charging TOYOTA PRIUS 2015 4.G User Guide

441
4-3. Do-it-yourself maintenance
PRIUS_OM_OM47A17U_DVD_(U)
4
Maintenance and care
■
Before recharging
When recharging, the 12-volt battery produces hydrogen gas which is flam-
mable and explosive. Therefore, observe the following precautions before
recharging:
●If recharging with the 12-volt battery installed on the vehicle, be sure to
disconnect the ground cable.
● Make sure the power switch on the charger is off when connecting and
disconnecting the charger cables to the 12-volt battery.
■ Exterior
Make sure that the 12-volt battery terminals are not corroded
and that there are no loose c onnections, cracks, or loose
clamps.
Terminals
Hold-down clamp

442 4-3. Do-it-yourself maintenance
PRIUS_OM_OM47A17U_DVD_(U)
■After recharging/reconnecting the 12-volt battery
●Unlocking the doors using the smart key system may not be possible
immediately after reconnecting the 12-volt battery. If this happens, use
the wireless remote control or the mechanical key to lock/unlock the
doors.
● Start the hybrid system with the “POWER” switch in ACCESSORY mode.
The hybrid system may not start with the “POWER” switch turned off.
However, the hybrid system will operate normally from the second
attempt.
● The “POWER” switch mode is recorded by the vehicle. If the 12-volt bat-
tery is reconnected, the vehicle will return the “POWER” switch mode to
the status it was in before the 12-volt battery was disconnected. Make
sure to turn off the power before disconnect the 12-volt battery. Take
extra care when connecting the 12-volt battery if the “POWER” switch
mode prior to discharge is unknown.
● Restart the hybrid system, depress the brake pedal, and confirm that it is
possible to shift into each shift position.
If the system will not start even after multiple attempts at all methods above,
contact your Toyota dealer.

445
4-3. Do-it-yourself maintenance
PRIUS_OM_OM47A17U_DVD_(U)
4
Maintenance and care
CAUTION
■
When disconnecting the 12-volt battery
NOTICE
■When recharging the 12-volt battery
Never recharge the 12-volt battery while the hybrid system is operating.
Also, be sure all accessories are turned off.
Do not disconnect the negative (-) termi-
nal on the body side as shown. The dis-
connected negative (-) terminal may
touch the positive (+) terminal, which may
cause a short and result in death or seri-
ous injury.

504 5-2. Steps to take in an emergency
PRIUS_OM_OM47A17U_DVD_(U)
Stop the vehicle immediately.The following warning indicates the possibility of damage to the vehi-
cle that may lead to an accident. Immediately stop the vehicle in a
safe place and contact your Toyota dealer.
Warning lightWarning light/Details
Charging system warning light Indicates a malfunction in the vehicle’s charging system
High coolant temperature warning light Indicates that the coolant temperature is too high
Changes from a flashing to a solid light when the engine
coolant temperature increases.

530 5-2. Steps to take in an emergency
PRIUS_OM_OM47A17U_DVD_(U)
Have the malfunction repaired immediately.If any of the following warnings is displayed when a hybrid system
start operation is performed, perform the appropriate action accord-
ing to the warning message display.
Warning messageDetailsCorrection procedure
Indicates an insufficient 12-volt
battery charge. A buzzer also sounds.
• The parking lock mechanism may not function.
• The hybrid system may not be able to start.
• It may not be possible to turn the “POWER” switch off.
If this happens, applying the
parking brake will enable the
switch to be turned off. When parking, park
the vehicle on a flat
surface and apply
the parking brake
securely.
Charge or replace
the 12-volt battery.
After charging the
12-volt battery, the
message may con-
tinue to be dis-
played until the
shift position is
changed from P.

558 5-2. Steps to take in an emergency
PRIUS_OM_OM47A17U_DVD_(U)
■Starting the hybrid system when the 12-volt battery is discharged
The hybrid system cannot be started by push-starting.
■ To prevent 12-volt battery discharge
●Turn off the headlights and the audio system while the hybrid system is
off.
● Turn off any unnecessary electrical components when the vehicle is run-
ning at a low speed for an extended period, such as in heavy traffic.
■ When the 12-volt battery is removed or discharged
●The hybrid system may not start. ( P. 442)
● If the 12-volt battery is depleted with the shift position in P, it will not be
possible to shift the shift position other than P. In this case, the vehicle
cannot be towed without lifting both front wheels because the front
wheels are locked by the parking lock. ( P. 495)
● When the 12-volt battery is reconnected, start the hybrid system, depress
the brake pedal, and confirm that it is possible to shift into each shift posi-
tion.
■ Charging the 12-volt battery
The electricity stored in the 12-volt battery will discharge gradually even
when the vehicle is not in use, due to natural discharge and the draining
effects of certain electrical appliances. If the vehicle is left for a long time, the
12-volt battery may discharge, and the hybrid system may be unable to start.
(The 12-volt battery recharges automatically while the hybrid system is oper-
ating.)

