Power TOYOTA CAMRY 2000 Service Service Manual

26
INTERIOR
 CUP HOLDER
2 cup holders are provided in the front of the console
box. 2 cup holders for the rear passengers are
provided in the rear of the console.
 POWER OUTLET
A power outlet is provided under the ashtray. The
power outlet can be used to supply power to various
car accessories.

32ENGINEÐ5S±FE ENGINE
 MAJOR DIFFERENCES
Major differences between the new 5S±FE engine and previous engine are listed below.
Item
Features
Engine ProperThe squish area of the combustion chamber in the cylinder head has been
optimised to improve torque in the low±to mid±speed range.
Cooling SystemAn aluminum radiator core is used for weight reduction.
Intake and Exhaust System
The ports of the manifold have been extended to improve torque in the low±
to mid±speed range.
The exhaust manifold is made of stainless steel plates for improve engine per-
formance and weight reduction.
Through the optimized allocation of the exhaust pipe supports, the number of
supports has been reduced from 5 to 4, thus reducing the noise and vibration
which are transmitted to the vehicle body.
Fuel SystemA fuel returnless system has been adopted to prevent the internal temperature
of the fuel tank from rising and to reduce evaporative emissions.
Ignition SystemThe DIS (Direct Ignition System) contributes to the powerful high output by
providing a powerful spark to the engine.
Engine MountingTo reduce noise and vibration and to improve drivability, the allocation of the
engine mounts*1 and their characteristics have been revised.
Engine Control System
The injection pattern for engine starting have changed form the 2 group
injection type to sequential multiport injection type.
In place of the oxygen sensor (bank 1, sensor 1), a new air fuel ratio sensor has
been adopted. *
2
The power steering idle±up control has been changed from the system using
an air control valve to the one using a pressure switch and an IAC valve.
Emission Control System
The EGR valve body has been changed from cast iron to aluminum alloy for
weight reduction.
A TWC (Three±Way Catalytic Converter) that is integrated with a stainless
steel exhaust manifold has been adopted.*
2
The TWC, which was previously installed below the exhaust manifold has
been discontinued.*3
*1: Only for Automatic Transaxle Models.
*
2: Only for California Specification Models.
*
3: Except for California Specification Models.

86CHASSISÐSTEERING
STEERING
 DESCRIPTION
As in the previous model, a rack and pinion type steering gear is used. An engine revolution sensing type power
steering is used on all models.
As in the previous model, all models are provided with tilt steering.
An energy absorbing mechanism has been changed.

Specifications
Model
NewPrevious
Engine Type5S FE1MZ FE5S FE1MZ FEItem5S±FE1MZ±FE5S±FE1MZ±FE
Gear Ratio (Overall)17.4 : 1uuu
No. of Turns Lock to
Lock3.13.03.13.0
Rack Stroke mm (in.)149 (5.87)145 (5.71)149 (5.87)u145 (5.71)
Fluid TypeATF Type DEXRON
II or IIIuuu

101 BODY ELECTRICALÐAIR CONDITIONING
AIR CONDITIONING
 DESCRIPTION
1. General
The air conditioning system in the new Camry has the following features:
The rotary switch and lever type heater control panel is used.
As in the previous model, an air conditioning unit that incorporates a blower, heater and cooler unit, has been
adopted.
The duct size of the blower unit has been enlarged.
An aluminum heater core has been adopted on all models.
The defroster nozzle inner wall is modified into a radial configuration for smoother air flow.
A defroster±linked air conditioning start up control, which automatically engages the air conditioning when the
defroster mode has been selected, is provided.
The air conditioning amplifier which is integrated with the ECM has been adopted on the 5S±FE engine model.

Performance
Model
NewPreviousItemNewPrevious
Heat Output W (Kcal/H)5580 (4800)u
HeaterAir Flow Volume* m3/h360u
Power Consumption W220u
Ai
Heat Output W (Kcal/H)5300 (4560)5350 (4600)
Air
ConditionerAir Flow Volume m3/h520530Conditioner
Power Consumption W260u
DefrosterAir Flow Volume* m3/h360u
*: With side vent closed.

