ignition TOYOTA LAND CRUISER 2009 J200 Service Manual

387
4-3. Do-it-yourself maintenance
4
Maintenance and care
L/C200_U (OM60D97U)
CAUTION
The engine compartment contains many mechanisms and fluids that may
move suddenly, become hot, or become electrically energized. To avoid death
or serious injury.
■
When working on the engine compartment
● Keep hands, clothing, and tools away from the moving fan and engine
drive belt.
● Be careful not to touch the engine, inverter, radiator, exhaust manifold, etc.
right after driving as they may be hot. Oil and other fluids may also be hot.
● Do not leave anything that may burn easily, such as paper or rags, in the
engine compartment.
● Do not smoke, cause sparks or expose an open flame to fuel or the bat-
tery. Fuel and battery fumes are flammable.
● Be extremely cautious when working on the battery. It contains poisonous
and corrosive sulfuric acid.
■ When working near the electric cooling fan or radiator grille
Be sure the ignition is off. With the “ENGINE START STOP” switch in IGNI-
TION ON mode, the electric cooling fan may automatically start to run if the
air conditioning is on and/or if the coolant temperature is high.
( P. 397)
■ When working on or under the vehicle
● Do not get under the vehicle with just the jack supporting it.
Always use automotive jack stands or other solid supports.
● Use eye protection to prevent flying or falling material, fluid spray, etc. from
getting in your eyes.
NOTICE
■If you remove the air cleaner filter
Driving with the air cleaner filter removed may cause excessive engine wear
due to dirt in the air. Also a backfire could cause a fire in the engine compart-
ment.

394 4-3. Do-it-yourself maintenance
L/C200_U (OM60D97U)
■Engine oil consumption
● The amount of engine oil consumed depends on the oil viscosity, the
quality of the oil and the way the vehicle is driven.
● More oil is consumed under driving conditions such as high speeds and
frequent acceleration and deceleration.
● A new engine consumes more oil.
● When judging the amount of oil consumption, keep in mind that the oil
may have become diluted, making it difficult to judge the true level accu-
rately.
■ Resetting the engine oil maintenance data
The oil change system should be reset. Perform the following procedures:
Switch the display to the trip meter A when the engine is running.
( P. 165)
Turn the “ENGINE START STOP” switch OFF.
While pressing the trip meter reset button, set the “ENGINE START
STOP” switch to IGNITION ON mode (but do not start the engine
because otherwise the reset mode will be cancelled). Continue to
press and hold the button until the multi-information display indi-
cates that the reset is complete.
STEP1
STEP2
STEP3

407
4-3. Do-it-yourself maintenance
4
Maintenance and care
L/C200_U (OM60D97U)
■
How to initialize the tire pressure warning system
Park the vehicle in safe place and turn the “ENGINE START
STOP” switch to OFF mode.
While the vehicle is moving, in itialization is not performed.
Adjust the tire inflation pressure to the specified cold tire infla-
tion pressure level. ( P. 516)
Make sure to adjust the tire pressure to the specified cold tire
inflation pressure level. The ti re pressure warning system will
operate based on this pressure level.
Turn the “ENGINE START STOP” switch to IGNITION ON
mode.
Press and hold the tire pressure
warning reset switch until the tire
pressure warning light blinks
slowly three times and the mes-
sage “TIRE PRESSURE RESET
PROCEEDING” appears on the
multi-information display.
Wait for a few minutes with the IGNITION ON mode, and then
turn the “ENGINE START STOP” switch to OFF mode.
STEP1
STEP2
STEP3
ITO43C130
SET
STEP4
STEP5

420
4-3. Do-it-yourself maintenance
L/C200_U (OM60D97U)
Air conditioning filter
The air conditioning filter must be cleaned or changed regularly to
maintain air conditioning efficiency.
■ Removal method
Turn the “ENGINE START STOP” switch IGNITION ON
mode and switch to recirculated air mode, then turn the
“ENGINE START STOP” switch off.
Open the glove box and
remove the partition.
Remove the filter cover.
STEP1
STEP2
STEP3