560 5-2. Steps to take in an emergency
PRIUS_OM_OM47A17U_DVD_(U)
CAUTION
■After recharging the 12-volt battery
Have the 12-volt battery inspected at your Toyota dealer as soon as possi-
ble.
If the 12-volt battery is deteriorating, continued use may cause the 12-volt
battery to emit a malodorous gas, which may be detrimental to the health of
passengers.
■ When replacing the 12-volt battery
P. 444
NOTICE
■When handling jumper cables
When connecting the jumper cables, ensure that they do not become entan-
gled in the cooling fans, etc.
■ Exclusive jump starting terminal
The exclusive jump starting terminal is to be used when charging the 12-volt
battery from another vehicle in an emergency. It cannot be used to jump start
another vehicle.

579
6-1. Specifications
6
Vehicle specifications
PRIUS_OM_OM47A17U_DVD_(U)
Electrical system
*1: Voltage is checked 30 seconds after the hybrid system and all lights are
turned off.
Transmission
*2: The fluid capacity is the quantity of reference.If replacement is necessary, contact your Toyota dealer.
12-volt batteryFully charged12.5 V or over
Open voltage*1
at 68°F (20°C):Half charged 11.0  12.5 V
Discharged Under 11.0 V
Charging rates 5 A max.
Fluid capacity*23.6 qt. (3.4 L, 3.0 Imp.qt.)
Fluid type Toyota Genuine ATF WS
NOTICE
■Transmission fluid type
Using transmission fluid other than “Toyota Genuine ATF WS” may cause
deterioration in shift quality, locking up of your transmission accompanied by
vibration, and ultimately damage the transmission of your vehicle.

639
Alphabetical index
PRIUS_OM_OM47A17U_DVD_(U)
Tonneau cover......................... 384
Tools......................................... 537
Touch tracer display ............... 218
Total load capacity .................. 322
Towing
Dinghy towing ....................... 329
Emergency towing ................ 498
Trailer towing ........................ 328
TRAC ........................................ 301
Traction control ....................... 301
Trailer towing........................... 328
Transmission
Hybrid transmission .............. 205
P position switch................... 208
Trip information....................... 232
Trip meter................................. 231
Turn signal lights Replacing light bulbs ............ 478
Switch ................................... 214
Wattage ................................ 582
USB port
*................................ 358
Vanity lights Vanity lights .......................... 371
Wattage ................................ 582
Vanity mirrors .......................... 371
Vehicle data recordings............ 24
Vehicle identification number................................... 573
Vehicle proximity notification system ..................................... 34
Vehicle stability control .......... 301
VSC ........................................... 301 Warning buzzers
Brake system ........................503
Open door ............................508
Seat belt reminder .................508
Warning lights Anti-lock brake system
(ABS) ..................................505
Automatic headlight leveling system ................................507
Brake system ................503, 506
Charging system .... ...............504
Cruise control ........................507
Electric power steering
system ................................505
High coolant temperature ......504
Hybrid system .......................505
Low fuel level ........................508
Low tire pressure...................509
Malfunction indicator lamp ....505
Open door .............................508
Pre-collision system ..............506
Radar cruise control. .............507
Seat belt warning light ...........508
Slip indicator..........................506
SRS airbags ..........................505
Tire pressure warning light ....509U
V
W
GW Refer to

642 What to do if...
PRIUS_OM_OM47A17U_DVD_(U)
■Warning lights
P. 509
or
P. 505
or
P. 503P. 505
P. 504P. 506
P. 504P. 506
P. 506
or
P. 505P. 507
P. 505P. 507
Master warning light ABS warning light
Brake system warning
light (red indicatorF
Electric power steering
system warning light
Charging system
warning lightPre-collision system
warning light
G
High coolant
temperature warning
light
Slip indicator light
Brake system warning
light (yellow indicator)
Malfunction indicator
lamp
Automatic headlight
leveling system
warning light
SRS warning lightCruise control indicator
light
G