Wiper TOYOTA CAMRY 1994 XV10 / 4.G Wiring Diagrams Workshop Manual

17
1. NORMALLY
OPENOpens and
closes circuits,
thereby
stopping (1) or
allowing (2)
current flow.
RESISTOR
An electrical component with a
fixed resistance, placed in a circuit
to reduce voltage to a specific
value.
RESISTOR, TAPPED
A resistor which supplies two or
more different non adjustable
resistance values.
SENSOR (Thermistor)
A resistor which varies its
resistance with temperature.
SHORT PIN
Used to provide an unbroken
connection within a junction block.
SOLENOID
An electromagnetic coil which
forms a magnetic field when
current flows, to move a plunger,
etc.SWITCH, DOUBLE THROW
A switch which continuously
passes current through one set
of contacts or the other.
SWITCH,
IGNITION
A key operated switch with
several positions which allows
various circuits, particularly the
primary ignition circuit, to
become operational.
Wires are always
drawn as straight lines
on wiring diagrams.
Crossed wires (1)
without a black dot at
the junction are not
joined; crossed wires
(2) with a black dot or
octagonal (
) mark at
the junction are spliced
(joined) connections. RELAY, DOUBLE THROW
A relay which passes current
through one set of contacts or the
other.
SENSOR, ANALOG SPEED
Uses magnetic impulses to open
and close a switch to create a
signal for activation of other
components.TRANSISTOR
A solidstate device typically used
as an electronic relay; stops or
passes current depending on the
voltage applied at ªbase.º SWITCH, WIPER PARK
Automatically returns wipers to
the stop position when the wiper
switch is turned off. SWITCH, MANUAL SPEAKER
An electromechanical device
which creates sound waves from
current flow.
2. NORMALLY
CLOSED
RESISTOR, VARIABLE or
RHEOSTAT
A controllable resistor with a
variable rate of resistance.
Also called a potentiometer or
rheostat. 2. NORMALLY
OPEN RELAY
1. NORMALLY
CLOSEDBasically, an electrically
operated switch which may
be normally closed (1) or
open (2).
Current flow through a
small coil creates a
magnetic field which either
opens or closes an
attached switch.
(2) SPLICED WIRES
(1) NOT
CONNECTED

28
ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[1MZ±FE]
A 2 A/C Triple Pressure SW (A/C Dual and Single Pressure F 1 Front Airbag Sensor LH
SW) F 2 Front Airbag Sensor RH
A 3 A/C Magnetic Clutch and Lock Sensor F 3 Front Clearance Light LH
A 4 ABS Actuator F 4 Front Clearance Light RH
A 5 ABS Actuator F 5 Front Side Marker LH
A 6 ABS Relay F 6 Front Side Marker RH
A 7 ABS Relay F 7 Front Turn Signal Light LH
A 8 ABS Speed Sensor Front LH F 8 Front Turn Signal Light RH
A 9 ABS Speed Sensor Front RH F 9 Front Wiper Motor
F 10 Fuse Box
B 2 Brake Fluid Level SW F 16 Fuse Box
F 18 Fuse Box
C 2 Cruise Control Actuator
C 17 Camshaft Position Sensor G 1 Generator (Alternator)
C 18 Crankshaft Position Sensor G 2 Generator (Alternator)
D 1 Data Link Connector 1 (Check Connector) H 1 Headlight Hi LH
D 2 Distributor H 2 Headlight Hi RH
H 3 Headlight Lo LH
E 1 EGR Gas Temp. Sensor H 4 Headlight Lo RH
E 2 Electronic Controlled Transmission Solenoid H 5 Horn LH
E 4 Engine Coolant Temp. Sensor (EFI Water Temp. H 6 Horn RH
Sensor) H 11 Heated Oxygen Sensor (Bank 1 Sensor 1)
E 5 Engine Coolant Temp. Sensor (Water Temp. Sensor) H 12 Heated Oxygen Sensor (Bank 2 Sensor 1)
(for Cooling Fan)

