A28I1829V 529
F1530I1929
: RELAY BLOCKS
CODESEE PAGERELAY BLOCKS (RELAY BLOCK LOCATION)
125R/B NO. 1 (LEFT KICK PANEL)
626R/B NO. 6 (BEHIND GLOVE BOX)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1A
1B
1C
1D20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1E
20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1G
1M
2B22ENGINE ROOM MAIN WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
2C22ENGINE WIRE AND J/B NO 2 (ENGINE COMPARTMENT LEFT)2D22ENGINE WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
2H22ENGINE WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
3A
3B24COWL WIRE AND J/B NO 3 (BEHIND COMBINATION METER)3C24COWL WIRE AND J/B NO. 3 (BEHIND COMBINATION METER)
3D
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
EE140 (1MZ±FE)ENGINE WIRE AND SENSOR WIRE
EF138 (1MZ±FE)ENGINE WIRE AND COWL WIRE
II142COWL WIRE AND INSTRUMENT PANEL WIRE
IJ142FLOOR NO. 1 WIRE AND COWL WIRE
IM142INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE
IP1
IP244ENGINE WIRE AND COWL WIRE
IP3
44ENGINE WIRE AND COWL WIRE
IQ144ENGINE WIRE AND INSTRUMENT PANEL WIRE
46 (S/D)
BX148 (C/P)FUEL GAUGE WIRE AND FLOOR NO. 1 WIREBX1
50 (W/G)
FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE

95
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1A
1B
1C20COWL WIRE AND J/B NO 1 (INSTRUMENT PANEL LEFT)1D20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1G
1M
2D22ENGINE WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
3A
3B24COWL WIRE AND J/B NO 3 (BEHIND COMBINATION METER)3C24COWL WIRE AND J/B NO. 3 (BEHIND COMBINATION METER)
3D
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IJ142FLOOR NO. 1 WIRE AND COWL WIRE
IP144ENGINE WIRE AND COWL WIREIP344ENGINE WIRE AND COWL WIRE
46 (S/D)
BX148 (C/P)FUEL GAUGE WIRE AND FLOOR NO. 1 WIREBX1
50 (W/G)
FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
EB40 (5S±FE)FRONT LEFT FENDER
EC40 (5S±FE)INTAKE MANIFOLD RH
ED40 (5S±FE)INTAKE MANIFOLD LH
IG42INSTRUMENT PANEL BRACE LH
46 (S/D)
BL48 (C/P)UNDER THE LEFT QUARTER PILLARBL
50 (W/G)
UNDER THE LEFT QUARTER PILLAR
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
E15I 244COWL WIREE16I1344COWL WIRE
E1740 (5S FE)ENGINE WIREI1844ENGINE WIRE
E1840 (5S±FE)ENGINE WIREI2044COWL WIREE19I2344COWL WIRE
E20

103
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IJ142FLOOR NO. 1 WIRE AND COWL WIRE
IP144ENGINE WIRE AND COWL WIREIP344ENGINE WIRE AND COWL WIRE
46 (S/D)
BX148 (C/P)FUEL GAUGE WIRE AND FLOOR NO. 1 WIREBX1
50 (W/G)
FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
EB40 (5S±FE)FRONT LEFT FENDER
EC40 (5S±FE)INTAKE MANIFOLD RH
ED40 (5S±FE)INTAKE MANIFOLD LH
IG42INSTRUMENT PANEL BRACE LH
46 (S/D)
BL48 (C/P)UNDER THE LEFT QUARTER PILLARBL
50 (W/G)
UNDER THE LEFT QUARTER PILLAR
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
E15E2040 (5S±FE)ENGINE WIRE
E16I1344COWL WIRE
E1740 (5S±FE)ENGINE WIREI1844ENGINE WIRE
E18
40 (5S FE)ENGINE WIRE
I2044COWL WIREE19I2344COWL WIRE

