transmission oil TOYOTA FJ CRUISER 2010 1.G Owners Manual

183 2-5. Driving information
2
When driving
NOTICE
■To prevent the water damage
●Take all necessary safety measures to ensure that water damage to the
engine or other components does not occur.
●Water entering the engine air intake will cause severe engine damage.
●Water entering the automatic transmission will cause deterioration in shift
quality, locking up of your transmission accompanied by vibration, and ulti-
mately damage.
●Water can wash the grease from wheel bearings, causing rusting and pre-
mature failure, and may also enter the differentials, transmission and
transfer case, reducing the gear oil’s lubricating qualities.
■When you drive through water
If driving through water, such as when crossing shallow streams, first check
the depth of the water and the bottom of the river bed for firmness. Drive
slowly and avoid deep water.
■Inspection after off-road driving
●Sand and mud that has accumulated in brake drums and around brake
discs may affect braking efficiency and may damage brake system compo-
nents.
●Always perform a maintenance inspection after each day of off-road driv-
ing that has taken you through rough terrain, sand, mud, or water. For
scheduled maintenance information, refer to the “Scheduled Maintenance
Guide” or “Owner’s Manual Supplement”.

5
When trouble arises
355 5-2. Steps to take in an emergency
Stop the vehicle immediately.
The following warnings indicate the possibility of damage to the vehi-
cle that may lead to an accident. Immediately stop the vehicle in a
safe place and contact your Toyota dealer.
*: The light may come on when the oil level is extremely low. It is not designed
to indicate low oil level, and the oil level must be checked using the engine
oil level dipstick.
Have the vehicle inspected immediately.
Failing to investigate the cause of the following warnings may lead to
the system operating abnormally and possibly cause an accident.
Have the vehicle inspected by your Toyota dealer immediately.
Warning lightWarning light/Details
Charging system warning light
Indicates a malfunction in the vehicle’s charging sys-
tem.
Low engine oil pressure warning light
Indicates that the engine oil pressure is too low*.
Warning lightWarning light/Details
Malfunction indicator lamp
Indicates a malfunction in:
• The electronic engine control system;
• The electronic throttle control system;
• The electronic automatic transmission control sys-
tem; or
• Emission control system.
SRS warning light
Indicates a malfunction in:
• The SRS airbag system;
• The front passenger occupant classification system;
or
• The seat belt pretensioner system.

392 6-1. Specifications
How to read oil container label:
The ILSAC (International Lubricant Standardization and Approval
Committee) Certification Mark is added to some oil containers to help
you select the oil you should use.
Cooling system
Ignition system
CapacityVehicles with an automatic transmission
10.4 qt. (9.8 L, 8.6 Imp.qt.)
Vehicles with a manual transmission
9.9 qt. (9.4 L, 8.3 Imp.qt.)
Coolant typeUse either of the following.
• “Toyota Super Long Life Coolant”
• Similar high-quality ethylene glycol-based
non-silicate, non-amine, non-nitrite, and
non-borate coolant with long-life hybrid
organic acid technology
Do not use plain water alone.
Spark plug
Make DENSO SK20HR11
Gap 0.043 in. (1.1 mm)

393 6-1. Specifications
6
Vehicle specifications
Electrical system
Differential
*: “Toyota Genuine Differential Gear Oil” is filled in your Toyota vehicle at
factory fill. Use Toyota approved “Toyota Genuine Differential Gear Oil” or
an equivalent of matching quality to satisfy the above specification. Please
contact your Toyota dealer for further details.
NOTICE
■Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust gap when tuning engine.
Battery
Open voltage at
68F (20C):12.6  12.8 V Fully charged
12.2  12.4 V Half charged
11 . 8  12.0 V Discharged
(Voltage checked 20 minutes after
the key is removed with all the lights
turned off)
Charging rates 5 A max.
Oil capacity
Front
(4WD models)Vehicles with a manual transmission
1.48 qt. (1.40 L, 1.23 Imp.qt.)
Vehicles with an automatic transmission
1.64 qt. (1.55 L, 1.36 Imp.qt.)
RearVehicles with a rear differential lock
2.59 qt. (2.45 L, 2.16 Imp.qt.)
Vehicles without a rear differential lock
2.64 qt. (2.50 L, 2.20 Imp.qt.)
Oil type and
viscosity
*
Front
(4WD models)Toyota Genuine Differential Gear Oil LT
75W-85 GL-5 or equivalent
RearToyota Genuine Differential Gear Oil LT
75W-85 GL-5 or equivalent

