air condition TOYOTA LAND CRUISER 2005 J100 Owner's Guide

292
If you perform maintenance by yourself,
be sure to follow the correct procedure
given in this section.
You should be aware that improper or in-
complete servicing may result in operating
problems.
Performing do−it−yourself maintenance
during the warranty period may affect your
warranty coverage. Read the separate
Toyota Warranty statement for details and
suggestions.
This part gives instructions only for those
items that are relatively easy for an owner
to perform. As explained in Section 6,
there are still a number of items that must
be done by a qualified technician with
special tools.
For information on tools and parts for do −
it −yourself maintenance, see “Parts and
tools” on page 293.
Utmost care should be taken when work-
ing on your vehicle to prevent accidental
injury. Here are a few precautions that
you should be especially careful to ob-
serve:CAUTION
When the engine is running, keep
hands, clothing, and tools away
from the moving fan and engine
drive belts. (Removing rings,
watches, and ties is advisable.)
Right after driving, the engine
compartment—the engine, radiator,
exhaust manifold, power steering
fluid reservoir and spark plug
boots, etc.—will be hot. So be care-
ful not to touch them. Oil, fluids
and spark plugs may also be hot.
If the engine is hot, do not remove
the radiator cap or loosen the drain
plugs to prevent burning yourself.
Do not leave anything that may
burn easily, such as paper or rags,
in the engine compartment.
Do not smoke, cause sparks or al-
low open flames around fuel or the
battery. Their fumes are flammable.
Be extremely cautious when work-
ing on the battery. It contains poi-
sonous and corrosive sulfuric acid.
Do not get under your vehicle with
just the body jack supporting it. Al-
ways use automotive jack stands or
other solid supports.
Be sure that the ignition is off if
you work near the electric cooling
fan or radiator grille. With the igni-
tion on, the electric cooling fan will
automatically start to run if the air
conditioning is on.
Use eye protection whenever you
work on or under your vehicle
where you may be exposed to flying
or falling material, fluid spray, etc.
Used engine oil contains potentially
harmful contaminants which may
cause skin disorders such as in-
flammation or skin cancer, so care
should be taken to avoid prolonged
and repeated contact with it. To re-
move used engine oil from your
skin, wash thoroughly with soap
and water.
Do not leave used oil within the
reach of children.
Doityourself service
precautions

329
Fuses
Engine compartment
Fuses1. ABS NO.2 40 A: Anti−lock brake sys-
tem
2. ABS NO.1 50 A:
Anti−lock brake system
3. AHC 50 A: No circuit
4. ST1 7.5 A:
Mutiport fuel injection system/
Sequential multiport fuel injection
5. TOWING 30 A: Trailer lights
6. MIR HTR 15 A: Outside rear view mirror
defogger
7. RR HTR 10 A: Rear air conditioning sys-
tem
Left side kick panel
8. HAZTRN 15 A: Emergency flashers,
Turn signal lights
9. ALTS 7.5 A: Charging system
10. NVIR 20 A: No circuit
11. FR FOG 15 A:
Fog lights
12. TOWING BRK 30 A: Trailer lights
13. HEAD CLNER 20 A:
Headlight cleaner
14. FRIG 10 A: Charging system
15. PANEL 7.5 A: Instrument panel light
16. TOWING TAIL 30 A: Trailer lights
17. TAIL 15 A: Parking lights, Tail lights
Right side kick panel
18. BAT 30 A: All components in “ECU− B2”
19. TEL 7.5 A: No circuit
20. AMP 30 A: Audio system
21. EFI or ECD No.1 25 A: Multiport fuel
injection system/Sequential multiport fuel
injection system
22. AM2 15 A: All components in “IGN”
23. ETCS 10 A: Multiport fuel injection sys-
tem/Sequential multiport fuel injection sys-
tem
24. HORN 10 A: Horns
25. HEAD (RHLWR) 10 A: Right−hand
headlight (low beam)

330
26. HEAD (LHLWR) 10 A: Left−hand head-
light (low beam)
27. HEAD (RHUPR) 20 A: Right −hand
headlight (high beam)
28. HEAD (LHUPR) 20 A: Left −hand head-
light (high beam)
29. PWR OUTLET 15 A: Power outlets
30. CIG 15 A: Cigarette lighter
31. ACC 7.5 A: Instrument panel light
32. AM1 7.5 A: Multiport fuel injection sys-
tem/Sequential multiport fuel injection
system
33. DEFOG 20 A:
Rear window defogger
34. AHCB 15 A: Active height control sus-
pension (AHC)
35. FUEL HTR 20 A: Fuel heater
36. POWER HTR 7.5 A: Power heater
37. AHCIG 20 A: Active height control sus-
pension (AHC)
38. EFI or ECD No.2 10 A: Emission con-
trol system
39. GAUGE1 10 A: Gauges and meters
40. ECUIG1 10 A: Multiport fuel injection
system/S equential multiport fuel injec-
tion system
41. ECUB1 10 A:
Navigation system
42. DBL LOCK 15 A: Double lock system
