check engine light TOYOTA MR2 SPYDER 2003 W30 / 3.G User Guide

1942003 MR2 from Aug. ’03 Prod. (OM17511U)
Power steering fluid level
Check the level through the reservoir. The
level should be in the “HOT” or “COLD”
range depending on the fluid temperature.
See page 210 in Section 72 for addition-
al information.
Exhaust system
If you notice any change in the sound of
the exhaust or smell exhaust fumes, have
the cause located and corrected immedi-
ately. (See “Engine exhaust cautions” on
page 133 in Section 2.)
INSIDE THE VEHICLE
Items listed below should be checked
regularly, e.g. while performing periodic
services, cleaning the vehicle, etc.
Lights
Make sure the headlights, stop lights, tail
lights, turn signal lights, and other lights
are all working. Check headlight aim.
Service reminder indicators and warning
buzzers
Check that all service reminder indicators
and warning buzzers function properly.
Steering wheel
Be alert for changes in steering condition,
such as hard steering or strange noise.Seats
Check that all seat controls such as seat
adjusters, seatback recliner, etc. operate
smoothly and that all latches lock securely
in any position. Check that the latches
lock securely.
Seat belts
Check that the seat belt system such as
buckles and retractors operate properly
and smoothly. Make sure the belt webbing
is not cut, frayed, worn or damaged.
Accelerator pedal
Check the pedal for smooth operation and
uneven pedal effort or catching.
Clutch pedal
Check the pedal for smooth operation.
Brake pedal
Check the pedal for smooth operation and
that the pedal has the proper clearance.
Check the brake booster function.
Brakes
At a safe place, check that the brakes do
not pull to one side when applied.
Parking brake
Check that the lever has the proper travel
and that, on a safe incline, your vehicle
is held securely with only the parking
brake applied.OUTSIDE THE VEHICLE
Items listed below should be performed
from time to time, unless otherwise
specified.
Fluid leaks
Check underneath for leaking fuel, oil, wa-
ter or other fluid after the vehicle has
been parked for a while. If you smell fuel
fumes or notice any leak, have the cause
found and corrected immediately.
Doors and trunk lid
Check that both the doors operate
smoothly and all latches lock securely.
Make sure the trunk lid secondary latch
secures the lid from opening when the
primary latch is released.
Tire pressure
Check the pressure with a gauge ev-
ery two weeks, or at least once a
month. See page 211 in Section 72
for additional information.
Tire surface and wheel nuts
Check the tires carefully for cuts,
damage or excessive wear. See page
213 in Section 72 for additional infor-
mation. When checking the tires,
make sure no nuts are missing, and
check the nuts for looseness. Tighten
them if necessary.
03 07.07

2032003 MR2 from Aug. ’03 Prod. (OM17511U)
Parts and tools
Here is a list of parts and tools you will
need to perform doityourself mainte-
nance. Remember all Toyota parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
“Toyota Genuine Motor Oil” or equiva-
lent
See page 206 in Section 72 for de-
tails about engine oil selection.
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT
LEVEL
Parts (if level is low):
“Toyota Super Long Life Coolant” or
similar high quality ethylene glycol
based nonsilicate, nonamine, nonni-
trite, and nonborate coolant with long
life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is
premixed with 50% coolant and 50%
deionized water.
Tools:
Funnel (only for adding coolant) CHECKING BRAKE FLUID
Parts (if level is low):
SAE J1703 or FMVSS No.116 DOT 3
brake fluid
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING POWER STEERING FLUID
Parts (if level is low):
Toyota P.S fluid EH or equivalent
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING BATTERY CONDITION
Tools:
Warm water
Baking soda
Grease
Conventional wrench (for terminal
clamp bolts)
CHECKING AND REPLACING FUSES
Parts (if replacement is necessary):
Genuine Toyota fuse or equivalent with
same amperage rating as original ADDING WASHER FLUID
Parts:
Water
Washer fluid containing antifreeze
(for winter use)
Tools:
Funnel
REPLACING LIGHT BULBS
Parts:
Bulb with same number and wattage
rating as original (See charts in
“Replacing light bulbs—” on page 226
in Section 73.)
Tools:
Screwdriver
03 07.07

