battery TOYOTA COROLLA 2011 10.G Workshop Manual

5
When trouble arises
457
5-2. Steps to take in an emergency
■
Avoiding a discharged battery
●Turn off the headlights and the audio system while the engine is turned
off.
● Turn off any unnecessary electrical components when the vehicle is run-
ning at a low speed for an extended period, such as in heavy traffic, etc.
Maintain the engine speed of the second vehicle, and turn
the engine switch to the “ON” position, then start the vehi-
cle's engine.
Once the vehicle’s engine has started, remove the jumper
cables in the exact reverse order in which they were con-
nected.
Once the engine starts, have the vehicle checked at your Toyota
dealer as soon as possible.STEP 3
STEP 4

458 5-2. Steps to take in an emergency
CAUTION
■Avoiding battery fires or explosions
Observe the following precautions to prevent accidentally igniting the flam-
mable gas that may be emitted from the battery.
●Make sure the jumper cable is connected to the correct terminal and that it
is not unintentionally in contact with any part other than the intended termi-
nal.
● Do not allow the jumper cables to come into contact with the “+” and “-” ter-
minals.
● Do not smoke, use matches, cigarette lighters or allow open flame near
the battery.
■ Battery precautions
The battery contains poisonous and corrosive acidic electrolyte, while
related parts contain lead and lead compounds. Observe the following pre-
cautions when handling the battery.
●When working with the battery, always wear safety glasses and take care
not to allow any battery fluids (acid) to come into contact with skin, clothing
or the vehicle body.
● Do not lean over the battery.
● In the event that battery fluid comes into contact with the skin or eyes,
immediately wash the affected area with water and seek medical attention.
Place a wet sponge or cloth over the affected area until medical attention
can be received.
● Always wash your hands after handling the battery support, terminals, and
other battery-related parts.
● Do not allow children near the battery.

476 6-1. Specifications
Electrical system
Manual transaxle
Battery
Open voltage at
68F (20 C): 12.6  12.8 V Fully charged
12.2  12.4 V Half charged
11 . 8
 12.0 V Discharged
(Voltage checked 20 minutes after the
engine and all the lights turned off)
Charging rates 5 A max.
Gear oil capacity (Reference) 1.8 L 4-cylinder (2ZR-FE) engine
2.0 qt. (1.9 L, 1.7 Imp. qt.) 2.4 L 4-cylinder (2AZ-FE) engine
2.6 qt. (2.5 L, 2.2 Imp. qt.)
Gear oil type TOYOTA Genuine Manual Transmission
Gear Oil LV or equivalent
Recommended API grade GL-4
Recommended gear oil
viscositySAE 75W
NOTICE
■
Manual transaxle gear oil
Using manual transaxle gear oil other than “TOYOTA Genuine Manual
Transmission Gear Oil LV” may cause occurrence of idle rattling noise and
bad fuel consumption.

490 6-1. Specifications
Tire related termMeaning
Normal occupant
weight 150 lb. (68 kg) times the number of occupants
specified in the second column of Table 1
* that
follows
Occupant distribution Distribution of occupants in a vehicle as speci-
fied in the third column of Table 1
* below
Production options
weight The combined weight of installed regular pro-
duction options weighing over 5 lb. (2.3 kg) in
excess of the standard items which they
replace, not previously considered in curb
weight or accessory weight, including heavy
duty brakes, ride levelers, roof rack, heavy duty
battery, and special trim
Rim A metal support for a tire or a tire and tube
assembly upon which the tire beads are seated
Rim diameter
(Wheel diameter) Nominal diameter of the bead seat
Rim size designation Rim diameter and width
Rim type designation The industry manufacturer's designation for a
rim by style or code
Rim width Nominal distance between rim flanges
Vehicle capacity
weight (Total load
capacity) The rated cargo and luggage load plus 150 lb.
(68 kg) times the vehicl
e's designated seating
capacity
Vehicle maximum load
on the tire The load on an individual tire that is determined
by distributing to each axle its share of the
maximum loaded vehicle weight, and dividing
by two
Vehicle normal load
on the tire The load on an individual tire that is determined
by distributing to each axle its share of curb
weight, accessory weight, and normal occu-
pant weight (distributed in accordance with
Ta b l e 1
* below), and dividing by two

