stop start TOYOTA CAMRY 1994 XV10 / 4.G Wiring Diagrams Workshop Manual

52
POWER SOURCE (Current Flow Chart)
The chart below shows the route by which current flows from the battery to each electrical source (Fusible Link,
Circuit Breaker, Fuse, etc.) and other parts.
The next page and following pages show the parts to which each electrical source outputs current.
Starter Battery
FL MAIN 2.0L30A AM2Ignition SW
(AM2)
Headlight Relay
(Point Side)
40A DEFOG 100A ALTGenerator
(Alternator) 7.5A SRS
Taillight Relay
(Coil Side) 40A MAIN
(Canada) 7.5A OBD
7.5A ALT±S
10A HAZ
10A HORN
15A ECU±B
15A EFI
20A DOMEHeadlight Relay
(Coil Side)
60A ABS 15A STOP
40A HEATER
Taillight Relay
(Point Side)
Engine Main
Relay (Point Side)
15A TEL
Daytime Running
Light Relay No. 2
(Coil Side)
Daytime Running
Light Relay No. 2
(Point Side)Starter Relay
(Point Side)
(5S±FE)
30A POWER
40A AM1
Daytime Running
Light Relay (Main)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
[LOCATION](1): J/B No. 1 (See page 20)(2): J/B No. 2 (See page 19)
(3): R/B No. 1 (See page 20)(7): R/B No. 7 (See page 19) 2022
25
27

54
POWER SOURCE (Current Flow Chart)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABS
A/C Condenser Fan Motor (5S±FE)
242
A4 A5 A11 A1*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
LocationA2 A3
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


A12 A6 A7 A13 A17 A18A14 A16 A21 B1 B2 B3 B4 B5 B6 B7 B9 B10 214 252126
252210 210 246246
252126222
224152 236 166246
252246
252126
246
252160
166 220 220
A/C Triple Pressure SW (A/C Dual
and Single Pressure SW)
A/C Magnetic Clutch and Lock
Sensor
ABS Actuator and ECU
(TMM Made)
ABS Actuator (TMC Made)
ABS Actuator and ECU
(TMM Made)
ABS Relay
A/C Amplifier
A/C SW
ABS ECU (TMC Made)
Air Inlet Control Servo Motor
Air Vent Mode Control Servo Motor
Ashtray Illumination
Auto Antenna Motor and Relay
Back±Up Light SW (M/T)
Brake Fluid Level SW
Back Door Lock Control SW
Blower Motor
Blower Resistor
Blower SW
Buckle SW LH
Back Door Lock Motor (W/G)
Buckle SW RH
A10246
252 210 210 210 214 246
252 242
246
252
ABS ECU (TMC Made)A/C Evaporator Temp. Sensor ABS Relay
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

56
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


D25 E9E8 130
134
138
140130
138160 80 220126
198
20480
Door Courtesy SW Front LH
Door Key Cylinder Light and SW
Engine Control Module (Engine
and Electronic Controlled
Transmission ECU) (A/T) (1MZ±FE)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABSE7 E6 E5 E3 E2
D24 D23 D22 D21 D20 D19 D18
D17 D16 D15 D14 D13 D12130
138
140130
134
138
140130
134
138
140160 160 160 160 160 160198
220220 242 80
90
98
19880
Engine Control Module (Engine
and Electronic Controlled
Transmission ECU) (A/T) (5S±FE) Engine Control Module (Engine
and Electronic Controlled
Transmission ECU) Engine Controlled
Transmission Pattern
Select SW Engine Coolant Temp. Sensor
(Water Temp. Sensor) (for
Cooling Fan) (1MZ±FE) Electronic Controlled Transmission
Solenoid (5S±FE) Electronic Controlled Transmission
Solenoid Diode (for Tension Reducer) (C/P) Date Ling Connector 3 Door Lock Motor Rear RH
(EX. C/P) Door Lock Motor Rear LH
(EX. C/P) Door Courtesy SW Front RH
Door Courtesy SW Rear LH
Door Courtesy SW Rear RH
Door Key Lck and Unlock SW LH
(Ex. C/P)
Door Key Lck and Unlock SW RH
(Ex. C/P)
Door Lock Control SW RH
Door Lock Motor and Door Unlock
Detection SW Front LH
Door Lock Motor and Door Unlock
Detection SW Front RH
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