2062003 MR2 from Aug. ’03 Prod. (OM17511U)
Checking the engine oil level
SB72010
Low levelFull level
Add oil O.K.
To o f u l l
With the engine at operating tempera-
ture and turned off, check the oil level
on the dipstick.
1. To get a true reading, the vehicle should be on a level ground. After turn-
ing off the engine, wait a few minutes
for the oil to drain back into the bottom
of the engine.
2. Pull the dipstick out, hold a rag under the end and wipe it clean.
3. Reinsert the dipstick—push it in as far as it will go, or the reading will not be
correct.
4. Pull the dipstick out and look at the oil level while holding a rag under the
end.
CAUTION
Be careful not to touch the hot ex-
haust manifold.
NOTICE
Be careful not to drop the engine oil
on the vehicle components.
If the oil level is below or only slightly
above the low level, add engine oil of
the same type as already in the engine.
Remove the oil filler cap and add engine
oil in small quantities at a time, checking
the dipstick. We recommend that you use
a funnel when adding oil.
The approximate quantity of oil needed to
fill between the low level and the full level
on the dipstick is indicated below for ref-
erence.
When the level reaches within the correct
range, install the f iller cap handtight.
Oil quantity, L (qt., lmp. qt.): 1.3 (1.4, 1.1)
NOTICE
 Be careful not to spill the engine
oil on the vehicle components.
 Avoid overfilling, or the engine
could be damaged.
 Check the oil level on the dipstick
once again after adding the oil.
ENGINE OIL SELECTION
“Toyota Genuine Motor Oil” is f illed in
your Toyota vehicle. Use Toyota approved
“Toyota Genuine Motor Oil” or equivalent
to satisfy the following grade and viscos-
ity.
Oil grade:
API grade SL “EnergyConserving” or
ILSAC multigrade engine oil.
03 07.07

2092003 MR2 from Aug. ’03 Prod. (OM17511U)
Z72109
Toyota recommends “Toyota Super Long
Life Coolant” which has been tested to
ensure that it will not cause corrosion nor
result in malfunction of your engine
coolant system with proper usage. “Toyota
Super Long Life Coolant” is formulated
with longlife hybrid organic acid
technology and has been specifically
designed to avoid engine cooling system
malfunction on Toyota vehicles.
Please contact your Toyota dealer for
further details.If any of the above parts are extremely
dirty or you are not sure of their condi-
tion, take your vehicle to a Toyota dealer.
CAUTION
To prevent burning yourself, be care-
ful not to touch the radiator or con-
denser when the engine is hot.
NOTICE
To prevent damage to the radiator
and condenser, do not perform the
work by yourself.
Checking brake fluid
SB72015
To check the fluid level, simply look at
the seethrough reservoir. The level
should be between the “MAX” and
“MIN” lines on the reservoir.
It is normal for the brake fluid level to go
down slightly as the brake pads wear. So
be sure to keep the reservoir filled.
If the reservoir needs frequent ref
illing, it
may indicate a serious mechanical prob-
lem.
03 07.07
Checking the radiator and
condenser

2102003 MR2 from Aug. ’03 Prod. (OM17511U)
If the level is low, add SAE J1703 or
FMVSS No.116 DOT 3 brake fluid to the
brake reservoir.
Remove and replace the reservoir cap by
hand. Fill the brake fluid to the dotted
line. This brings the fluid to the correct
level when you put the cap back on.
Use only newly opened brake fluid. Once
opened, brake fluid absorbs moisture from
the air, and excess moisture can cause a
dangerous loss of braking.
CAUTION
Take care when filling the reservoir
because brake fluid can harm your
eyes and damage painted surfaces. If
fluid gets in your eyes, flush your
eyes with clean water immediately. If
you still feel uncomfortable with your
eyes, go to the doctor.
NOTICE
If you spill the fluid, be sure to wash
it off with water to prevent it from
damaging the parts or paint.
SB72002
Open
Close
If hot add
If cold addIf hot
O.K.
If cold
O.K.
Check the fluid level through the reser-
voir. If necessary, add Toyota P.S fluid
EH or equivalent.
Before checking the power steering
fluid, remove the cover inside the
trunk. (See “Replacing light bulbs” on
page 226 in Section 73.)
If the vehicle has been driven around 80
km/h (50 mph) for 20 minutes (a little
more in frigid temperatures), the fluid is
hot (60
°C—80 °C or 140 °F—175 °F). You
may also check the level when the fluid
is cold (about room temperature,
10 °C—30 °C or 50 °F—85 °F) if the engine
has not been run for about five hours. Clean all dirt from outside of the reservoir
tank and look at the fluid level. If the fluid
is cold, the level should be in the “COLD”
range. Similarly, if it is hot, the fluid level
should be in the “HOT” range. If the level
is at the low side of either range, add
Toyota P.S fluid EH or equivalent to bring
the level within the range.
To remove the reservoir cap, turn it coun-
terclockwise and lift up. To reinstall it,
turn it clockwise. After replacing the reser-
voir cap, visually check the steering box
case, vane pump and hose connections
for leaks or damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.
NOTICE
Avoid overfilling, or the power steer-
ing could be damaged.
03 07.07
Checking power steering fluid

