overheating TOYOTA PRIUS V 2012 Owners Manual (in English)

39
1-1. Hybrid system
1
Before driving
PRIUS v_U (OM47674U)
NOTICE
■
Hybrid battery (traction battery) air vent
● Do not put foreign objects near the air vent. The hybrid battery (traction
battery) may overheat and be damaged.
● Clean the air vent regularly to prevent the hybrid battery (traction battery)
from overheating.
● Do not wet or allow foreign substances to enter the air vent as this may
cause a short circuit and damage the hybrid battery (traction battery).
● Do not carry large amounts of water such as water cooler bottles in the
vehicle. If water spills onto the hybrid battery (traction battery), the battery
may be damaged. Have the vehicle inspected by your Toyota dealer.

170 2-1. Driving procedures
PRIUS v_U (OM47674U)
CAUTION
■Exhaust gases
Exhaust gases include harmful carbon monoxide (CO), which is colorless
and odorless. Inhaling exhaust gases may lead to death or a serious health
hazard.
● If the vehicle is in a poorly ventilated area, stop the hybrid system. In a
closed area, such as a garage, exhaust gases may collect and enter the
vehicle. This may lead to death or a serious health hazard.
● The exhaust system should be checked occasionally. If there is a hole or
crack caused by corrosion, damage to a joint or abnormal exhaust noise,
be sure to have the vehicle inspected and repaired by your Toyota dealer.
Failure to do so may allow exhaust gases to enter the vehicle, resulting in
death or a serious health hazard.
■ When taking a nap in the vehicle
Always turn the hybrid system off. Otherwise, if you accidentally move the
shift lever or depress the accelerator pedal, this could cause an accident or
fire due to hybrid system overheating. Additionally, if the vehicle is parked in
a poorly ventilated area, exhaust gases may collect and enter the vehicle,
leading to death or a serious health hazard.
■ When braking
● When the brakes are wet, drive more cautiously.
Braking distance increases when the brakes are wet, and this may cause
one side of the vehicle to brake differently than the other side. Also, the
parking brake may not securely hold the vehicle.
● If the electronically controlled assist function does not operate, do not fol-
low other vehicles closely and avoid downhill or sharp turns that require
braking.
In this case, braking is still possible, but the brake pedal should be
depressed more firmly than usual. Also, the braking distance will increase.
● The brake system consists of 2 individual hydraulic systems; if one of the
systems fails, the others will still operate. In this case, the brake pedal
should be depressed more firmly than usual and the braking distance will
increase. If this happens, do not continue to drive the vehicle. If the brake
system warning light (red indicator) comes on while driving, immediately
stop the vehicle in a safe place and contact your Toyota dealer.

193
2-1. Driving procedures
PRIUS v_U (OM47674U)
2
When driving
Parking brake
■Parking brake engaged warning buzzer
 P. 442
■ Usage in winter time
See “Winter driving tips” for parking brake usage in winter time. ( P. 271)
NOTICE
■Before driving
Fully release the parking brake.
Driving the vehicle with the parking brake set will lead to brake components
overheating, which may affect braking performance and increase brake
wear.
To set the parking brake, fully
depress the parking brake
pedal with your left foot while
depressing the brake pedal
with your right foot.
(Depressing the pedal again
releases the parking brake.)
U.S.A.
Canada

205
2-2. Instrument cluster
PRIUS v_U (OM47674U)
2
When driving
■
Engine speed
On hybrid vehicles, engine speed is precisely controlled in order to help
improve fuel efficiency and reduce exhaust emissions etc.
There are times when the engine speed that is displayed may differ even
when vehicle operation and driving conditions are the same.
■ Brightness of the instrument panel light
If the headlight switch is turned to ON while the surrounding area is dark, the
instrument panel lights will dim.
■ When disconnecting and reconnect ing 12-volt battery terminals
The average fuel consumption and cruising range will be reset.
NOTICE
■ To prevent damage to the engine and its components
The engine may be overheating if the high coolant temperature warning light
comes on or flashes. In this case, immediately stop the vehicle in a safe
place, and check the engine after it has cooled completely. ( P. 485)
■ The trip information disp lay at low temperatures
Allow the interior of the vehicle to warm up before using the liquid crystal
information display. At extremely low temperatures, the information display
monitor may respond slowly, and display changes may be delayed.