517
Alphabetical index
Alphabetical index
A/C .................................... 192, 198
ABS........................................... 166
Air conditioning filter .............. 384
Air conditioning systemAir conditioning filter ............. 384
Automatic air conditioning system................................ 192
Manual air conditioning system................................ 198
Airbags
Airbag operating conditions .... 88
Airbag precautions for your child...................................... 92
Airbag warning light .............. 425
Curtain shield airbag operating conditions ............. 89
Curtain shield airbag precautions .......................... 92
Front passenger occupant
classification system ............ 97
General airbag precautions .... 92
Locations of airbags ............... 85
Modification and disposal of airbags ................................. 96
Proper driving posture ...... 83, 92
Side airbag operating
conditions ............................. 89
Side airbag precautions.......... 92
SRS airbags ........................... 85
Antenna .................................... 214
Anti-lock brake system ........... 166
Ashtray ..................................... 324
Audio input .............................. 253 Audio system
Antenna .................................214
Audio input ............................253
AUX port................................253
CD player/changer ................217
iPod .......................................233
MP3/WMA disc......................225
Optimal use ...........................248
Portable music player............253
Radio .....................................210
Steering wheel audio switch ..................................255
Type ......................................206
USB memory .........................240
Automatic air conditioning system ....................................192
Automatic transmission Automatic transmission .........137
If the shift lever cannot be shifted from P......................450
S mode ..................................140
AUX port ...................................253
Auxiliary boxes ........................318
Back-up lights
Replacing light bulbs .............400
Wattage .................................479
Battery Checking ...............................366
If the vehicle has a discharged battery ..............454
Preparing and checking before winter .......................174
Bluetooth
® audio .....................259
Bluetooth® phone ....................275
Bottle holder .............................320
Brake Fluid ......................................363
Parking brake ........................145
Brake assist ..............................166
Break-in tips .............................120
A
B

518 Alphabetical index
CareExterior .................................. 336
Interior ................................... 338
Seat belts .............................. 339
Cargo capacity ......................... 170
CD changer ............................... 217
CD player .................................. 217
Chains ....................................... 174
Child restraint system
Booster seats, definition ........ 102
Booster seats, installation ..... 106
Convertible seats, definition ............................. 102
Convertible seats,
installation ........................... 106
Front passenger occupant classification system .............97
Infant seats, definition ........... 102
Infant seats, installation......... 106
Installing CRS with LATCH anchors ............................... 107
Installing CRS with seat belts ............................ 109
Installing CRS with top tether straps ........................ 113
Child safety
Airbag precautions ..................92
Battery precautions ....... 367, 458
Child restraint system............ 102
Child-protectors .......................40
How your child should wear the seat belt ..........................60
Installing child restraints ........ 106
Moon roof precautions ............74
Power window lock switch.......69
Power window precautions .....70
Removed key battery precautions ......................... 389
Seat belt comfort guide ........... 57
Seat belt extender precautions ...........................63 Seat belt precautions .............. 61
Seat heater precautions ........ 327
Trunk precautions ................... 47
Child-protectors ......................... 40
Cleaning Exterior.................................. 336
Interior ................................... 338
Seat belts .............................. 339
Clock ......................................... 323
Compass................................... 330
Condenser ................................ 363
Console box ............................. 314
Cooling system Engine overheating ............... 460
Cruise control .......................... 162
Cup holder ................................ 316
Curtain shield airbags ............... 85
Customizable features ............ 495
Daytime running light system .................................... 158
Defogger
Rear window ......................... 205
Side mirror ............................ 205
Dimension ................................ 468
Dinghy towing ................... 187,188
Display Trip information ..................... 154
Do-it-yourself maintenance .... 347
Doors Door lock ..................... 23, 34, 39
Door windows ......................... 69
Side mirrors............................. 67
Driver's seat belt reminder
light ......................................... 426
Driving Break-in tips .......................... 120
Correct posture ....................... 83
Procedures............................ 118
Winter driving tips ................. 174C
D

519
Alphabetical index
Electric power steering........... 166
Electronic key
If your electronic key battery is discharged .......... 452
Emergency flashers
Switch ................................... 414
Emergency, in case of If a warning light turns on ..... 424
If the electronic key does
not operate properly ........... 452
If the engine will not start...... 448
If the shift lever cannot be
shifted from P ..................... 450
If the vehicle has a
discharged battery ............. 454
If the warning buzzer sounds ............................... 424
If you have a flat tire ............ 436
If you lose your keys............. 451
If you think something is wrong ................................. 420
If your vehicle becomes stuck................................... 463
If your vehicle has to be stopped in an emergency... 465
If your vehicle needs to be
towed ................................. 415
If your vehicle overheats ...... 460
Engine
Compartment........................ 356
Engine switch ............... 129, 133
Hood ..................................... 351
How to start the engine ........................ 129, 133
Identification number ............ 468
If the engine will not start...... 448
Ignition switch ............... 129, 133
Overheating .......................... 460
Engine coolant Capacity ............................... 475
Checking .............................. 362
Preparing and checking before winter ...................... 174 Engine coolan
t temperature
gauge ......................................147
Engine immobilizer system.......79
Engine oil Capacity ................................473
Checking ...............................358
Preparing and checking before winter .......................174
Engine oil maintenance data .........................................360
Engine switch light ..................309
EPS ............................................166
Event data recorder .................422
Floor mat...................................329
Fluid
Brake .....................................363
Washer ..................................368
Fog lights
Replacing light bulbs .............400
Switch....................................159
Wattage .................................479
Front passenger occupant classification system ..............97
Front passenger's seat belt
reminder light.........................426
Front seats Adjustment ..............................49
Front side marker lights Replacing light bulbs .............400
Switch....................................157
Wattage .................................479
Front turn signal lights Replacing light bulbs .............400
Switch....................................144
Wattage .................................479E
F