Specifications
Model
NewPreviousItemNewPrevious
aterTypeDimpled Tube Typeu
and Hea
t
Heater CoreSize WxHxL mm (in.)160 x 220 x 32
(6.3 x 8.7 x 1.3)u
ion a
n
Fin Pitch mm (in.)1.8 (0.07)u
ntilati
o
Blower
Motor TypeA80Fs13TS80Fs12.5T
Ve n
tBlowerFan Size Dia. xH mm (in.)150 x 75 (5.9 x 3.0)u
Type3 Passage Flow Typeu
g
CondenserSize WxHxL mm (in.)415.6 x 726 x 22
(16.4 x 28.6 x 0.9)435.2 x 686 x 22
(17.1 x 27.0 x 0.9)
ingFin Pitch mm (in.)4.5 (0.18)3.5 (0.14)
ioni
n
TypeDrawn Cup Typeu
onditi
o
EvaporatorSize WxHxL mm (in.)260 x 252 x 90
(10.2 x 9.9 x 3.5)u
r C
oFin Pitch mm (in.)4.0 (0.16)u
Air CompressorType10PA17CuARefrigerandTypeHFC134a (R134a)u

105 BODY ELECTRICALÐACCESSORIES
ACCESSORIES

DESCRIPTION
The new Camry includes the accessory systems shown in the below.
System
Outline
Power Window System
The power window system includes one±touch auto down and key±off opera-
tion functions. The one±touch auto down function automatically opens the
driver 's door window fully. The key±off operation function makes it possible
to operate the power windows for approximately 45 seconds after the igni-
tion key is turned to the ACC or LOCK position, if the front doors are not
opened.
The basic construction and operation of this system are the same as in the
previous model.
Door Lock Control System
This system has a ªkey±linked lock and unlock functionº and a ªkey±confine
prevention functionº. All doors can be locked and unlocked simultaneously
by a key operation at the front right or left foor. (The key needs to be oper-
ated twice to unlock all the doors at the driver's door.) If the door lock opera-
tion is performed when one of the front doors is open and the ignition key is
inserted in the key cylinder, doors are unlocked automatically to prevent the
ignition key from being left inside the vehicle.
The basic construction and operation are the same as in the previous model.
Wireless Door Lock Remote Con-
trol System
A remote control system in which the lock and unlock functions of all doors
and panic alarm function can be controlled by the signals emitted from a
transmitter is adopted. The transmitter is also provided with a 2±step unlock
function to unlock all the doors by pressing the switch twice.
The basic construction and operation are the same as in the '96 Avalon.
However, certain functions have been changed. For details, see page 107.
Theft Deterrent System
When an attempt is made to forcibly enter the vehicle or open the hood or
trunk lid without a key, or when the battery terminals are removed and re-
connected, this system sounds the horn and flashes the headlights and tail-
lights for about 1 minute to alert the owner. At the same time, it locks all the
doors and electronically disconnects the starter.
The basic operation is the same as in the '96 Avalon.
Power Seat
As in the previous model, the front seats are power assisted by electric mo-
tors so that the seat positions can be adjusted easily by a simple switch op-
eration.
The basic construction and operation are the same as in the previous model.

106BODY ELECTRICALÐACCESSORIES
SystemOutline
SRS Airbag
The SRS (Supplemental Restraint System) airbag is provided for the driver
and front passenger. The SRS airbag has been designed to lessen the shock to
the head and chest of the driver and front passenger in the event of a frontal
impact collision as a supplement to the seat belt.
A 1±sensor type airbag system is used in which the detection of decelera-
tion during a collision as well as control of the airbag system is accom-
plished by the airbag sensor assembly.
The basic construction and operation are the same as in the '96 Avalon.
However, the inflator for front passsenger and airbag sensor assembly have
been changed.
For details, see page 111.
Cruise Control System
Once it has been set at a desired vehicle speed, this system automatically
adjusts the engine throttle position to maintain the vehicle speed at the de-
sired speed without operating the acceleration pedal.
The basic construction and operation are the same as in the previous model.
However, in the new model, a new type acutator has been adopted. Also, the
functions of the cruise control ECU has been changed. For details, see page
116.
Moon Roof
The moon roof is a tilt±up and sliding type the same as in the previous mod-
el. This system includes ªkey±off operationº, which is the same as with the
power window system. The new model offers an additional ªone±touch slide
openº function which enables the moon roof to fully open when the slide
switch is pressed toward the opening side for a few seconds.
Electrical Remote Control Mirror
The electrical remote control mirrors used in the previous model are also
used in the new model. Also, the internal heater to remove water drops from
the mirror surface is provided.
Key Reminder System
When the driver's door is opened with the ignition key in the ACC or LOCK
position, this system sounds a buzzer to warn the driver that the ignition key
has not been removed.
The basic construction and operation are the same as in the previous model.