252 2-4. Using other driving systems
PRIUS v_U (OM47674U)
■Reduced effectiveness of the EPS system
The effectiveness of the EPS system is reduced to prevent the system from
overheating when there is frequent steering input over an extended period of
time. The steering wheel may feel heavy as a result. Should this occur,
refrain from excessive steering input or stop the vehicle and turn the hybrid
system off. The EPS system should return to normal within 10 minutes.
■ Electric power steering system warning light (warning buzzer)
 P. 451
CAUTION
■The ABS does not operate effectively when
● Tires with inadequate gripping ability are used (such as excessively worn
tires on a snow covered road).
● The vehicle hydroplanes while driving at high speed on wet or slick road.
■ Stopping distance when the ABS is operating may exceed that of nor-
mal conditions
The ABS is not designed to shorten the vehicle’s stopping distance. Always
maintain a safe distance from the vehicle in front of you in the following situ-
ations:
● When driving on dirt, gravel or snow-covered roads
● When driving with tire chains
● When driving over bumps in the road
● When driving over roads with potholes or uneven surfaces
■ TRAC may not operate effectively when
Directional control and power may not be achievable while driving on slip-
pery road surfaces, even if the TRAC system is operating.
Do not drive the vehicle in conditions where stability and power may be lost.
■ When the VSC is activated
The slip indicator light flashes. Always drive carefully. Reckless driving may
cause an accident. Exercise particular care when the indicator light flashes.

318 3-5. Other interior features
PRIUS v_U (OM47674U)
CAUTION
■Burns
● Use caution when seating the following persons in a seat with the seat
heater on to avoid the possibility of burns:
• Babies, small children, the elderly, the sick and the physically chal-
lenged
• Persons with sensitive skin
• Persons who are fatigued
• Persons who have taken alcohol or drugs that induce sleep (sleeping drugs, cold remedies, etc.)
● Do not cover the seat with anything when using the seat heater.
Using the seat heater with a blanket or cushion increases the temperature
of the seat and may lead to overheating.
● Do not use the seat heater more than necessary. Doing so may cause
minor burns or overheating.
NOTICE
■To prevent seat heater damage
Do not put heavy objects that have an uneven surface on the seat and do
not stick sharp objects (needles, nails, etc.) into the seat.
■ To prevent 12-volt battery discharge
Turn the seat heaters off when the hybrid system is off.

5
When trouble arises
485
5-2. Steps to take in an emergency
PRIUS v_U (OM47674U)
If your vehicle overheats
Correction procedures■ If the high coolant temperature warning light flashes or comes
on
Stop the vehicle in a safe place and turn off the air condition-
ing system.
Check to see if steam is coming out from under the hood.
If you see steam: Stop the hybrid system. Carefully lift the hood after the
steam subsides and then restart the hybrid system.
If you do not see steam: Leave the hybrid system operating and carefully lift the
hood.
Check to see if the cooling fans are operating.
If the fans are operating: Wait until the high coolant temperature warning light goes
off and then stop the hybrid system.
If the fans are not operating: Stop the hybrid system immediately and call your Toyota
dealer.
The following may indicate that your vehicle is overheating:
●The high coolant temperature warn ing light flashes or comes on:
The engine may be overheating.
● The hybrid system overhe at warning light comes on:
The power control unit may be overheating.
Follow the correction procedure as described below.
STEP 1
STEP 2
STEP 3

