air filter TOYOTA LAND CRUISER 1998 Factory Repair Manual

DI-508- DIAGNOSTICSABS & VEHICLE STABILITY CONTROL (VSC) &
BRAKE ASSIST (BA) SYSTEM
701 Author
: Date
:
2004 LAND CRUISER (RM1071U)WHEEL SPD FL
Front Left wheel speed/
Min.: 0km/h, Max.: 326.4 km/hActual wheel speedSpeed indicated on speedometer
WHEEL SPD RRRear Right wheel speed/
Min.: 0km/h, Max.: 326.4 km/hActual wheel speedSpeed indicated on speedometer
WHEEL SPD RLRear Left wheel speed/
Min.: 0km/h, Max.: 326.4 km/hActual wheel speedSpeed indicated on speedometer
DECELERAT SENSG sensor (GL1 filter)/
Min.: -1.869 G, Max.: 1.869Approximately 0 ± 0.13 G at still
conditionReading changes when vehicle is
bounced
DECELERAT SENS2G sensor (GL2 filter)/
Min.: -1.869 G, Max.: 1.869Approximately 0 ± 0.13 G at still
conditionReading changes when vehicle is
bounced
IG VOLTAGEECU IG power voltage/
UNDER or NORMAL or OVER--
SFRRSFRR/ ON or OFF--
SFRHSFRH/ ON or OFF--
SFLRSFLR/ ON or OFF--
SFLHSFLH/ ON or OFF--
SRRR (SRR)SRRR (SRR)/ ON or OFF--
SRRH (SRH)SRRH (SRH)/ ON or OFF--
SRLRSRLR/ ON or OFF--
SRLHSRLH/ ON or OFF--
SRCF (SA1)SRCF (SA1)/ ON or OFF--
SRCR (SA2)SRCR (SA2)/ ON or OFF--
SRMF (SMCF, SA3)SRMF (SMCF, SA3)/ ON or OFF--
SRMR (SMCR, STR)SRMR (SMCR, STR)/ ON or OFF--
THROTTLEThrottle position sensor/
Min.: 0 deg, Max.: 125 deg--
ENGINE SPDEngine Speed/
Min.: 0 rpm, Max.: 6000 rpmActual engine speed-
YAW R AT EYaw rate sensor/
Min.: -128 deg/s, Max.: 128 deg/s--
YAW ZERO VALUEMemorized zero value/
Min.: -128 deg/s, Max.: 128 deg/s--
STEERING ANG
Steering sensor/
Min.: -1682 deg,
Max.: 1877 deg
-1682 to 1877 deg
Turning the steering wheel
changes the value
Left : Becomes grater
Right : Becomes smaller
MAS CYL PRS 1Master cylinder pressure 1/
Min.: 0 V, Max.: 5 VWhen brake pedal is released:
0.3 - 0.9 VReading increases when brake
pedal is depressed
AIR BLD SUPPORTAir bleed support/
NOT SUP or SUPPORTw/ BA: Supported
w/ VSC: Not supported-
TEST MODETest mode operation/
NORMAL or TESTNORMAL: Normal mode
TEST: During test mode-
#CODESNumber of Trouble Code/
Min.: 0, Max.: 255MIn.: 0, Max.: 45-

A21040
Reference (Bank 1 Sensor 1 System Drawing)
From
BatteryEFI or ECD
No. 1 FuseEFI or ECD
RelayEFI or ECD
No. 2 FuseHeater Oxygen
Sensor
Heater
SensorHT1A
OX1A
E2
MRELECM
- DIAGNOSTICSENGINE
DI-1 15
308 Author
: Date
:
2004 LAND CRUISER (RM1071U)
NG Repair or replace harness or connector.
OK
6 Check air induction system (See page SF-1).
CHECK:
Check the air induction system for vacuum leaks.
NG Repair or replace
air induction system.
OK
7 Check fuel pressure (See page SF-7).
CHECK:
Check the fuel pressure (high or low pressure).
NG Check and repair fuel pump, pressure regulator,
fuel pipe line and filter (See page SF-1).
OK

A21040
Reference (Bank 1 Sensor 1 System Drawing)
From
BatteryEFI or ECD
No. 1 FuseEFI or ECD
RelayEFI or ECD
No. 2 FuseHeater Oxygen
Sensor
Heater
SensorHT1A
OX1A
E2
MRELECM
- DIAGNOSTICSENGINE
DI-127
320 Author
: Date
:
2004 LAND CRUISER (RM1071U)
NG Repair or replace harness or connector.
OK
6 Check air induction system (See page SF-1).
CHECK:
Check the air induction system for vacuum leaks.
NG Repair or replace air induction system.
OK
7 Check fuel pressure (See page SF-7).
CHECK:
Check the fuel pressure (high or low pressure).
NG Check and repair fuel pump, pressure regulator,
fuel pipe line and filter (See page SF-1).
OK

