Brake TOYOTA MATRIX 2010 E140 / 2.G Workshop Manual

5
When trouble arises
381 5-2. Steps to take in an emergency
CAUTION
■When the spare tire is attached
The vehicle speed may not be correctly detected, and the following sys-
tems may not operate correctly:
●ABS & Brake assist
●VSC (if equipped)
●TRAC (if equipped)
●Navigation system (if equipped)
Also, not only can the following system not be utilized fully, it may actu-
ally negatively effect the drive-train components:
●Active torque control 4WD system (if equipped)

384
5-2. Steps to take in an emergency
If the shift lever cannot be shifted from P (automatic transmission)
If the shift lever cannot be shifted with your foot on the brake, there
may be a problem with the shift lock system (a system to prevent
accidental operation of the shift lever). Have the vehicle inspected by
your Toyota dealer.
The following steps may be used as an emergency measure to
ensure that the shift lever can be shifted.
Set the parking brake.
Turn the engine switch to the “ACC” position.
Depress the brake pedal.
Pry the cover up with a flat-
head screwdriver or equiva-
lent.
Press the shift lock override
button.
The shift lever can be shifted
while the button is pressed.
STEP1
STEP2
STEP3
STEP4
STEP5

394
5-2. Steps to take in an emergency
If the vehicle becomes stuck
CAUTION
■When attempting to free a stuck vehicle
If you choose to rock the vehicle back and forth to free it, make sure the sur-
rounding area is clear, to avoid striking other vehicles, objects or persons.
The vehicle may also lunge forward or lunge back suddenly as it becomes
free. Use extreme caution.
■When shifting the shift lever
For vehicles with an automatic transmission, be careful not to shift the shift
lever with the accelerator pedal depressed.
This may lead to unexpected rapid acceleration of the vehicle that may
cause an accident and result in death or serious injury.
NOTICE
■To avoid damaging the transmission and other components
●Avoid spinning the wheels and do not rev the engine.
●If the vehicle remains stuck after trying these procedures, the vehicle may
require towing to be freed.
Carry out the following procedures if the tires spin or the vehicle
becomes stuck in mud, dirt, or snow.
Stop the engine. Set the parking brake and put the shift
lever in P (automatic transmission) or N (manual transmis-
sion).
Remove the mud, snow, or sand from around the stuck tire.
Place wood, stones or some other material to help provide
traction under the tires.
Restart the engine.
Shift the shift lever to the D or R position (automatic trans-
mission) or 1 or R position (manual transmission) and care-
fully apply the accelerator to free the vehicle.STEP1
STEP2
STEP3
STEP4
STEP5

406 6-1. Specifications
Brakes
*1: Minimum pedal clearance when depressed with a force of 66 lbf (294 N, 30
kgf) while the engine is running
*2: 2.4 L 4-cylinder (2AZ-FE) engine with 18-inch tires or AWD models
*3: Parking brake lever travel when pulled up with a force of 44 lbf (200 N, 20
kgf)
Pedal clearance*1
1.8 L 4-cylinder (2ZR-FE) engine
• With vehicle stability control:
3.4 in. (87 mm)
• Without vehicle stability control:
3.2 in. (81 mm)
2.4 L 4-cylinder (2AZ-FE) engine
• AWD models: 3.4 in. (87 mm)
• Vehicles with P215/45R18 tires:
3.4 in. (87 mm)
• Vehicles with tires other than the
above: 3.3 in. (85 mm)
Pedal free play 0.04  0.24 in. (1  6 mm)
Brake pad wear limit 0.04 in. (1.0 mm)
Parking brake lining wear limit*20.04 in. (1.0 mm)
Parking brake lever travel*36  9 clicks
Fluid type SAE J1703 or FMVSS No.116 DOT 3