520 Alphabetical index
FuelCapacity ................................ 472
Fuel gauge ............................ 147
Fuel pump shut off system .... 421
Gas station information ......... 528
Information ............................ 480
Refueling .................................75
Type ...................................... 472
Fuel door.....................................75
Fuel filler door ............................75
Fuel pump shut off system ..... 421
Fuses......................................... 390
Gas station information........... 528
Gauges ...................................... 147
Glove box.................................. 314
Hands-free phone system (for cellular phone) ................275
Hazard lights Switch.................................... 414
Head restraints Adjusting ................................54
Headlights
Replacing light bulbs ............. 400
Switch.................................... 157
Wattage ................................. 479
Heaters Seat heater............................ 327
Side mirror............................. 205
Hood .......................................... 351
Horn........................................... 146 I/M test ...................................... 346
Identification number
Engine ................................... 468
Vehicle .................................. 468
Ignition switch.................. 129, 133
Illuminated entry system......... 310
Indicator lights ......................... 150
Initialization
Items to initialize ................... 499
Inside rear view mirror .............. 65
Interior lights Interior lights ......................... 309
Switch ................................... 311
Wattage................................. 479
Jack Positioning a floor jack .......... 353
Vehicle-equipped jack ........... 436
Jack handle .............................. 436
Keyless entry ............................. 34
Keys
Electronic key.......................... 20
Engine switch ................ 129, 133
If you lose your keys ............. 451
If your electronic key battery is discharged .......... 452
Ignition switch ............... 129, 133
Key number............................. 20
Keyless entry .......................... 34
Keys ........................................ 20
Mechanical key ....................... 20
Wireless remote control key.... 34
G
H
I
J
K

522 Alphabetical index
Radiator .................................... 363
Radio ......................................... 210
Rear seatsFolding down ...........................52
Rear side marker lights
Replacing light bulb ............... 400
Switch.................................... 157
Wattage ................................. 479
Rear turn signal lights Replacing light bulbs ............. 400
Switch.................................... 144
Wattage ................................. 479
Rear view mirror Compass ............................... 330
Rear window defogger ............ 205
Replacing Fuses .................................... 390
Key battery ............................ 386
Light bulbs ............................. 400
Tires ...................................... 436
Reporting safety defects for U.S.A. owners ........................ 502 Seat belts
Adjusting the seat belt............. 56
Automatic Locking
Retractor ............................... 59
Child restraint system
installation........................... 106
Cleaning and maintaining the seat belts ...................... 339
Emergency Locking Retractor ............................... 59
How to wear your seat belt ..... 56
How your child should wear
the seat belt .......................... 60
Pregnant women, proper seat
belt use ................................. 59
Reminder light ....................... 426
Seat belt extenders ................. 60
Seat belt pretensioners ........... 58
Seat heaters ............................. 327
Seating capacity ...................... 173
Seats Adjustment .............................. 49
Adjustment precautions .......... 51
Child seats/child restraint system installation .............. 106
Cleaning ................................ 338
Head restraint ......................... 54
Properly sitting in the seat....... 83
Rear seat folding down ........... 52
Seat heaters.......................... 327
Service reminder indicators .............................. 150
Shift lever Automatic transmission ......... 137
If the shift lever cannot be shifted from P ................ 450
Manual transmission ............. 143
Shift lock system ..................... 450
Side airbags ............................... 85
Side marker lights Replacing light bulbs ............. 400
Switch ................................... 157
Wattage................................. 479RS

524 Alphabetical index
Trunk lightWattage ................................. 479
Turn signal lights Replacing light bulbs ............. 400
Switch.................................... 144
Wattage ................................. 479
Valet key .....................................20
Vanity mirrors........................... 322
Vehicle identification number ................................... 468
Vehicle stability control........... 166
VSC............................................ 166
Warning buzzers Brake system ........................ 424
Downshifting.......................... 141
Seat belt reminder ................. 426
Warning lights Anti-lock brake system .......... 425
Brake assist system .............. 425
Brake system ........................ 424
Charging system .... ............... 424
Electric power steering
system ................................ 425
Engine oil maintenance ......... 426
Engine oil pressure ............... 424
Low fuel level ........................ 426
Low tire pressure warning light ..................................... 426
Malfunction indicator lamp .... 425
Open door ............................. 426
Pretensioners ........................ 425
Seat belt reminder light ......... 426
Smart key system... ............... 434
SRS airbags .......................... 425
Tire pressure warning light .... 426
Washer fluid .......................... 426 Washer
Checking ............................... 368
Preparing and checking
before winter ....................... 174
Switch ................................... 160
Washing and waxing ............... 336
Weight Cargo capacity ...................... 170
Load limits ............................. 173
Weight ................................... 468
Wheels ...................................... 382
Window glasses ........................ 69
Window lock switch................... 69
Windows
Power windows ....................... 69
Rear window defogger .......... 205
Washer.................................. 160
Windshield wipers ................... 160
Wireless remote control key Replacing the battery ............ 386
Wireless remote control .......... 34
WMA disc.................................. 225
V
W