DI-136
- DIAGNOSTICSENGINE
329 Author
: Date
:
2004 LAND CRUISER (RM1071U)
7 Check whether misfire is occurred or not by monitoring DTC and data list.
NG Perform troubleshooting for misfire
(See page DI-167).
OK
8 Check air induction system (See page SF-1).
CHECK:
Check the air induction system for vacuum leaks.
NG Repair or replace air induction system.
OK
9 Check fuel pressure (See page SF-7).
CHECK:
Check the fuel pressure (high or low pressure).
NG Check and repair fuel pump, pressure regulator,
fuel pipe line and filter (See page SF-1).
OK
10 Check injector injection (See page SF-24)
NG Replace injector.
OK

DI-154
- DIAGNOSTICSENGINE
347 Author
: Date
:
2004 LAND CRUISER (RM1071U)
7 Check fuel pressure (See page SF-7).
CHECK:
Check the fuel pressure (high or low pressure).
NG Check and replace fuel pump, pressure regula-
tor, fuel pipe line and filter (See page SF-1).
OK
8 Check exhaust system for gas leakage.
NG Repair or replace exhaust gas leakage point.
OK

- DIAGNOSTICSENGINE
DI-183
376 Author
: Date
:
2004 LAND CRUISER (RM1071U)
15 Check valve timing (Check for looseness or a jumped tooth of timing belt)
(See page EM-22).
NG Adjust valve timing (Repair or replace timing
belt).
OK
16 Check fuel pressure (See page SF-7).
NG Check and repair fuel pump, pressure regulator,
fuel pipe line and filter (See page SF-1).
OK

- DIAGNOSTICSENGINE
DI-1 1
204 Author
: Date
:
4 Check air filter.
PREPARATION:
Remove the air filter.
CHECK:
Visual check that the air filter is not excessively dirty or oily.
NG Repair or replace
air filter.
OK
5 Check idle speed.
PREPARATION:
(a) Warm up the engine to the normal operating temperature.
(b) Switch off all the accessories.
(c) Switch off the A/C.
(d) Shift the transmission into the N position.
(e) Connect the OBD II scan tool or hand-held tester to the DLC3 of the vehicle.
CHECK:
Use CURRENT DATA to check the idle speed.
OK:
Idle speed:
650 to 750 rpm
NG Proceed to problem symptoms table on page
DI-48.
OK

EM-2
- ENGINE MECHANICALCO/HC
1575 Author
: Date
:
2004 LAND CRUISER (RM1071U)
6. TROUBLESHOOTING
HINT:
If the CO/HC concentration does not comply with the regula-
tions, perform troubleshooting in the order given below.
See the table below for possible causes, and then inspect and
correct the applicable causes if necessary.
COHCProblemsCauses
NormalHighRough idle1. Faulty ignitions:

Incorrect timing

Fouled, shorted or improperly gapped plugs
2. Incorrect valve clearance
3. Leaky intake and exhaust valves
4. Leaky cylinders
LowHighRough idle
(fluctuating HC reading)1. Vacuum leaks:

PCV hoses

Intake manifold

Throttle body

Brake booster line
2. Lean mixture causing misfire
HighHighRough idle
(Black smoke from exhaust)1. Restricted air filter
2.Faulty SFI systems:

Faulty pressure regulator

Defective ECT sensor

Faulty ECM

Faulty injectors

Faulty throttle position sensor

Faulty MAF meter

2004 LAND CRUISER (EWD548U)
69 G
Position of Parts in Engine Compartment
H 1 Headlight LH (High)
H 2 Headlight LH (Low)
H 3 Headlight RH (High)
H 4 Headlight RH (Low)
H 5 Heated Oxygen Sensor (Bank 1 Sensor 1)
H 6 Heated Oxygen Sensor (Bank 1 Sensor 2)
H 7 Heated Oxygen Sensor (Bank 2 Sensor 1)
H 8 Heated Oxygen Sensor (Bank 2 Sensor 2)
H 9 Horn LH
H 10 Horn RH
I 1 Ignition Coil and Igniter No.1
I 2 Ignition Coil and Igniter No.2
I 3 Ignition Coil and Igniter No.3
I 4 Ignition Coil and Igniter No.4
I 5 Ignition Coil and Igniter No.5
I 6 Ignition Coil and Igniter No.6
I 7 Ignition Coil and Igniter No.7
I 8 Ignition Coil and Igniter No.8
I 9 Injector No.1
I 10 Injector No.2
I 11 Injector No.3
I 12 Injector No.4
I 13 Injector No.5
I 14 Injector No.6
I 15 Injector No.7
I 16 Injector No.8K 1 Knock Sensor 1
K 2 Knock Sensor 2
M 1 Mass Air Flow Meter
M 4 Master Cylinder Pressure Sensor
N 1 Noise Filter (Ignition)
O 2 Oil Pressure Sender
P 1 Park/Neutral Position SW
P 2 Parking Light LH
P 3 Parking Light RH
S 1 Starter
S 2 Starter
T 1 Theft Deterrent Horn
T 16 Throttle Control Motor and Sensor
T 17 Turbine Speed Sensor
V 2 Vehicle Speed Sensor (Combination Meter)
V 3 Vehicle Speed Sensor
(Electronically Controlled Transmission)
V 4 VSV (EVAP)
V 9 VSV (Canister Closed Valve)
W 1 Washer Motor

