tire size TOYOTA HILUX 2013 Owners Manual (in English)

226 2-4. Using other driving systems
HILUX_OM_OM0K189E_(EE)
CAUTION
Replacing tires
Make sure that all tires are of the specified size, brand, tread pattern and
total load capacity. In addition, make sure that the tires are inflated to the
recommended tire inflation pressure level.
The ABS and VSC systems will not function correctly if different tires are
installed on the vehicle.
Contact any authorized Toyota dealer or repairer, or another duly qualified
and equipped professional for further information when replacing tires or
wheels.
Handling of tires and the suspension
Using tires with any kind of problem or modifying the suspension will affect
the driving assist systems, and may cause the system to malfunction.

235
2-5. Driving information
2
When driving
HILUX_OM_OM0K189E_(EE)
Winter driving tips
Carry out the necessary preparations and inspections before driving
the vehicle in winter. Always drive the vehicle in a manner appropri-
ate to the prevailing weather conditions.
Pre-winter preparations
Use fluids that are appropriate to the prevailing outside tem-
peratures.
• Engine oil
• Engine coolant
• Washer fluid
Have a service technician inspect the level and specific grav-
ity of battery electrolyte.
Have the vehicle fitted with four snow tires or purchase a set
of tire chains for the rear tires.
Ensure that all tires are the same size and brand, and that chains
match the size of the tires.

237 2-5. Driving information
2
When driving
HILUX_OM_OM0K189E_(EE)
Selecting tire chains
Use the correct tire chain size when mounting the snow chains.
Chain size is regulated for each tire size.
Regulations on the use of tire chains
Regulations regarding the use of tire chains vary depending on loca-
tion and type of road. Always check local regulations before installing
chains.
Tire chain installation
Observe the following precautions when installing and removing chains:
Install and remove tire chains in a safe location.
Install tire chains on the rear tires. Do not install tire chains on the front
tires.
Install tire chains on rear tires as tightly as possible. Retighten chains
after driving 0.5 - 1.0 km (1/4 - 1/2 mile).
Install tire chains following the instructions provided with the tire chains.

238 2-5. Driving information
HILUX_OM_OM0K189E_(EE)
CAUTION
Driving with snow tires
Observe the following precautions to reduce the risk of accidents.
Failing to do so may result in a loss of vehicle control and cause death or
serious injury.
Use tires of the specified size.
Maintain the recommended level of air pressure.
Do not drive at speeds in excess of the speed limit or the speed limit spec-
ified for the snow tires being used.
Use snow tires on all, not just some wheels.
Driving with tire chains
Observe the following precautions to reduce the risk of accidents.
Failing to do so may result in the vehicle being unable to be driven safely,
and may cause death or serious injury.
Do not drive in excess of the speed limit specified for the tire chains being
used, or 50 km/h (30 mph), whichever is lower.
Avoid driving on bumpy road surfaces or over potholes.
Avoid sudden turns and braking, as use of chains may adversely affect
vehicle handling.
Slow down sufficiently before entering a curve to ensure that vehicle con-
trol is maintained.

504 4-3. Do-it-yourself maintenance
HILUX_OM_OM0K189E_(EE)
When to replace your vehicle’s tires
Tires should be replaced if:
You have tire damage such as cuts, splits, cracks deep enough to
expose the fabric, and bulges indicating internal damage
A tire goes flat repeatedly or cannot be properly repaired due to the size
or location of a cut or other damage
If you are not sure, consult with any authorized Toyota dealer or repairer, or
another duly qualified and equipped professional.
Vehicles with spare tire of the same wheel type as the installed
tires
Rotate the tires in the order
shown.
To equalize tire wear and help
extend tire life, Toyota recom-
mends that tire rotation is car-
ried out approximately every
10000 km (6000 miles).
Front

505 4-3. Do-it-yourself maintenance
4
Maintenance and care
HILUX_OM_OM0K189E_(EE)
Tire life
Any tire over 6 years old must be checked by a qualified technician even if it
has seldom or never been used or damage is not obvious.
If the tread on snow tires wears down below 4 mm (0.16 in.)
The effectiveness of the tires as snow tires is lost.
CAUTION
When inspecting or replacing tires
Observe the following precautions to prevent accidents.
Failure to do so may cause damage to parts of the drive train as well as dan-
gerous handling characteristics, which may lead to an accident resulting in
death or serious injury.
Do not mix tires of different makes, models or tread patterns.
Also, do not mix tires of remarkably different treadwear.
Do not use tire sizes other than those recommended by Toyota.
Do not mix differently constructed tires (radial, bias-belted or bias-ply
tires).
Do not mix summer, all season and snow tires.
Do not use tires that have been used on another vehicle.
Do not use tires if you do not know how they were used previously.

