Check hybrid system TOYOTA PRIUS 2010 3.G Owners Manual

1
2
3
4
5
6
7
5
PRIUS_U (OM47668U) U.S.A.
4-1. Maintenance and careCleaning and protecting 
the vehicle’s exterior ......... 404
Cleaning and protecting 
the vehicle’s interior .......... 407
4-2. Maintenance Maintenance 
requirements ..................... 410
General maintenance.......... 412
Emission inspection 
and maintenance (I/M) 
programs........................... 415
4-3. Do-it-yourself maintenance Do-it-yourself service 
precautions ....................... 416
Hood ................................... 420
Positioning a floor jack ........ 423
Engine compartment ........... 425
12 volt battery ..................... 436
Tires .................................... 441
Tire inflation pressure ......... 451
Wheels ................................ 455
Air conditioning filter............ 457
Electronic key battery.......... 460
Checking and replacing 
fuses ................................. 462
Light bulbs........................... 472 5-1. Essential information
Emergency flashers............ 486
If your vehicle needs 
to be towed....................... 487
If you think something is  wrong ............................... 493
Event data recorder ............ 494
5-2. Steps to take in an emergency If a warning light turns 
on or a warning buzzer 
sounds.............................. 496
If a warning message is 
displayed .......................... 508
If you have a flat tire ........... 524
If the hybrid system 
will not start ...................... 538
If you lose your keys........... 540
If the electronic key does 
not operate properly ......... 541
If the 12 volt battery is 
discharged........................ 543
If your vehicle overheats .... 548
If the vehicle becomes 
stuck ................................. 553
4Maintenance and care5When trouble arises

22
PRIUS_U (OM47668U) U.S.A.
For your information
Main Owner’s Manual
Please note that this manual applies to all models and explains all equip-
ment, including options. Therefore, you may find some explanations for
equipment not installed on your vehicle.
All specifications provided in this manual are current at the time of printing.
However, because of the Toyota policy of continual product improvement, we
reserve the right to make changes at any time without notice.
Depending on specifications, the vehicle shown in the illustration may differ
from your vehicle in terms of equipment.
Noise from under vehicle after turning off the hybrid system
Approximately five hours after the hybrid system is turned off, you may hear
sound coming from under the vehicle for several minutes. This is the sound
of a fuel evaporation leakage check and, it does not indicate a malfunct\
ion.
Accessories, spare parts and modification of your Toyota
A wide variety of non-genuine spare parts and accessories for Toyota vehi-
cles are currently available in the market. You should know that Toyota does
not warrant these products and is not responsible for their performance,
repair, or replacement, or for any damage they may cause to, or adverse
effect they may have on, your Toyota vehicle.
This vehicle should not be modified with non-genuine Toyota products. Mod-
ification with non-genuine Toyota products could affect its performance,
safety or durability, and may even violate governmental regulations. In addi-
tion, damage or performance problems resulting from the modification may
not be covered under warranty.

23
PRIUS_U (OM47668U) U.S.A.
Installation of a mobile two-way radio system
As the installation of a mobile two-way radio system in your vehicle could
affect electronic systems such as the multiport fuel injection system/sequen-
tial multiport fuel injection system, cruise control system, anti-lock brake sys-
tem, vehicle stability control system, SRS airbag system, seat belt
pretensioner system or hybrid system, be sure to check with your Toyota
dealer for precautionary measures or special instructions regarding installa-
tion.
High voltage parts and cables on the hybrid vehicles emit approximately the
same amount of electromagnetic waves as the conventional gasoline pow-
ered vehicles or home electronic appliances despite of their electromagnetic
shielding.
Unwanted noise may occur in the reception of the mobile two-way radio.
Scrapping of your Toyota
The SRS airbag and seat belt pretensioner devices in your Toyota contain
explosive chemicals. If the vehicle is scrapped with the airbags and seat belt
pretensioners left as they are, this may cause an accident such as fire. Be
sure to have the systems of the SRS airbag and seat belt pretensioner
removed and disposed of by a qualified service shop or by your Toyota
dealer before you scrap your vehicle.
Perchlorate Material
Special handling may apply, 
See www.dtsc.ca.gov/hazardouswaste/perchlorate.
Your vehicle has components that may contain perchlorate. These compo-
nents may include airbag, seat belt pretensioners, and wireless remote con-
trol batteries.