30
ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[5S±FE]
A 1 A/C Condenser Fan Motor E 1 EGR Gas Temp. Sensor
A 2 A/C Triple Pressure SW (A/C Dual and Single Pressure E 2 Electronic Controlled Transmission Solenoid
SW) E 3 Electronic Controlled Transmission Solenoid
A 3 A/C Magnetic Clutch and Lock Sensor E 4 Engine Coolant Temp. Sensor (EFI Water Temp.
A 4 ABS Actuator Sensor)
A 5 ABS Actuator E 5 Water Temp. SW (for Cooling Fan)
A 6 ABS Relay
A 7 ABS Relay F 1 Front Airbag Sensor LH
A 8 ABS Speed Sensor Front LH F 2 Front Airbag Sensor RH
A 9 ABS Speed Sensor Front RH F 3 Front Clearance Light LH
F 4 Front Clearance Light RH
B 1 Back±Up Light SW (M/T) F 5 Front Side Marker LH
B 2 Brake Fluid Level SW F 6 Front Side Marker RH
F 7 Front Turn Signal Light LH
C 2 Cruise Control Actuator F 8 Front Turn Signal Light RH
F 9 Front Wiper Motor
D 1 Data Link Connector 1 (Check Connector) F 10 Fuse Box
D 2 Distributor F 16 Fuse Box
F 17 Fuse Box
F 18 Fuse Box
G 1 Generator (Alternator)
G 2 Generator (Alternator)

53
Integration Relay 7.5A IGN
Daytime Running
Light Relay (Main)
Ignition SW
(AM1)(USA)
Starter Relay
(Coil Side) 10A MIR HTRABS Actuator
Light Control SW
[Comb. SW]15A HEAD (LH)
10A A/CABS ECU ABS Actuator
and ECU(TMM Made)
ABS Relay
Integration
Relay
Defogger Relay
(Point Side)
Heater Relay
(Point Side)
15A TAIL
Power Main Relay
(Point Side)Clutch Start
SW Light Control SW
[Comb. SW]
* These are the page numbers of the first page on which the related
system is shown.
The part indicated is located somewhere in the system, not
necessarily on the page indicated here.
(Canada)
Dimmer SW
[Comb. SW]
30A RDI FAN
30A CDS FAN15A HEAD (RH)
7.5A DRL
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
(Canada)
10A STARTER
Starter
(M/T)
(A/T)
Park/Neutral
Position SW
(Neutral Start SW)
Engine Control
Module (Engine and
Electronic Controlled
Transmission ECU)
7.5A TURN
10A GAUGE
15A ECU±IG
15A CIG/RADIO
20A WIPER (TMC Made) ABS Relay
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

54
POWER SOURCE (Current Flow Chart)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABS
A/C Condenser Fan Motor (5S±FE)
242
A4 A5 A11 A1*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
LocationA2 A3
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


A12 A6 A7 A13 A17 A18A14 A16 A21 B1 B2 B3 B4 B5 B6 B7 B9 B10 214 252126
252210 210 246246
252126222
224152 236 166246
252246
252126
246
252160
166 220 220
A/C Triple Pressure SW (A/C Dual
and Single Pressure SW)
A/C Magnetic Clutch and Lock
Sensor
ABS Actuator and ECU
(TMM Made)
ABS Actuator (TMC Made)
ABS Actuator and ECU
(TMM Made)
ABS Relay
A/C Amplifier
A/C SW
ABS ECU (TMC Made)
Air Inlet Control Servo Motor
Air Vent Mode Control Servo Motor
Ashtray Illumination
Auto Antenna Motor and Relay
Back±Up Light SW (M/T)
Brake Fluid Level SW
Back Door Lock Control SW
Blower Motor
Blower Resistor
Blower SW
Buckle SW LH
Back Door Lock Motor (W/G)
Buckle SW RH
A10246
252 210 210 210 214 246
252 242
246
252
ABS ECU (TMC Made)A/C Evaporator Temp. Sensor ABS Relay
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