117 BODY ELECTRICALÐACCESSORIES
2) Auto Cancel Function
When the vehicle is being driven under cruise control, if any of th econditions listed below is present, the vehicle speed
stored in membor is deleted, the control is lifetd, the current to the actuator is disrupted, and th power indicator ligh
is made to flash. The methods to reactivate the cruise control at that time, in accordance with that particular condition
(malfunction category A or B), are classified in the chart below.
Other auto cancel functions are basically the same as those of the previous model.
Condition
Malfunction CategoryHow to reactivate
Continuous current applied to the motor's accel-
eration output.
The motor did not move.
A
Turn off the ignition switch, and
turn it back on. Then turn on the
main switch.
Excessive current flowed to the motor or
magnetic clutch drive transistor.
Open circuit in magnetic clutch.
The vehicle speed signal is not sent for a
predetermined period of time (approx. 140 msec.)
The vehicle speed is equal to the set speed minus
approximately 16 km/h (10 mph) or below.
Short circuit in the control switch.
An open circuit malfunction of the ªdecreaseº
side of the motor (including open circuit in the
motor).
Abnormal vehicle speed signal.
BTurn the main switch back on.
3) Diagnosis Function
a. Wawrning Indication
The cruise control ECU immediately blinks the power indicator light in the combination meter on and off repeatedly
to alert the driver of a system malfunction.
When the power indicator light is flashing, and the cruise control is released by pressing on the main switch, the power
indicator light will be turned off. When the main switch is turned back on, the power indicator light blinking pattern
as shown on the next page outputs according to the malfunction categories A or B. When a category A malfunction
is occuring, the power indicator ligh will flash again. This indicates that the system cannot operate. But if it is a
category B malfunction, the indicator light will remain on indicating that the system is operating.

118BODY ELECTRICALÐACCESSORIES

Power Indicator Light Blinking Pattern
*: ªAº and ªBº Indicate the Malfunction Categories.
b. Diagnostic Trouble Code Indication
The diagnostic trouble codes have been modified in the new model. For details of inspection, diagnostic trouble codes
and repair procedures, see 1997 Camry Repair Manual (Pub. No. RM 503U).

