fuel TOYOTA CAMRY 1994 XV10 / 4.G Wiring Diagrams Workshop Manual
[x] Cancel search | Manufacturer: TOYOTA, Model Year: 1994, Model line: CAMRY, Model: TOYOTA CAMRY 1994 XV10 / 4.GPages: 307, PDF Size: 5.48 MB
Page 15 of 307
15
ABBREVIATIONS
ABBREVIATIONS
The following abbreviations are used in this manual.
ABS = Anti±Lock Brake System
ACIS = Acoustic Control Induction System
A/C = Air Conditioning
A/T = Automatic Transmission
COMB. = Combination
C/P = Coupe
ECU = Electronic Control Unit
EFI = Electronic Fuel Injection
EGR = Exhaust Gas Recirculation
ESA = Electronic Spark Advance
Ex. = Except
FL = Fusible Link
IAC = Idle Air Control
ISC = Idle Speed Control
J/B = Junction Block
LH = Left-Hand
MFI = Multiport Fuel Injection
M/T = Manual Transmission
O/D = Overdrive
R/B = Relay Block
RH = Right±Hand
RPM = Engine Speed
S/D = Sedan
SFI = Sequential Multiport Fuel Injection
SRS = Supplemental Restraint System
SW = Switch
TEMP. = Temperature
VSV = Vacuum Switching Valve
W/G = Wagon
w/ = With
w/o = Without
*The titles given inside the components are the names of the terminals (terminal codes) and
are not treated as being abbreviations.
Page 16 of 307
METER, ANALOG
Current flow activates a magnetic
coil which causes a needle to
move, thereby providing a relative
display against a background
calibration. LED (LIGHT EMITTING DIODE)
Upon current flow, these diodes
emit light without producing the
heat of a comparable light. IGNITION COIL
Converts low±voltage DC current
into high±voltage ignition current
for firing the spark plugs. 1. SINGLE
FILAMENT
GROUND
The point at which wiring attaches
to the Body, thereby providing a
return path for an electrical circuit;
without a ground, current cannot
flow.Current flow causes a headlight
filament to heat up and emit light.
A headlight may have either a
single (1) filament or a double (2)
filament. BATTERY
Stores chemical energy and
converts it into electrical energy.
Provides DC current for the auto's
various electrical circuits.
CAPACITOR (Condenser)
A small holding unit for temporary
storage of electrical voltage.
CIRCUIT BREAKER
Basically a reusable fuse, a circuit
breaker will heat and open if too
much current flows through it. Some
units automatically reset when cool,
others must be manually reset.
DIODE
A semiconductor which allows
current flow in only one direction.
DIODE, ZENER
A diode which allows current flow
in one direction but blocks reverse
flow only up to a specific voltage.
Above that potential, it passes the
excess voltage. This acts as a
simple voltage regulator.
FUSE
A thin metal strip which burns
through when too much current
flows through it, thereby stopping
current flow and protecting a
circuit from damage.
FUSIBLE LINK
A heavy±gauge wire placed in
high amperage circuits which
burns through on overloads,
thereby protecting the circuit.
The numbers indicate the cross±
section surface area of the wires.HORN
An electric device which sounds a
loud audible signal.
LIGHT
Current flow through a filament
causes the filament to heat up
and emit light.
METER, DIGITAL
Current flow activates one or
many LED's, LCD's, or fluorescent
displays, which provide a relative
or digital display.
MOTOR
A power unit which converts
electrical energy into mechanical
energy, especially rotary motion. CIGARETTE LIGHTER
An electric resistance heating
element.
DISTRIBUTOR, IIA
Channels high±voltage current
from the ignition coil to the
individual spark plugs.2. DOUBLE
FILAMENT HEADLIGHTS
FUEL
(for High Current Fuse or
Fusible Link.)