43. A/C 15 A: Air conditioning system
44. STOP 15 A: Stop lights
45. OBD2 7.5 A: On −board diagnosis sys-
tem
46. IDEL UP 7.5 A: Idle −up system
47. LH SEAT 30 A: Power seat system
48. DOOR 25 A: Power door lock system,
Power windows
49. SUN ROOF 25 A: Electronic moon roof
50. RR WIPER 15 A: Rear wiper system
51.ECUB2 10 A: Power door lock system,
Power window
52. DIFF 20 A: Four−wheel drive system
53. WASHER 15 A: Windshield washer
54. RADIO 10 A: Audio system
55. DOME 10 A: Interior lights
56. VGRS 40 A: Variable gear ratio steer-
ing system
57. P/W (FL) 20 A: Power window
58. P/W (RL) 20 A: Power window
59. WIPER 25 A: Windshield wiper
60. ECUIG2 10 A: Rear air conditioning
system
61. SEAT HTR 15 A: Seat heater 62. GAUGE2 10 A:
Back−up lights
63. MET 7.5 A: Gauges and meters
64. IGN 7.5 A: Multiport fuel injection sys-
tem/Sequential multiport fuel injection
system
65. SECURITY 7.5 A: Theft deterrent sys-
tem
66. P/W (RR) 20 A: Power window
67. P/W (FR) 20 A: Power window
68. BATT CHARGE 30 A: Trailer charging
system
69. TIL&TEL 20 A: Tilt and telescopic
steering
70. RR A/C 30 A: Rear air conditioning
system
71. RH SEAT 30 A: Power seat system

334 A
Adding washer fluid315
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 36
. . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 48
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Second seat 37
38
. . . . . . . . . . . . . . . . . . . .
Third seat 42 . . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 176 . . . . . . . . . . . . . . .
Airbags 58 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 309 . . . . . . . . . .
Anti −theft steering column lock 134 . . . . . . . .
Appearance care
Cleaning the interior 279 . . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 276 . . . . . . . . . . . . . . . . . . .
Washing and waxing 277 . . . . . . . . . . . . . . . .
Armrest 37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 135 . . . . . . . . . . . . . . . . . . . . .
Shift lock override button 272 . . . . . . . . . . . .
Shift pattern 135 . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 135 . . . . . . . . . . . . . . . . . . . . .
Auxiliary box 198 . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 27 . . . . . . . . . . .
B
Back door 25
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 25
. . . . . . . . . . . . . . . . . . . . . . . . Battery
Checking battery condition 312
. . . . . . . . . .
Gas caution 312
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 312
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 313
. . . . . . . . . . . . .
Winter driving tips 240
. . . . . . . . . . . . . . . . . .
Before starting the engine 236
. . . . . . . . . . . . .
Brake pad wear limit indicators 219 . . . . . . . .
Brake system 215
. . . . . . . . . . . . . . . . . . . . . . . .
Brakes
Fluid level 300
. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 219
. . . . . . . . . . . .
Parking 142
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Break −in tips 209
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 110
. . . . . . . . . . . . . . . . . . . .
C
Car audio system 152
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 213
. . . . . . . . . . . . .
Cargo and luggage
Capacity 230
. . . . . . . . . . . . . . . . . . . . . . . . . .
Distribution 231
. . . . . . . . . . . . . . . . . . . . . . . .
Stowage precautions 230
. . . . . . . . . . . . . . .
Cassette player 152
. . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 314
. . . . . . . . .
Checking and replacing tires 304
. . . . . . . . . .
Checking brake fluid 300
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 296
. . . . . . . . . .
Checking the radiator and condenser 299
. . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 77
. . . . . . . . . . . . . . .
Installation 78, 83
. . . . . . . . . . . . . . . . . . . . . . Precautions
76
. . . . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 77 . . . . . . . .
Using a top strap 92
. . . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtray 192
. . . . . . . . . .
Cleaning the interior 279
. . . . . . . . . . . . . . . . . .
Clock 188
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coat hooks 205
. . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 240
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc auto changer
controller 152
. . . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc player 152
. . . . . . . . . . . . . . . . . .
Controls, Instrument panel 2, 6
. . . . . . . . . . . .
Cooling system
Coolant level 298
. . . . . . . . . . . . . . . . . . . . . .