236
COMBINATION METER
AB
IJ1 5IJ111 IJ118
BX1 3 BX1 2 BX1 1 IP3 2
IP3 6
IP1 8IP 3 11 IP314
IP3 5
IP3 161
ED1 A 4
A 8A7A6A 5A12 B 11 B7B10 C 8C7C 4
123
23
4
1 I9
I9 C C
6 FROM POWER SOURCE SYSTEM(
SEE PAGE 64)
R±L
R±L R±L R±L
BRY±L Y±R
BR BR BR Y±L Y±R Y±R
Y±L
BR
BR BR
B Y±G
BY±G
B
P
LG GG±B
G±B G±B
R±W
Y±B Y±BV±Y
R±L JUNCTION
CONNECTOR
BR
BR
FROM E NGINE CONTROL MODULE
(
E NGINE A ND E LE CTRONIC CONTROLLED
TRANSMISSION ECU)(
A/T)
FROM E NGINE CONTROL MODULE
(
ENGINE ECU)(
M/T)
FROM CRUISE CONTROL ECU
SPEEDFUEL
FUEL
WATER TEMP.
TA CHO
ABS
SEAT BELT
OIL
FUEL SENDER
WATER TEMP.
SENDER
IGNITER
VEHICLE SPEED
SENSOR
(
SPEED SENSOR)
TO AB S ECU
TO INTEGRATION
RELAY
OIL P RES SURE
SW
J2
B
W2
I2
V5
O1F1 5C
COMBINATION METER C8 ,C9 , C10
TO BACK±UP LIGHT SW(
M/T)
TO PARK/NEUTRAL POSITION SW
(
NEUTRAL START SW)(
A/T)
TO GENERA TOR(
ALTERNATOR) R±L
R±L
I18 6
TA C
COOLING FAN
ECU C14
BR
B
B JUNCTION CONNECTOR J7
(
*6) (
*6)
(
*7)A
A
(
*7)
(
*6)
1B 6 1D 610A
GAUGE
3D 13
3D 12
1D 121D 13
3C 133C 12

239
B 2 BRAKE FLUID LEVEL SW1±2 : CLOSED WITH FLOAT DOWN
C 8(A), C 9(B), C10(C)
COMBINATION METER(A)2, (B)6, (B)9±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON POSITION
(A)3, (B)14, (C)8±GROUND : ALWAYS CONTINUITY
F15
FUEL SENDER2±3 : APPROX. 3
WITH FUEL FULL
APPROX. 110.0
WITH FUEL EMPTY
O 1
OIL PRESSURE SW1±GROUND : CLOSED WITH OIL PRESSURE BELOW 0.2 KG/CM2 (2.84 PSI, 19.61 KPA)
P 2
PARKING BRAKE SW (1MZ±FE A/T)1±GROUND : CLOSED WITH PARKING BRAKE PEDAL DEPRESSED
P 3
PARKING BRAKE SW (EX. 1MZ±FE A/T)1±GROUND : CLOSED WITH PARKING BRAKE LEVER PULLED UP
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
B 228 (1MZ±FE), 30 (5S±FE)D 432P 233
C 8A32F1534 (S/D), 35 (C/P), 36 (W/G)P 333
C 9B32I 228 (1MZ±FE), 30 (5S±FE)V 528 (1MZ±FE), 30 (5S±FE)
C10C32J 233W 228 (1MZ±FE), 30 (5S±FE)
C1432O 128 (1MZ±FE), 30 (5S±FE)
: RELAY BLOCKS
CODESEE PAGERELAY BLOCKS (RELAY BLOCK LOCATION)
125R/B NO. 1 (LEFT KICK PANEL)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1B
1C
1D20COWL WIRE AND J/B NO 1 (INSTRUMENT PANEL LEFT)1F20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1L
1M
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
3A
3B24COWL WIRE AND J/B NO 3 (BEHIND COMBINATION METER)3C24COWL WIRE AND J/B NO. 3 (BEHIND COMBINATION METER)
3D
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
II142COWL WIRE AND INSTRUMENT PANEL WIRE
IJ142FLOOR NO. 1 WIRE AND COWL WIRE
IP144ENGINE WIRE AND COWL WIREIP344ENGINE WIRE AND COWL WIRE
46 (S/D)
BX148 (C/P)FUEL GAUGE WIRE AND FLOOR NO. 1 WIREBX1
50 (W/G)
FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
ED38 (1MZ±FE)INTAKE MANIFOLD LHED40 (5S±FE)INTAKE MANIFOLD LH
IE42LEFT KICK PANELIF42LEFT KICK PANEL
IG42INSTRUMENT PANEL BRACE LH
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
I 644INSTRUMENT PANEL WIREI1344COWL WIRE
I 944COWL WIREI1844ENGINE WIRE
SERVICE HINTS