(for Medium Current Fuse)
M
16
GLOSSARY OF TERMS AND SYMBOLS
Page 29 of 307
29
Position of Parts in Engine Compartment
[1MZ±FE]
I 1 Idle Air Control Valve (ISC Valve) N 1 Noise Filter (for Ignition System)
I 2 Igniter
I 4 Injector No. 1 O 1 Oil Pressure SW
I 5 Injector No. 2 O 6 O/D Direct Clutch Speed Sensor
I 6 Injector No. 3
I 7 Injector No. 4 P 1 Park/Neutral Position SW (Neutral Start SW) (A/T)
I 8 Injector No. 5
I 9 Injector No. 6 S 1 Solenoid Valve (for Hydrauric Motor)
I 15 Igniter S 3 Starter
I 16 Ignition Coil No. 1 S 4Starter
I 17 Ignition Coil No. 2
I 18 Ignition Coil No. 3 T 1 Throttle Position Sensor
I 19 Ignition Coil No. 4
I 20 Ignition Coil No. 5 V 1 VSV (for A/C Idle±Up)
I 21 Ignition Coil No. 6 V 2 VSV (for EGR System)
V 3 VSV (for Fuel Pressure Up)
J 6 Junction Connector V 4 VSV (for Intake Air Control)
V 5 Vehicle Speed Sensor (Speed Sensor)
K 1 Knock Sensor 1
K 2 Knock Sensor 2 W 1 Washer Motor
W 2 Water Temp. Sender
M 6 Mass Air Flow (Air Flow Meter)
Page 31 of 307
31
Position of Parts in Engine Compartment
[5S±FE]
H 1 Headlight Hi LH O 1 Oil Pressure SW
H 2 Headlight Hi RH O 2 Oxygen Sensor (Sub)
H 3 Headlight Lo LH O 3 Oxygen Sensor (Main)
H 4 Headlight Lo RH
H 5 Horn LH P 1 Park/Neutral Position SW (Neutral Start SW) (A/T)
H 6 Horn RH
R 1 Radiator Fan Motor
I 1 Idle Air Control Valve (ISC Valve)
I 2 Igniter S 3 Starter
I 3 Ignition Coil S 4Starter
I 4 Injector No. 1
I 5 Injector No. 2 T 1 Throttle Position Sensor
I 6 Injector No. 3
I 7 Injector No. 4 V 1 VSV (for A/C Idle±Up)
I 10 Intake Air Temp. Sensor (In±Air Temp. Sensor) V 2 VSV (for EGR System)
V 3 VSV (for Fuel Pressure Up)
K 1 Knock Sensor V 5 Vehicle Speed Sensor (Speed Sensor)
M 1 Manifold Absolute Pressure Sensor (Vacuum Sensor) W 1 Washer Motor
W 2 Water Temp. Sender
N 1 Noise Filter (for Ignition System)
Page 34 of 307
34
ELECTRICAL WIRING ROUTING
Position of Parts in Body
[Sedan]
A 19 ABS Speed Sensor Rear LH L 3 Luggage Compartment Light
A 20 ABS Speed Sensor Rear RH L 4 Luggage Compartment Light SW
A 21 Auto Antenna Motor and Relay
M 2 Moon Roof Control Relay
D 10 Door Courtesy Light Front LH M 3 Moon Roof Control SW and Personal Light (w/ Moon
D 11 Door Courtesy Light Front RH Roof)
D 12 Door Courtesy SW Front LH M 4 Moon Roof Limit SW
D 13 Door Courtesy SW Front RH M 5 Moon Roof Motor
D 14 Door Courtesy SW Rear LH
D 15 Door Courtesy SW Rear RH P 9 Power Window Control SW Front RH
D 16 Door Key Cylinder Light and SW P 10 Power Window Control SW Rear LH
D 17 Door Key Lock and Unlock SW LH P 11 Power Window Control SW Rear RH
D 18 Door Key Lock and Unlock SW RH P 12 Power Window Master SW and Door Lock Control SW
D 19 Door Lock Control SW RH LH
D 20 Door Lock Motor and Door Unlock Detection SW Front P 13 Power Window Motor Front LH