394 6-1. Specifications
Automatic transmission
*: The fluid capacity is the quantity of reference. If replacement is necessary,
contact your Toyota dealer.
Manual transmission
Clutch
Fluid capacity *11.3 qt. (10.7 L, 9.4 Imp.qt.)
Fluid type Toyota Genuine ATF WS
NOTICE
■Automatic transmission fluid type
Using automatic transmission fluid other than “Toyota Genuine ATF WS”
may cause deterioration in shift quality, locking up of your transmission
accompanied by vibration, and ultimately damage the automatic
transmission of your vehicle.
Gear oil capacity (Reference) 1.9 qt. (1.8 L, 1.6 Imp.qt.)
Gear oil type Gear oil API GL-4 or GL-5
Recommended gear oil viscosity SAE 75W-90
Clutch free play 0.2  0.6 in. (5 15 mm)
Fluid type FMVSS No. 116 DOT 3 or SAE J1703

395 6-1. Specifications
6
Vehicle specifications
Transfer (4WD models)
*: “Toyota Genuine Transfer Gear oil LF” is filled in your Toyota vehicle at
factory fill. Use Toyota approved “Toyota Genuine Transfer Gear oil LF” or
an equivalent of matching quality to satisfy the above specification. Please
contact your Toyota dealer for further details.
Brakes
*1: Minimum pedal clearance when depressed with a force of 110 lbf (490 N,
50 kgf) with the engine running.
*2: Parking brake lever travel when pulled with a force of 44.1 lbf (196 N, 20.0
kgf).
Oil capacityVehicles with an automatic transmission
1.1 qt. (1.0 L, 0.9 Imp.qt.)
Vehicles with a manual transmission
1.5 qt. (1.4 L, 1.2 Imp.qt.)
Oil type*Toyota Genuine Transfer Gear oil LF or
equivalent
Recommended oil viscosity SAE 75W
Pedal clearance *12.1 in. (54 mm) Min.
Pedal free play 0.04  0.24 in. (1  6 mm)
Brake pad wear limit 0.04 in. (1.0 mm)
Parking brake lining wear limit 0.04 in. (1.0 mm)
Parking brake lever travel *25 — 7 clicks
Fluid type FMVSS No. 116 DOT 3 or SAE J1703

406 6-1. Specifications
Warning: The temperature grades for this tire are established for a
tire that is properly inflated and not overloaded.
Excessive speed, underinflation, or excessive loading, either
separately or in combination, can cause heat buildup and possible
tire failure.
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation
pressure
Tire pressure when the vehicle has been
parked for three hours or more, or has not
been driven more than 1 mile or 1.5 km under
that condition
Maximum inflation
pressureThe maximum cold inflated pressure to which a
tire may be inflated, shown on the sidewall of
the tire
Recommended
inflation pressureCold tire inflation pressure recommended by a
manufacturer
Accessory weight
The combined weight (in excess of those
standard items which may be replaced) of
transmission, power steering, power brakes,
power windows, power seats, radio and heater,
to the extent that these items are available as
factory-installed equipment (whether installed
or not)
Curb weight
The weight of a motor vehicle with standard
equipment, including the maximum capacity of
fuel, oil and coolant, and if so equipped, air
conditioning and additional weight optional
engine
Maximum loaded
vehicle weight
The sum of:
(a) Curb weight
(b) Accessory weight
(c) Vehicle capacity weight
(d) Production options weight