2232003 MR2 from Aug. ’03 Prod. (OM17511U)
NOTICE
Be sure the engine and all accesso-
ries are off before performing main-
tenance.
 When checking the battery, remove
the ground cable from the negative
terminal (“” mark) first and rein-
stall it last.
 Be careful not to cause a short cir-
cuit with tools.
 Take care no solution gets into the
battery when washing it.
—Checking battery c ondition
Z73001
Ty p e A
Ty p e BGreen Dark
Clear or
light yellow
Blue White Red
CHECKING BY INDICATOR
Check the battery condition by the indi-
cator color. Indicator color
ConditionTy p e ATy p e B
GreenBlueGood
DarkWhite
Charging
necessary. Have
battery checked
by your Toyota
dealer.
Clear orlight
yellow
Red
Have battery
checked by your
Toyota dealer.
Battery recharging precautions
During recharging, the battery is pro-
ducing hydrogen gas.
Therefore, before recharging:
1. If recharging with the battery installed on the vehicle, be sure to disconnect
the ground cable.
2. Be sure the power switch on the re- charger is off when connecting the
charger cables to the battery and when
disconnecting them.
CAUTION
Always charge the battery in an un-
confined area. Do not charge the
battery in a garage or closed room
where there is not sufficient ventila-
tion.
Only do a slow charge (5 A or
less). Charging at a quicker rate is
dangerous. The battery may explode
causing personal injuries.
NOTICE
Never recharge the battery while the
engine is running. Also, be sure all
accessories are turned off.
03 07.07

2482003 MR2 from Aug. ’03 Prod. (OM17511U)
A
Adding washer fluid225
. . . . . . . . . . . . . . . .
Adjustment
Seats 30
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 31
. . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 113
. . . . . . . . . . . . .
Airbags 37
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 219 . . . . . . . .
Antiglare inside rear view mirror 66 . . . . .
Antilock brake system warning light 77
. . . . . . . . . . . . . . . . . . . . . .
Antitheft steering column lock 84 . . . . . . .
Appearance care Cleaning the interior 188
. . . . . . . . . . . . . .
Protecting your Toyota from
corrosion 184
. . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 185
. . . . . . . . . . . . . .
Auxiliary box 124
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Trunk lid 15
. . . . . . . . . . . . .
B
Battery
Checking battery condition 222 . . . . . . . .
Gas caution 222 . . . . . . . . . . . . . . . . . . . . .
Handling safety 222 . . . . . . . . . . . . . . . . . .
Recharging precautions 223 . . . . . . . . . . .
Winter driving tips 156 . . . . . . . . . . . . . . . .
Before starting the engine 154 . . . . . . . . . . .
Brake pad wear limit indicators 138 . . . . . .
Brake system 135 . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 77 . . . . . . . . . . Brakes
Fluid level 209 . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 138 . . . . . . . . . .
Parking 97 . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 130 . . . . . . . . . . . . . . . . . . . . . .
Brightness control 70 . . . . . . . . . . . . . . . . . . .
C
Car audio system 101
. . . . . . . . . . . . . . . . . .
Carbon monoxide caution 133
. . . . . . . . . . .
Cargo and luggage Capacity 149
. . . . . . . . . . . . . . . . . . . . . . . .
Distribution 150
. . . . . . . . . . . . . . . . . . . . . .
Stowage precautions 149
. . . . . . . . . . . . .
Cassette player 102
. . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 224 . . . . . . . .
Checking and replacing tires 213 . . . . . . . .
Checking brake fluid 209
. . . . . . . . . . . . . . . .
Checking the engine oil level 206 . . . . . . . .
Checking power steering fluid 210 . . . . . . .
Child restraint Child restraint system 47
. . . . . . . . . . . . .
Installation with seat belt 49
. . . . . . . . . . .
Precautions 46
. . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 48 . . . . . .
Cigarette lighter and ashtray 122
. . . . . . . . .
Cleaning the interior 188
. . . . . . . . . . . . . . . .
Clock 122
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather operation 156
. . . . . . . . . . . . .
Compact disc player 102
. . . . . . . . . . . . . . . .
Cooling system Coolant level 208
. . . . . . . . . . . . . . . . . . . . Engine overheating
166
. . . . . . . . . . . . . . .
Radiator and condenser 209
. . . . . . . . . . .
Radiator and reservoir 208
. . . . . . . . . . . .
Radiator cap 166
. . . . . . . . . . . . . . . . . . . . .
Winter driving tips 156
. . . . . . . . . . . . . . . .
Corrosion prevention 184
. . . . . . . . . . . . . . .
Cruise control 98
. . . . . . . . . . . . . . . . . . . . . .
Cup holders 127
. . . . . . . . . . . . . . . . . . . . . . . D
Defogger, Rear window 71
. . . . . . . . . . . . . .
Dimensions and weight 238
. . . . . . . . . . . . .
Dimmer switch, Headlight 68
. . . . . . . . . . . .
Dinghy towing 157
. . . . . . . . . . . . . . . . . . . . .
Directional signals 68
. . . . . . . . . . . . . . . . . .
Discharge warning light 77
. . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 203
. . . . . . . . . . . . . . . . . . .
Service precautions 201
. . . . . . . . . . . . . .
Does your vehicle need
repairing? 195
. . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt light 77
. . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 77 . . . . .
Driving Driving tips 155,156
. . . . . . . . . . . . . . . . . .
Manual transmission 96
. . . . . . . . . . . . . .
Sequential manual transmission 85 . . . .
Driving tips Driving tips in various
conditions 155
. . . . . . . . . . . . . . . . . . . . .
Driving with a manual transmission 96
. . . . . . . . . . . . . . . . . . . .
03 07.07