Radiator and reservoir 298
. . . . . . . . . . . . . .
Winter driving tips 240
. . . . . . . . . . . . . . . . . .
Corrosion prevention 276
. . . . . . . . . . . . . . . . .
Cruise control 142
. . . . . . . . . . . . . . . . . . . . . . .
Cup holder 199
. . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger, Rear window 115
. . . . . . . . . . . . . . .
Differential, Limited slip 220
. . . . . . . . . . . . . . .
Dimmer switch, Headlight 108
. . . . . . . . . . . . .
Directional signals 108
. . . . . . . . . . . . . . . . . . .

335
Do−it−yourself maintenance
Parts and tools 293 . . . . . . . . . . . . . . . . . . . . .
Service precautions 292 . . . . . . . . . . . . . . . .
Does your vehicle need repairing? 287 . . . . .
Driving
Automatic transmission 135 . . . . . . . . . . . . .
Driving tips 236 . . . . . . . . . . . . . . . . . . . . . . . .
Driving tips
Driving tips in various conditions 237 . . . . .
Driving with an automatic transmission 135 . . . . . . . . . . . . . . . . . . . . .
Economical driving 249 . . . . . . . . . . . . . . . . .
Good driving practice 135 . . . . . . . . . . . . . . .
Winter driving tips 240 . . . . . . . . . . . . . . . . . .
During
Break −in 209 . . . . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel and repairs 249 . . . . . . . . . . . . . . . . . . . . . .
Electric moon roof 31 . . . . . . . . . . . . . . . . . . . . .
Electrical system
Battery 312, 313 . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 291 . . . . . . . . . . . . . . . . . . . . .
Fuses 314 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 110 . . . . . . . . . . . . . Emergency, In case of
Blown fuse 314 . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 110 . . . . . . . . . . .
Flat tire 257 . . . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot shift automatic transmission selector lever 272 . . . . . . . .
If you lose your keys 273 . . . . . . . . . . . . . . . .
If your engine stalls while driving 256 . . . . .
If your vehicle needs to be towed 269 . . . . .
If your vehicle will not start 252 . . . . . . . . . .
Jump starting 253 . . . . . . . . . . . . . . . . . . . . . .
Towing 269 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine
Before starting the engine 236 . . . . . . . . . . .
Checking the coolant level 298 . . . . . . . . . .
Emission control device 212 . . . . . . . . . . . . .
Engine compartment 290 . . . . . . . . . . . . . . .
Exhaust gas caution 213 . . . . . . . . . . . . . . . .
Hood release 27 . . . . . . . . . . . . . . . . . . . . . . .
Oil consumption 214 . . . . . . . . . . . . . . . . . . . .
Oil level 296 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil pressure gauge 119 . . . . . . . . . . . . . . . . .
Starting procedure 236 . . . . . . . . . . . . . . . . .
Three −way catalytic converter 212 . . . . . . .
Engine coolant
Temperature gauge 118 . . . . . . . . . . . . . . . . .
Winter driving tips 240 . . . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 118 . . . . .
Engine immobiliser system 12 . . . . . . . . . . . . .
Engine oil
Winter driving tips 240 . . . . . . . . . . . . . . . . . .
Engine oil pressure gauge 119 . . . . . . . . . . . . .
Exhaust gas caution 213 . . . . . . . . . . . . . . . . . .
F
Facts about engine oil consumption 214 . . . .
First −aid kit holder 199 . . . . . . . . . . . . . . . . . . .
Flasher, Headlight 108 . . . . . . . . . . . . . . . . . . . .
Flat tire
After changing wheels 267 . . . . . . . . . . . . . .
Changing tire 265 . . . . . . . . . . . . . . . . . . . . . .
If you have a flat tire 257 . . . . . . . . . . . . . . . .
Jack point 263 . . . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 257 . . . . . . . . . . . . . . . .
Jacking up 264 . . . . . . . . . . . . . . . . . . . . . . . .
Loosening wheel nuts 262 . . . . . . . . . . . . . . .
Lowering vehicle 266 . . . . . . . . . . . . . . . . . . .
Reinstalling wheel ornament 267 . . . . . . . . .
Removing wheel ornament 262 . . . . . . . . . .
Wheel block 261 . . . . . . . . . . . . . . . . . . . . . . .
Wheel nuts 266 . . . . . . . . . . . . . . . . . . . . . . . .
Floor mat 204 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid level
Brake 300 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 301 . . . . . . . . . . . . . . . . . . . . .
Washer fluid 315 . . . . . . . . . . . . . . . . . . . . . . .
Fog light switch, Front 111 . . . . . . . . . . . . . . . .
Foreign countries, Operation in 211 . . . . . . . .