426 Alphabetical index
Turn signal lights switch ........ 133
Wattage ................................. 397
Limited slip differential............ 168
Load capacity ........... 184, 187, 388
Lock steering column ................63
Luggage storage box............... 267
Luggage compartment
features................................... 268
Maintenance
Do-it-yourself maintenance ... 289
General maintenance ............ 285
Maintenance data.................. 388
Maintenance requirements.... 283
Vehicle exterior ..................... 278
Vehicle interior ...................... 280
Malfunction indicator lamp ..... 355
Manual air conditioning
system .................................... 204
Manual transmission ............... 131
Meter
Accessory meter ................... 143
Instrument panel light
control ................................. 138
Meters ................................... 137
Mirrors
Inside rear view mirror.............64
Side mirrors .............................68
Vanity mirrors ........................ 255
MP3 disc ................................... 227
Noise from under vehicle ..........22
Odometer .................................. 137
Off-road precautions
Driving ................................... 181
Vehicle .................................. 179
Oil
Engine oil .............................. 295
Warning light ..................355,357
Opener
Hood...................................... 293Outside rear view mirror
illumination lights
Replacing light bulbs ............. 341
Switch ................................... 145
Wattage................................. 397
Outside rear view mirrors
Adjusting and folding............... 68
Outside temperature
display .................................... 257
Overheating, Engine ................ 382
Parking assist .......................... 153
Parking brake ........................... 134
Parking lights
Replacing light bulbs ............. 338
Switch ................................... 145
Wattage................................. 397
Personal lights
Switch ................................... 246
Wattage................................. 397
Power outlet ..................... 258, 259
Power steering
Fluid ...................................... 302
Power windows .......................... 71
Radiator ............................ 294, 300
Radio ......................................... 214
Rear seat
Folding down........................... 49
Removing rear seat bottom
cushions ............................... 50
Rear side marker lights
Replacing light bulbs ............. 339
Switch ................................... 145
Wattage................................. 397
Rear turn signal lights
Lever ..................................... 133
Replacing light bulbs ............. 339
Switch ................................... 133
Wattage................................. 397
Rear view monitor system ...... 158
Rear window............................... 43
M
N
O
P
R

429 Alphabetical index
Vanity mirrors .......................... 255
Vehicle identification
number................................... 389
Vehicle stability control .......... 174
Voltmeter.................................. 137
VSC ........................................... 174
Warning buzzers
Key reminder ........................ 359
Seat belt reminder ................ 357
Warning lights
ABS ...................................... 355
Airbag system....................... 355
Anti-lock brake system ......... 355
Automatic transmission fluid
temperature........................ 355
Brake system........................ 354
Charging system .................. 355
Driver’s seat belt................... 357
Electronic engine control
system................................ 355
Engine oil replacement ......... 357
Front passenger occupant
classification system .......... 355
Front passenger’s seat belt .. 357
Low brake fluid ..................... 354
Low engine oil pressure ....... 355
Low fuel level........................ 357
Low tire inflation pressure .... 357
Low washer fluid................... 358
Malfunction indicator lamp.... 355
Open door ............................ 357
Seat belt ............................... 357
Seat belt pretensioner
system................................ 355
SRS ...................................... 355
SRS airbag system............... 355
Tire pressure ........................ 357
Tire pressure warning
system................................ 357
Unengaged “Park” ................ 355Washer
Checking ...............................306
Preparing and checking
before winter .......................188
Switch............................147, 149
Washing and waxing ...............278
Weight
Cargo capacity ......................184
Load limits .............................187
Weight ...................................388
Wheels ......................................317
Window glasses ..................43, 71
Window lock switch ...................71
Windows
Power windows .......................71
Rear window defogger ..........210
Washer ..........................147, 149
Windshield wipers ...........147, 149
Wireless remote control key
Replacing the battery ............322
Wireless remote control ..........30
Winter driving tips ...................188
WMA disc ..................................227V
W

432 What to do if...
■Warning lights
P. 354 P. 356
P. 355 P. 356
P. 355 P. 357
P. 355 P. 357
P. 358
or
P. 3 5 6P. 357
P. 3 5 8P. 357
P. 3 5 5P. 358
*: Slip indicator comes on.P. 3 5 6
Brake system warning
light
Charging system warning
light
Low engine oil pressure
warning light
Malfunction indicator
lamp
ABS warning lightLow fuel level warning
light
Driver’s seat belt reminder
light
Maintenance required
reminder light
SRS warning lightLow washer fluid
warning light
Unengaged Park warning
light
Slip indicator*
Open door warning light
Front passen-
ger’s seat belt
Tire pressure warning
light
Automatic transmission
fluid temperature
warning light