421 6-1. Specifications
6
Vehicle specifications
Warning: The temperature grades for this tire are established for a
tire that is properly inflated and not overloaded.
Excessive speed, underinflation, or excessive loading, either sepa-
rately or in combination, can cause heat buildup and possible tire fail-
ure.
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation pres-
sureTire pressure when the vehicle has been
parked for three hours or more, or has not
been driven more than 1 mile or 1.5 km under
that condition
Maximum inflation
pressureThe maximum cold inflated pressure to which a
tire may be inflated, shown on the sidewall of
the tire
Recommended infla-
tion pressureCold tire inflation pressure recommended by a
manufacturer
Accessory weightThe combined weight (in excess of those stan-
dard items which may be replaced) of auto-
matic transmission, power steering, power
brakes, power windows, power seats, radio
and heater, to the extent that these items are
available as factory-installed equipment
(whether installed or not)
Curb weightThe weight of a motor vehicle with standard
equipment, including the maximum capacity of
fuel, oil and coolant, and if so equipped, air
conditioning and additional weight optional
engine
Maximum loaded vehi-
cle weightThe sum of:
(a) Curb weight
(b) Accessory weight
(c) Vehicle capacity weight
(d) Production options weight

422 6-1. Specifications
Tire related termMeaning
Normal occupant
weight150 lb. (68 kg) times the number of occupants
specified in the second column of Table 1
* that
follows
Occupant distributionDistribution of occupants in a vehicle as speci-
fied in the third column of Table 1
* below
Production options
weightThe combined weight of installed regular pro-
duction options weighing over 5 lb. (2.3 kg) in
excess of the standard items which they
replace, not previously considered in curb
weight or accessory weight, including heavy
duty brakes, ride levelers, roof rack, heavy duty
battery, and special trim
RimA metal support for a tire or a tire and tube
assembly upon which the tire beads are seated
Rim diameter
(Wheel diameter)Nominal diameter of the bead seat
Rim size designation Rim diameter and width
Rim type designationThe industry manufacturer's designation for a
rim by style or code
Rim width Nominal distance between rim flanges
Vehicle capacity
weight (Total load
capacity)The rated cargo and luggage load plus 150 lb.
(68 kg) times the vehicle's designated seating
capacity
Vehicle maximum load
on the tireThe load on an individual tire that is determined
by distributing to each axle its share of the
maximum loaded vehicle weight, and dividing
by two
Vehicle normal load
on the tireThe load on an individual tire that is determined
by distributing to each axle its share of curb
weight, accessory weight, and normal occu-
pant weight (distributed in accordance with
Ta b l e 1
* below), and dividing by two

436
Abbreviation list
Abbreviation/Acronym list
ABBREVIATIONSMEANING
4WD 4 Wheel Drive
A/C Air Conditioning
ABS Anti-lock Brake System
ACC Accessory
ALR Automatic Locking Retractor
AWD All Wheel Drive
CRS Child Restraint System
ECU Electronic Control Unit
EDR Event Data Recorder
ELR Emergency Locking Retractor
GAWR Gross Axle Weight Rating
GVWR Gross Vehicle Weight Rating
I/M Emission inspection and maintenance
LATCH Lower Anchors and Tethers for Children
LED Light Emitting Diode
MMT Methylcyclopentadienyl Manganese Tricarbonyl
M + S Mud and Snow
MTBE Methyl Tertiary Butyl Ether
OBD On Board Diagnostics
SRS Supplemental Restraint System
TIN Tire Identification Number
TPMS Tire Pressure Warning System
TRAC Traction Control
VIN Vehicle Identification Number
VSC Vehicle Stability Control