430 4-3. Do-it-yourself maintenance
L/C200_U (OM60D97U)
Fuse layout and amperage ratings■ Engine compartment
FuseAmpereCircuit
1A/F15 A
A/F heater
2HORN10 AHorn
3EFI MAIN25 A
EFI, A/F heater
4IG2 MAIN 30 AInjector, ignition, meter
5RR A/C50 ANo circuit
6SEAT-A/C LH25 A
No circuit
7RR S/HTR20 ARear seat heater
8DEICER20 AWindshield wiper de-icer
9CDS FAN25 A
Condenser fan
10TOW TAIL30 ATowing tail
11RR P/SEAT30 ANo circuit
12ALT-CDS10 A
Alternator condenser
13FR FOG15 AFront fog lights
14SECURITY5 ASecurity horn
15SEAT-A/C RH25 A No circuit

432 4-3. Do-it-yourself maintenance
L/C200_U (OM60D97U)
41ECU-B25 ADriving position memory sys-
tem
42TEL5 A
No circuit
43RSE7.5 A Rear seat entertainment
44TOWING30 ATo w i n g
45DOOR NO.225 A
Main body ECU
46STR LOCK20 ASteering lock system
47TURN-HAZ15 AMeter, front turn signal lights,
rear turn signal lights, towing
converter
48EFI MAIN220 A
Fuel pump
49ETCS10 A
EFI
50ALT-S5 AIC-ALT
51AMP30 A Audio system
52RAD NO.110 ANavigation system, radio
receiver assembly
53ECU-B15 ASmart key system, overhead
module, tilt and telescopic
steering, meter, cool box, gate-
way ECU, steering sensor
54DOME15 A
Door courtesy lights, clock
55HEAD LH15 A Headlight high beam (left)
56HEAD LL15 AHeadlight low beam (left)
57INJ10 A
Injector, ignition
58MET5 AMeter
59IGN10 A Circuit open, SRS airbag sys-
tem, gateway ECU, occupant
detection system, smart key
system, ABS, VSC, steering
lock system, GBS
60HEAD RH15 A
Headlight high beam (right)
FuseAmpereCircuit

470 5-2. Steps to take in an emergency
L/C200_U (OM60D97U)
■If the tire pressure warning light comes on after blinking for 1
minute frequently
If the tire pressure warning light comes on after blinking 1 minute fre-
quently when the “ENGINE START STOP” switch is turned to IGNITION
ON mode, have it checked by Toyota dealer.
CAUTION
■If the tire pressure warning light comes on
Be sure to observe the following precautions. Failure to do so could
cause loss of vehicle control and re sult in death or serious injury.
●Stop your vehicle in a safe place as soon as possible. Adjust the tire
inflation pressure immediately.
●If the tire pressure warning light comes on even after tire inflation pres-
sure adjustment, it is pr obable that you have a flat tire. Check the tires.
If the tire is flat, change to the spare tire and have the flat tire repaired
by the nearest Toyota dealer.
●Avoid abrupt maneuvering and braking. If the vehicle tires deteriorate,
you could lose control of the steering wheel or the brakes.
■If a blowout or sudden air loss should occur
The tire pressure warning syste m may not activate immediately.

512 6-1. Specifications
L/C200_U (OM60D97U)
Cooling system
Ignition system
Capacity16.3 qt. (15.4 L, 13.6 lmp.qt.)
Coolant type
Use either of the following:• “Toyota Super Long Life Coolant”
• Similar high-quality ethylene glycol-based non-silicate, non-amine, non-nitrite, and non-borate
coolant with long-life hybrid organic acid technol-
ogy
Do not use plain water alone.
Spark plug
Make DENSO
GapSK20HR11
0.043 in. (1.1 mm)
NOTICE
■ Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust gap when tuning engine.

