clutch TOYOTA RAIZE 2023 User Guide

1854-2. Driving procedures
RAIZE_OM_General_BZ358E
Driving
4
Stopping the engine
aStop the vehicle completely
b Continuously variable transmission vehicles: Apply the parking brake
( ➞ P. 197) and set the shift lever in P
Manual transmission vehicles: Apply the parking brake ( ➞P. 197) and
set the shift lever in N
c Press the engine switch
d Release your foot from the brake pedal, and make sure that the engine
switch indicator light is off
Changing the engine switch mode
You can switch the modes by pushing the engine switch without stepping
on the brake pedal (continuously vari able transmission vehicles) or the
clutch pedal (manual transmission ve hicles). (Each time the switch is
pressed, the mode changes)
“OFF”*
The emergency flashers can be used.
“ACC”
You can use electrical components, such
as a power outlet.
The indicator of the engine switch will
flash in green at a slow pace.
“ON”
All electrical components can be used.
The indicator of the engine switch will
flash in green at a slow pace.
*When the shift lever is set to other
than the P position, it becomes “ACC”,
but will not be switched to “OFF”. (Con-
tinuously variable transmission vehi-
cles)
KBRO420203E
RAIZE_OM_General_BZ358E.book 185 ページ ２０２２年５月１７日　火曜日　午後１時５９分

1944-2. Driving procedures
RAIZE_OM_General_BZ358E✽
: If equipped
Driving the manual transmission vehicle✽
Moving the shift lever
Firmly step on the clutch pedal and operate the shift lever slowly.
To prevent mishandling, the gear cannot be shifted directly from 5-speed to R.
Shift the gear to N and then move it to R.
⬛Speed limit of each shift position
To avoid over-revving of the engine, tr y not to exceed the value specified for
each shift position listed below.
WARNING
⬛On slippery road surfaces
Be careful since sudden acceleration or changes in engine braking force may
cause the vehicle to skid or spin.
Shift positionMax. speed km/h (mph)
WA-VE engine1KR-VET engine
4150 (93)150 (93)
3105 (65)110 (68)
270 (43)65 (40)
135 (21)35 (21)
KBRO420401E
RAIZE_OM_General_BZ358E.book 194 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2936-2. Maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
Do-it-yourself maintenance
⚫What about do-it-yourself maintenance?
Many of the maintenance items are easy to do yourself if you have a little mechanical
ability and a few basic automotive tools. Simple instructions for how to perform them
are presented in this section.
Note, however, that some maintenance task s require special tools and skills. These
are best performed by qualified technician s. Even if you are an experienced do-it-
yourself mechanic, we recommend that repairs and maintenance be conducted by
your Toyota dealer who will keep a record of maintenance on your vehicle. This
record could be helpful should you ever require Warranty Service.
⬛Does your vehicle need repairs?
Be on the alert for changes in performance and sounds, and visual tip-offs that
indicate service is needed. Some important clues are:
⚫Engine misses, stumbling or pinging
⚫Appreciable loss of power
⚫Strange engine noises
⚫A fluid leak under the vehicle (However , water dripping from the air condi-
tioning system after use is normal.)
⚫Change in exhaust sound (This may indica te a dangerous carbon monoxide leak.
Drive with the windows open and have th e exhaust system checked immediately.)
⚫Flat-looking tires, excessive tire squeal when cornering, uneven tire wear
⚫Vehicle pulls to one side when driven straight on a level road
⚫Strange noises related to suspension movement
⚫Loss of brake effectiveness, spongy feeling brake pedal or clutch pedal (vehi-
cles with a manual transmission), pe dal almost touches the floor, vehicle
pulls to one side when braking
⚫Engine coolant temperature continually higher than normal
If you notice any of these clues, take yo ur vehicle to your Toyota dealer as soon
as possible. Your vehicle may need adjustment or repair.
WARNING
⬛If your vehicle is not properly maintained
Improper maintenance could result in serious damage to the vehicle and pos-
sible death or serious injury.