120APPENDIX
MAJOR TECHNICAL SPECIFICATIONS
Item AreaU.S.A..
.Body Type4±Door SedanVehicle GradeCELEXLEModel CodeSXV20L±CEMDKASXV20L±CEPDKASXV20L±A(C)EPNKASXV20L±A(C)EPGKALength mm (in.)4785(188.4)uuu
OverallWidth mm (in.)1780(70.1)uuuOverallHeight* mm (in.)1415 (55.7)uuuWheel Base mm (in.)2670(105.1)uuu
TreadFront mm (in.)1545 (60.8)uuuTreadRear mm (in.)1520 (59.8)uuu
Effective Head RoomFront mm (in.)1105 (43.5)uuuEffective Head RoomRear mm (in.)902 (35.5)uuu
sEffective Leg RoomFront mm (in.)980 (38.6)uuu
ghtsEffective Leg RoomRear mm (in.)940 (37.0)uuu
Weig
h
Shoulder RoomFront mm (in.)1427 (56.2)uuu
icle WShoulder RoomRear mm (in.)1425 (56.1)uuu
VehicOverhangFront mm (in.)970 (38.2)uuu
s & VeOverhangRear mm (in.)1140 (44.9)uuu
sions
&Min.. Running Ground Clearance mm (in.)145 (5.7)uuu
mensioAngle of Approach degrees175uuu
DimeAngle of Departure degrees175uuu
ajor DFront kg (lb)820 (1808)840 (11852)860 (1896)*1, 865 (1970)*2865 (1907)*1, 870 (1918)*2
MajoCurb WeightRear kg (lb)530 (1168)u530 (1168)*1, 535 (1179)*2
530 (1168)*1, 535 (1179)*2
MCurb WeightTotal kg (lb)1350 (2976)1370 (3020)1390 (3064)*1, 1400 (3086)*2
1395 (3075)*1, 1405 (3097)*2
Front kg (lb)980 (2161)uuuGross Vehicle WeightRear kg (lb)870 (1918)uuuGross Vehicle WeightTotal kg (lb)1850 (4079)uuuFuel Tank Capacityl (U.S. gal., Imp. gal.)70 (18.5, 15.4)uuuLuggage Compartment Capacity m3 (cu. ft.)0.399 (14.1)uuuMax. Speed km/h (mph)180 (112)uuuMax. Cruising Speed km/h (mph)ÐÐÐÐ
Acceleration0 to 100 km/h sec.ÐÐÐÐ
ceAcceleration0 to 400 m sec.ÐÐÐÐ
mance1st Gear km/h (mph)52 (32)69 (43)uu
rform
a
Max Permissible Speed2nd Gear km/h (mph)93 (58)125 (78)uuPerfoMax. Permissible Speed3rd Gear km/h (mph)147 (91)ÐÐÐP4the Gear km/h (mph)ÐÐÐÐTurning DiameterWall to Wall m (ft.)11.5 (37.7)uuuTurning Diameter(Outside Front)Curb to Curb m (ft.)11.0 (36.1)uuuEngine Type5S±FEuuuValve Mechanism16±Valve, DOHCuuuBore x Stroke mm (in.)87.0x91.0(3.43x3.58)uuu
eDisplacement cm3 (cu. in..)2164 (132.0)uuu
ngineCompression Ratio9.5 : 1uuuEngCarburetor TypeSFIuuuResearch Octane No. RON91uuuMax. Output (SAE±NET) kW/rpm (HP @ rpm)99/5200(133@5200),97/5200(130@5200)*3uuuMax. Torque (SAE±NET) N.m/rpm (lb±ft @ rpm)199/4400(147@4400,197/4400(145@44003uuu
alBattery Capacity (5HR) Voltage & Amp. hr.12±52, 12±48*4uuu
ginectric a lGenerator Output Watts960uuuEnginElectrStarter Output kW1.4uuuClutch TypeDry, Single PlateÐÐÐTransmission TypeS51A140Euu
uIn First3.5382.810uuIn Second1.9601.549uu
Transmission Gear RatioIn Third1.2501.000uuTransmission Gear RatioIn Fourth0.9450.706uuIn Fifth0.731ÐÐÐIn Reverse3.1532.296uuCounter Gear RatioÐ0.945uuDifferential Gear Ratio (Final)3.944uuu
ssisBrake TypeFrontVentilated Discuuu
ChassiBrake TypeRearL.T. DrumuuuChParking Brake TypeDrumuuuBrake Booster Type and Style in.Tandem 8º + 9ºuTandem 8.5º + 8.5º*1,
8º
+
9º*2uProportioning Valve TypeDual±P Valveuuu
Suspension TypeFrontMacPherson StrutuuuSuspension TypeRearMacPherson Strutuuu
Stabilizer BarFrontSTDuuuStabilizer BarRearSTDuuuSteering Gear TypeRack & PinionuuuSteering Gear Ratio (Overall)17.4 : 1uuuPower Steering TypeIntegral Typeuuu
* : Unladen Vehicle, *1 : Produced by TCM, *2 : Produced by TMM, *3 : California Specification Model, *4
: Without Cold Area Specification Model

