jump cable TOYOTA RAV4 1996 Service Repair Manual

IG0317IG0151P25066A06618
1.1 − 1.3 mm
(0.043 − 0.051 in.)
A00404
”10 (+)
#30 (+)#40 (+) ON
#20 (+)
− DIAGNOSTICSENGINE
DI−53
1996 RAV4 (RM447U)
INSPECTION PROCEDURE
1 Check spark plug and spark of misfiring cylinder.
PREPARATION:
(a) Disconnect the high−tension cord from spark plug.
(b) Remove spark plug.
CHECK:
(a) Check the carbon deposits on electrode.
(b) Check electrode gap.
OK:
(1) No large carbon deposit present.
Not wet with gasoline or oil.
(2) Electrode gap: 1.1 − 1.3 mm (0.043 − 0.051 in.)
PREPARATION:
(a) Install the spark plug to the high − tension cord.
(b) Disconnect injector connector.
(c) Ground spark plug.
CHECK:
Check if spark occurs while engine is being cranked.
NOTICE:
To prevent excess fuel being injected from the injectors
during this test, do not crank the engine for more than 5 −
10 seconds at a time.
OK:
Spark jumps across electrode gap.
NG Replace or check ignition system (See page
IG−1).
OK
2 Check voltage of ECM terminal for injector of failed cylinder.
PREPARATION:
(a) Remove side trim cover (See page SF−61).
(b) Turn ignition switch ON.
CHECK:
Measure voltage between applicable terminal of ECM connec-
tor and body ground.
OK:
Voltage: 9 − 14 V
OK Go to step 4
NG

MX01Z−08
− MANUAL TRANSAXLETROUBLESHOOTING
MX−1
1996 RAV4 (RM447U)
TROUBLESHOOTING
PROBLEM SYMPTOMS TABLE
Use the table below to help you find the cause of the problem. The numbers indicate the priority of the likely
cause of the problem. Check each part in order. If necessary, replace these parts.
SymptomSuspect AreaSee page
Noise
14.Oil (Level low) 2WD
4WD
15. Oil (Wrong) 2WD
4WD
16.Gear (Worn or damaged)
17.Bearing (Worn or damaged)MX−3
MX−9
MX−3
MX−9
MX−12
MX−79
MX−12
MX−79
Oil leakage
1. Oil (Level too high) 2WD
4WD
2. Gasket (Damaged)
3. Oil seal (Worn or damaged)
4. O−Ring (Worn or damaged)MX−3
MX−9
MX−12
MX−79
MX−12
MX−79
MX−12
MX−78
MX−79
Hard to shift or will not shift
1. Control cable (Faulty)
2. Synchronizer ring (Worn or damaged)
3. Shift key spring (Damaged)MX−77
MX−12
MX−29
MX−36
MX−12
MX−29
MX−36
Jumps out of gear
1. Locking ball spring (Damaged)
2. Shift fork (Worn)
3. Gear (Worn or damaged)
4. Bearing (Worn or damaged)MX−12
MX−12
MX−79
MX−12
MX−79
MX−12
MX−79
Tight corner braking1. Differential, Center differential (Faulty)MX−58
MX−72