LHP 14 Power Window Motor Front RH
D 21 Door Lock Motor and Door Unlock Detection SW Front P 15 Power Window Motor Rear LH
RHP 16 Power Window Motor Rear RH
D 22 Door Lock Motor Rear LH
D 23 Door Lock Motor Rear RH R 8 Rear Combination Light LH
R 9 Rear Combination Light LH
F 11 Front Door Speaker LH R 10 Rear Combination Light RH
F 12 Front Door Speaker RH R 11 Rear Combination Light RH
F 13 Front Tweeter (Speaker) LH R 12 Rear Speaker LH
F 14 Front Tweeter (Speaker) RH R 13 Rear Speaker RH
F 15 Fuel Pump and Sender R 16 Rear Window Defogger (+)
R 17 Rear Window Defogger (±)
H 10 High Mount Stop Light R 20 Remote Control Mirror LH
R 21 Remote Control Mirror RH
I 14 Interior Light
V 8 Vanity Light LH
L 1 License Plate Light V 9 Vanity Light RH
L 2 Light Failure Sensor
Page 35 of 307
35
Position of Parts in Body
[Coupe]
A 19 ABS Speed Sensor Rear LH M 2 Moon Roof Control Relay
A 20 ABS Speed Sensor Rear RH M 3 Moon Roof Control SW and Personal Light
A 21 Auto Antenna Motor and Relay (w/ Moon Roof)
M 4 Moon Roof Limit SW
D 10 Door Courtesy Light Front LH M 5 Moon Roof Motor
D 11 Door Courtesy Light Front RH
D 12 Door Courtesy SW Front LH P 9 Power Window Control SW Front RH
D 13 Door Courtesy SW Front RH P 12 Power Window Master SW and Door Lock Control
D 16 Door Key Cylinder Light and SW SW LH
D 19 Door Lock Control SW RH P 13 Power Window Motor Front LH
D 26 Door Lock Motor, Door Unlock Detection SW P 14 Power Window Motor Front RH
Door Key Lock and Unlock SW LH
D 27 Door Lock Motor, Door Unlock Detection SW R 8 Rear Combination Light LH
Door Key Lock and Unlock SW RH R 9 Rear Combination Light LH
D 28 Door Lock Control SW LH (w/o Power Window) R 10 Rear Combination Light RH
R 11 Rear Combination Light RH
F 11 Front Door Speaker LH R 12 Rear Speaker LH
F 12 Front Door Speaker RH R 13 Rear Speaker RH
F 13 Front Tweeter (Speaker) LH R 16 Rear Window Defogger (+)
F 14 Front Tweeter (Speaker) RH R 17 Rear Window Defogger (±)
F 15 Fuel Pump and Sender R 20 Remote Control Mirror LH
R 21 Remote Control Mirror RH
H 10 High Mount Stop Light
T 2 Tension Reducer Solenoid LH
I 14 Interior Light T 3 Tension Reducer Solenoid RH
L 1 License Plate Light V 8 Vanity Light LH
L 2 Light Failure Sensor V 9 Vanity Light RH
L 3 Luggage Compartment Light
L 4 Luggage Compartment Light SW
Page 36 of 307
36
ELECTRICAL WIRING DIAGRAM
Position of Parts in Body
[Wagon]
A 19 ABS Speed Sensor Rear LH F 13 Front Tweeter (Speaker) LH P 11 Power Window Control SW Rear
A 20 ABS Speed Sensor Rear RH F 14 Front Tweeter (Speaker) RH RH
A 21 Auto Antenna Motor and Relay F 15 Fuel Pump and Sender P 12 Power Window Master SW and
Door Lock Control SW LH
D 10 Door Courtesy Light Front LH H 10 High Mount Stop Light P 13 Power Window Motor Front LH