35
1-1. Hybrid system
1
Before driving
PRIUS_U (OM47668U) U.S.A.
●
When the desired speed is reached
Release the accelerator pedal
once. Then, depress the acceler-
ator pedal slowly and drive at a
constant speed, keeping the indi-
cator bar within the Eco area.
When aiming to improve fuel
economy, try to drive within the
Hybrid Eco area. By doing so,
the drive force of the electric
motor (traction motor) will often
be used alone without the need
for fuel consumption, thus allow-
ing you to enjoy driving with
improved fuel economy.
■ Checking fuel consumption
The 5-minute/1-minute interval
fuel consumption display shows
the average fuel consumption
and the regenerated energy
amount in 5-minute or 1-minute
intervals. (P. 194)
Hybrid Eco area

38 1-1. Hybrid system
PRIUS_U (OM47668U) U.S.A.
CAUTION
■High voltage precautions
The vehicle has high voltage DC and AC systems as well as a 12 volt sys-
tem. DC and AC high voltage is very dangerous and can cause severe burns
and electric shock that may result in death or serious injury.
● Never touch, disassemble, remove or replace the high voltage parts,
cables and their connectors.
● The hybrid system will become hot after starting as the system uses high
voltage. Be careful of both the high voltage and the high temperature, and
always obey the caution labels attached to the vehicle.
■ Hybrid battery (traction battery)
Your vehicle contains a sealed nickel- metal hydride battery. If disposed of
improperly, it is hazardous to the environment and there is a risk of severe
burns and electrical shock that may result in death or serious injury.
■ Emergency shut off system
● Carefully check to see if there are exposed high voltage parts or cables.
Never touch the parts or cables. (
P. 32)
● Carefully inspect the ground under the vehicle. If you find that liquid has
leaked onto the ground, the fuel system may have been damaged. Leave
the vehicle as soon as possible.
●Never try to open the service plug
access hole located in the luggage
compartment. The service plug is used
only when the vehicle is serviced and is
subject to high voltage.
● Do not subject the service plug to
strong impacts. Also, avoid splashing
large amount of water onto the luggage
compartment, for example while in a
high-pressure car wash.

155
2-1. Driving procedures
2
When driving
PRIUS_U (OM47668U) U.S.A.
CAUTION
●
Do not let the vehicle roll backwards while the shift lever is in a driving
position, or roll forward while the shift lever is in “R”. 
Doing so may cause the hybrid system not to operate or lead to poor
brake and steering performance, resulting in an accident or damage to th\
e
vehicle.
● If the smell of exhaust is noticed inside the vehicle, open the windows and
check that the back door is closed. Large amounts of exhaust in the vehi-
cle can cause driver drowsiness and an accident, resulting in death or a
serious health hazard. Have the vehicle inspected by your Toyota dealer
immediately.
● Do not shift the shift position to "P" while the vehicle is moving. 
Doing so can damage the transmission and may result in a loss of vehicle\

control.
● Do not shift the shift position to "R" while the vehicle is moving forward. 
Doing so can damage the transmission and may result in a loss of vehicle\

control.
● Do not shift the shift position to "D" while the vehicle is moving backward. 
Doing so can damage the transmission and may result in a loss of vehicle\

control.
● Moving the shift position to "N" while the vehicle is moving will disengage
the hybrid system. Engine braking is not available with the hybrid system
disengaged.
● During normal driving, do not turn off the hybrid system. Turning the hybrid
system off while driving will not cause loss of steering or braking control,
but the power assist to these systems will be lost. This will make it more
difficult to steer and brake, so you should pull over and stop the vehicle as
soon as it is safe to do so. 
However, in the event of an emergency, such as if it becomes impossible
to stop the vehicle in the normal way: P. 496
● Use engine braking (“B”) to maintain a safe speed when driving down a
steep hill. 
Using the brakes continuously may cause the brakes to overheat and lose
effectiveness. ( P. 173)

