engine TOYOTA RAV4 1996 Service Repair Manual

18
F RELAY LOCATIONS
[Engine Compartment]
[Instrument Panel]

22
F RELAY LOCATIONS
2: R/B No. 2Engine Compartment Left (See Page 18)
*1 : 15A H-LP LH
*2 : 15A H-LP RH

25
F
6: R/B No. 6Engine Compartment Left (See Page 18)
Fusible Link BlockNear The Battery (See Page 18)

28
G ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
*1 : w/ A/C
*2 : w/o A/C
A 1 A/C Condenser Fan Motor E 1 Electronically Controlled Transmission Solenoid
A 2 A/C Magnetic Clutch and Lock Sensor E 2 Engine Coolant Temp. Sensor
A 3 A/C Triple Pressure SW (A/C Dual and Single
Pressure SW) F 1 Front Side Marker Light LH
A 4 A/C Water Temp. SW F 2 Front Side Marker Light RH
A 5 A/T Fluid Temp. SW F 3 Front Turn Signal Light LH and Front Parking
A 6 ABS Actuator Light LH
A 7 ABS Actuator F 4 Front Turn Signal Light RH and Front Parking
A 8 ABS Relay Light RH
A 9 ABS Relay F 5 Front Washer Motor
A 10 ABS Speed Sensor Front LH F 6 Front Wiper Motor
A 11 ABS Speed Sensor Front RH F 7 Fusible Link Block
B 1 Back-Up Light SW (M/T) G 1 Generator
B 2 Brake Fluid Level Warning SW G 2Generator
C 1 Center Diff. Lock Warning Buzzer SW H 1 Headlight LH
C 2 Crankshaft Position Sensor H 2 Headlight RH
C 3 Cruise Control Actuator H 3 Horn
D 1 Data Link Connector 1

29
G
Position of Parts in Engine Compartment
I 1 Idle Air Control Valve R 1Radiator Fan Motor
I 2 Igniter R 2 Rear Washer Motor
I 3 Ignition Coil and Distributor
I 4 Ignition Coil and Distributor S 1 Solenoid Valve SLD
I 5 Injector No. 1 S 2 Starter
I 6 Injector No. 2 S 3 Starter
I 7 Injector No. 3
I 8 Injector No. 4 T 1 Throttle Position Sensor
I 9 Intake Air Temp. Sensor
V 1 Vapor Pressure Sensor
K 1 Knock Sensor V 2 Vehicle Speed Sensor (Combination Meter)
V 3 Vehicle Speed Sensor (Front)
M 1 Manifold Absolute Pressure Sensor V 4 Vehicle Speed Sensor (Rear)
V 5 VSV (Center Diff. Lock No. 1)
N 1 Noise Filter (Ignition System) V 6 VSV (Center Diff. Lock No. 2)
V 7 VSV (EGR)
O 1 Oil Pressure SW V 8 VSV (EVAP)
O 2 Oxygen Sensor (Bank 1 Sensor 1) V 9 VSV (Vapor Pressure Sensor)
O 3 Oxygen Sensor (Bank 1 Sensor 2)
W 1 Water Temp. Sender
P 1 Park/Neutral Position SW (A/T)

30
G ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
A 12 A/C Amplifier C 6 Cigarette Lighter Illumination
A 13 A/C Control SW C 7 Clock
A 14 A/C Thermistor C 8 Clutch Start SW
A 15 ABS Deceleration Sensor C 9 Combination Meter
A 16 ABS ECU C 10 Combination Meter
A 17 ABS ECU C 11 Combination Meter
A 18 Airbag Sensor Assembly C 12 Combination SW
A 19 Airbag Squib (Front Passenger Airbag Assembly) C 13 Combination SW
A 20 Airbag Squib (Steering Wheel Pad) C 14 Combination SW
C 15 Cruise Control Clutch SW
B 3 Blower Motor C 16 Cruise Control ECU
B 4 Blower Resisitor
B 5 Blower SW D 2 Data Link Connector 3
B 6 Buckle SW LH D 3 Defroster Mode SW
D 4 Diode (Engine Idle-Up)
C 4 Center Diff. Lock Control SW D 5 Door Lock Control Relay
C 5 Cigarette Lighter

31
G
Position of Parts in Instrument Panel
E 3 Electronically Controlled Transmission Pattern J 9 Junction Connector
Select SW J 10 Junction Connector
E 4 Engine Control Module J 11 Junction Connector
E 5 Engine Control Module
E 6 Engine Control Module K 2 Key Interlock Solenoid
F 8 Fuse Block O 4 O/D Main SW
H 4 Hazard SW P 2 Parking Brake SW
I 10 Ignition SW R 3 Radio and Player
R 4 Radio and Player
J 1 Junction Connector R 5 Rear Window Defogger SW
J 2 Junction Connector R 6 Remote Control Mirror SW
J 3 Junction Connector R 7 Rheostat
J 4 Junction Connector
J 5 Junction Connector S 4 Shift Lock ECU
J 6 Junction Connector S 5 Stop Light SW
J 7 Junction Connector
J 8 Junction Connector U 1 Unlock Warning SW

35
G
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
EA1ENGINE WIRE AND ENGINE ROOM MAIN WIRE (INSIDE OF R/B NO. 2)

37
G
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IB1ENGINE ROOM MAIN WIRE AND INSTRUMENT PANEL WIRE (LEFT KICK PANEL)
IB2ENGINE ROOM MAIN WIRE AND INSTRUMENT PANEL WIRE (RIGHT KICK PANEL)
IC1FRONT DOOR LH WIRE AND INSTRUMENT PANEL WIRE (LEFT KICK PANEL)
ID1FLOOR WIRE AND INSTRUMENT PANEL WIRE (LEFT KICK PANEL)ID2FLOOR WIRE AND INSTRUMENT PANEL WIRE (LEFT KICK PANEL)
IE1ROOF WIRE AND INSTRUMENT PANEL (LEFT KICK PANEL)

39
G
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IF1ENGINE ROOM MAIN WIRE AND FLOOR WIRE (LEFT KICK PANEL)
IG1ENGINE WIRE AND INSTRUMENT PANEL WIRE (UNDER THE INSTRUMENT PANEL CENTER)IG2ENGINE WIRE AND INSTRUMENT PANEL WIRE (UNDER THE INSTRUMENT PANEL CENTER)
IH1HEATER BLOWER WIRE AND INSTRUMENT PANEL WIRE (RIGHT KICK PANEL)
II1FRONT DOOR RH AND INSTRUMENT PANEL WIRE (RIGHT KICK PANEL)
IJ1FRONT DOOR LH AND FLOOR WIRE (LEFT KICK PANEL)