55
192 17711 4
11 8
Cruise Control Actuator
C2 C5 C10 C11 C13 D8C12 C3 C4 C6 C8 C9 C14 C16 D1 D3 D4 D6 D7
Center Airbag Sensor Assembly
Cigarette Lighter
Cigarette Lighter Illumination
Clock
Combination Meter
(Turn Signal Indicator Light)Combination Meter
(Cruise Control Indicator Light)
Combination Meter
Combination Meter
(Meter Illmination)
Combination Meter
(Open Door Warning Light)
Combination Meter
(Seat Belt Warning Light)
Combination Meter
(Charge Warning Light)
Combination Meter
(High Beam Indicator Light)
Combination Meter
(Rear Light Warning Light)
Combination Meter
Combination Meter
(SRS Warning Light)
Combination Meter
(A/T Indicator Light)
Combination SW (Horn SW)
Combination SW
(Turn Signal SW)
Combination SW
(Light Control SW)
Combination SW
Front Wiper and Washer SW)
Cooling Fan ECU (1MZ±FE)
Cruise Control ECU
Data Link Connector 1
(Check Connector)
Data Link Connector 2
(TDCL (Toyota Diagnostic
Communication Link))
Daytime Running Light Relay
(Main) (CANADA)
Diode (for Idle±Up)
Diode (for Courtesy) (W/G) Door Lock Control Relay
18912618968
72192236210
21476 130
134
138
140 126120
124
144
148236126
198
204104
11 2
144244 80
90
98
214 90
192
214106
23680
90
98130
134
138
140156
140 104
106
D9 C717080
90
98177 17311 4
11 8106
126
148184
186192 98
204134
140
Diode (for Courtesy) Combination Meter
(Malfunction Indicator Light) Combination Meter
(ABS Warning Light) Clutch Start SW (M/T)
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

56
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


D25 E9E8 130
134
138
140130
138160 80 220126
198
20480
Door Courtesy SW Front LH
Door Key Cylinder Light and SW
Engine Control Module (Engine
and Electronic Controlled
Transmission ECU) (A/T) (1MZ±FE)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABSE7 E6 E5 E3 E2
D24 D23 D22 D21 D20 D19 D18
D17 D16 D15 D14 D13 D12130
138
140130
134
138
140130
134
138
140160 160 160 160 160 160198
220220 242 80
90
98
19880
Engine Control Module (Engine
and Electronic Controlled
Transmission ECU) (A/T) (5S±FE) Engine Control Module (Engine
and Electronic Controlled
Transmission ECU) Engine Controlled
Transmission Pattern
Select SW Engine Coolant Temp. Sensor
(Water Temp. Sensor) (for
Cooling Fan) (1MZ±FE) Electronic Controlled Transmission
Solenoid (5S±FE) Electronic Controlled Transmission
Solenoid Diode (for Tension Reducer) (C/P) Date Ling Connector 3 Door Lock Motor Rear RH
(EX. C/P) Door Lock Motor Rear LH
(EX. C/P) Door Courtesy SW Front RH
Door Courtesy SW Rear LH
Door Courtesy SW Rear RH
Door Key Lck and Unlock SW LH
(Ex. C/P)
Door Key Lck and Unlock SW RH
(Ex. C/P)
Door Lock Control SW RH
Door Lock Motor and Door Unlock
Detection SW Front LH
Door Lock Motor and Door Unlock
Detection SW Front RH
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