157
2-1. Driving procedures
2
When driving
PRIUS_U (OM47668U) U.S.A.
CAUTION
■
When the vehicle is stopped
● Do not race the hybrid system. 
If the vehicle is in any shift position other than “P” or “N” the vehicle may
accelerate suddenly and unexpectedly, and may cause an accident.
● Do not leave the vehicle with the hybrid system on for a long time. 
If such a situation cannot be avoided, park the vehicle in an open space
and check that exhaust fumes do not enter the vehicle interior.
● Always keep a foot on the brake pedal while the hybrid system is operating
to prevent an accident caused by the vehicle moving.
■ When the vehicle is parked
● Do not leave glasses, cigarette lighters, spray cans, or soft drink cans in
the vehicle when it is in the sun. 
Doing so may result in the following:
• Gas may leak from a cigarette lighter or spray can, and may lead to a fire.
• The temperature inside the vehicle may cause the plastic lenses and plastic material of eye glasses to deform or crack.
• Soft drink cans may fracture, causing the contents to spray over the interior of the vehicle, and may also cause a short circuit in the vehi-
cle’s electrical components.
● Always apply the parking brake, push the “P” position switch, stop the
hybrid system and lock the vehicle. 
Do not leave the vehicle unattended while the hybrid system is operating.

158 2-1. Driving procedures
PRIUS_U (OM47668U) U.S.A.
CAUTION
●Do not touch the exhaust pipe while the hybrid system is operating or
immediately after turning the hybrid system off. 
Doing so may cause burns.
● Do not leave the hybrid system operating in an area with snow build-up, or
where it is snowing. If snowbanks build up around the vehicle while the
hybrid system is operating, exhaust gases may collect and enter the vehi-
cle. This may lead to death or a serious health hazard.
■ Exhaust gases
Exhaust gases include harmful carbon monoxide (CO) that is colorless and
odorless. Inhaling exhaust gases may lead to death or a serious health haz-
ard.
● If the vehicle is in a poorly ventilated area, stop the hybrid system. In a
closed area, such as a garage, exhaust gases may collect and enter the
vehicle. This may lead to death or a serious health hazard.
● The exhaust should be checked occasionally. If there is a hole or crack
caused by corrosion, damage to a joint or abnormal exhaust noise, be
sure to have the vehicle inspected and repaired by your Toyota dealer.
Failure to do so may allow exhaust gases to enter the vehicle, resulting in
death or a serious health hazard.

161
2-1. Driving procedures
2
When driving
PRIUS_U (OM47668U) U.S.A.
NOTICE
■
If you get a flat tire while driving
A flat or damaged tire may cause the following situations. Hold the steering
wheel firmly and gradually press the brake pedal to slow down the vehicle.
● It may be difficult to control your vehicle.
● The vehicle will make abnormal sounds.
● The vehicle will behave abnormally.
Replace a flat tire with a new one. ( P. 527)
■ When encountering flooded roads
Do not drive on a road that has flooded after heavy rain etc. Doing so may
cause the following serious damage to the vehicle.
● Engine stalling
● Short in electrical components
● Engine damage caused by water immersion
In the event that you drive on a flooded road and the vehicle is flooded, be
sure to have your Toyota dealer check the following.
● Brake function
● Changes in quantity and quality of oil and fluid used for the engine, hybrid
system, transmission, etc.
● Lubricant condition for the bearings and suspension joints (where possi-
ble) and the function of all joints, bearings, etc.

162
2-1. Driving procedures
PRIUS_U (OM47668U) U.S.A.
Power (ignition) switch
Performing the following operations when carrying the electronic
key on your person starts the hybr id system or changes “POWER”
switch modes.
■ Starting the hybrid system
Check that the parking brake is set.
Sit in the driver’s seat and firmly depress the brake pedal.
The “POWER” switch indicator turns green.
Press the “POWER” switch.
The hybrid system can be
started from any mode.
After a few seconds, the
“READY” indicator comes on
with a beep sound.
The vehicle can move when
the “READY” indicator is on,
even if the engine is stopped.
STEP1
STEP2
ITO21P112
STEP3