58
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


I5 I6 I7 I8 I9 I11 I12
I13I14 I16 I17 I18
I19 8068
72
80 130
134
138
140106
120
130
144
76
11 4
130
170
214
246
177
Injector No. 2
Injector No. 3
Injector No. 4
Injector No. 5 (1MZ±FE)
Injector No. 6 (1MZ±FE)
Injector Key Cylinder Light
Ignition SW and Unlock Warning
SW
Integration Relay
Interior Light
Ignition Coil No. 1 (1MZ±FE)
Ignition Coil No. 2 (1MZ±FE)
Ignition Coil No. 3 (1MZ±FE)
Ignition Coil No. 4 (1MZ±FE)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABS
Ignition Coil No. 5 (1MZ±FE)
Ignition Coil No. 6 (1MZ±FE)
Junction Connector
Junction Connector
Junction Connector
Junction Connector (for Airbag
System)
I20 I21 J1 J2 J3 J4 80 80 80 8011 2
126
140
17068
8068
8068
8068
8068
8068
80
90
11 8
134
192
224
252 98
120
138
210 80
154
182
190
204126
156
189
198
236130
156
182
214
226
234134
160
198
222
228
236154
168
204
224
230130
134
138
140130
134
138
140
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

59
11 8
180
186
22480
J5 J6 K3
120
124
144
148168 198130
138
168168120
124
182
192198
204
210
214236
Junction Connector (W/G)
Junction Connector (1MZ±FE)
Key Interlock Solenoid
License Plate Light
Light Failure Sensor
Luggage Compartment Light
Luggage Compartment Light SW
Moon Roof Control RelayMoon Roof Control SW and Personal
Light (w/ Moon Roof) (EX. W/G)Moon Roof Limit SW (EX. W/G)
Moon Roof Motor (EX. W/G)
Mass Air Flow (Air Flow Meter)
(1MZ±FE)
Noise Filter (for Ignition System)
Oil Pressure SW
O/D Main SW and A/T Indicator
Light (Shift Lever)
Park/Neutral Position SW
(Neutral Start SW) (A/T)
Parking Brake SW (for 1MZ±FE)
Parking Brake SW (for 5S±FE)
J7 L1 L2 L4L3 M2 M3 M5M4 M6 N1 N2 N3 O1 O5 P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12
Junction Connector (1MZ±FE)
Noise Filter (for Stop Light)
Noise Filter (for Stop Light)
Power Seat Control SW
Power Seat Motor
(for Front Vertical Control)
Power Seat Motor
(for Rear Vertical Control)
Power Seat Motor
(for Slide control)
Power Seat Motor
(for Reclining Control)
Power Window Control SW Front
RH
Power Window Control SW Rear
LH (EX. C/P)
Power Window Control SW Rear
RH (EX. C/P)
Power Window Master SW and
Door Lock control SW LH
182 144130
134
138
140130
134
138
140168 80 80120
124
182
192198
204
210
214126
198
204 68
72
152
198
204236 236 180 180 180 180 180 156 156 156156
160
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

60
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
156
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


P13 P14 P15 P16 R1 R2 R3 R5 R6 R7 R8 R9156 156126
222
224
228
234126
190154120
124
Power Window Motor Front LH
Power Window Motor Front RH
Power Window Motor Rear LH
(EX. C/P)
Radiator Fan Motor (5S±FE)
Radio and Player (w/ CD Player)
Radio and Player (w/o CD Player)
Rear Window Defogger SW
Remote Control mirror SW
Rheostat
Stop Light LH
[Rear Comb. Light LH]
Taillight LH
[Rear Comb. Light LH]
Rear Turn Signal Light LH
[Rear Comb. Light LH]
Stop Light LH
[Rear Comb. Light LH]
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABSR10 R11 R16 R17
Power Window Motor Rear RH
(EX. C/P)
Taillight LH
[Rear Comb. Light LH]
Back±up Light LH
[Rear Comb. Light LH]
Stop Light RH
[Rear Comb. Light RH]
Taillight RH
[Rear Comb. Light RH]
Rear Turn Signal Light RH
[Rear Comb. Light RH]
Taillight RH
[Rear Comb. Light RH]
Stop Light RH
[Rear Comb. Light RH]
Back±up Light RH
[Rear Comb. Light RH]
Rear Window Defogger (+)
(EX. W/G)
Rear Window Defogger (±)
(EX. W/G)
Rear Window Defogger (±)
(W/G)
156 242 126 126144
14811 4
148120
124144
148152120
124144
14811 4
11 8144
148120
124152 190 190 190
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