57
E10 80
98
204 80
90
98
236 184
F376 144
148126
246252
Engine Control Module (Engine
and Electronic Controlled
Transmission ECU)
High Mount Stop Light
Heated Oxygen Sensor (Bank 2
Sensor 1) (1MZ±FE)
Idle Air Control Valve (ISC Valve)
Igniter
Ignition Coil
Injector No. 1
F4 F5 F6 F7 F8 F9 F15 G2 G3 G4 H1 H2 H3 H4 H5 H6 H7 H8 H9 H10 H11 H12 I1 I2 I3 I4 90
198144
148144
148144
14811 4
11 811 4
11 8126 126 104 106 104 106 104 106 104 106 173 17311 4
11 8
12680120
12480 8080
90
9868
8072
98
23672 80
Heated Oxygen Sensor (Bank 1
Sensor 1) (1MZ±FE) Heated Oxygen Sensor (Bank 1
Sensor 2) Air Vent Mode Control SW (for
Lever Control SW Type) Heater Control SW (for Push
Control SW Type) Hazard SW Horn RH
Horn LH Front Clearance Light LH
Front Clearance Light RH
Front Side Marker LH
Front Side Marker RH
Front turn Signal Light LH
Front turn Signal Light RH
Front Wiper Motor
Fuel Pump and Sender
Generator (Alternator)
Glove Box Light
Glove Box Light SW
Headlight Hi LH (USA)
Headlight Hi LH (CANADA)
Headlight Hi RH (USA)
Headlight Hi RH (CANADA)
Headlight Lo LH (USA)
Headlight Lo LH (CANADA)
Headlight Lo RH (USA)
Headlight Lo RH (CANADA)
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

58
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


I5 I6 I7 I8 I9 I11 I12
I13I14 I16 I17 I18
I19 8068
72
80 130
134
138
140106
120
130
144
76
11 4
130
170
214
246
177
Injector No. 2
Injector No. 3
Injector No. 4
Injector No. 5 (1MZ±FE)
Injector No. 6 (1MZ±FE)
Injector Key Cylinder Light
Ignition SW and Unlock Warning
SW
Integration Relay
Interior Light
Ignition Coil No. 1 (1MZ±FE)
Ignition Coil No. 2 (1MZ±FE)
Ignition Coil No. 3 (1MZ±FE)
Ignition Coil No. 4 (1MZ±FE)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABS
Ignition Coil No. 5 (1MZ±FE)
Ignition Coil No. 6 (1MZ±FE)
Junction Connector
Junction Connector
Junction Connector
Junction Connector (for Airbag
System)
I20 I21 J1 J2 J3 J4 80 80 80 8011 2
126
140
17068
8068
8068
8068
8068
8068
80
90
11 8
134
192
224
252 98
120
138
210 80
154
182
190
204126
156
189
198
236130
156
182
214
226
234134
160
198
222
228
236154
168
204
224
230130
134
138
140130
134
138
140
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

60
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
156
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


P13 P14 P15 P16 R1 R2 R3 R5 R6 R7 R8 R9156 156126
222
224
228
234126
190154120
124
Power Window Motor Front LH
Power Window Motor Front RH
Power Window Motor Rear LH
(EX. C/P)
Radiator Fan Motor (5S±FE)
Radio and Player (w/ CD Player)
Radio and Player (w/o CD Player)
Rear Window Defogger SW
Remote Control mirror SW
Rheostat
Stop Light LH
[Rear Comb. Light LH]
Taillight LH
[Rear Comb. Light LH]
Rear Turn Signal Light LH
[Rear Comb. Light LH]
Stop Light LH
[Rear Comb. Light LH]
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABSR10 R11 R16 R17
Power Window Motor Rear RH
(EX. C/P)
Taillight LH
[Rear Comb. Light LH]
Back±up Light LH
[Rear Comb. Light LH]
Stop Light RH
[Rear Comb. Light RH]
Taillight RH
[Rear Comb. Light RH]
Rear Turn Signal Light RH
[Rear Comb. Light RH]
Taillight RH
[Rear Comb. Light RH]
Stop Light RH
[Rear Comb. Light RH]
Back±up Light RH
[Rear Comb. Light RH]
Rear Window Defogger (+)
(EX. W/G)
Rear Window Defogger (±)
(EX. W/G)
Rear Window Defogger (±)
(W/G)
156 242 126 126144
14811 4
148120
124144
148152120
124144
14811 4
11 8144
148120
124152 190 190 190
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29