5
When trouble arises
487
5-2. Steps to take in an emergency
PRIUS v_U (OM47674U)
After the hybrid system has
cooled down, check the power
control unit coolant level and
inspect the cooling system for
leaks.
If necessary, add power control
unit coolant up to the “F” line.
Water can be used in an emer-
gency measure if power control
unit coolant is unavailable.
(
P. 499)
Have the vehicle checked at nearest Toyota dealer as soon as possi-
ble.
STEP 4
STEP 5
■ Overheating
The following symptoms may occur when your vehicle is overheating:
● Hybrid system output decrease
● Steam is coming from under the hood

551
Alphabetical index
PRIUS v_U (OM47674U)
Bluetooth®*
Bottle holders .......................... 309
Brake
Fluid...................................... 501
Parking brake ....................... 193
Brake assist ............................. 250
Break-in tips ............................ 163
Brightness control Instrument panel light
control ................................ 197
Camera
*
Care Exterior ................................. 346
Interior .................................. 350
Seat belts ............................. 351
Cargo capacity ........................ 270
Cargo hooks ............................ 326
CD player
*
Chains ...................................... 272
Child restraint system
Booster seats, definition ....... 141
Booster seats, installation .... 150
Convertible seats, definition............................. 141
Convertible seats, installation .......................... 150
Front passenger occupant classification system .......... 135
Infant seats, definition .......... 141
Infant seats, installation ........ 150
Installing child restraint system with LATCH anchors .......... 147
Installing child restraint system with seat belts .................... 150
Installing child restraint system
with top tether strap ........... 155 Child safety
Airbag precautions ................129
Back door precautions ............78
Child restraint system............141
Child-protectors .......................72
How your child should wear the seat belt ..........................99
Installing child restraints ........146
Panoramic roof precautions .........................322
Power window lock switch.....109
Power window precautions ...111
Removed electronic key battery precautions .........................407
Seat belt extender
precautions .........................103
Seat belt precautions ............100
Seat heater precautions ........318
12-volt battery precautions ....384
Child-protectors .........................72
Cleaning Exterior ..................................346
Interior ...................................350
Seat belts ..............................351
Clock .........................................314
Condenser ................................377
Console box .............................306
Cooling system
Engine overheating ...............485
Hybrid system overheating....485
Cruise control
Cruise control ........................229
Dynamic radar cruise control .................................233
Cup holders ..............................307
Curtain shield airbags .............121
Customizable features.............523
C
*: Refer to “Display Audio System Owner’s Manual” or “Navigation System Owner’s Manual”.

553
Alphabetical index
PRIUS v_U (OM47674U)
Engine
Accessory mode ................... 175
Compartment........................ 370
Hood ..................................... 364
How to start the hybrid system................................ 173
Identification number ............ 495
If the hybrid system will not start .................................... 474
Ignition switch ....................... 173
Overheating .......................... 485
“POWER” switch .................. 173
Engine coolant Capacity ............................... 499
Checking .............................. 375
Preparing and checking before winter ...................... 271
Engine/power control unit coolant
Capacity ............................... 499
Checking .............................. 375
Preparing and checking before winter ...................... 271
Engine oil Capacity ............................... 497
Checking .............................. 371
Preparing and checking before winter ...................... 271
Enhanced VSC......................... 250
EPS ........................................... 250
EV drive mode switch ............. 180
Event data recorder .................. 22 Floor mats.................................324
Fluid
Brake .....................................501
Washer ..................................380
Fog lights Replacing light bulbs .............419
Switch....................................219
Wattage .................................504
Foot lights.................................299
Front fog lights
Replacing light bulbs .............419
Switch....................................219
Wattage .................................504
Front passenger occupant classification system ............135
Front passenger’s seat belt reminder light.........................449
Front seats
Adjustment ..............................81
Flattening seatbacks ...............82
Front side marker light Replacing light bulbs .............419
Wattage .................................504
Front turn signal lights Replacing light bulbs .............419
Switch....................................192
Wattage .................................504
Fuel
Capacity ................................496
Fuel gauge ............................195
Information ............................505
Refueling ...............................112
Type ......................................505
Fuel door...................................112
Fuel filler door ..........................112
Fuses.........................................408F