546 Alphabetical index
L/C200_U (OM60D97U)
Wireless remote control key .... 40
Doors Back door ................................48
Side door ................................. 43
Side mirrors .............................82
Driver’s seat belt reminder
light ......................................... 465
Driving Break-in tips .......................... 143
Correct posture ..................... 100
Off-road precautions ............. 220
Procedures............................ 142
Winter driving tips.................. 233
Driving position memory...........62
Electronic key If your electronic key
battery is discharged...423, 494
Emergency flashers .................452
Emergency, in case of If a warning message is
displayed............................. 473
If the electronic key does not operate properly............ 494
If the engine will not start ......489
If the shift lever cannot be shifted from P......................491
If the vehicle has discharged battery ................................497
If the warning buzzer
sounds ................................462
If the warning light turns on ...462
If you cannot operate back door opener ........................493
If you have a flat tire ............. 476
If you lose your keys ............. 492
If you think something is wrong .................................. 458
If your vehicle becomes
stuck ...................................504
If your vehicle needs to be towed .................................. 453
If your vehicle overheats ....... 501 Engine
Compartment ........................ 389
Engine switch ........................ 151
Hood ..................................... 388
How to start the engine ......... 151
Identification number............. 509
If the engine will not start ...... 489
Ignition switch ....................... 151
Overheating .......................... 501
Engine coolant Capacity ................................ 512
Checking ............................... 396
Preparing and checking before winter ....................... 233
Engine coolan t temperature
gauge ...................................... 164
Engine immobilizer system ...... 95
Engine oil Capacity ................................ 511
Checking ............................... 391
Preparing and checking before winter ....................... 233
Engine oil maintenance data ......................................... 394
Engine switch........................... 151
Event data recorder ................. 460
First-aid kit holder ................... 365
Floor mat .................................. 363
Fluid
Brake..................................... 398
Power steering ...................... 400
Washer.................................. 404
Fog lights Replacing light bulbs ............. 439
Switch ................................... 177
Wattage................................. 517
Four-wheel drive system......... 201
Front fog lights Replacing light bulbs ............. 439
Switch ................................... 177
E
F

547
Alphabetical index
L/C200_U (OM60D97U)
Wattage ................................ 517
Front passenger’s seat belt reminder light ........................ 465
Front seats Adjustment ............................. 51
Driving position memory ......... 62
Front side marker light Replacing light bulbs ............ 439
Wattage ................................ 517
Front turn signal lights Replacing light bulbs ............ 439
Wattage ................................ 517
Fuel Capacity ............................... 510
Fuel gauge ........................... 164
Fuel pump shut off system ... 459
Gas station information ........ 556
Information ........................... 518
Refueling ................................ 91
Type ..................................... 518
Fuel door .................................... 91
Fuel filler door ........................... 91
Fuel pump shut off system ................................... 459
Fuses ........................................ 426
Garage door opener ................ 366
Gas station information .......... 556
Gauges ..................................... 164
Glove box ................................. 342
Glove box light ........................ 342
Head restraints
Adjusting................................. 66
Headlight cleaner .................... 187
Headlights
Replacing light bulbs ............ 439
Switch ................................... 174
Wattage ................................ 517
Heaters Seat heaters ......................... 360 Hill-start assist control ............212
Hood ..........................................388
Hooks
Cargo hook............................364
Tie-down hooks .....................364
Horn...........................................163
I/M test.......................................384
Identification
Engine ...................................509
Vehicle ..................................509
Ignition Engine switch ........................151
Keys ........................................24
Ignition switch........................151
Ignition switch ..........................151
Illuminated entry system .........338
Indicator lights .........................167
Initialization
Items to initialize....................537
Inside rear view mirror ..............81
Instrument panel light
control ....................................165
Interior lights
Interior lights..........................338
Switch....................................339
Wattage .................................517
Jack Replacing the wheel ..............476
Jack handle ..............................476
KDSS .........................................212
Keyless entry..............................26
Keys Electronic key ..........................24
If you lose your keys .............492
If your electronic key battery is discharged...423, 494
Ignition switch........................151
Keyless entry...........................26
Key number .............................24
G
H
I
J
K