⬛Handling of the battery
Battery posts, terminals and related accessories contain lead and lead com-
pounds which are known to cause brain damage. Wash your hands after han-
dling. ( ➞P. 321)
RAIZE_OM_General_BZ358E.book 293 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2966-2. Maintenance
RAIZE_OM_General_BZ358E
FUEL AND EMISSION CONTROL SYSTEMS
12Fuel filter*3R96
13Air cleaner filterIRIRI: 24
R: 48
14
Fuel tank cap, fuel
lines, connections
and fuel vapor con-
trol valve*
2
II24
15Charcoal canisterII24
CHASSIS AND BODY
16Clutch pedal
(1KR-VET engine)IIIIIIII12
17Clutch pedal
(WA-VE engine)IIIIIIII12
18Brake pedal and
parking brakeIIIIIIII6
19
Brake linings and
drums (include park-
ing brake linings and
drums)
IIII12
20Brake pads and discsIIII6
21Brake fluidIIIRIIIRI: 6
R: 24
22Clutch fluid
(1KR-VET engine)IIIRIIIRI: 6
R: 24
23Brake pipes and
hosesIIII12
24
Steering wheel, link-
age and steering
gear box
IIII12
SERVICE
INTERVAL:ODOMETER READING
MONTHS
(Odometer reading or months,
whichever
comes first.) x1000
km 1 1020304050607080
x1000 miles 1 6 12 18 24 30 36 42 48
RAIZE_OM_General_BZ358E.book 296 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3026-2. Maintenance
RAIZE_OM_General_BZ358E
CHASSIS AND BODY
13
Brake linings and
drums (include park-
ing brake linings and
drums)
IIII12
14Brake pads and discsIIII6
15Brake fluidIIIRIIIRI: 6
R: 24
16Clutch fluidIIIRIIIRI: 6
R: 24
17Brake pipes and
hosesIIII12
18
Steering wheel, link-
age and steering
gear box
IIII12
19Drive shaft bootsIIIIIIII6
20Suspension ball joint
and dust coverIIII12
21
Manual transmis-
sion oil (including
front differential)
IRI: 48
R: 96
22
Continuously varia-
ble transmission
fluid (including front
differential)
Inspect every 12 months, Replace every
100000 km (60000 miles)―
23Front and rear sus-
pensionIIII12
24Front wheel align-
ment (toe-in)II48
25Air conditioning filterRRRR24
SERVICE
INTERVAL:ODOMETER READING
MONTHS
(Odometer reading or months,
whichever
comes first.) x1000
km 10 20 30 40 50 60 70 80
x1000 miles 6 12182430364248
RAIZE_OM_General_BZ358E.book 302 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3076-2. Maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
Clutch pedal
⚫Does the clutch pedal move smoothly?
⚫Does the clutch pedal have appropriate clearance
from the floor?
⚫Does the clutch pedal have the correct amount of free
play? (➞P. 427)
Head restraints⚫Do the head restraints move smoothly and lock
securely?
Horn⚫Function properly?
Indicators/buzzers⚫Do the indicators and bu zzers function properly?
Lights⚫Do all the lights come on?
Parking brake
⚫Does the parking brake operate normally?
⚫When parked on a slope and the parking brake is on, is
the vehicle securely stopped?
Seat belts⚫Do the seat belts operate smoothly?
⚫The seat belts should not be damaged.
Seats⚫Do the seat controls operate properly?
Steering wheel
⚫Does the steering wheel rotate smoothly?
⚫Does the steering wheel have the correct amount of
free play?
⚫There should not be any st range sounds coming from
the steering wheel.
ItemsCheck points
RAIZE_OM_General_BZ358E.book 307 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4067-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
If the electronic key does not work properly
(vehicles with key-free system)
The key-free system and wireless remote control cannot be used
when communication between the electronic key and vehicle is
blocked (➞P. 125) or when the electronic key battery is dead. In such
cases, you can open the doors or start the engine by following the
steps below.