L PART NUMBER OF CONNECTORS
Code Part Name Part NumberCodePart Name Part Number
Note : Not all of the above part numbers of the connector are established for the supply.
2004 LAND CRUISER (EWD548U)
408
J16Junction Connector90980-1 1915J17Junction Connector90980-1 1915
J18Junction Connector
J19Junction Connector90980-1 1661J20Junction Connector90980-1 1661
J21Junction Connector
J22Junction Connector
J23Junction Connector90980-1 1915J25Junction Connector90980-1 1915
J26Junction Connector
K 1Knock Sensor 190980-1 1166K 2Knock Sensor 290980-1 1166
K 3Key Interlock Solenoid90980-10825
L 1License Plate Light LH90980-1 1148L 2License Plate Light RH90980-1 1148
L 3Lumbar Support Control SW (Driver's Seat)90980-10601
M 1Mass Air Flow Meter90980-1 1317
M 2Moon Roof Control ECU90980-10997
M 3Moon Roof Control SW90980-10789
M 4Master Cylinder Pressure Sensor90980-1 1451
M 5Multi-Display90980-12203
M 6Multi-Display90980-12410
M 7Multi-Display90980-12012
M 9Multi-Display90980-12094
N 1Noise Filter (Ignition)90980-10843
N 2Navigation ECU90980-1 1973
N 3Navigation ECU90980-1 1923
N 4Navigation ECU90980-12221
O 2Oil Pressure Sender90980-1 1363
O 5Overhead J/B90980-12155
P 1Park/Neutral Position SW90980-1 1784
P 2Parking Light LH90980-1 1156P 3Parking Light RH90980-11156
P 4Power Outlet (Front)90980-10760
P 5Power Outlet (Rear Console Box)90980-10860
P 6Power Quarter Window SW LH90980-10797
P 7Power Quarter Window SW RH90980-10996
P 8Parking Brake SW90980-10871
P 9Power Outlet (Luggage Compartment)
P10Power Vent Window Motor LH90980-10860
P11Power Vent Window Motor RH
P12Power Window Master SW90980-12166
P14Power Window Motor Front LH
P15Power Window Motor Front RH90980-1 1599P16Power Window Motor Rear LH90980-11599
P17Power Window Motor Rear RH
P18Power Window Control SW Front RH
P19Power Window Control SW Rear LH90980-1 1947
P20Power Window Control SW Rear RH
P21Pretensioner LH90980-1 1862P22Pretensioner RH90980-1 1862
P23Power Seat Control SW (Driver's Seat)
P24Power Seat Control SW (Front Passenger's
Seat)90980-10803
P25Power Seat Motor (Driver's Seat Front
Vertical Control)
P26Power Seat Motor (Driver's Seat Lumbar
Support Control)
P27Power Seat Motor (Driver's Seat Rear
Vertical Control)
P28Power Seat Motor (Driver's Seat Reclining
Control)
P29Power Seat Motor (Driver's Seat Slide
Control)90980-10825
P30Power Seat Motor (Front Passenger's Seat
Front Vertical Control)
P31Power Seat Motor (Front Passenger's Seat
Rear Vertical Control)
P32Power Seat Motor (Front Passenger's Seat
Reclining Control)
P33Power Seat Motor (Front Passenger's Seat
Slide Control)
R 5Remote Control Mirror SW90980-1 1657
R 6Rheostat90980-10799
R 7Room Temp. Sensor (Front)90980-1 1918
R 8Rear A/C Control SW90980-1 1503
R 9Rear Air Mix Control Servo Motor90980-1 1319
R10Rear Combination Light LH90980-1 1587
R11Rear Combination Light LH90980-10908R12Rear Combination Light RH90980-10908
R13Rear Combination Light RH90980-1 1587
R14Rear Cooler Blower Motor90980-10214
R15Rear Cooler Magnetic Valve90980-10860
R16Rear Cooler Power Transistor90980-10171R17Rear Cooler Relay90980-10171
R19Rear Door Speaker LH90980-10935R20Rear Door Speaker RH90980-10935
R21Rear Evaporator Temp. Sensor90980-1 1918
R22Rear Heater Blower Motor90980-10860
R25Rear Heater Power Transistor90980-10171
R26Rear Inlet Air Temp. Sensor90980-1 1369
R27Rear Interior Light90980-10935
R28Rear Window Defogger90980-1 1097R29Rear Window Defogger90980-1 1097
R30Rear Wiper Motor90980-10795