437
Alphabetical index
Alphabetical index
A/C ............................................ 168
ABS........................................... 142
Active torque control 4WD
system ................................... 142
Air conditioning filter .............. 323
Air conditioning system
Air conditioning filter ............. 323
Air conditioning
system................................ 168
Airbags
Airbag operating conditions .... 73
Airbag precautions for your
child...................................... 77
Airbag warning light .............. 360
Curtain shield airbag operating
conditions ............................. 74
Curtain shield airbag
precautions .......................... 77
Front passenger occupant
classification system ............ 82
General airbag precautions .... 77
Locations of airbags ............... 70
Modification and disposal of
airbags ................................. 81
Proper driving posture ...... 68, 77
Side airbag operating
conditions ............................. 74
Side airbag precautions.......... 77
SRS airbags ........................... 70
Antenna .................................... 181
Anti-lock brake system ........... 142
Ashtray ..................................... 253
Audio input .............................. 202Audio system
Antenna .................................181
Audio input ............................202
AUX adapter..........................202
CD player/changer ................184
MP3/WMA disc......................191
Optimal use ...........................199
Portable music player............202
Radio .....................................178
Steering wheel audio
switch ..................................203
Type ......................................175
Automatic transmission
Automatic transmission .........116
If the shift lever cannot be
shifted from P......................384
S mode ..................................118
AUX adapter .............................202
Auxiliary boxes ................248, 262
Back-up lights
Wattage .................................411
Back door
Back door ................................33
Wireless remote control ..........26
Battery
Checking ...............................304
If the vehicle has a
discharged battery ..............386
Preparing and checking before
winter ..................................151
Bluetooth
®................................206
Bottle holder .............................247
Brake
Fluid ......................................302
Parking brake ........................124
Brake assist ..............................142
Break-in tips .............................104
A
B

440 Alphabetical index
Floor mat................................... 260
Fluid
Brake ..................................... 302
Washer .................................. 306
Fog lights
Replacing light bulbs ............. 337
Switch.................................... 135
Wattage ................................. 411
Front passenger occupant
classification system ..............82
Front passenger's seat belt
reminder light......................... 362
Front seats
Adjustment ..............................37
Front side marker lights
Replacing light bulbs ............. 337
Switch.................................... 132
Wattage ................................. 411
Front turn signal lights
Replacing light bulbs ............. 337
Switch.................................... 123
Wattage ................................. 411
Fuel
Capacity ................................ 400
Fuel gauge ............................ 126
Fuel pump shut off system .... 356
Gas station information ......... 448
Information ............................ 412
Refueling .................................61
Type ...................................... 400
Fuel door.....................................61
Fuel filler door ............................61
Fuel pump shut off system ..... 356
Fuses......................................... 328Gas station information .......... 448
Gauges...................................... 126
Glove box ................................. 243
Grocery bag hooks .................. 257
Hands-free phone system
(for cellular phone) ................ 206
Hazard lights
Switch ................................... 348
Head restraints
Adjusting ................................ 43
Headlights
Replacing light bulbs ............. 337
Switch ................................... 132
Wattage................................. 411
Heaters
Side mirror ............................ 174
Hood.......................................... 289
Hooks
Cargo hooks.......................... 261
Grocery bag hooks................ 257
Horn .......................................... 125FG
H

442 Alphabetical index
Noise from under vehicle ..........18
Odometer .................................. 126
Oil
Engine oil .............................. 296
Opener
Fuel filler door .........................61
Hood...................................... 289
Outside rear view mirrors
Adjusting and folding ...............54
Outside temperature
display .................................... 126
Overheating, Engine ................391
Parking brake ........................... 124
Parking lights
Replacing light bulb ............... 337
Switch.................................... 132
Wattage ................................. 411
Personal lights
Switch............................ 240, 241
Wattage ................................. 411
Power outlet ............................. 255
Power windows ..........................56Radiator .................................... 301
Radio ......................................... 178
Rear seats
Folding down........................... 41
Rear side marker lights
Replacing light bulb............... 337
Switch ................................... 132
Wattage................................. 411
Rear turn signal lights
Replacing light bulbs ............. 337
Switch ................................... 123
Wattage................................. 411
Rear view mirror
Compass ............................... 268
Rear window defogger ............ 174
Rear window wiper .................. 138
Replacing
Fuses .................................... 328
Key battery ............................ 325
Light bulbs............................. 337
Tires ...................................... 369
Reporting safety defects for
U.S.A. owners ........................ 432N
O
P
R