509
4-3. Do-it-yourself maintenance
4
Maintenance and care
HILUX_OM_OM0K189E_(EE)
Wheels
If a wheel is bent, cracked or heavily corroded, it should be replaced.
Otherwise, the tire may separate from the wheel or cause a loss of
handling control.
Wheel selection
When replacing wheels, care should be taken to ensure that
they are equivalent to those removed in load capacity, diameter,
rim width and inset
*.
Replacement wheels are available at any authorized Toyota
dealer or repairer, or another duly qualified and equipped profes-
sional.
*: Conventionally referred to as “offset”.
Toyota does not recommend using the following:
Wheels of different sizes or types
Used wheels
Bent wheels that have been straightened
Aluminum wheel precautions
Use only Toyota wheel nuts and wrenches designed for use
with your aluminum wheels.
When rotating, repairing or changing your tires, check that the
wheel nuts are still tight after driving 1600 km (1000 miles).
Be careful not to damage the aluminum wheels when using
tire chains.
Use only Toyota genuine balance weights or equivalent and a
plastic or rubber hammer when balancing your wheels.

510 4-3. Do-it-yourself maintenance
HILUX_OM_OM0K189E_(EE)
CAUTION
When replacing wheels
Do not use wheels that are a different size from those recommended in the
Owner’s Manual, as this may result in a loss of handling control.
Never use an inner tube in a leaking wheel which is designed for a tube-
less tire. Doing so may result in an accident, causing death or serious
injury.
When installing the wheel nuts
Never use oil or grease on the wheel bolts or wheel nuts.
Oil and grease may cause the wheel nuts to be excessively tightened,
leading to bolt or disc wheel damage. In addition, the oil or grease can
cause the wheel nuts to loosen and the wheel may fall off, causing an acci-
dent and resulting in death or serious injury. Remove any oil or grease
from the wheel bolts or wheel nuts.
Be sure to install the wheel nuts with
the tapered end facing inward. Install-
ing the nuts with the tapered end facing
outward can cause wheel to break and
eventually cause a wheel to come off
while driving, which could lead to an
accident resulting in death or serious
injury.
Tapered
portion

620 6-1. Specifications
HILUX_OM_OM0K189E_(EE)
Tires and wheels
15 inch tires
16 inch tires
Tire size 255/70R15C 112/110S
Tire inflation pressure
(Recommended cold tire
inflation pressure)Front wheel
kPa (kgf/cm2
or bar, psi)Rear wheel
(unloaded)
kPa (kgf/cm2
or bar, psi)Rear wheel
(loaded)
kPa (kgf/cm
2
or bar, psi)
Single-cab models 200 (2.0, 29) 200 (2.0, 29) 250 (2.5, 36)
Extra-cab and
double-cab models200 (2.0, 29) 200 (2.0, 29)250 (2.5, 36)*1
250 (2.5, 36)*2, 3
310 (3.1, 45)*2, 4
Wheel size 15  7JJ, 15  7J
Wheel nut torque 105 N•m (10.7 kgf•m, 77 ft•lbf)
Tire size 205R16C 8PR 110/108S
Tire inflation pressure
(Recommended cold tire
inflation pressure)Front wheel
kPa (kgf/cm2
or bar, psi)Rear wheel
(unloaded)
kPa (kgf/cm2
or bar, psi)Rear wheel
(loaded)
kPa (kgf/cm
2
or bar, psi)
Single-cab models 240 (2.4, 35) 240 (2.4, 35) 320 (3.2, 46)
Extra-cab and
double-cab models240 (2.4, 35) 240 (2.4, 35)320 (3.2, 46)*1
320 (3.2, 46)*2, 3
400 (4.0, 58)*2, 4
Wheel size 16  6J
Wheel nut torque 105 N•m (10.7 kgf•m, 77 ft•lbf)

621 6-1. Specifications
6
Vehicle specifications
HILUX_OM_OM0K189E_(EE)17 inch tires
*1: Left-hand drive vehicles
*2: Right-hand drive vehicles
*3: Half loaded
*4: Full loaded
Tire size265/65R17 112S
Tire inflation pressure
(Recommended cold tire
inflation pressure)DLX grade models with 1KD-FTV engine
230 kPa (2.3 kgf/cm
2 or bar, 33 psi)
SR grade models with 2KD-FTV engine
Single-cab models
230 kPa (2.3 kgf/cm
2 or bar, 33 psi)
Double-cab models
200 kPa (2.0 kgf/cm
2 or bar, 29 psi)
Other models
200 kPa (2.0 kgf/cm
2 or bar, 29 psi)
Wheel size 17  7 1/2J
Wheel nut torque 105 N•m (10.7 kgf•m, 77 ft•lbf)