61
186
R18 R19 R20 R21 S3 S8 S9 S10 V1 V2 V3 V468
72182226
23080
90
98
Rear Wiper Motor (W/G)
Rear Wiper Relay (W/G)
Remote Control Mirror LH
Remote Control Mirror RH
Shift Lock ECU
Stereo Component Amplifier
Stereo Component Amplifier
Stop Light SW
VSV (for A/C Idle±Up)
VSV (for EGR System) (1MZ±FE)
VSV (for Fuel Pressure Up)
VSV (for Intake Air Control)
(1MZ±FE)
Vehicle Speed Sensor
(Speed Sensor)
Vanity Light LH
Vanity Light RH
Washer Motor
Water Temp. Sender
Diode
Noise Filter
Defogger Relay (Coil Side)
Power Main Relay (Coil Side)
S5 V5 V8 V9 W1 W2
Starter (1MZ±FE)
Defogger Relay (Point Side)
Power Main Relay (Point Side)
Taillight Relay (Coil Side)
Taillight Relay (Point Side)
Starter Relay (Point Side)
Starter Relay (Coil Side)
EFI Main Relay (Coil Side)
EFI Main Relay (Point Side)
Headlight Relay (Coil Side)
186 154 154226
230120
192
204182
198
210
21480
9080
90
9880 80
98
198 90
192
236130
134
138130
134
138184
186236130
134
138190 190 190156
160
168156
160
16811 2
12612668
7268
72 80
90
98
198
204 80
90
98
198
204106
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

62
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


106
Horn Relay
Headlight Relay (Point Side)
Radiator Fan Relay (Point Side)
Turn Signal Flasher
Heater Relay (Point Side)
Radiator Fan Relay No. 2
(Coil Side)
A/C Magnetic Clutch Relay
(Coil Side)
Daytime Running Light Relay No. 3
(Coil Side)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABS
Radiator Fan Relay (Coil Side)
Heater Relay (Coil Side)
Radiator Fan Relay No. 2
(Point Side)
Radiator Fan Relay No. 3
(Point Side)
A/C Magnetic Clutch Relay
(Point Side)
Circuit Opening Relay (Coil Side)
Circuit Opening Relay (Coil Side)
Daytime Running Light Relay No. 4
(Coil Side)
106 173 106 242 24211 4
11 8246 246 242 242 242 246 24680
90
9880
90
98
[LOCATION](1)
(4): J/B No. 1 (See page 20)
: R/B No. 4 (See page )(2)
(5): J/B No. 2 (See page 19)
: R/B No. 5 (See page )(3)
(6): R/B No. 1 (See page 23)
: R/B No. 6 (See page )
(7): R/B No. 7 (See page 20)(8): Fuse Box (F10, F17 See
on page 19) 20 2225
25
28 2926 26
27

65
E7 E6
21
7521
12 1E4
1E2
1G10
1G3
1G8 4
103
2
7
9 AM2 AM1ACC
IG1
ST1
IG2
ST2
EB IG 5
5 11M1
1C10 W
W
W
W±R
W±B
B±R
WB±R
B±R
WW
W
WW±B W
W
P±L
B±Y
B±O B±W
W
W±B
W±B
15A STOP
7. 5A SRS
15A TAIL
TAILLIGHT
RE LA Y
POWER MAIN
RELAY
DEFOGGER
RE LA Y
15A CIG/RADIO
15A ECU±IG
20A WIPER
10A GAUGE
7. 5A TURN
15A HEAD(
LW R±RH)
15A HEAD(
LWR±LH)
7. 5A DRL B±R
TO STARTER
3412 53
12
53
53
W±B
IGNITION SW I12
7 5R±W
R
W±R 1A7
EB11TO DOOR LOCK
CONTROL RELAY
10A MIR HTR
7. 5A IGN
10A STARTER
54 B±R
IP1172130A POWER
1240A DEFOG
E10 : 1MZ±FE
E20 : 5S±FE