Locking and unloc king the doors
Using the emergency key ( ➞P. 118),
you can:
a Lock all doors
b Unlock all doors
If set, the alarm will sound. ( ➞P. 73)
Starting the engine
a Continuously variable transmission vehicles: Step on the brake pedal
with the shift lever placed in P
Manual transmission vehicles: Step on the clutch pedal with the shift
lever placed in N
b Touch the electronic key to the
engine switch, as shown in the
illustration
⦁The indicator of the engine switch
lights up in green.
⦁ The alarm will shut off. (➞ P. 73)
cPress the engine switch
If you are still unable to start the engine after following the above steps,
contact your Toyota dealer.
12
KBRO720801E
KBRO820801E
RAIZE_OM_General_BZ358E.book 406 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4077-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
⬛Stopping the engine
As you usually would when stopping the engine, set the shift lever to P for con-
tinuously variable transmission vehicles , and set it to N for manual transmis-
sion vehicles, then press the engine switch.
⬛Replacing the battery
The method to start the engine descri bed here is a temporary workaround. We
recommend that you replace dead batteries immediately. ( ➞P. 344)
⬛Changing the engine switch mode
In step c of “Starting the engine ”, if you press the engine switch by releasing
your foot from the clutch pedal for manual transmission vehicles and from the
brake pedal for continuously variable tr ansmission vehicles, the engine will not
start. Instead, the mode changes each time you press the switch. (➞P. 185)
⬛If the electronic key does not work properly
Check whether the electronic key is set to battery-saving mode. If the mode is
set, cancel it ( ➞P. 125)
RAIZE_OM_General_BZ358E.book 407 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4278-1. List of specifications
RAIZE_OM_General_BZ358E✽
: If equipped
Vehicle information
8
Clutch
Brakes
*1Minimum pedal clearance when depressed with a force of 294 N (30 kgf, 66
lbf) while the engine is running
*2Parking brake lever travel when pulled up wi th a force of 196 N (20 kgf, 44 lbf)
Steering
Pedal free play
▶WA-VE engine
19.0 - 30.0 mm (0.75 - 1.18 in.)
▶1KR-VET engine
5.9 - 18.3 mm (0.23 - 0.72 in.)
Fluid type✽FMVSS No. 116 DOT 3
Pedal clearance*188 mm (3.5 in.)
Pedal free play0.5 - 2.0 mm (0.02 - 0.08 in.)
Parking brake lever
travel*25 - 8 clicks
Fluid typeFMVSS No.116 DOT 3
Free playLess than 10 mm (0.4 in.)
RAIZE_OM_General_BZ358E.book 427 ページ ２０２２年５月１７日　火曜日　午後１時５９分

437What to do if... (Troubleshooting)
RAIZE_OM_General_BZ358E
If you think something is wrong
The engine does not start (vehicles without key-free system)
⚫Continuously variable transmission vehicles
Is the shift lever in P? (➞P. 180)
⚫Manual transmission vehicles
Did you turn the engine switch while firmly depressing the clutch pedal?
(➞ P. 1 8 0 )
⚫Isn’t the steering wheel locked? ( ➞P. 182)
⚫Isn’t the battery discharged? ( ➞P. 408)
The engine does not start (vehicles with key-free system)
⚫Continuously variable transmission vehicles
Did you press the engine switch while firmly depressing the brake
pedal? ( ➞P. 184)
⚫Manual transmission vehicles
Did you press the engine switch wh ile firmly stepping on the clutch
pedal? ( ➞P. 184)
⚫Continuously variable transmission vehicles
Is the shift lever in P? ( ➞P. 184)
⚫Is the key anywhere detectable inside the vehicle? ( ➞P. 122)
⚫Isn’t the steering wheel locked? ( ➞P. 187)
⚫Is the key battery weak or depleted?
In this case, the engine can be started in a temporary way. ( ➞P. 406)
⚫Isn’t the battery discharged? ( ➞P. 408)
RAIZE_OM_General_BZ358E.book 437 ページ ２０２２年５月１７日　火曜日　午後１時５９分