D 11 Door Courtesy Light Front RH P 14 Power Window Motor Front RH
D 12 Door Courtesy SW Front LH I 14 Interior Light P 15 Power Window Motor Rear LH
D 13 Door Courtesy SW Front RH P 16 Power Window Motor Rear RH
D 14 Door Courtesy SW Rear LH L 1 License Plate Light
D 15 Door Courtesy SW Rear RH L 2 Light Failure Sensor R 8 Rear Combination Light LH
D 16 Door Key Cylinder Light and SW L 3 Luggage Compartment Light R 9 Rear Combination Light LH
D 17 Door Key Lock and Unlock SW LH L 4 Luggage Compartment Light SW R 10 Rear Combination Light RH
D 18 Door Key Lock and Unlock SW RH R 11 Rear Combination Light RH
D 19 Door Lock Control SW RH M 2 Moon Roof Control Relay R 12 Rear Speaker LH
D 20 Door Lock Motor and Door Unlock M 3 Moon Roof Control SW and R 13 Rear Speaker RH
Detection SW Front LH Personal Light (w/ Moon Roof) R 16 Rear Window Defogger (+)
D 21 Door Lock Motor and Door Unlock M 4 Moon Roof Limit SW R 17 Rear Window Defogger (±)
Detection SW Front RH M 5 Moon Roof Motor R 20 Remote Control Mirror LH
D 22 Door Lock Motor Rear LH R 21 Remote Control Mirror RH
D 23 Door Lock Motor Rear RH P 9 Power Window Control SW Front
RH V 8 Vanity Light LH
F 11 Front Door Speaker LH P 10 Power Window Control SW Rear V 9 Vanity Light RH
F 12 Front Door Speaker RH LH
Page 47 of 307
47
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
BW1REAR DOOR LH WIRE AND FLOOR NO. 1 WIRE (LEFT CENTER PILLAR)
BX1FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE (UNDER THE REAR SEAT CUSHION)
BY1REAR DOOR RH WIRE AND FLOOR NO. 2 WIRE (RIGHT CENTER PILLAR)
BZ1LUGGAGE ROOM NO. 1 WIRE AND FLOOR NO. 1 WIRE (LUGGAGE COMPARTMENT LEFT)
Ba1FLOOR NO. 1 WIRE AND LUGGAGE ROOM NO. 2 WIRE (LUGGAGE COMPARTMENT DOOR)
Page 49 of 307
49
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
BX1FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE (UNDER THE REAR SEAT CUSHION)
BZ1LUGGAGE ROOM NO. 1 WIRE AND FLOOR NO. 1 WIRE (LUGGAGE COMPARTMENT LEFT)
Ba1FLOOR NO. 1 WIRE AND LUGGAGE ROOM NO. 2 WIRE (LUGGAGE COMPARTMENT DOOR)
Page 51 of 307
51
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
BW1REAR DOOR LH WIRE AND FLOOR NO. 1 WIRE (LEFT CENTER PILLAR)
BX1FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE (UNDER THE REAR SEAT CUSHION)
BY1REAR DOOR RH WIRE AND FLOOR NO. 2 WIRE (RIGHT CENTER PILLAR)
Bb1LUGGAGE ROOM NO. 1 WIRE AND FLOOR NO. 1 WIRE (LUGGAGE COMPARTMENT LEFT)
Bc1
Bc2BACK DOOR NO. 1 (WIRE AND FLOOR NO. 1 WIRE (LEFT QUARTER TRIM INNER)
Bc3
BACK DOOR NO. 1 (WIRE AND FLOOR NO. 1 WIRE (LEFT QUARTER TRIM INNER)
Bd1
Bd2BACK DOOR NO. 1 WIRE AND BACK DOOR NO. 2 WIRE (BACK DOOR LEFT)
Bd3
BACK DOOR NO. 1 WIRE AND BACK DOOR NO. 2 WIRE (BACK DOOR LEFT)
Be1REAR WINDOW NO. 1 WIRE AND BACK DOOR NO. 2 WIRE (BACK DOOR LEFT)