122APPENDIX
Item AreaCanadaBody Type4±Door SedanVehicle GradeLECELEModel CodeSXV20L±CEPNKKMCV20L±CEPDKKMCV20L±CEPNKKLength mm (in.)4785 (188.4)uu
OverallWidth mm (in.)1780 (70.1)uuOverallHeight* mm (in.)1415 (55.7)1420 (55.9)uWheel Base mm (in.)2670 (105.1)uu
TreadFront mm (in.)1545 (60.8)uuTreadRear mm (in.)1520 (59.8)uu
Effective Head RoomFront mm (in.)1105 (43.5)uuEffective Head RoomRear mm (in.)902 (35.5)uu
sEffective Leg RoomFront mm (in.)980 (38.6)uu
ghtsEffective Leg RoomRear mm (in.)940 (37.0)uu
Weig
h
Shoulder RoomFront mm (in.)1427 (56.2)uu
icle WShoulder RoomRear mm (in.)1425 (56.1)uu
VehicOverhangFront mm (in.)970 (38.2)uu
s & VeOverhangRear mm (in.)1140 (44.9)uu
sions
&Min.. Running Ground Clearance mm (in.)145 (5.7)148 (5.8)u
mensioAngle of Approach degrees175uu
DimeAngle of Departure degrees175uu
ajor DFront kg (lb)865 (1907)890 (1962)920 (2028)MajoCurb WeightRear kg (lb)535 (1179)540 (1191)uMCurb WeightTotal kg (lb)1400 (3086)1430 (3153)1460 (3219)Front kg (lb)980 (2161)1035 (2282)uGross Vehicle WeightRear kg (lb)870 (1918)875 (1929)uGross Vehicle WeightTotal kg (lb)1850 (4079)1910 (4211)uFuel Tank Capacityl (U.S. gal., Imp. gal.)70 (18.5, 15.4)uuLuggage Compartment Capacity m3 (cu. ft.)0.399 (14.1)uuMax. Speed km/h (mph)180 (112)210 (130)uMax. Cruising Speed km/h (mph)ÐÐu
Acceleration0 to 100 km/h sec.ÐÐÐ
ceAcceleration0 to 400 m sec.ÐÐÐ
mance1st Gear km/h (mph)69 (43)70 (43)u
rform
a
Max Permissible Speed2nd Gear km/h (mph)125 (78)127 (79)uPerfoMax. Permissible Speed3rd Gear km/h (mph)ÐÐÐP4th Gear km/h (mph)ÐÐÐTurning DiameterWall to Wall m (ft.)11.5 (37.7)11.9 (39.0)uTurning Diameter(Outside Front)Curb to Curb m (ft.)11.0 (36.1)11.4 (37.4)uEngine Type5S±FE1MZ±FEuValve Mechanism16±Valve, DOHC24±Valve, DOHCuBore x Stroke mm (in.)87.0x91.0 (3.43x3.58)87.5x83.0 (3.44x3.27)u
eDisplacement cm3 (cu. in..)2164 (132.0)2995 (182.7)u
ngineCompression Ratio9.5 : 110.5:1uEngCarburetor TypeSFIuuResearch Octane No. RON9191 or higheruMax. Output (SAE±NET) kW/rpm (HP @ rpm)99/5200(133@5200)145/5200 (194@5200)uMax. Torque (SAE±NET) N.m/rpm (lb±ft @ rpm)199/4400(147@4400)283/4400 (209@4400)u
alBattery Capacity (5HR) Voltage & Amp. hr.12±52uu
ginectric a lGenerator Output Watts960uuEnginElectrStarter Output kW1.4uuClutch TypeÐÐÐTransmission TypeA140EA541EuIn First2.810uuIn Second1.549uu
Transmission Gear RatioIn Third1.000uuTransmission Gear RatioIn Fourth0.7060.375uIn FifthÐÐÐIn Reverse2.296uuCounter Gear Ratio0.945uuDifferential Gear Ratio (Final)3.9443.933u
ssisBrake TypeFrontVentilated Discuu
ChassiBrake TypeRearL.T. DrumSolid DiscuChParking Brake TypeDrumuuBrake Booster Type and Style in.Tandem 8º + 9ºuuProportioning Valve TypeDual±P Valveuu
Suspension TypeFrontMacPherson StrutuuSuspension TypeRearMacPherson Strutuu
Stabilizer BarFrontSTDuuStabilizer BarRearSTDuuSteering Gear TypeRack & PinionuuSteering Gear Ratio (Overall)17.4 : 1uuPower Steering TypeIntegral Typeuu
* : Unladen Vehicle