260
GROUND POINT* 2 : TMM MADE *
1:TMCMADE
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
J 133J 536 (W/G)
J 233J 733
: RELAY BLOCKS
CODESEE PAGERELAY BLOCKS (RELAY BLOCK LOCATION)
125R/B NO. 1 (LEFT KICK PANEL)
425R/B NO. 4 (RIGHT KICK PANEL)
526R/B NO. 5 (ENGINE COMPARTMENT LEFT)
626R/B NO. 6 (BEHIND GLOVE BOX)
727R/B NO. 7 (NEAR THE BATTERY)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1C
1F20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1G
20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1I20 (*1)ROOF WIRE AND J/B NO. 1 (INSTRUMENT PANEL) TMC MADE1I20 (*2)COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL) TMM MADE
1M20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
2B22ENGINE ROOM MAIN WIRE AND J/B NO 2 (ENGINE COMPARTMENT LEFT)2E22ENGINE ROOM MAIN WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
2F22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
3A
3B24COWL WIRE AND J/B NO 3 (BEHIND COMBINATION METER)3C24COWL WIRE AND J/B NO. 3 (BEHIND COMBINATION METER)
3D
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
EA138 (1MZ±FE)ENGINE ROOM MAIN WIRE AND ENGINE ROOM NO. 3 WIRE
EB138 (1MZ±FE)ENGINE ROOM MAIN WIRE AND RELAY WIREEB140 (5S±FE)ENGINE ROOM MAIN WIRE AND RELAY WIRE
IH242FRONT DOOR LH WIRE AND INSTRUMENT PANEL WIRE
IJ142FLOOR NO. 1 WIRE AND COWL WIRE
IK142COWL WIRE AND A/C SUB WIRE
IL142COWL WIRE AND SERVO MOTOR SUB WIRE
IM242INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE
IO142FLOOR NO. 1 WIRE AND SEAT WIRE
IP344ENGINE WIRE AND COWL WIRE
IQ144ENGINE WIRE AND INSTRUMENT PANEL WIRE
IT144FRONT DOOR RH WIRE AND INSTRUMENT PANEL WIRE
IV144ROOF WIRE AND COWL WIRE
IV244ROOF WIRE AND COWL WIRE MADE IN USA
46 (S/D)
BX148 (C/P)FUEL GAUGE WIRE AND FLOOR NO. 1 WIREBX1
50 (W/G)
FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE
BZ146 (S/D)LUGGAGE ROOM NO 1 WIRE AND FLOOR NO 1 WIREBZ148 (C/P)LUGGAGE ROOM NO. 1 WIRE AND FLOOR NO. 1 WIRE
Ba146 (S/D)FLOOR NO 1 WIRE AND LUGGAGE ROOM NO 2 WIREBa148 (C/P)FLOOR NO. 1 WIRE AND LUGGAGE ROOM NO. 2 WIRE
Bb150 (W/G)LUGGAGE ROOM NO. 1 WIRE AND FLOOR NO. 1 WIRE
Bc150 (W/G)BACK DOOR NO. 1 WIRE AND FLOOR NO. 1 WIRE
Bd350 (W/G)BACK DOOR NO. 1 WIRE AND BACK DOOR NO. 2 WIRE