2492003 MR2 from Aug. ’03 Prod. (OM17511U)
Economical driving158
. . . . . . . . . . . . . . .
Good driving practice 96
. . . . . . . . . . . . . .
Winter driving tips 156
. . . . . . . . . . . . . . . .
During
Breakin 130
. . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel
and repairs 158 . . . . . . . . . . . . . . . . . . . .
Electrical system Battery 222,223 . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 200 . . . . . . . . . . . . . . . . . . .
Fuses 224 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 69 . . . . . . . . . . . .
Emergency, In case of Blown fuse 224 . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 69 . . . . . . . . . .
Flat tire 167 . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot increase the
engine speed 166 . . . . . . . . . . . . . . . . . .
If you cannot shift the sequential manual transmission
selector lever 181 . . . . . . . . . . . . . . . . . .
If you lose your keys 182 . . . . . . . . . . . . . .
If your engine stalls
while driving 165 . . . . . . . . . . . . . . . . . . .
If your vehicle needs to be towed 177 . . . . . . . . . . . . . . . . . . . .
If your vehicle will not start 162 . . . . . . . .
Jump starting 163 . . . . . . . . . . . . . . . . . . . .
Overheating 166 . . . . . . . . . . . . . . . . . . . . . Towing 177
. . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and Maintenance (I/M) programs 195 . . . . . . .
Engine
Before starting the engine 154 . . . . . . . . .
Checking the coolant level 208 . . . . . . . .
Emission control device 132 . . . . . . . . . . .
Engine compartment 198 . . . . . . . . . . . . . .
Exhaust gas caution 133 . . . . . . . . . . . . . .
Hood release 16 . . . . . . . . . . . . . . . . . . . . .
Identification Number 139 . . . . . . . . . . . . . . . . . . . . . . .
Oil consumption 134 . . . . . . . . . . . . . . . . . .
Oil level 206 . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 166 . . . . . . . . . . . . . . . . . . . . .
Starting procedure 154 . . . . . . . . . . . . . . .
Threeway catalytic converter 132 . . . . .
Engine coolant Temperature gauge 74 . . . . . . . . . . . . . . . .
Winter driving tips 156 . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 74 . . . .
Engine immobilizer system 10 . . . . . . . . . . .
Engine oil Winter driving tips 156 . . . . . . . . . . . . . . . .
Exhaust gas cautions 133 . . . . . . . . . . . . . . .
F
Facts about engine oil
consumption 134 . . . . . . . . . . . . . . . . . . . . .
Flasher, Headlight 68 . . . . . . . . . . . . . . . . . . .
Flat tire After changing wheels 175 . . . . . . . . . . . . Changing tire 173
. . . . . . . . . . . . . . . . . . . .
If you have a flat tire 167 . . . . . . . . . . . . . .
Jack point 172 . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 167 . . . . . . . . . . . . . .
Jacking up 172 . . . . . . . . . . . . . . . . . . . . . .
Loosening wheel nuts 171 . . . . . . . . . . . . .
Lowering vehicle 174 . . . . . . . . . . . . . . . . .
Wheel block 171 . . . . . . . . . . . . . . . . . . . . .
Wheel nuts 173 . . . . . . . . . . . . . . . . . . . . . .
Floor mat 128 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid level Brake 209 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 210 . . . . . . . . . . . . . . . . . . .
Washer fluid 225 . . . . . . . . . . . . . . . . . . . . .
Foreign countries, Operation in 132 . . . . . .
Front box 123 . . . . . . . . . . . . . . . . . . . . . . . . . .
Front fog light switch 70 . . . . . . . . . . . . . . . .
Fuel Filler door o pener 18. . . . . . . . . . . . . . . . .
Fuel economy 158 . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 132 . . . . . . . . .
Gauge 74 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 132 . . . . .
Tank cap 18 . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 130 . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 132 . . . . . . . . . .
Fuses Fuse box 199 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 200 . . . . . . . . . . . . . . . . . . . . .
03 07.07