84
ENGINE CONTROL (1MZ±FE)
CIRCUIT OPENING RELAY2±1 : CLOSED WITH STARTER RUNNING OR MEASURING PLATE (VOLUME AIR FLOW (AIR FLOW METER)) OPEN
EFI MAIN RELAY2±4 : CLOSED WITH IGNITION SW AT ON OR ST POSITION
E 4
ENGINE COOLANT TEMP. SENSOR (EFI WATER TEMP. SENSOR) 1±2 : 10.0 ± 20.0 K (±20°C, ±4°F)
: 4.0 ± 7.0 K (0°C, 32°F)
: 2.0 ± 3.0 K (20°C, 68°F)
: 0.9 ± 1.3 K (40°C, 104°F)
: 0.4 ± 0.7 K (60°C, 140°F)
: 0.2 ± 0.4 K (80°C, 176°F)
E 7(A), E 8(B), E 9(C), E10(D)
ENGINE CONTROL MODULE (ENGINE AND ELECTRONIC CONTROLLED
TRANSMISSION ECU)
VOLTAGE AT ENGINE CONTROL MODULE (ECU) WIRING CONNECTOR
BATT ± E1: ALWAYS 9.0±14.0 VOLTS
+B ± E1:9.0±14.0 VOLTS (IGNITION SW AT ON POSITION)
+B1 ± E1:9.0±14.0 VOLTS (IGNITION SW AT ON POSITION)
IDL ± E1:9.0±14.0 VOLTS (IGNITION SW ON AND THROTTLE VALVE FULLY OPEN)
0±3.0 VOLTS (IGNITION SW ON AND THROTTLE VALVE FULLY CLOSED)
VC ± E1: ALWAYS 4.5±5.5 VOLTS (IGNITION SW AT ON POSITION)
VTA ± E1:0.3±0.8 VOLTS (IGNITION SW ON AND THROTTLE VALVE FULLY CLOSED)
3.2±4.9 VOLTS (IGNITION SW ON AND THROTTLE VALVE FULLY OPEN)
VG ± E1:4.0±5.5 VOLTS (IGNITION SW AT ON POSITION)
THA ± E1:0.5±3.4 VOLTS (IGNITION SW ON AND INTAKE AIR TEMP. 20°C, 68°F)
THW ± E1:0.2±1.0 VOLTS (ENGINE IDLING AND COOLANT TEMP. 80°C, 176°F)
#10, #20, #30, #40, #50, #60
± E01:9.0±14.0 VOLTS (IGNITION SW AT ON POSITION)
PULSE GENERATION (ENGINE IDLING)
IGT1, IGT2, IGT3
IGT4, IGT5, IGT6 ± E1: PULSE GENERATION (ENGINE IDLING)
IGF ± E1:4.5±5.5 VOLTS (IGNITION SW AT ON POSITION)
PULSE GENERATION (ENGINE IDLING)
G22+ ± G±: PULSE GENERATION (ENGINE IDLING)
NE+ ± G±: PULSE GENERATION (ENGINE IDLING)
RSC, RSO ± E1: PULSE GENERATION (ENGINE IDLING AND A/C OPERATION)
OXS, OXL, OXR ± E1: PULSE GENERATION (MAINTAIN ENGINE SPEED AT 2500 RPM FOR TWO MINUTES AFTER WARMING UP)
HTS, HTL, HTR ± E01:9.0±14.0 VOLTS (IGNITION SW AT ON POSITION)
0±3.0 VOLTS (ENGINE IDLING)
KNKL, KNLR ± E1: PULSE GENERATION (ENGINE IDLING)
NSW ± E1:9.0±14.0 VOLTS (IGNITION SW ON AND OTHER SHIFT POSITION IN P OR N POSITION)
BELOW 3.0 VOLTS (IGNITION SW ON AND SHIFT POSITION IN P OR N POSITION)
SP1 ± E1: PULSE GENERATION (IGNITION SW ON AND ROTATE DRIVING WHEEL SLOWLY)
TE1 ± E1:9.0±14.0 VOLTS (IGNITION SW AT ON POSITION)
TE2 ± E1:9.0±14.0 VOLTS (IGNITION SW AT ON POSITION)
W ± E1: BELOW 3.0 VOLTS (MULFUNCTION INDICATOR LAMP ON)
9.0±14.0 VOLTS (MULFUNCTION INDICATOR LAMP OFF AND ENGINE RUNNING)
A/C ± E1: BELOW 1.5 VOLTS (ENGINE IDLING AND A/C SW ON)
7.5±14.0 VOLTS (A/C SW OFF)
ACT ± E1:9.0±14.0 VOLTS (ENGINE IDLING AND A/C SW ON)
BELOW 1.5 VOLTS (A/C SW OFF)
ACIS ± E01:9.0±14.0 VOLTS (IGNITION SW AT ON POSITION)
STA ± E1:6.0 VOLTS OR MORE (ENGINE CRANKING)
I 4, I 5, I 6, I 7, I 8, I 9
INJECTOR1±2 : APPROX. 13.8 
T 1
THROTTLE POSITION SENSOR3±1 :0.2±5.7 KWITH CLEARANCE BETWEEN LEVER AND STOP SCREW 0 MM (0 IN.)
2±1 : LESS THAN 2.3 KWITH CLEARANCE BETWEEN LEVER AND STOP SCREW 0.5 MM (0.020 IN.)
WITH CLEARANCE BETWEEN LEVER AND STOP SCREW 0.7 MM (0.0276 IN.)
3±1 :2.0±10.2 KWITH THROTTLE VALVE FULLY OPEN
SERVICE HINTS