Four −wheel drive
Operating the four −wheel
drive system 139 . . . . . . . . . . . . . . . . . . . . .
Front fog light switch 111 . . . . . . . . . . . . . . . . .
Front seats 35, 36 . . . . . . . . . . . . . . . . . . . . . . . .
Fuel
Filler door opener 29 . . . . . . . . . . . . . . . . . . .
Fuel economy 249 . . . . . . . . . . . . . . . . . . . . .
Gauge 118 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 211 . . . . . . .

337
N
New vehicle break
−in 209 . . . . . . . . . . . . . . . . .
O
Odometer 121
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Off road vehicle precautions 208
. . . . . . . . . . .
Oil
Consumption 214
. . . . . . . . . . . . . . . . . . . . . .
Power steering 301
. . . . . . . . . . . . . . . . . . . . .
Pressure gauge 119
. . . . . . . . . . . . . . . . . . . .
Viscosity and grade 296
. . . . . . . . . . . . . . . .
Oil consumption 214
. . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 211
. . . . . . . . .
Outside rear view mirror heaters 115 . . . . . . .
Outside temperature display 188
. . . . . . . . . . .
Overheating, Engine coolant 118
. . . . . . . . . .
Overview
Engine compartment 290
. . . . . . . . . . . . . . .
P
Parking brake
Operation 142 . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 142 . . . . . . . . . . . . . . . . . . . . .
Personal light 112 . . . . . . . . . . . . . . . . . . . . . . . .
Polishing 277 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power outlet 192 . . . . . . . . . . . . . . . . . . . . . . . . .
Power quarter windows 24 . . . . . . . . . . . . . . . .
Power rear view mirror control 99 . . . . . . . . . .
Power steering
Fluid level 301 . . . . . . . . . . . . . . . . . . . . . . . . .
Power window switches 22 . . . . . . . . . . . . . . . .
Preloaders (seat belt pretensioners) 55 . . . . . Pretensioners
(seat belt pretensioners) 55 . . . . . . . . . . . . .
Protecting your Toyota from corrosion 276 . . . . . . . . . . . . . . . . . . . . .
Q
Quarter windows 24
. . . . . . . . . . . . . . . . . . . . . .
R
Radiator
Coolant, Engine 298 . . . . . . . . . . . . . . . . . . . .
Radio 152 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear air conditioning system 184 . . . . . . . . . .
Rear seat
Third seat entry 38 . . . . . . . . . . . . . . . . . . . . .
Rear seat audio system 170 . . . . . . . . . . . . . . .
Rear step bumper 219 . . . . . . . . . . . . . . . . . . . .
Rear view mirrors
Folding 100 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside 99 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power 99 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear view monitor system 189 . . . . . . . . . . . . .
Rear window defogger switch 115 . . . . . . . . . .
Rear window wiper and washer switch 114 . .
Reporting safety defects for U.S. owners 332 . . . . . . . . . . . . . . . . . . . .
Rollover sensing of curtain shield airbag off switch 193 . . . . . . . . . . . . . . . . . . .
Roof luggage carrier 202 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 35 . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 53 . . . . . . . . . . . . . . . . . . . . .
Seat belts
Cleaning 279 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastening 48 . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt precautions 48 . . . . . . . . . . . . . . . .
Seat belt pretensioners 55 . . . . . . . . . . . . . .
Seat heater switches 47 . . . . . . . . . . . . . . . . . .
Seating capacity 230 . . . . . . . . . . . . . . . . . . . . .
Seats 34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Second seat 37, 38 . . . . . . . . . . . . . . . . . . . . . . .
Service and maintenance 284 . . . . . . . . . . . . .
Side door locks 18 . . . . . . . . . . . . . . . . . . . . . . .
Skyhook TEMS 145, 147 . . . . . . . . . . . . . . . . .
Spare fuse 314 . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare tire 259 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spark plugs
Iridium −tipped spark plugs 215 . . . . . . . . . .
Specifications 324 . . . . . . . . . . . . . . . . . . . . . . .
SRS driver and
front passenger airbags 58 . . . . . . . . . . . . . .
SRS side and curtain shield airbags with rollover sensing function 65 . . . . . . . . .
Starting
Cold weather 236 . . . . . . . . . . . . . . . . . . . . . .
Engine 236 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 253 . . . . . . . . . . . . . . . . . . . . . .
Steering
Power tilt steering wheel 98 . . . . . . . . . . . . .
Steering column
Column lock 134
. . . . . . . . . . . . . . . . . . . . . . .
Steering pad switches 172
. . . . . . . . . . . . . . . .
Sun visors 105
. . . . . . . . . . . . . . . . . . . . . . . . . . .